wheel CHRYSLER CONCORDE 2004 2.G Warranty Booklet
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2004, Model line: CONCORDE, Model: CHRYSLER CONCORDE 2004 2.GPages: 131, PDF Size: 1.11 MB
Page 8 of 131
8
7/115 POWERTRAIN WARRANTY
The following powertrain components are covered for 7 years or 115,000 kilometres, whichever occurs first, measured from thevehicleÕs original warranty start date. A $100 deductible per repairvisit applies after the 3-year or 60,000-kilometre basic warrantyexpires (whichever occurs first) Vehicles placed in Police, Taxi, Limousine, Postal or Ambulance service are excluded from the 7-year or 115,000-kilometrepowertrain warranty and are covered only under the 3-year or60,000-kilometre basic warranty. ¥ Engine Ð Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing;intake and exhaust manifolds; flywheel with starter ring gear; coreplugs; valve covers; oil pan; turbocharger housing and internalparts; turbocharger wastegate actuator; supercharger; serpentinebelt tensioner; seals and gaskets for listed components only. ¥
Transmission Ð Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;transmission control module; bell housing; oil pan; seals andgaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time .
¥ Front-Wheel Drive Ð Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differentialcover; oil pan; transaxle speed sensors; transaxle solenoidassembly; PRNDL position switch; transaxle electronic controller;torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
¥ All-Wheel Drive (AWD) Ð Power transfer unit and all internal
parts; viscous coupler; axle housing and all internal parts;constant velocity joints and boots; drive shaft and axle shaftassemblies; differential carrier assembly and all internal parts;output ball bearing; output flange; end cover; overrunning clutch;vacuum motor; torque tube; pinion spacer and shim, seals andgaskets for listed components only.
7/115 POWERTRAIN WARRANTY
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 8
Page 12 of 131
12
WHAT IS NOT COVERED
WHAT IS NOT COVERED
DAMAGE FROMMISUSE ORACCIDENT
The warranties in this booklet do not cover repairs required due to fire, accidents, abuse, negligence, objects striking your vehicle,carrying corrosive materials (such as chemicals, acids andfertilizers), misuse (such as driving over curbs, overloading,spinning wheels, etc.), racing or participating in a racing event,improper disconnection of components, modifying the exhaustsystem, tampering or making adjustments which do not complywith DaimlerChrysler specifications.
Disconnecting, tampering with or changing the reading of the
odometer will void your warranties. D AMAGE FROMTHEENVIRONMENT
The warranties in this booklet do not cover fading or deterioration caused by exposure to the elements, or repairs required due toairborne fallout, acid rain, chemicals, tree sap, insects, bird or insectdroppings, salt, sand, gravel, road hazards, hail, windstorms,lightning, floods or any other event of nature. Road salt, car washes, scuffs and scratches, and everyday
abrasion from sand and dirt can affect the appearance of a vehicleÕs wheels (steel, chrome and aluminum) and other undercarriageparts. Some surface corrosion with use is normal; it is not a defectand is not covered by any warranty. N ORMAL MAINTENANCE ANDWEAR
The warranties in this booklet do not cover normal maintenance services, such as oil and filter changes, generallubrication, tire rotation, alignments, engine tune-ups and replacing spark plugs, light bulbs and fuses. Requiredmaintenance services are described in detail in your OwnerÕsManual and herein. The warranties also do not cover worn wiperblades, clutch discs, brake rotors, pads, linings or drums,windshield and rear window (unless they are defective, see
page 7).
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 12
Page 25 of 131
25
1.
POWER TRAIN PLANS
Plan 737 complements the powertrain factory warranty by eliminating the deductible and providing a car rental allowance.Plan 738 provides additional distance coverage. Major components covered are: ¥ engine ¥ transmission ¥ front-wheel drive ¥ rear-wheel drive¥ four-wheel drive (4x4) ¥ all-wheel-drive vehicles Maximum terms available on new vehicles registered in Canada only.
P LAN CODE TERM DEDUCTIBLE
Plan 737 7 years or 115,000 km* $0
Plan 7387 years or 160,000 km* $0
*Whichever comes first. Measured from the warranty start date (the original in-service date of the vehicle) and from zero metrage.
NOTE: Purchase price of contract plans varies. See dealer for further details. 2.
ÒG OLD Ó PLAN S
Each plan provides full mechanical repair protection to non-powertrain (Gold) components. Plans 705, 706 and 708 also provide fullmechanical protection against powertrain component repairs beyondyour vehicleÕs 7-year or 115,000-kilometre powertrain warrantycoverage. Contracts are available with or without a deductible. Major components covered are: ¥ steering ¥ air conditioning ¥ engine cooling and fuel ¥ frontsuspension ¥ rear suspension ¥ electrical ¥ hydraulic brakecomponents ¥ anti-lock brakes Maximum terms available on new vehicles registered in Canada only.
P LAN CODE TERM DEDUCTIBLE
Plan 701 4 years or 80,000 km* $0
Plan 7023 years or 80,000 km* $0
Plan 7034 years or 100,000 km* $0
Plan 7045 years or 100,000 km* $0
Plan 7055 years or 120,000 km* $0
OPTIONAL DAIMLERCHRYSLER CANADA SERVICE CONTRACTS
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 25
Page 40 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
24,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-05-01 3N.
Maint enance Service Sc hedule ÒBÓ
24,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Replace the engine air cleaner filter (Pacifica, Concorde, Intrepid and 300M only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained
high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 39
Page 41 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary(Sebring, Sebring Convertible only).
l Replace the engine air cleaner filter (Pacifica, Concorde,Intrepid and 300M only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hotweather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.Maint enance Service Sc hedule ÒBÓ
24,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 40
Page 44 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
34,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-07-01 3N.
Maint enance Service Sc hedule ÒBÓ
34,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (all models).
l Change the all-wheel-drive overrunning clutch and rear carrier fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained
high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 43
Page 45 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (all models).
l Change the all-wheel-drive overrunning clutch and rear carrier fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hotweather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.Maint enance Service Sc hedule ÒBÓ
34,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 44
Page 50 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
48,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-10-01 3N.
Maint enance Service Sc hedule ÒBÓ
48,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel drive power transfer unit fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 49
Page 51 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drivepower transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hotweather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.Maint enance Service Sc hedule ÒBÓ
48,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 50
Page 58 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
67,000 km
Dealer copy.
Remove and attach to Repair Order 26-92-14-01 3N.
Maint enance Service Sc hedule ÒBÓ
67 ,000 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (all models).
l Change the all-wheel-drive overrunning clutch and rear carrier fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 57