checking oil CHRYSLER 300 2007 1.G Owners Manual
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2007, Model line: 300, Model: CHRYSLER 300 2007 1.GPages: 432, PDF Size: 7.53 MB
Page 60 of 432
damaged, deteriorated, or mispositioned parts. Open
seams or loose connections could permit exhaust fumes
to seep into the passenger compartment. In addition,
inspect the exhaust system each time the vehicle is raised
for lubrication or oil change. Replace as required.
WARNING!
•Exhaust gases can injure or kill. They contain
carbon monoxide (CO) which is colorless and
odorless. Breathing it can make you unconscious
and can eventually poison you. To avoid breath-
ing (CO) follow the safety tips below.
•If you are required to drive with the trunk open,
make sure that all windows are closed, and the
climate control blower switch is set at high speed.
DO NOT use the recirculation mode.
Safety Checks You Should Make Inside The
Vehicle
Seat Belts
Inspect the belt system periodically, checking for cuts,
frays, and loose parts. Damaged parts must be replaced
immediately. Do not disassemble or modify the system.
Front seat belt assemblies must be replaced after a
collision. Rear seat belt assemblies must be replaced after
a collision if they have been damaged (bent retractor, torn
webbing, etc. If there is any question regarding belt or
retractor condition, replace the belt.
Airbag Warning Light
The light should come on and remain on for 6 to 8
seconds as a bulb check when the ignition switch is first
turned ON. If the light is not lit during starting, see you
authorized dealer. If the light stays on, flickers, or comes
on while driving, have the system checked by an autho-
rized dealer.
60 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
Page 335 of 432
WARNING!
You can be badly injured working on or around a
motor vehicle. Only do service work for which you
have the knowledge and the proper equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
MAINTENANCE PROCEDURES
The pages that follow contain therequiredmaintenance
services determined by the engineers who designed your
vehicle.
Besides the maintenance items for which there are fixed
maintenance intervals, there are other items that should
operate satisfactorily without periodic maintenance.
However, if a malfunction of these items does occur, it
could adversely affect the engine or vehicle performance.
These items should be inspected if a malfunction is
observed or suspected.
Engine Oil
Checking Oil Level — 2.7L, 3.5L Engines
To assure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level at
regular intervals, such as every fuel stop.
The best time to check the engine oil level is about 5
minutes after a fully warmed engine is shut off or before
starting the engine after it has sat overnight.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings. Maintain
the oil level between the MIN and MAX markings on the
dipstick. Adding 1.0 quart (1.0L) of oil when the reading
is at the MIN mark will result in a MAX reading on these
engines.
MAINTAINING YOUR VEHICLE 335
7
Page 336 of 432
CAUTION!
Overfilling or underfilling will cause oil aeration or
loss of oil pressure. This could damage your engine.
Checking Oil Level — 5.7L Engine
To assure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level at
regular intervals, such as every fuel stop.The best time to check the engine oil level is about 5
minutes after a fully warmed engine is shut off or before
starting the engine after it has sat overnight.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings. Maintain
the oil level in the “SAFE” range. Adding 1.0 quart (1.0L)
of oil when the reading is at the bottom of the “SAFE”
range will result in an oil level at the top of the “SAFE”
range on these engines.
Engine Oil Dipstick
Engine Oil Dipstick
336 MAINTAINING YOUR VEHICLE
Page 346 of 432
Refer to the “Maintenance Schedule” in this manual for
the recommended air conditioning filter replacement
intervals.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.
WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturer’s recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from allsurfaces. Refer to “Fluids, Lubricants, and Genuine
Parts” in this section for the correct fluid type.
Front & Rear Suspension Ball Joints
The suspension ball joints should be inspected for exter-
nal leakage or damage when other maintenance is per-
formed.
Steering Linkage
The tie rod end ball joints should be inspected for
external leakage or damage when other maintenance is
performed.
Body Lubrication
Locks and all body pivot points, including seat tracks,
door hinges, trunk hinges, and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to insure proper function. When performing other
underhood services, the hood latch, release mechanism,
and safety catch should be cleaned and lubricated.
346 MAINTAINING YOUR VEHICLE
Page 388 of 432
At Each Stop for Fuel
•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean, and tighten the termi-
nals as required.
•Check the fluid levels of coolant reservoir and brake
master cylinder, and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the coolant level, hoses, and clamps.
388 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Page 417 of 432
Dealer Service......................... 334
Defroster, Rear Window.................. 229
Defroster, Windshield...............61,220,225
Delay (Intermittent) Wipers............... 110
Diagnostic System, Onboard............... 332
Dimmer Switch, Headlight................ 107
Disposal
Antifreeze (Engine Coolant)............. 352
Door Locks............................ 22
Door Locks, Automatic................... 24
Door Opener, Garage.................... 141
Drive Belts............................ 340
Driving
On Slippery Surfaces.................. 250
DVD Player (Video Entertainment System).... 210
Electric Remote Mirrors................... 70
Electrical Power Outlets.................. 149
Electronic Speed Control (Cruise Control) . . 118,121
Electronic Stability Program (ESP).......... 259
Electronic Throttle Control Warning Light..... 168
Electronic Vehicle Information Center (EVIC) . . 171Emergency, In Case of
Freeing Vehicle When Stuck............. 324
Hazard Warning Flasher................ 312
Jacking............................. 314
Jump Starting........................ 322
Overheating......................... 312
Towing............................. 325
Emission Control System Maintenance....333,386
Engine.........................329,330,331
Air Cleaner.......................... 341
Block Heater......................... 237
Break-In Recommendations............... 58
Checking Oil Level.................335,336
Compartment..................329,330,331
Coolant (Antifreeze)................349,383
Cooling............................ 349
Exhaust Gas Caution................59,292
Fails to Start......................... 235
Flooded, Starting..................... 235
Fuel Requirements.................289,382
Oil ..........................335,382,383
Oil Change Interval................... 337
Oil Filler Cap.....................338,339
INDEX 417
10
Page 423 of 432
Navigation Radio....................... 206
Navigation System...................... 206
New Vehicle Break-In Period............... 58
Occupant Restraints...................... 32
Octane Rating, Gasoline (Fuel)............. 289
Odometer............................ 167
Trip ............................... 167
Oil, Engine.........................335,383
Capacity............................ 382
Change Interval...................... 337
Checking........................335,336
Dipstick.........................335,336
Disposal............................ 340
Filter...........................340,383
Filter Disposal....................... 340
Identification Logo.................... 338
Materials Added to.................... 339
Recommendation..................337,382
Synthetic........................... 339
Viscosity......................338,339,382
Onboard Diagnostic System............332,333
Opener, Garage Door (HomeLink) ......... 141Operating Precautions................... 332
Outside Rearview Mirrors................. 69
Overdrive............................ 242
Overhead Console...................... 140
Overheating, Engine..................167,312
Owner’s Manual (Operator Manual)......... 409
Panic Alarm........................... 20
Park Assist System, Rear................. 136
Parking Brake......................... 251
Parking On Hill........................ 251
Passing Light.......................... 107
Pedals, Adjustable...................... 117
Personal Settings....................... 182
Pets.................................. 58
Phone, Cellular......................... 72
Phone, Hands-Free (UConnect™)............ 72
Placard, Tire and Loading Information....... 267
Power
Brakes............................. 253
Distribution Center (Fuses).............. 363
Door Locks.......................... 23
Mirrors............................. 70
INDEX 423
10