gearbox Citroen C1 2014 1.G Owner's Guide

159
FuseN° Rating
(A) Functions
27 7. 5VSC system
28 60Passenger compartment fusebox
29** 125***Heated rear screen and door mirror heating -
Heated seats
- Electric fabric roof - ABS system -
VSC system - Cooling fan
- Front foglamps - LED daytime
running lamps
30 50
Electronic gearbox
40 Stop & Start
31 50Power steering
32 50*
Cooling fan
30
40
33 50ABS system - VSC system
34 10Spare fuse
* VTi 82 engine.
** VTi 68 engine.
***

T

his fuse must be replaced only by a
CITROËN dealer or a qualified workshop.
9
Practical information

161
12 V battery
The battery is located under the bonnet.
For access to the (+) terminal:
F
r
elease the bonnet using the interior lever,
then the exterior safety catch,
F

r
aise the bonnet and secure it with its stay,
F

l
ift the plastic cover for access to the
(+) terminal.
Access to the battery
Procedure for starting the engine using another battery or charging a discharged battery.
Before doing any work
Immobilise the vehicle: apply the
parking brake, put the gearbox in
neutral, then switch off the ignition.
Check that all electrical equipment is
switched off.
The presence of this label, in particular
with the Stop & Start system, indicates
the use of a 12 V lead-acid battery with
special technology and specification;
the involvement of a CITROËN dealer
or a qualified workshop is essential
when replacing or disconnecting the
battery.
After refitting the battery, the Stop &
Start system will only be active after a
continuous period of immobilisation of the
vehicle, a period which depends on the
climatic conditions and the state of charge
of the battery (up to about 8 hours).
do not push the vehicle to start the
engine if you have an ETG electronic
gearbox.
9
Practical information

165
Towing the vehicle
F Take the removable towing eye stowed in the tool box, under the boot carpet.
F

U
nclip the plastic cover, by pressing at the
bottom.
F

F
ully screw in the towing eye.
General
recommendations
Observe the legislation in force in your
c o unt r y.
Ensure that the weight of the towing vehicle
is higher than that of the towed vehicle.
The driver must remain at the wheel of the
towed vehicle and must have a valid driving
licence.
When towing a vehicle with all four wheels
on the ground, always use an approved
towing arm; rope and straps are prohibited.
The towing vehicle must move off gently.
When towing a vehicle with the engine off,
there is no longer any power assistance for
braking or steering.
In the following cases, you must always call
on a professional recovery service:
- vehicle broken down on a motor way or fast road,
-

f
our-wheel drive vehicle,
-

w
hen it is not possible to put the
gearbox into neutral, unlock the
steering, or release the parking
brake,
-

t
owing with only two wheels on the
ground,
-

w
here there is no approved towing
arm available...
Your vehicle can only be towed at the front.
F

I

nstall the towing bar.
F

P

ut the gear lever into neutral (position N
for the ETG electronic gearbox).
F

ailure to observe this instruction may
lead to damage to certain components
(braking, transmission, ...) and the absence
of braking assistance when the engine is
started.
F

U

nlock the steering and release the
parking brake.
F

S

witch on the hazard warning lamps on
both vehicles.
Never use the radiator crossmember.
9
Practical information

175
Checks
12 V battery
The battery does not require any maintenance.
However, check that the terminals are clean
and correctly tightened, particularly in summer
and winter.Refer to the maintenance and
warranty guide for details of the
replacement intervals for these
components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the maintenance and
warranty guide for details of the
replacement interval for this
component.
Oil filter
Unless other wise indicated, check these components in accordance with the maintenance and warranty guide and according to your engine.
Other wise, have them checked by a CITROËN dealer or a qualified workshop.
Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle
(e.g. city driving), replace them twice as often if
necessary .
A clogged passenger compartment filter may have
an adverse effect on the per formance of the air
conditioning system and generate undesirable odours.When carrying out work on the battery, refer
to the "12 V battery" section for details of the
precautions to be taken before disconnecting
the battery and following its reconnection.
Manual gearbox
The gearbox does not require any
maintenance (no oil change).
Refer to the maintenance and
warranty guide for the checking
interval for this component.
Clutch
The clutch is operated mechanically and
requires regular adjustment.
Refer to the maintenance and warranty guide
for information on when the adjustment should
be checked.
In the event of an operating fault
(difficulty moving off, for example),
contact a CITROËN dealer or a
qualified workshop.
10
Checks

176
ETG electronic gearbox
The ETG gearbox does not require
any maintenance (no oil change).
Refer to the maintenance and
warranty guide for information on
when this unit should be checked.
Brake wear depends on the style
of driving, particularly in the case
of vehicles used in town, over short
distances. It may be necessary to
Brake pads
For information on checking brake
disc wear, contact a CITROËN dealer
or a qualified workshop.
Brake disc wearOnly use products recommended by
CITROËN or products of equivalent
quality and specification.
In order to optimise the operation of
units as important as those in the
braking system, CITROËN selects and
offers very specific products.
After washing the vehicle, dampness,
or in wintry conditions, ice can form
on the brake discs and pads: braking
efficiency may be reduced. Make light
brake applications to dry and defrost
the brakes.
Parking brake
If excessive travel or a loss of
effectiveness of this system is
noticed, the parking brake must
be checked, even between two
services.
Checking this system must be done by a
CITROËN dealer or a qualified workshop.
have the condition of the brakes checked, even
between vehicle services.
Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake
pads are worn.
Checks

177
Petrol engineVTi 68
e-VTi 68VTi 82
Manual gearbox
(5 - speed) ETG electronic
gearbox
(5 - speed) Manual gearbox
(5 - speed) Manual gearbox
(5 - speed)
Model codes PM, PN PSCFBB - B1A000

PSCFBB-H1A000
PSCFBB-P1A000
PSCFBB-W1A000 PSCFBB-B1C000
PSCFBB-H1C000 PSCFBB-P1C000
PSCFBB-W1C000 PSCFB2-B1B000
PSCFB2-H1B000 PSCFB2-P1B000
PSCFB2-W1B000 PAHMTB - B1A000
PAHMTB-H1A000 PAHMTB-P1A000
PAHMTB-W1A000
Cubic capacity (cc) 9989989981 199
Bore x stroke (mm) 71 x 8471 x 8471 x 8477 x 85.8
EU standard maximum power (kW)* 50505060
Max power engine speed (rpm) 6 0006 0006 000 5 750
EU standard max torque (Nm) 95.595.595.5 11 6
Max torque engine speed (rpm) 4 8004 8004 800 2 750
Fuel Unleaded petrolUnleaded petrol Unleaded petrol
Catalytic converter Ye sYe sYe s
Engine oil capacity (with filter replacement) 3.23.23.23.25
* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).
Engines
11
Technical data

178
EngineVTi 68
e-VTi 68VTi 82
Manual gearbox
(5 - speed) ETG electronic
gearbox
(5 - speed) Manual gearbox

(5 - speed) Manual gearbox
(5 - speed)
Model codes PSCFBB - B1A000
PSCFBB-H1A000 PSCFBB-P1A000
PSCFBB-W1A000 PSCFBB-B1C000
PSCFBB-H1C000 PSCFBB-P1C000
PSCFBB-W1C000 PSCFB2-B1B000
PSCFB2-H1B000 PSCFB2-P1B000
PSCFB2-W1B000 PAHMTB - B1A000
PAHMTB-H1A000 PAHMTB-P1A000
PAHMTB-W1A000
Kerb weight 840860 860 865
Gross vehicle weight (GV W) 1 2401 2401 2401 240
Gross train weight (GTW) 1 2401 2401 2401 240
Weights (in kg)
The design of your vehicle does not permit the fitting of a towbar.
Technical data

239
Dashboard fuses 152-156
Instruments and controls
Opening the bonnet 1 70
Door mirrors
5
1
Electric windows
4
2
Courtesy lamp
1
01
Control for electric fabric roof
4
2
Rear view mirror
5
2
Sun visors
6
5
Manual parking brake
7
6Heating, ventilation
5

3-55
Manual air conditioning
5
6-57
Automatic air conditioning
5
8 - 61
Windscreen demist / defrost
6
2
Rear screen demist /
defrost
6
3
7-inch touch screen tablet
1
81-220
Setting the time
2
9
Audio system
2
21-236
Setting the time
2
8
Manual gearbox
7
6
ETG electronic gearbox

7
7- 80
Gear shift indicator

8
1
Stop & Start

8
3 - 85
Hill start assist

8
2
12 V accessory socket
6 5
USB port 6 6
Jack auxiliary socket

6
6
B4_en_Chap13_recherche-visuelle_ed01-2014
.
Visual search

243
Filling with fuel ......................................13 4, 13 5
Fitting a wheel ............................... ................14 4
Fittings, boot

................................................... 69
F

lashing indicators
................ 1
02, 148, 150, 151
Folding/unfolding the door mirrors

.................51
F

requency (radio)
.................................. 1
91, 225
Front seats
..............................

........................47
Fuel ..............................................8, 25, 134, 135
Fuel gauge

..............................................2
5, 134
Fuel tank..................................................25, 134
Fusebox, dashboard
..................................... 15

4
Fuses
................

............................................. 152
F
Gearbox - ETG ............................... ..... 8, 77, 176
Gearbox, manual .......................... 8 , 76, 83, 175
Gear shift indicator

......................................... 81
G

ear lever
..............................
........................... 8
Gear lever, ETG gearbox

................................77
G

ear lever, manual gearbox
...........................76
G

love box
..................................................6
4, 65
G
Engine compartment fusebox .......................15 7
Engine, petrol ................................ 1 35, 171, 177
Engines
..............................

...........................17 7
Environment
..................8

, 54, 63, 103, 163, 174
Halogen headlamps
...................................... 14

7
Hands-free kit

..............................
.........200, 231
Hazard warning lamps
.................................. 10

3
H
Headlamps ................................93, 98, 148, 149
Head restraints, rear ....................................... 50
H
eating
................
............................... 55, 56, 59
Hill start assist

................................................. 8

2
Hooks
...............................

...............................70
I
Identification plates ....................................... 18 0
Indicators, direction ...................................... 10
2
Inflating accessories (using the kit)

..............13

9
Inflating tyres

..............................
..............8, 180
Instrument panel

...............................
..............10
Instrument panel screen

.................................11
I

nterior fittings
...........................................6
4, 65
Interior lamp

...............................
...................101
iPhone connection
...............................

.........206
IS
oFI

X
...............
........................................... 131
ISOFIX mountings ................................. 127, 131
J
Jack ............................................................... 142
Jack cable .............................................1 94, 228
JACK socket

............................. 6
4, 66, 194, 228
K
Keeping children
safe ............... ........................112, 114, 118 -133
key .......

........................................................... 30
ke
y, electronic
..................................... 3
3 -35, 37
Key in ignition warning
....................................
71
K
eyless Entry and Starting
................ 3
3, 34, 72
L
Lamps, front ...........................................
14 7-149
Lamps, rear ............................... .............150 -151
Lamps, warning and indicator

..................13

-23
Level, brake fluid

........................................... 17

3
Levels and checks

..............................
...171-174
Lighting bulbs (replacement)

.................1

47-151
Lighting control stalk

.................................
93, 94
Lighting dimmer

..............................
................26
Lighting, guide-me home

................................97
L

ighting on reminder
....................................... 95
Lo

ading
..............................
............................... 8
Locating your vehicle

...................................... 31
L

ocking/unlocking a door from the inside....... 38
MMain beam ..............................................93, 148
Maintenance .............................. ....................... 8
Manual mode
.................................................. 77
M

at
.......
........................................................... 67
Menu
.............................1

86, 188, 198, 214, 216
Mini fuel level

..............................
............25, 134
Mirror, rear view

.............................................. 52
M

irrors, door.................................................... 51
Mountings for ISOFIX seats

................. 1
27, 131
.
alphabetical index