automatic transmission fluid FORD TAURUS 2006 4.G Owners Manual
[x] Cancel search | Manufacturer: FORD, Model Year: 2006, Model line: TAURUS, Model: FORD TAURUS 2006 4.GPages: 232, PDF Size: 2.19 MB
Page 191 of 232
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
3.0L V6 Vulcan engine
1. Automatic transmission fluid dipstick
2. Brake fluid reservoir
3. Air filter assembly
4. Battery
5. Engine oil filler cap
6. Engine oil dipstick
7. Power steering fluid reservoir
8. Engine coolant reservoir
9. Windshield washer fluid reservoir
786543
912
2006 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
191
Page 215 of 232
3. Turn the engine off.
4. Check the fluid level on the
dipstick. It should be between the
arrows in the FULL HOT range. Do
not add fluid if the level is within
this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the FULL HOT range. Be sure to put the
dipstick back in the reservoir.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your dealer immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transaxle does not consume
fluid. However, the fluid level should be checked if the transaxle is not
working properly, i.e., if the transaxle slips or shifts slowly or if you
notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
F
U
L
L
H
O
T
MAX
2006 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
215
Page 216 of 232
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated areas for normal operating temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is at the bottom of the dipstick
and the outside temperatures are
above 50°F (10°C).
Correct fluid level
The transmission fluid should be checked at normal operating
temperatures 150°F-170°F (66°C-77°C) on a level surface. The normal
operating temperature can be reached after approximately 20 miles (30
km) of driving.
The transmission fluid should be in
this range if at normal operating
temperature (150°F-170°F
[66°C-77°C]).
High fluid level
Fluid levels above the safe range
may result in transaxle failure. An
overfill condition of transmission
fluid may cause shift and/or
engagement concerns and/or possible damage.
High fluid levels can be caused by an overheating condition.
Adjusting automatic transmission fluid levels
Before adding any fluid, make sure the correct type is used. The type of
fluid used is normally indicated on the dipstick and also in the
Lubricant specificationssection in this chapter.
DON’T ADD IF IN CROSSHATCH AREA--CHECH WHEN HOT-IDLING
DON’T ADD IF IN CROSSHATCH AREA--CHECH WHEN HOT-IDLING
DON’T ADD IF IN CROSSHATCH AREA--CHECH WHEN HOT-IDLING
2006 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
216
Page 217 of 232
Use of a non-approved automatic transmission fluid may cause
internal transaxle component damage.
If necessary, add fluid in 1/2 pint (250 mL) increments through the filler
tube until the level is correct.
If an overfill occurs, excess fluid
should be removed by a qualified
technician.
An overfill condition of
transmission fluid may cause shift and/or engagement concerns
and/or possible damage.
Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transmission components.
MOTORCRAFT PART NUMBERS
Component 3.0L V6 Vulcan
engine3.0L FFV V6
engine
Air filter element
1FA-1683 FA-1683
Fuel filter FG-1060 FG-1060
Battery BXT-36R BXT-36R
Oil filter FL-400-S FL-400-S
PCV valve
2
Spark plugs3
1
Do not use oil-impregnated air filter elements. Failure to use the correct
air filter element may result in severe engine damage. The customer
warranty may be voided for any damage to the engine if the correct air
filter element is not used.
2The PCV valve is a critical emission component. It is one of the items
listed inscheduled maintenance informationand is essential to the
life and performance of your vehicle and to its emissions system.
For PCV valve replacement, see your dealer or a qualified service
technician. Refer to thescheduled maintenance informationfor the
appropriate intervals for changing the PCV valve.
Replace the PCV valve with one that meets Ford material and
design specifications for your vehicle, such as a Motorcraft or
equivalent replacement part. The customer warranty may be void
for any damage to the emissions system if such a PCV valve is not
used.
DON’T ADD IF IN CROSSHATCH AREA--CHECH WHEN HOT-IDLING
2006 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
217
Page 220 of 232
ItemsFord Part
Name or
equivalentFord Part
NumberFord
Specification
Power steering
fluidMotorcraft
MERCONAT FXT-2-QDX MERCON
Windshield
washer fluidMotorcraft
Premium
Windshield
Washer
ConcentrateZC-32–A WSB-M8B16–A2
1Ensure the correct automatic transmission fluid is used. Transmission
fluid requirements are indicated on the dipstick or on the dipstick
handle. Check the container to verify the fluid being added is of the
correct type. Refer to yourscheduled maintenance informationto
determine the correct service interval.
Some transmission fluids may be labeled as dual usage, such as
MERCONand MERCONV. These dual usage fluids are not to be used
in an automatic transmission that requires use of the MERCONtype
fluid. However, these dual usage fluids may be used in transmissions that
require the MERCONV type fluid.
MERCONand MERCONV type fluids are not interchangeable.
DO NOT mix MERCONand MERCONV. Use of a transmission
fluid that indicates dual usage (MERCONand MERCONV) in
an automatic transmission application requiring MERCONmay
cause transmission damage. Use of any fluid other than the
recommended fluid may cause transmission damage.
ENGINE DATA
Engine 3.0L V6 Vulcan
engine3.0L FFV V6 engine
Cubic inches 182 182
Required fuel 87 octane 87 octane or Ethanol
(E 85)
Firing order 1-4-2-5-3-6 1-4-2-5-3-6
Ignition system EDIS EDIS
2006 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
220
Page 227 of 232
A
Accessory delay ..........................44
Air cleaner filter .......................217
Air conditioning ..........................25
Airbag supplemental restraint
system ............................95–96, 102
and child safety seats ..............97
description ........................96, 102
disposal ....................................104
driver airbag ................96, 98, 103
indicator light .........................101
operation .....................96, 98, 103
passenger airbag .........96, 98, 103
side airbag ...............................102
Antifreeze
(see Engine coolant) ................198
Anti-lock brake system
(see Brakes) ..............................145
Anti-theft system ........................75
arming the system ....................76
disarming a triggered
system .......................................76
Audio system (see Radio) ...15, 18
Automatic transaxle
fluid, adding ............................215
fluid, checking ........................215
fluid, refill capacities ..............218
fluid, specification ..................220
Automatic transmission
driving an automatic
overdrive .................................151
Auxiliary power point .................42
Axle
lubricant specifications ..........219
B
Battery .......................................196acid, treating emergencies .....196
jumping a disabled battery ....168
maintenance-free ....................196
replacement, specifications ...217
servicing ..................................196
BeltMinder ...................................90
Brakes ........................................144
anti-lock ...................................145
anti-lock brake system (ABS)
warning light ...........................146
fluid, checking and adding ....215
fluid, refill capacities ..............218
fluid, specifications .........219–220
lubricant specifications ..219–220
parking ....................................146
shift interlock ..........................148
Bulbs ............................................33
C
Capacities for refilling fluids ....218
Cargo net .....................................62
CD changer .................................20
CD-single premium ...............15, 18
Cell phone use ..............................7
Changing a tire .........................162
Child safety restraints ..............105
child safety belts ....................105
Child safety seats ......................107
attaching with tether straps ..112
in front seat ............................109
in rear seat ......................109, 111
Cleaning your vehicle
engine compartment ..............184
instrument panel ....................186
interior .....................................186
interior trim ............................186
plastic parts ............................185
2006 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
227
Page 228 of 232
washing ....................................183
waxing .....................................183
wheels ......................................184
wiper blades ............................185
Climate control (see Air
conditioning or Heating) ............25
Clock adjust
AM/FM/Cassette ........................15
AM/FM/CD .................................18
Compass
zone/calibration adjustment ....56
Compass Display .........................55
Console ........................................42
Controls
power seat .................................79
Coolant
checking and adding ..............198
refill capacities ................202, 218
specifications ..................219–220
Cruise control
(see Speed control) ....................45
Customer Assistance ................154
Ford Extended Service
Plan ..........................................180
Getting assistance outside the
U.S. and Canada .....................181
Getting roadside assistance ...154
Getting the service you
need .........................................174
Ordering additional owner’s
literature .................................182
The Dispute Settlement
Board .......................................177
Utilizing the
Mediation/Arbitration
Program ...................................179D
Daytime running lamps
(see Lamps) ................................29
Defrost
rear window ..............................27
Dipstick
automatic transmission
fluid ..........................................215
engine oil .................................193
Doors
lubricant specifications ..........219
Driving under special
conditions ..................................153
through water .........................153
E
Electronic message center .........53
Emergencies, roadside
jump-starting ..........................168
Emergency Flashers .................155
Emission control system ..........212
Engine ................................220–221
cleaning ...................................184
coolant .....................................198
idle speed control ...................196
lubrication
specifications ..................219–220
refill capacities ........................218
service points ..........................191
starting after a collision .........155
Engine block heater .................144
Engine oil ..................................193
checking and adding ..............193
dipstick ....................................193
filter, specifications ........195, 217
recommendations ...................195
refill capacities ........................218
2006 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
228
Page 231 of 232
Safety belts (see Safety
restraints) ........................80, 84–88
Safety defects, reporting ..........182
Safety restraints ..............80, 84–88
belt minder ...............................90
extension assembly ..................94
for adults .............................85–87
for children .....................104–105
lap belt ......................................89
Occupant Classification
Sensor ........................................82
safety belt maintenance ...........94
warning light and chime ....89–90
Safety seats for children ..........107
Safety Compliance
Certification Label ....................222
Seat belts
(see Safety restraints) ...............80
Seats ............................................77
child safety seats ....................107
front seats .................................78
Servicing your vehicle ..............189
Setting the clock
AM/FM/Cassette ........................15
AM/FM/CD .................................18
Spare tire
(see Changing the Tire) ...........162
Spark plugs,
specifications .............217, 220–221
Specification chart,
lubricants ...........................219–220
Speed control ..............................45
Starting a flex fuel vehicle .......143
Starting your
vehicle ........................140–141, 143
jump starting ..........................168Steering wheel
tilting .........................................41
T
Tilt steering wheel ......................41
Tires ...........................116–117, 162
alignment ................................128
care ..........................................126
changing ..........................162, 164
checking the pressure ............119
inspecting and inflating .........118
label .........................................126
replacing ..................................121
rotating ....................................128
safety practices .......................127
sidewall information ...............121
snow tires and chains ............130
spare tire .................................163
terminology .............................117
tire grades ...............................117
treadwear ........................116, 126
Towing .......................................136
recreational towing .................139
trailer towing ..........................136
wrecker ....................................173
Traction control ........................147
Transaxle
fluid, refill capacities ..............218
lubricant specifications ..........220
Transmission .............................148
brake-shift interlock (BSI) ....148
fluid, checking and adding
(automatic) .............................215
lubricant specifications ..........219
Trunk .....................................62, 64
remote release ....................62, 67
Turn signal ..................................32
V
Vehicle dimensions ...................221
2006 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
231