belt CHRYSLER 300 2004 1.G Warranty Booklet
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2004, Model line: 300, Model: CHRYSLER 300 2004 1.GPages: 131, PDF Size: 1.11 MB
Page 8 of 131
8
7/115 POWERTRAIN WARRANTY
The following powertrain components are covered for 7 years or 115,000 kilometres, whichever occurs first, measured from thevehicleÕs original warranty start date. A $100 deductible per repairvisit applies after the 3-year or 60,000-kilometre basic warrantyexpires (whichever occurs first) Vehicles placed in Police, Taxi, Limousine, Postal or Ambulance service are excluded from the 7-year or 115,000-kilometrepowertrain warranty and are covered only under the 3-year or60,000-kilometre basic warranty. ¥ Engine Ð Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing;intake and exhaust manifolds; flywheel with starter ring gear; coreplugs; valve covers; oil pan; turbocharger housing and internalparts; turbocharger wastegate actuator; supercharger; serpentinebelt tensioner; seals and gaskets for listed components only. ¥
Transmission Ð Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;transmission control module; bell housing; oil pan; seals andgaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time .
¥ Front-Wheel Drive Ð Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differentialcover; oil pan; transaxle speed sensors; transaxle solenoidassembly; PRNDL position switch; transaxle electronic controller;torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
¥ All-Wheel Drive (AWD) Ð Power transfer unit and all internal
parts; viscous coupler; axle housing and all internal parts;constant velocity joints and boots; drive shaft and axle shaftassemblies; differential carrier assembly and all internal parts;output ball bearing; output flange; end cover; overrunning clutch;vacuum motor; torque tube; pinion spacer and shim, seals andgaskets for listed components only.
7/115 POWERTRAIN WARRANTY
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 8
Page 40 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
24,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-05-01 3N.
Maint enance Service Sc hedule ÒBÓ
24,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Replace the engine air cleaner filter (Pacifica, Concorde, Intrepid and 300M only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained
high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 39
Page 41 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary(Sebring, Sebring Convertible only).
l Replace the engine air cleaner filter (Pacifica, Concorde,Intrepid and 300M only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hotweather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.Maint enance Service Sc hedule ÒBÓ
24,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 40
Page 50 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
48,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-10-01 3N.
Maint enance Service Sc hedule ÒBÓ
48,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel drive power transfer unit fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 49
Page 51 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drivepower transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hotweather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.Maint enance Service Sc hedule ÒBÓ
48,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 50
Page 60 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
72,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-15-01 3N.
Maint enance Service Sc hedule ÒBÓ
72,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Replace the engine air cleaner filter (Pacifica, Concorde, Intrepid and 300M only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Concorde, Intrepid, 300M and Pacifica only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 59
Page 61 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Replace the engine air cleaner filter (Pacifica, Concorde,Intrepid and 300M only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Concorde, Intrepid, 300M and Pacifica only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/ rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hotweather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.Maint enance Service Sc hedule ÒBÓ
72,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 60
Page 70 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
96,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-20-01 3N.
Maint enance Service Sc hedule ÒBÓ
96,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the air conditioning filter (Pacifica only).
l Replace the ignition cables (2.4L).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Replace drive belts (Concorde, Intrepid and 300M only).
l Replace the accessory drive belts (2.7L Sebring, Sebring Convertible only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica only).
l Replace power steering fluid (Concorde, Intrepid and 300M only).
l Change the automatic transaxle fluid and filter.
l Change the all-wheel-drive power transfer unit fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 69
Page 71 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
Maint enance Service Sc hedule ÒBÓ
96,0 00 kmlChange engine oil and engine oil filter (or every 3 months). l Inspect and lubricate as required all steering and suspension components.lReplace the engine air cleaner filter if required (all models).
l Replace the air conditioning filter (Pacifica only).
l Replace the ignition cables (2.4L).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Replace drive belts (Concorde, Intrepid and 300M only).
l Replace the accessory drive belts (2.7L Sebring, Sebring Convertible only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica only).
l Replace power steering fluid (Concorde, Intrepid and 300M only).
l Change the automatic transaxle fluid and filter.
l Change the all-wheel-drive power transfer unit fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hotweather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 70
Page 80 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
120,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-25-01 3N.
Maint enance Service Sc hedule ÒBÓ
120,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring and Sebring Convertible only).
l Replace the engine air cleaner filter (Pacifica, Concorde, Intrepid and 300M only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Replace the spark plugs (Pacifica only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 79