engine oil YAMAHA FX HO CRUISER 2017 User Guide

Pre-operation checks
67
water separator, drain it. (See page 30 for in-
formation on draining the water separator.)
EJU40182Engine unit check
Check the exterior of the engine unit for dam-
age or other problem.
EJU36886Engine oil level check
Make sure that the engine oil level is between
the minimum and maximum level marks onthe dipstick. (See page 59 for information on
checking the engine oil level.)
EJU32456Bilge water check
Make sure that no bilge water has collected in
the engine compartment. If bilge water has
collected in the engine compartment, drain it.
(See page 61 for information on draining the
bilge water.)
EJU32485Battery checks
Make sure that the battery terminals and
breather hose are not damaged and that the
battery leads and breather hose are connect-
ed properly. WARNING! Fire or explosion
could result if the breather hose is dam-
1Water separator
1
1Dipstick
1Maximum level mark
2Minimum level mark
1
1
2
UF2T77E0.book Page 67 Monday, July 11, 2016 9:31 AM

Maintenance
94
EJU43101Periodic maintenance chart
The periodic maintenance chart gives general guidelines for periodic maintenance. Have a
Yamaha dealer perform the checks in the following chart. However, maintenance may need
to be performed more frequently depending on your operating conditions. If you have any
questions, consult a Yamaha dealer.
This “√” mark indicates items to be checked and serviced by a Yamaha dealer.
Item OperationInitial Thereafter every
Page
10 hours50 hours
or 12
months
*1100
hours or
12
months
*1200
hours or
24
months
*1
Fuel lineCheck fuel hoses and
clamps√—
Fuel filler cap/Wa-
ter separatorCheck O-rings for cracks
and deformation√—
Fuel tankCheck installation and
straps√—
Water inlet strainerCheck for clogs and dam-
age√—
Cooling water hos-
esCheck for damage and
leakage, and check
clamps√—
Engine oilReplace√√96
Oil filterReplace√96
Intermediate hous-
ingLubricate√—
Spark plugsCheck√√—
BatteryCheck state of charge,
terminals, bands, and
breather hose√—
Battery leadsCheck terminals√—
Steering masterCheck operation and for
looseness√√—
Steering cableCheck exterior and con-
nections, and lubricate√—
Electric trim rodCheck exterior and con-
nections, and lubricate√—
Shift rod and re-
verse gateCheck exterior and con-
nections, and lubricate√—
Air filter elementCheck for damage and
dirt√—
Air intake hosesCheck for damage, and
check clamps√
—
Throttle bodyLubricate throttle valves√—
UF2T77E0.book Page 94 Monday, July 11, 2016 9:31 AM

Maintenance
96
EJU36943Engine oil and oil filter
WARNING
EWJ00341
Engine oil is extremely hot immediately af-
ter the engine is turned off. Coming in con-
tact with or getting any engine oil on your
clothes could result in burns.
NOTICE
ECJ00992
Do not run the engine with too much or not
enough oil in the engine, otherwise the en-
gine could be damaged.
It is recommended to have a Yamaha dealer
change the engine oil and the engine oil filter.
However, if you choose to change the oil and
filter on your own, consult a Yamaha dealer.
UF2T77E0.book Page 96 Monday, July 11, 2016 9:31 AM

Specifications
97
EJU34543
Specifications
Watercraft capacity:
Maximum people on board:
3 person
Maximum load capacity:
240 kg (530 lb)
Dimensions and weight:
Length:
3560 mm (140.2 in)
Width:
1230 mm (48.4 in)
Height:
1230 mm (48.4 in)
Dry weight:
376 kg (829 lb) (FX HO)
377 kg (831 lb) (FX Cruiser HO)
Performance:
Maximum output (according to ISO 8665/SAE
J1228):
132.4 kW at 7600 r/min
Maximum fuel consumption:
48.5 L/h (12.8 US gal/h, 10.7 Imp.gal/h)
Cruising range at full throttle:
1.44 hour
Trolling speed:
1300 ±100 r/min
Engine:
Engine type:
Liquid cooled 4-stroke, DOHC
Number of cylinders:
4
Engine displacement:
1812 cm³
Bore × stroke:
86.0 × 78.0 mm (3.39 × 3.07 in)
Compression ratio:
11.0 : 1
Valve clearance-intake (cold):
0.14–0.23 mm (0.0055–0.0091 in)
Valve clearance-exhaust (cold):
0.28–0.37 mm (0.0110–0.0146 in)
Lubrication system:
Wet sump
Cooling system:
Water
Starting system:
ElectricIgnition system:
T.C.I.
Spark plug (NGK):
LFR6A
Spark plug gap:
0.8–0.9 mm (0.031–0.035 in)
Battery capacity:
12 V, 19 Ah
Charging system:
Flywheel magneto
Drive unit:
Propulsion system:
Jet pump
Jet pump type:
Axial flow, single stage
Impeller rotation:
Counterclockwise
Jet thrust nozzle angle:
24+24 °
Jet thrust nozzle trim angle:
-6, -3, 0, 3, 6 °
Fuel and oil:
Recommended fuel:
Regular unleaded gasoline
Minimum octane rating (PON):
86
Minimum octane rating (RON):
90
Recommended engine oil:
YAMALUBE 4W or 4-stroke motor oil
Recommended engine oil type SAE:
SAE 10W-30, 10W-40, 20W-40, 20W-50
Recommended engine oil grade API:
API SG, SH, SJ, SL
Fuel tank total capacity:
70 L (18.5 US gal, 15.4 Imp.gal)
Engine oil quantity with oil filter replacement:
3.6 L (3.81 US qt, 3.17 Imp.qt)
Engine oil quantity without oil filter replacement:
3.5 L (3.70 US qt, 3.08 Imp.qt)
Engine oil total quantity:
5.3 L (5.60 US qt, 4.66 Imp.qt)
UF2T77E0.book Page 97 Monday, July 11, 2016 9:31 AM

Trouble recovery
99
Engine runs irregu-
larly or stallsFuel Fuel tank empty Refill as soon as pos-
sible57
Stale or contaminat-
edHave serviced by
Yamaha dealer—
Fuel tank Water or dirt present Have serviced by
Yamaha dealer—
Spark plug Fouled or defective Have serviced by
Yamaha dealer—
Incorrect heat range Have serviced by
Yamaha dealer—
Gap incorrect Have serviced by
Yamaha dealer—
Electrical wir-
ingLoose connection Have serviced by
Yamaha dealer—
Fuel injec-
tion systemFaulty or clogged in-
jectorsHave serviced by
Yamaha dealer—
Warning light or in-
dicator blinks or
comes onFuel level
warningFuel tank empty Refill as soon as pos-
sible57
Oil pressure
warningOil pressure dropped Have serviced by
Yamaha dealer43
Engine over-
heat warningJet intake clogged Clean
101
Check en-
gine warningFaulty sensors Have serviced by
Yamaha dealer44 TROUBLE POSSIBLE CAUSE REMEDY PAGE
UF2T77E0.book Page 99 Monday, July 11, 2016 9:31 AM

Trouble recovery
100
Watercraft slow or
loses powerWatercraft
operation
modeLow RPM Mode acti-
vatedDeactivate Low RPM
Mode 35
Cavitation Jet intake clogged Clean 101
Impeller damaged or
wornHave serviced by
Yamaha dealer101
Engine over-
heat warningEngine speed reduc-
tion control activatedClean jet intake and
cool engine43
Oil pressure
warningEngine speed reduc-
tion control activatedAdd oil
43
Spark plug Fouled or defective Have serviced by
Yamaha dealer—
Incorrect heat range Have serviced by
Yamaha dealer—
Gap incorrect Have serviced by
Yamaha dealer—
Electrical wir-
ingLoose connection Have serviced by
Yamaha dealer—
Fuel Stale or contaminat-
edHave serviced by
Yamaha dealer—
Air filter Clogged Have serviced by
Yamaha dealer—
Oil buildup Have serviced by
Yamaha dealer—
Throttle lever Faulty Have serviced by
Yamaha dealer— TROUBLE POSSIBLE CAUSE REMEDY PAGE
UF2T77E0.book Page 100 Monday, July 11, 2016 9:31 AM

107
Index
A
Adjustable tilt steering system ................. 29
Adjustable tilt steering system checks .... 69
After removing the watercraft from the
water ..................................................... 86
Analog speedometer/tachometer ............ 39
B
Battery care.............................................. 88
Battery checks ......................................... 67
Battery, jumping ..................................... 102
Beaching and docking the watercraft ...... 85
Beverage holders ..................................... 54
Bilge water check..................................... 67
Bilge water, draining ................................ 61
Bilge water, draining on land ................... 61
Bilge water, draining on water ................. 61
Boarding alone ......................................... 81
Boarding and starting off from a dock ..... 84
Boarding the watercraft ........................... 81
Boarding with passenger(s) ..................... 82
Bow eye ................................................... 50
Bow storage compartment ...................... 51
Builder’s plate ............................................ 2
C
Capsized watercraft ................................. 84
Check engine warning ............................. 44
Cleaning ................................................... 91
Cleaning the watercraft ............................ 88
Cleat ......................................................... 50
Cooling water pilot outlet ......................... 30
Cooling water pilot outlet check .............. 72
Craft Identification Number (CIN)............... 1
Cruise assist............................................. 37
Cruising limitations................................... 11
D
Digital speedometer ................................. 40
E
Electric trim system.................................. 33
Emergency procedures .......................... 101
Engine break-in ........................................ 63
Engine compartment check ..................... 66
Engine cover, removing and installing ..... 92
Engine idling speed check ....................... 74
Engine oil ................................................. 59
Engine oil and oil filter .............................. 96Engine oil level check ............................... 67
Engine oil requirements ........................... 59
Engine overheat warning.......................... 43
Engine serial number ................................. 1
Engine shut-off cord (lanyard) check ....... 70
Engine shut-off switch ............................. 27
Engine stop switch ................................... 27
Engine unit check ..................................... 67
Enjoy your watercraft responsibly ............ 19
Equipment ................................................ 48
F
Fire extinguisher check ............................ 71
Fire extinguisher holder and cover........... 56
Fire extinguisher holder, cover, and
band checks ......................................... 71
Flushing the cooling water passages....... 87
Fuel .......................................................... 57
Fuel level check........................................ 66
Fuel level meter ........................................ 42
Fuel level warning..................................... 43
Fuel requirements .................................... 57
Fuel system checks ................................. 66
Fuses, replacing ..................................... 103
G
Getting to know your watercraft .............. 75
Glossary, watercraft ................................. 20
Glove compartment ................................. 52
H
Handgrip .................................................. 49
Hazard information................................... 15
Hood check .............................................. 72
Hour meter/voltmeter ............................... 41
Hull and deck check ................................ 71
I
Identification numbers ............................... 1
Information display................................... 40
J
Jet intake and impeller, cleaning............ 101
Jet intake checks ..................................... 71
Jet thrust nozzle and reverse gate
check .................................................... 71
Jumper cables, connecting .................... 102
L
Labels, important ....................................... 4
Labels, other .............................................. 8
UF2T77E0.book Page 107 Monday, July 11, 2016 9:31 AM

Index
108
Labels, warning .......................................... 5
Launching the watercraft ......................... 76
Learning to operate your watercraft ........ 75
Leaving the watercraft ............................. 77
Limitations on who may operate the
watercraft.............................................. 10
Long-term storage ................................... 91
Low RPM Mode ....................................... 35
Lubrication ............................................... 91
M
Main components, location of ................. 21
Maintenance ............................................ 92
Manufactured date label ............................ 2
Model information ...................................... 2
Multifunction display ................................ 44
Multifunction information center .............. 39
Multifunction information center check ... 72
N
No-wake mode ........................................ 36
O
Oil pressure warning ................................ 43
Operating in weeded areas ...................... 85
Operating the watercraft .......................... 77
Operating the watercraft in reverse or
neutral ................................................... 80
Operating your watercraft ........................ 75
Operation requirements ........................... 12
P
Periodic maintenance chart ..................... 94
Post-launch checks ................................. 72
Post-operation care ................................. 87
Pre-launch checks ................................... 66
Pre-operation check points ..................... 66
Pre-operation checklist ............................ 64
Primary Identification (PRI-ID) number ...... 1
Pull-up cleats (FX Cruiser HO) ................. 51
R
Raising the reverse gate ........................ 102
Reboarding grip ....................................... 49
Reboarding step ...................................... 49
Recommended equipment ...................... 14
Remote control transmitter ...................... 25
Remote control transmitter check ........... 70
RiDE lever................................................. 28
RiDE lever checks .................................... 69Riding position ......................................... 76
Rustproofing ............................................ 91
S
Safe boating rules .................................... 18
Safety equipment check .......................... 71
Seats ........................................................ 48
Shift indicator ........................................... 45
Shift system ............................................. 31
Shift system check ................................... 73
Start switch .............................................. 27
Starting off ............................................... 83
Starting off from a trailer .......................... 84
Starting the engine on water .................... 76
Steering system ....................................... 28
Steering system checks ........................... 68
Stern drain plug checks ........................... 71
Stern eyes ................................................ 50
Stern storage compartment ..................... 53
Stopping the engine ................................. 77
Stopping the watercraft ........................... 79
Storage compartment checks.................. 71
Storage compartments ............................ 51
Submerged watercraft ........................... 105
Switch checks .......................................... 70
T
Throttle lever ............................................ 28
Throttle lever checks ................................ 69
Tool kit ..................................................... 92
Towing the watercraft ............................ 105
Transporting on a trailer ........................... 62
Trim indicator ........................................... 45
Trim indicator check ................................ 73
Troubleshooting ....................................... 98
Troubleshooting chart .............................. 98
Turning the watercraft .............................. 78
W
Wakeboarding and water-skiing .............. 17
Water separator ....................................... 30
Water separator check ............................. 66
Watercraft characteristics ........................ 15
Watercraft control functions..................... 25
Watercraft information ............................. 46
Watercraft operation functions ................ 31
Watercraft operation modes .................... 35
Watertight storage compartments ........... 54
UF2T77E0.book Page 108 Monday, July 11, 2016 9:31 AM