maintenance CHRYSLER 300 2003 1.G Warranty Booklet

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
144,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-30-01 3N.
Maint enance Service Sc hedule ÒBÓ
144,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Replace the make-up air filter located inside the air cleaner (Neon and PT Cruiser only).
l Adjust the generator belt tension (Neon and PT Cruiser only).
l Inspect the generator belt, replace if necessary (2.4L Minivan only).
l Inspect and adjust the power steering pump belt tension (2.4L Minivan only).
l Replace the engine timing belt (2.4L Minivan, Sebring and Sebring Convertible only).
l Change the all-wheel-drive power transfer unit fluid (Minivan only).*
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the tie rod ends and boot seals (Minivan, Neon and PT Cruiser only).
lInspect the front and rear brake linings and components (all except Sebring and Sebring Convertible).l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
03Minivan and Car Maint 1/15/03 9:55 AM Page 89

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
149,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-31-01 3N.
Maint enance Service Sc hedule ÒBÓ
149,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 91

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
154,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-32-01 3N.
Maint enance Service Sc hedule ÒBÓ
154,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Replace the air conditioning filter (Minivan only).
l Change the automatic transaxle fluid and filter.
l Replace the differential fluid (Concorde, Intrepid and 300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 93

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
158,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-33-01 3N.
Maint enance Service Sc hedule ÒBÓ
158,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Replace the spark plugs (Concorde, Intrepid and 300M only).
l Flush and replace engine coolant at 60 months or 160,000 kilometres.
l Replace the engine timing belt (Concorde, Intrepid and 300M only).
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all except Sebring and Sebring Convertible).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 95

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
163,0 00 km
Maint
enance Service Sc hedule ÒBÓ
163,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
Dealer copy.
Remove and attach to Repair Order 26-92-34-01 3N.
03Minivan and Car Maint 1/15/03 9:55 AM Page 97

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
168,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-35-01 3N.
Maint enance Service Sc hedule ÒBÓ
168,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect and replace, if required, the air cleaner element (PT Cruiser and Neon only).
l Replace the engine air cleaner filter if required (Minivan, Concorde, Intrepid and 300M only).
l Replace the spark plugs (2.7L Sebring and Sebring Convertible only).
l Inspect and replace, if required, the make-up air filter located inside the air cleaner (Neon and PT Cruiser only).
l Replace the accessory drive belts (2.7L Sebring, Sebring Convertible only).
l Inspect the generator belt, replace if necessary (2.4L Minivan only).
l Inspect and adjust the power steering pump belt tension (2.4L Minivan only).
l Replace the engine timing belt (2.4L PT Cruiser only).
l Change the all-wheel-drive power transfer unit fluid (Minivan only).*
l Change the all-wheel-drive overrunning clutch and rear carrier fluid (Minivan only).*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
03Minivan and Car Maint 1/15/03 9:55 AM Page 99

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
173,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-36-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 73,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Replace the air conditioning filter (Minivan only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all models).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 101

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
178,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-37-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 78,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 103

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
182,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-38-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 82,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 105

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
187 ,000 km
Dealer copy.
Remove and attach to Repair Order 26-92-39-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 87 ,000 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all except Sebring and Sebring Convertible).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 107