steering Citroen BERLINGO FIRST RHD 2009 1.G User Guide

Page 85 of 115

PRACTICAL INFORMATION82 -
1. Power steering reservoir.

2. Windscreen/headlamp wash
reservoir.

3. Coolant reservoir.
4. Brake fl uid reservoir.

5. Battery.

6. Air fi lter.
7. Dipstick.

8. Engine oil reservoir.

9. Priming pump.
1.6 LITRE TURBO DIESEL HDI ENGINE

Page 86 of 115

PRACTICAL INFORMATION84 -
CHECKING THE LEVELS
Dipstick
Oil change
According to the information given in
the servicing booklet.

Note: avoid used oil coming into
prolonged contact with the skin.
Empty the used oil into the contain-
ers intended for this purpose in the
CITROËN network. Viscosity selection
In all cases, the oil selected must meet
the manufacturer’s requirements.

Note: the coolant does not need to
be changed.

For vehicles equipped with a parti-
cle fi lter, the engine fan may operate
after the ignition has been switched
off, even when the engine is cold.
There are two marks
on the dipstick:

A = maximum
Never fi ll past this
mark.

B = minimum
To maintain the reliability
of engines and emission
control systems, the use
of additives in engine oil
is prohibited. Brake fluid level:
The brake fl uid must be changed ac-
cording to the manufacturer’s servicing
schedule.
Use fl uids recommended by the
manufacturer, which fulfi l DOT4
standards.

Note: brake fl uid is harmful to health
and very corrosive. Avoid all contact
with the skin.
Cooling system
Use the fl uid recommended by the
manufacturer.
When the engine is warm, the tem-
perature of the coolant is controlled
by the engine fan. As this fan can op-
erate with the ignition key removed
and because the cooling system is
pressurised, wait for at least one hour
after the engine has stopped before
carrying out any work.
Slacken the cap by two turns to re-
lease the pressure to prevent any
risk of scalding. When the pressure
has dropped, remove the cap and
top up the level. Used oil
Do not dispose of used oil, brake fl uid or
coolant into drains or onto the ground.
Power steering reservoir

 Open the reservoir, with the en-
gine at ambient temperature. The
level should always be above the
MIN. mark and close to the MAX.
mark.
Windscreen and headlamp
wash level
For best quality cleaning and for
your safety, we would advise that
you use products recommended by
CITROËN .
For optimum cleaning and to prevent
freezing, this fl uid must not be topped
up or replaced with water.
Oil level

 Check the level regularly and top
up between changes. The maxi-
mum consumption is 0.5 l per
600 miles (1 000 km).
Check the level with the vehicle level,
engine cold, using the oil level gauge
on the instrument panel or the dipstick.

Page 87 of 115

85PRACTICAL INFORMATION-
CHECKS Oil filter
Change the fi lter regularly, in accordance
with the servicing schedule.
Only use products recom-
mended by CITROËN or
products of equivalent quality
and specifi cations.
To ensure best performance from
components as important as the
power steering and the braking sys-
tem, CITROËN selects and offers
quite specifi c products.
To prevent damage to the electrical
units, avoid washing the engine.
RUNNING OUT OF FUEL (DIESEL)
If you should run out of fuel, it is neces-
sary to re-prime the circuit:
- fi ll the fuel tank with at least fi ve litres of diesel,
- squeeze and release the manual re-priming pump, under the bonnet
under the protective cover, until fuel
appears in the transparent pipe,
- operate the starter until the engine starts.
FUEL SUPPLY CUT-OFF (PETROL)
In a serious collision, a mechanism pre-
vents fuel from reaching the engine.
To re-establish the fuel supply, press
the switch on the corner of the front
right-hand suspension assembly, un-
der the bonnet.
Air filter and passenger
compartment filter
Have the fi lter elements replaced regu-
larly.
If you drive in dusty conditions,
change them twice as often.
Brake pads
Brake pad wear depends on the style
of driving, in particular for vehicles
which are used in town, over short
distances.
It may be necessary to check the
thickness of the pads, even between
services.
Disc and drum wear status
For any information relating to checking
the disc and drum wear status, contact
a CITROËN dealer. Manual gearbox
This does not require an oil change.
Check the level in accordance with the
manufacturer’s servicing schedule.

To check the main levels and cer-
tain components, in accordance
with the manufacturer’s servicing
schedule, refer to the pages of
the servicing booklet which corre-
spond to your vehicle’s engine.
Handbrake
Where the handbrake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services.
Have the system checked by a
CITROËN dealer.
Battery
At the start of winter, have your battery
checked by a CITROËN dealer.

Page 104 of 115

PRACTICAL INFORMATION100 - ACCESSORIES
These accessories and parts, having
been tested and approved for reli-
ability and safety, are all adapted to
your vehicle. A wide range of recom-
mended accessories and original
parts is offered. The fi tting of electrical equip-
ment or accessories which
are not recommended by
Automobiles CITROËN may
result in the failure of your
vehicle’s electronic system. Please
note this specifi c warning. You are
advised to contact a representative of
the Marque to be shown the range of
recommended equipment and acces-
sories.
Depending on the country in which
the vehicle is sold or operated, it is
compulsory to have a high visibility
safety jacket, warning triangle and
replacement bulbs available in the
vehicle.
Screenwash, interior and exterior
cleaning and maintenance products,
replacement bulbs, ...
Anti-theft alarm, window engraving,
fi rst aid kit, high visibility safety jacket,
rear parking assistance, warning tri-
angle, ... Audio equipment, hands-free kit,
speakers, CD changer, navigation, ...
Regardless of the audio and telematic
equipment offered on the market, the
technical constraints linked with the
fi tting of equipment of these families
of products mean that the special fea-
tures of the equipment and its com-
patibility with the capacities of the your
vehicle’s standard equipment must be
taken into account. Please contact a
CITROËN dealer for information be-
fore fi tting such equipment. Front mud fl aps, rear mud fl aps,
15/17 inch alloy wheels, wheelarch
trim, leather steering wheel, ...
Range of professional equipment
Load retainers (all models).
Loading roller.
Towbar, towbar harness: trailer towbar
which must be fi tted by the CITROËN
network.
Separation partitions and grilles, smooth,
non-slip wooden protective fl oor.
Protective grilles.
Range of comfort, leisure and
maintenance equipment Front seat covers compatible with air
bags, bench, rubber mats, carpet mats,
snow chains, blind, tailgate bicycle car-
rier, roof bars (max load 120 kg), trans-
verse roof bars (max load 100 kg), ...
To prevent the mat from becoming
caught under the pedals:
- ensure that the mat and its fi xings
are positioned correctly,
- never fi t one mat on top of another. external aerial on your vehicle, you
are advised to contact a representa-
tive of the CITROËN marque.
The CITROËN Network will inform
you of the specifi cations (frequency
band, maximum output power, aerial
position, specifi c installation con-
ditions) of the transmitters which
can be fi tted, in accordance with
the Motor Vehicle Electromagnetic
Compatibility Directive (2004/104/CE).
Installation of
radiocommunication transmitters
Before installing accessory radio-
communication transmitters with an

Page:   < prev 1-10 11-20