boot CHRYSLER 200 2013 1.G Warranty Booklet

TOWING IS COVERED
If your vehicle has to be towed because a part covered by warranty failed, towing to the nearest
Chrysler or Dodge Retailer will be covered by the Roadside Assistance Program (for details, see
page 10).
Important: Some vehicles have special towing requirements. See your Owner’s Manual for towing instructions.
3/60 BASIC WARRANTY
If required because of a defect in material or workmanship, the 3/60 Basic Warranty will cover the
adjustment, repair or replacement of any factory-installed part of your vehicle except tires for3 years
or 60,000 kilometres, whichever occurs first. The following items are exceptions; they are only
covered (if defective) for 1 year or 20,000 kilometres, whichever occurs first:
 light bulbs and fuses
 wiper blades
 clutch discs
 brakes (rotors, pads, linings and drums)
 windshield and rear window
 wheel alignment and wheel balancing
Tires are warranted by the tire manufacturers, not by Chrysler. For details, see the tire manufacturer’s
warranty booklet in your glovebox. Your Chrysler Retailer may be able to assist you if you experience
a problem with a factory-installed tire.
Tires and spare tire should be replaced after six years, regardless of the remaining tread. Failure to
follow this warning can result in sudden tire failure. You could lose control and have an accident
resulting in serious injury or death.
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or 100,000 kilometres,whichever
occurs first, measured from the vehicle’s original warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT vehicles are excluded
from the 5-year or 100,000-kilometre Powertrain Warranty and are covered only under the 3-year or
60,000-kilometre Basic Warranty.
 Engine - Cylinder block and all internal parts; cylinder head assemblies; timing case, timing chain,
timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing; intake and
exhaust manifolds; flywheel with starter ring gear; core plugs; valve covers; oil pan; turbocharger
housing and internal parts; turbocharger wastegate actuator; supercharger; serpentine belt ten-
sioner; seals and gaskets for listed components only.
 Front-Wheel Drive (If equipped) -Transaxle case and all internal parts; axle shaft assemblies;
constant velocity joints and boots; differential cover; oil pan; transaxle speed sensors; transaxle
solenoid assembly; PRNDL position switch; transaxle electronic controller; torque converter; seals
and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
 Rear-Wheel Drive (If equipped)- Transmission case and all internal parts; torque converter,
drive/flex plate; transmission range switch; transmission control module; bell housing; oil pan;
seals and gaskets for listed components only. Rear axle housing and all internal parts; axle shafts;
axle shaft bearings; driveshaft assemblies; driveshaft centre bearings; universal joints and yokes;
seals and gaskets for listed components only.
 4-Wheel Drive (4x4) (If equipped)- Transfer case and all internal parts; transfer case control
module and shift mode motor assembly; axle housing and all internal parts; axle shafts; axle shaft
bearings; driveshaft assemblies (front and rear); driveshaft centre bearings; universal joints and
yokes; disconnect housing assembly; seals and gaskets for listed components only.
4

All-Wheel Drive (AWD) (If equipped)- Power transfer unit and all internal parts; driveshaft and
axle shaft assemblies; constant velocity joints and boots; axle housing and all internal parts;
differential carrier assembly and all internal parts; output ball bearing; output flange; end cover;
viscous converter clutch; overrunning clutch; vacuum motor; torque tube; pinion spacer and shim;
seals and gaskets for these parts only.
CORROSION WARRANTY
For 3 years, regardless of distance driven, your Corrosion Warranty covers any body sheet metal
panel which develops a hole caused by corrosion.
In addition, outer body panels are covered against holes caused by corrosion up to 5 years or 160,000
kilometres, whichever occurs first. An outer body panel is a sheet metal panel which can be seen
while walking around the vehicle, and which is painted body colour.
This warranty applies only to holes caused by corrosion. Cosmetic or surface corrosion (resulting
from stone chips or scratches in the paint, for example) will not be repaired under this warranty.
If corrosion damage is obviously neglected and allowed to worsen until a hole develops, this warranty
will not cover the repair.
EMISSION WARRANTIES
Chrysler Canada warrants that your new vehicle was designed, built and equipped to conform at the
time of sale with applicable federal and provincial emissions standards, and that the vehicle is, at the
time of sale, free from defects in material and workmanship which would cause it to fail to conform
to the applicable emission standards within the warranty periods specified. A covered defect is one
which causes your vehicle to fail to meet applicable emission control regulations.
To keep your vehicle operating properly and in conformance with emission regulations, see the Scheduled Maintenance instructions in your Owner’s Manual and herein. Only Chrysler parts
should be used for maintenance and repair of your vehicle’s emission control systems.
You should keep any receipts for maintenance service and pass them on to the next owner of your
vehicle, in case questions arise concerning maintenance. Chrysler Canada has the right to deny
warranty coverage if your vehicle has not been properly maintained, or if repairs are needed because
parts other than Chrysler parts were used; however, denial will not be based on the lack of
maintenance records alone.
Warranty service must be performed by an authorized Chrysler or Dodge Retailer.
If emergency warranty service is required and an authorized retailer is not available, contact Chrysler
Canada Customer Assistance (page 9) and request emission warranty service help.
EMISSION DEFECT WARRANTY
The 3/60 Basic Warranty covers all emission control components for 3 years or 60,000 kilometres,
whichever occurs first. The Emission Defect Warranty provides longer coverage for specified components.
The Defect Warranty covers the following major emission control parts, if so equipped, for 8 years
or 130,000-kilometres, whichever occurs first:
 catalytic converter
 powertrain control module
To receive this coverage the vehicles onboard diagnostic system must indicate a failed emission component.
5

Perform Maintenance At 32,000 km or 24 Months
Inspect the front suspension components, tie rod ends and boot seals; replace if necessary.
Inspect the brake linings, parking brake function.
Replace the air conditioning filter.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
Perform Maintenance At 48,000 km or 36 Months
Inspect the CV joints.
Replace the engine air filter.
Replace the spark plugs. (2.4L Engine) **
** The spark plug change interval is metrage based only, monthly intervals do not apply.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
16

Perform Maintenance At 64,000 km or 48 Months
Inspect the front suspension components, tie rod ends and boot seals; replace if necessary.
Inspect the brake linings, parking brake function.
Replace the air conditioning filter.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
Perform Maintenance At 96,000 km or 72 Months
Inspect the CV joints.
Inspect the front suspension components, tie rod ends and boot seals; replace if necessary.
Inspect the brake linings, parking brake function.
Replace the air conditioning filter.
Replace the engine air filter.
Replace the spark plugs. (2.4L Engine) **
Change the automatic transmission fluid and filter if using your vehicle for any of the follow-
ing: police, taxi, fleet or frequent trailer towing
** The spark plug change interval is metrage based only, monthly intervals do not apply.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
17

Perform Maintenance At 128,000 km or 96 Months
Inspect the front suspension components, tie rod ends and boot seals; replace if necessary.
Inspect the brake linings, parking brake function.
Replace the air conditioning filter.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
Perform Maintenance At 144,000 km or
108 Months
Inspect the CV joints.
Replace the engine air filter.
Replace the spark plugs. (2.4L Engine) **
** The spark plug change interval is metrage based only, monthly intervals do not apply.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
18

Perform Maintenance At 160,000 km or
120 Months
Inspect the front suspension components, tie rod ends and boot seals; replace if necessary.
Inspect the brake linings, parking brake function.
Replace the air conditioning filter.
Replace the spark plugs. (3.6L Engine) **
Flush and replace the engine coolant at 10 years or 240,000 kilometres, which ever comes first.
Inspect the PCV valve; replace if necessary.
** The spark plug change interval is metrage based only, monthly intervals do not apply.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
Perform Maintenance At 192,000 km or
144 Months
Inspect the CV joints.
Inspect the front suspension components, tie rod ends and boot seals; replace if necessary.
Inspect the brake linings, parking brake function.
Replace the air conditioning filter.
Replace the engine air filter.
Replace the spark plugs. (2.4L Engine) **
Change the automatic transmission fluid and filter.
** The spark plug change interval is metrage based only, monthly intervals do not apply.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
19

Perform Maintenance At 224,000 km or
168 Months
Inspect the front suspension components, tie rod ends and boot seals; replace if necessary.
Inspect the brake linings, parking brake function.
Replace the air conditioning filter.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
Perform Maintenance At 240,000 km or
180 Months
Inspect the CV joints.
Replace the engine air filter.
Replace the spark plugs. (2.4L Engine) **
Flush and replace the engine coolant at 10 years or 240,000 kilometres, which ever comes first.
** The spark plug change interval is metrage based only, monthly intervals do not apply.
Odometer Reading
Date
Repair Order No.
Signature of authorized Chrysler Canada Retailer
C HRYSLER
R ETAILER STAMP
20