air con JAGUAR XJ 2004 X350 / 3.G Owner's Guide
[x] Cancel search | Manufacturer: JAGUAR, Model Year: 2004, Model line: XJ, Model: JAGUAR XJ 2004 X350 / 3.GPages: 227, PDF Size: 4.22 MB
Page 163 of 227
6 - 12 Roadside Emergency
Transporter tie-down procedure
!WARNING:
Avoid body contact with a hot
exhaust pipe when securing the
vehicle to the transporter.
IMPORTANT – Use straps over the
wheels/tyres only, to secure the vehicle to
the transporter.
Caution: Do not use the tie-down
brackets on the vehicle rear
underbody; these are for Jaguar
factory use only. In time, with the
engine switched off, the vehicle body
will drop due to settling of the air
suspension system and cause the tie-
down chains/straps to become slack if
connected to these brackets.
The towing eye is not designed for
securing the vehicle during
transportation. Vehicle failure
The removable towing eye is primarily for
emergency use when towing for SHORT
DISTANCES, e.g. removing the vehicle if it
is causing an obstruct
ion or for winching
the vehicle onto a re covery transporter.
To prevent damage to the automatic
transmission whilst the vehicle is being
towed with the rear wheels on the
ground, towing distance must be
restricted to 0.5 miles (0.8 kilometres).
Towing speed must not exceed 30 mph
(48 km/h).
Always obey towing regulations.
In certain countries the registration
number of the towing vehicle and an
‘ON TOW’ sign or warning triangle must
be displayed in a prominent position at
the rear of the vehicle being towed. When being towed, the gear selector
lever must be in neutral (position ‘N’)
with the ignition key turned to
position ‘II’ to release the steering lock
and render the indicators, horn and
brake lights operational.
!WARNING:
When the engine is not running the
steering and brakes will no longer be
power-assisted.
Therefore, be prepared for relatively
heavy steering and the need for
greatly increased brake pedal
pressure.
Page 172 of 227
Roadside Emergency 6 - 21
Fuses and Fuse Boxes
Do not fit a new fuse if the wiring is
damaged; contact a Jaguar Retailer.
After renewing a fuse have the circuit
checked by a Jaguar Retailer.
Two types of fuses are fitted in the fuse
boxes, ATO type and Midi type.
Spare fuses and a special tool for
removing and replacing fuses are located
on a removable panel clipped to the rear
of the trunk ( A).
Use only the spare fuses supplied. If a
spare fuse is used, renew it with a Jaguar
approved fuse of the same amperage
rating.
Checking and Renewing a
Blown Fuse
Make sure the new fuse is the correct
rating (amperage).
Fuses are colour coded according to the
amperage and the rating is also marked
on each fuse.
Caution: When a fuse box lid is
removed, take care to protect the box
from moisture, and refit the lid at the
earliest opportunity. ATO-fuse replacement
Push the tool on to the suspect ATO fuse
and withdraw the fuse. If the wire in the
fuse is broken, the fuse has blown.
Fit a new fuse using the tool.
Midi fuse replacement
(not shown)
Unscrew the two nuts and remove the
fuse. Note that the fuse is supplied
directly from the battery +ve; take care
not to short a spanner or other metal tool
to the chassis when removing the nuts.!WARNING:
1. Do not fit a fuse of a different amperage from that removed.
The electrical circuits may
become overloaded with the
subsequent possibility of a fire.
2. No attempt should be made to repair a fuse that has blown as this
may cause a fire hazard or serious
damage elsewhere in the
electrical circuit.
Page 175 of 227
6 - 24 Roadside Emergency
Engine compartment fuse boxFuse No Fuse
Type Rating
(amps) Colour
Circuit
F1 ATO 10A Red Front ignition, UHEGO, fu el pump, rear ignition relay coils
F2 – F3 Not used
F4 ATO 30A Green Powerwash pump
F5 Not used
F6 ATO 40A Orange Air suspension compressor
F7 ATO 40A Orange Right-hand front screen heater or wiper park zone heater
F8 ATO 20A Yellow Right-hand dipped beam
F9 ATO 20A Yellow Left-hand dipped beam
F10, F11 Not used
F12 ATO 10A Red Engine control module
F13 ATO 10A Red Fuel injectors
F14 ATO 10A Red Purge valve, EGR valve, canister close valve (CCV), port deactivation, V6 intake manifold
tuning valves (IMTV), MAFS, air filter solenoid, radiator fan controller
F15 Not used
F16 ATO 20A Yellow Right-hand main beam, left-hand main beam
F17 ATO 10A Red Engine control module, transmission control module
F18 ATO 15A Blue Front fog lights, instrument cluster front fog status
Page 177 of 227
6 - 26 Roadside Emergency
Cabin fuse boxFuse No Fuse
Type Rating
(amps) Colour
Circuit
F1 ATO 10A Red Climate control unit, fan, screen heaters and wiper relay coils, smog sensor
F2 ATO 5A Tan Radiator fan controller, cruise control switch, adaptive cruise control
F3 ATO 5A Tan Rear outer seat, electrochromic mirror, driver seat heater, electric parkbrake, left and right-hand HID lamps levelling, left and right-hand seat belt switches
F4 ATO 5A Tan Instrument cluster
F5 – F6 Not used
F7 ATO 5A Tan Cigar lighter, sunroof module, electric park brake switch illumination, accessory relays (trunk fuse box)
F8 ATO 5A Tan Instrument cluster
F9 ATO 10A Red Left-hand direction indicator and repeater
F10 ATO 5A Tan Glove compartm ent door motor and lamps
F11 ATO 5A Tan Radio muting (engine start), ignition feed
F12 ATO 10A Red Front electronic module (FEM), passenger mirror
F13 ATO 20A Yellow Rear electronic module (REM), door locks
F14 ATO 10A Red Courtesy light, footwell lamps, rain sensor, FEM
F15 ATO 5A Tan ECM, FEM, instrument cluster air bag fa ult lamp, instrument cluster ignition (run/start)
F16 ATO 5A Tan Diagnostic connector
Page 178 of 227
Roadside Emergency 6 - 27
F17 ATO 5A Tan ABS module
F18 Not used
F19 ATO 5A Tan Ignition relay, ECM, REM, fuel pump relay, start relay
F20 ATO 5A Tan Telephone transceiver, TV module, VICS (Japan), voice module, rear telematics
F21 – F23 Not used
F24 ATO 10A Red PATS transponder
F25 ATO 10A Red Right-hand direction indicator and repe ater, right-hand front lamp, header console map
lamp
F26 ATO 15A Blue Screenwash pump
F27 ATO 10A Red ACC module
F28 ATO 10A Red Climate control modules (front and rear), driver’s door module (DDM)
F29 ATO 10A Red Air bag module, occupancy se nsing module, passenger weight sensor
F30 ATO 10A Red Voice, front/rear sound, DVD, telematics, TV
F31 ATO 15A Blue Sunroof
F32 ATO 5A Tan Front/rear parking aid, trailer tow module, battery backed sounder, voice module, telephone receiver
F33 ATO 5A Tan Transmission control, J-gate, generator
F34 ATO 5A Tan Navigation system
Fuse No
Fuse
Type Rating
(amps) Colour
Circuit
Page 180 of 227
Roadside Emergency 6 - 29
Trunk fuse boxFuse No Fuse
Type Rating
(amps) Colour
Circuit
F1 – F4 Not used
F5 ATO 40A Orange Right-hand front seat
F6 ATO 10A Red Accessory connector
F7 ATO 40A Orange Front blower motor
F8 ATO 10A Red Heater circuit water pump
F9 ATO 25A Natural Rear seat motors
F10 Not used
F11 ATO 5A Tan Rear footwell lamps, grab handle lamps
F12 ATO 10A Red Air suspension
F13 ATO 20A Yellow REM, rear seat heaters
F14 Not used
F15 ATO 5A Tan Right-hand rear light cluster
F16 ATO 10A Red Trunk lights, driver seat switch pack, rear switch seat pack
F17 ATO 10A Red Left-hand rear fog and reversing lamps
F18 ATO 10A Red Number plate lamps, side marker lamps
F19 ATO 30A Green Heated rear window
Page 202 of 227
Maintenance 7 - 19
Wear
All tyres fitted as original equipment
include tread wear indicators (TWI) in
their tread pattern. When the tread has
worn to a remaining depth of 1.6 mm the
indicators appear at the surface as bars
which connect the tread pattern across
the full width of the tyre.
It is illegal, in certain countries,
to continue to use tyres after the tread
has worn to less than 1.6 mm over three
quarters of the width and the entire
circumference of the tyre.It should be noted that the properties of
many tyres alter progressively with wear.
In particular the ‘wet grip’ and
aquaplaning resistance are gradually but
substantially reduce
d. Extra care and
speed restriction should therefore be
exercised on wet roads as the effective
tread depth diminishes.
Incorrect wheel alignm ent will accelerate
tyre wear. Fins on the inner or outer
edges of the tread pattern are caused by
excessive toe-in or toe-out respectively.
As fins may also be caused by high
cornering speeds or road camber, it is
advantageous to have the cause detected
by having the wheel alignment checked.
Tyre repair
It is recommended that damaged tyres
are discarded and new tyres fitted.
They must not be repaired in view of the
high performance capability of the
vehicle. Damage
Excessive local distortion can cause the
casing of a tyre to
fracture and may lead
to premature failure. Tyres should be
examined especially for cracked walls,
exposed cords, etc. Flints and other sharp
objects must be removed from the tyre
tread; if left in they may work through the
cover. Clean off any oil or grease
contamination by using a suitable
cleaner.
Caution: Do not use paraffin
(kerosene), because this has a
detrimental effect on rubber.
Tyre use after vehicle storage
After a long period of a vehicle standing,
tyres may become locally distorted with a
flat area. This will cause an uneven ride
for a few miles until the tyres have
warmed up and the ‘flat’ rounds off.
However, to reduce the effects of
flat-spots, the tyres of a stored vehicle
may be inflated to pressures not
exceeding 60 lbf/in² (4.2 bar, 420 kPa,
4.3 kg/cm²).
Page 218 of 227
Specifications 8 - 9
Tow-bar Fixing Points
The mounting points (A) require drilling
for tow-bar mountings.
Tow-ball centre height from the ground at
Gross Vehicle Weight (GVW):
(B ) = 15.157 inches (38.5 cm).
Tow-ball centre distance from bumper
cover: (C ) =3 inches (7.6 cm).
Caution: Contact your Jaguar Retailer
for details of additional parts that are
advised to be fitted before towing.
This is particularly important with
this vehicle having air suspension.
If unapproved towing equipment is
used whilst towing, the air
suspension speed lowering function
will not be inhibited. This may result
in a change in trailer weight
distribution and attitude.
Page 220 of 227
Index
Adaptive cruise control . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 51
Air conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Alarms and audible signals . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
– audible signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
– error signal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 16
– full alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
Alloy wheels – care of . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24
Anti-freeze . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
Anti-lock braking system (ABS) . . . . . . . . . . . . . . . . . . . . 4 - 47
Audible warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 10
Automatic car wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 23
Automatic climate control . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Automatic transmission . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 43
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 13
– back-up sounder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 18
– charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 15
– electrolyte level – check/top up . . . . . . . . . . . . . . . . . . 7 - 15
– lead connection/disconnection . . . . . . . . . . . . . . . . . . 7 - 16
– reconnection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 18
Brake fluid level check . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 9
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 47
Brightwork – polishing . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24 Bulb renewal
– front direction indicator . . . . . . . . . . . . . . . . . . . . . . . 6 - 15
– front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– front parking (side) light . . . . . . . . . . . . . . . . . . . . . . . . 6 - 16
– headlight – dipped beam . . . . . . . . . . . . . . . . . . . . . . . 6 - 15
– headlight – main beam . . . . . . . . . . . . . . . . . . . . . . . . 6 - 16
– number plate light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– rear light assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 19
– side marker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 18
– side repeater indicator . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– top access cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 14
C
Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 12
Carpets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 22
Catalytic converters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 68
Checks and top up
– brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 9
– engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
– engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 6
– power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 8
– washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 10
Child restraint tether anchorages . . . . . . . . . . . . . . . . . . 3 - 29
Child safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 23
– door locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 14
Chromework – polishing . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24
Climate control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Clock adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 32
Coolant level – check/top up . . . . . . . . . . . . . . . . . . . . . . 7 - 11
Cruise (speed) control . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 49
Page 224 of 227
Index
Mirror
– door mirror heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 8
– door mirror power foldback . . . . . . . . . . . . . . . . . . . . . 3 - 8
– electrochromic door mirrors . . . . . . . . . . . . . . . . . . . . . 3 - 8
– interior rear view . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 9
– mirror dip when reversing . . . . . . . . . . . . . . . . . . . . . . . 3 - 8
Mobile/portable telephones . . . . . . . . . . . . . . . . . . . . . . . 1 - 9
O
Occupant protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 11
– air bags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 14
– beltminder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 11
– driving position . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 22
– front belt height adjustment . . . . . . . . . . . . . . . . . . . . 3 - 11
– occupancy sensing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 17
– rear impact protection . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 20
– seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 11
– side protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 19
Oil specification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 7
P
Paint chips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24
Paint – polishing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24
Panic alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 17
Park distance control . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 35
Parkbrake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 34
Parking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 60
Pedal adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 6
Power steering fluid level check . . . . . . . . . . . . . . . . . . . . 7 - 8
Powerwash system fluid level check . . . . . . . . . . . . . . . . 7 - 10
Protect the environment . . . . . . . . . . . . . . . . . . . . . . . . . . 1 - 9Rain sensitive wiper control . . . . . . . . . . . . . . . . . . . . . . 4 - 31
Rear park distance control . . . . . . . . . . . . . . . . . . . . . . . 4 - 35
Recommended engine oil . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 7
Regular checks and top up . . . . . . . . . . . . . . . . . . . . . . . . 7 - 3
– brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 9
– engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
– engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 6
– power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 8
– windscreen washer fluid . . . . . . . . . . . . . . . . . . . . . . . 7 - 10
Regular servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 - 8
Roof-rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 61
– capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 - 5
S
Seat belt
– fitting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 12
– inertia reel mechanism check . . . . . . . . . . . . . . . . . . . 3 - 13
Seats
– adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 3
– heaters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 5
Security and locks
– lock the vehicle and set the alarm . . . . . . . . . . . . . . . . . 2 - 8
– luggage compartment (trunk) . . . . . . . . . . . . . . . . . . . . 2 - 12
Security features
– battery back-up sounder . . . . . . . . . . . . . . . . . . . . . . . 2 - 18
– battery reconnection . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 18
– panic alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 17
Smog sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 9
Snow chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 21
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 3