Transmission GMC SAVANA 1997 Owner's Guide

At Least Twice a Year At Least Once
a Year
Restraint System Check Key Lock Cylinders
Service
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly.
Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its
job, have it
repaired. Have
any torn or frayed safety belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag system
does not need regular maintenance.) Lubricate the key lock
cylinders with the lubricant
specified in Part
D.
Body Lubrication Service
Lubricate all hood hinges, hood prop rod pivot, fuel
filler door, rear compartment hinges, latches, locks and
any moving seat hardware.
Part D tells you what to use.
More frequent lubrication may be required when
exposed
to a corrosive environment.
Wiper Blade Check Starter Switch Check
Inspect wiper blades
for wear or cracking. Replace blade
inserts that appear worn or damaged or that streak or
miss areas of the windshield. Also see “Wiper Blades,
Cleaning” in the Index.
Automatic Transmission Check
Check the transmission fluid level; add if needed. See
“Automatic Transmission” in the Index.
A fluid loss
may indicate a problem. Check the system and repair
if needed.
I
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
I. Before you start, be sure you have enough room
around the vehicle.
7-46
ProCarManuals.com

2.
3.
Firmly apply both the parking brake (see “Parking Brake” in the Index if necessary) and the regular brake.
NOTE:
Do not use the accelerator pedal, and be
ready to turn off the engine immediately if it starts.
Try to start the engine in each gear. The starter
should work only in PARK
(P) or NEUTRAL (N). If
the starter works in any other position, your vehicle
needs service.
Brake-Transmission Shift Interlock (BTSI) Check
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough around the vehicle. It should
be parked on a level surface.
2. Firmly apply the parking brake (see “Parking Brake”
in the Index
if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins
to move.
3. With the engine off, turn the key to the RUN
position, but don’t start the engine. Without applying
the regular brake, try
to move the shift lever out
of PARK (P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle’s BTSI
needs service.
Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to
LOCK in each shift lever position.
0 The key should turn to LOCK only when the shift
lever is in PARK (P).
The key should come out only in LOCK.
7-47
ProCarManuals.com

Parking Brake and Automatic Transmission
PARK
(P) Mechanism Check
I II
/r CA JTdN:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in case
it begins to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability:
With
the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure
from
the regular brake pedal. Do this until the vehicle is
held by the parking brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to PARK (P). Then
release all brakes.
7-48
ProCarManuals.com

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
(Gasoline
Engine)
Engine Coolant
Hydraulic Brake
System
FLUIDLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil”
in the Index.
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench’ DEX-COOL@
or Havoline@ DEX-COOL@
coolant. See “Engine Coolant” in
the Index.
Delco Supreme 11
@ Brake Fluid
(GM Part No. 12377967 or
equivalent DOT-3 brake fluid).
USAGE
Parking Brake
Cable Guides
Power Steering System
Automatic
Transmission
Key Lock
Cylinders
Chassis
Lubrication
FLUIDlLUBRICANT
Chassis lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI
## 2, Category LB
or GC-LB.
GM Power Steering Fluid
(GM Part
No. 1052884 - 1 pint,
10500 17 - 1 quart, or equivalent).
DEXRON@-IU Automatic
Transmission Fluid.
Multi-Purpose lubricant, Superlube@ (GM
Part No. 12346241
or equivalent).
Chassis lubricant
(GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI ## 2, Category LB
or GC-LB.
c
7-5 1
ProCarManuals.com

1997 GMC SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing \
of your vehicle can be purchased by filling 01
the Service Publication Order Form in this book and mailing it in with your check, money order,
or credit card information to Helm, Incorporated (address below.) \
CURRENT PUBLICATIONS FOR 1997 GMC
SERVICE MANUALS
Service Manuals have the diagnosis and repair information
on engines, transmission, axle, suspension, brakes,
electrical, steering, body, etc. RETAIL SELL PRICE:
$90.00
TRANSMISSION, TRANSAXLE, TRANSFER CASE UNIT
REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1997 GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE:
$40.00
SERVICE BULLETINS
Service Bulletins give technical service informarlon needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle.
OWNER’S INFORMATION
Owner publications are written directly for Owners and
intended
to provide basic operational information about th
vehicle. The owner’s manual will include the Maintenance
Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner’s Manual and
i
Warranty Booklet.
RETAIL SELL PRICE:
$1 5.00
Without Portfolio: Owner’s Manual only.
RETAIL SELL PRICE:
$1 0.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past model
GM vehicles. To request an order form, please
specify year and model name of the vehicle.
ProCarManuals.com

Section 9 Index
Adjustable Mast Antenna ........................ 3-28
AirBag
....................................... 1-25
Adding Equipment
............................ 1-32
How Does it Restrain
.......................... 1-30
How
it Works ................................ 1-28
Location
.................................... 1-28
Readiness Light
......................... 1.27. 2.5 1
Servicing ................................... 1-31
What Makes
it Inflate .......................... 1-29
What Will
You See After it Inflates ............... 1-30
When Should it Inflate
......................... 1-29
Aircleaner
.................................... 6-17
Air Conditioning
................................ 3 -7
Air Conditioning Refrigerants
..................... 6-67
Alignment and Balance. Tire
...................... 6-47
Aluminum Wheels. Cleaning
...................... 6-55
Antenna. Adjustable Mast
........................ 3-28
Antenna. Power
................................ 3-28
Antifreeze
..................................... 6-22
Anti-Lock
Brake System Warning Light
................ 2.53. 4.7
Brakes
...................................... 4-7
Appearance Care
............................... 6-49
Air Control.
Climate Control System
................. 3-3 Appearance
Care Materials
....................... 6-57
Arbitration Program .............................. 8-9
Audio Systems
.................................. 3-8
Automatic Transmission
Transmission Check
........................... 7-46
Transmission Fluid
............................ 6-18
Transmission Operation
........................ 2-20
Transmission Park Mechanism Check
............. 7-48
Axle. Locking Rear
............................. 2-23
Axle. Rear
.................................... 6-22
Ashtrays
...................................... 2-43
Shifting
..................................... 2-20
Battery
...................................... 6-32
Jump Starting
................................. 5-3
Replacement. Remote Keyless Entry
............... 2-8
Warnings
.................................... 5-3
Warnings
.................................... 5-3
Before Leaving on a Long Trip
.................... 4-21
Blizzard. Driving In
............................. 4-25
BBB Auto
Line
................................. 8-9
Better Business Bureau Mediation
................... 8-9
9-1
ProCarManuals.com

Climate Control. Standard ......................... 3-2
Climate Control System
........................... 3-2
Clock. Setting the
................................ 3-8
Comfort Controls ................................ 3-2
Compact Disc Care
............................. 3-27
Compact Disc Player
....................... 3.18. 3.22
Console Storage
................................ 2-44
Control of a Vehicle
.............................. 4-6
Convex Outside Mirror
.......................... 2-44
Coolant
....................................... 6-22
RecoveryTank
............................... 5-16
Cooling System
................................ 5-14
Courtesy Transportation
........................... 8-8
Cruise Control ................................. 2-36
Cupholders
.................................... 2-44
Customer Assistance for Text Telephone Users
......... 8-4
Customer Assistance Information ................... 8- 1
Customer Satisfaction Procedure
.................... 8-2
Damage. Finish
............................... 6-56
Damage. Sheet Metal
............................ 6-55
Daytime Running Lamps
......................... 2-40
Daytime Running Lamps Indicator Light
............ 2-54
Dead Battery
................................... 5-3
Defects. Reporting Safety
........................ 8-10
Defensive Driving
............................... 4-2
Defogging
................................. 3-2. 3-4
Defrosting
................................. 3.2. 3.4
Dome Lamps
.................................. 2-40 Door
Locks
....................................... 2-4
Sliding
...................................... 2-11
Storagepocket
............................... 2-45
Swing-Out Side
............................... 2-9
Drive Position, Automatic Transmission
............. 2-22
Driver Position
................................. 1-15
Driving
City
........................................ 4-19
. Defensive .................................... 4-2
Drunken
..................................... 4-3
Freeway
.................................... 4-20
InaBlizzard
................................. 4-25
In Foreign Countries
........................... 6-5
IntheRain
.................................. 4-16
Night
...................................... 4-14
OnCurves
................................... 4-9
On Grades While Towing a Trailer
............... 4-36
On Hill
and Mountain Roads .................... 4-22
On Snow and Ice
............................. 4-24
Throughwater
............................... 4-18
WetRoads
.................................. 4-16
Winter
...................................... 4-24
With a Trailer
................................ 4-34
DrunkenDriving
................................ 4-3
Dual Tire Operation
............................. 6-45
Storage
..................................... 2-45
9-3
ProCarManuals.com

Electrical Equipment. Adding .................... 6-59
Electrical System ............................... 6-5.9
Electronic Road Speed Governor (Gasoline Engines) ... 2-60
Engine ........................................ 6-9
Coolant ..................................... 6-22
Coolant Level Check
.......................... 7-45
Coolant Temperature Gage
..................... 2-59
Cooling System
.............................. 6-65
Exhaust ..................................... 2-28
FuseBlock
.................................. 6-63
Identification ........................... 6.58. 6.65
OilLevelCheck .............................. 7-45
Overheating
................................. 5- 12
Running While Parked ......................... 2-28
Starting Your
................................ 2- 17
Engine Oil
.................................... 6-12
Adding ..................................... 6-12
Additives ................................... 6-16
Checking ................................... 6-13
Pressure Gage ................................ 2-57
Used
....................................... 6-16
Whentochange .............................. 6-16
Exhaust. Engine ................................ 2-28
Fabric Cleaning
............................... 6-50
Fan Control. Climate Control System ................ 3-2
FillingYourTank ................................ 6-5
Filter. Air ..................................... 6-17
Finish Care .................................... 6-54
Finish Damage ................................. 6-56
First Gear. Automatic Transmission ................ 2-22
Flashers. Hazard Warning
......................... 5-2
Flat Tire. Changing ............................. 5-23
Fluids and Lubricants
............................ 7-51
Foreign Countries. Fuel
........................... 6-5
French Language Manual 11
Front Parkingnurn Signal Lamp Bulb Replacement .... 6-35
Front Storage Area .............................. 2-44
FrontTowing
.................................. 5-10
Fuel .......................................... 6-3
Canada ...................................... 6-5
Filling Your Tank .............................. 6-5
Gage ....................................... 2-58
In Foreign Countries
........................... 6-5
Tankcapacity ............................... 6-66
Fuses and Circuit Breakers ....................... 6-60
.. ...........................
Gages Engine Coolant Temperature
.................... 2-59
Engine Oil Pressure ........................... 2-57
Fuel
....................................... 2-58
Speedometer ................................. 2-49
Voltmeter
................................... 2-60
Gear Positions. Automatic Transmission ............. 2-20
Gross Axle Weight Rating
........................ 4-28
Gross Vehicle Weight Rating
...................... 4-27
Guide en Franqais
11
GAWR ....................................... 4-28
.. .................................
GVWR ....................................... 4-27
9-4
ProCarManuals.com

Halogen Bulbs ................................ 6-32 .
Hazard Warning Flashers .......................... 5-2
Head Restraints
................................. 1-5
Headlamps .................................... 2-39
Bulb Replacement
............................ 6-33
High/Low Beam Changer
...................... 2-34
OnReminder
................................ 2-40
Wiring
..................................... 6-59
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-7
High-Beam Headlamps
.......................... 2-34
Highway Hypnosis
.............................. 4-22
Hill and Mountain Roads
......................... 4-22
Hitches. Trailer
................................. 4-33
Hood
Checking Things Under
......................... 6-7
Prop
........................................ 6-8
Release
...................................... 6-7
Horn ......................................... 2-32
Hydroplaning
.................................. 4-18
Ignition Switch
................................ 2- 16
Ignition Transmission Lock Check
................. 7-47
Inflation. Tire
.................................. 6-42
Inside Daymight Rearview Mirror
................. 2-43
Inspections
.................................... 7-49
Brakesystem
................................ 7-50
Exhaust Systems
............................. 7-49
Radiator and Heater Hose
...................... 7-49
RearAxle
................................... 7-50 Steering
.................................... 7-49
Suspension
.................................. 7-49
Throttle Linkage
.............................. 7-49
Brightness Control
............................ 2-38
Cleaning
.................................... 6-52
Cluster ..................................... 2-48
FuseBlock
.................................. 6-60
Interior Lamps ................................. 2-40
.................................... J ack. Tire 5-25
Jump Starting
................................... 5-3
Keyless Entry System
........................... 2-6
Keys
.......................................... 2-2
Labels 4-27
Certification
................................. 4-27
CertificationEire
............................. 4-27
Service Parts Identification
..................... 6-58
Tire-Loading Information
...................... 4-27
Vehicle Identification Number
................... 6-58
Lamps
........................................ 2-38
Dome
...................................... 2-40
Interior
..................................... 2-40
OnReminder
................................ 2-40
Panel
....................................... 2-40
Underhood
.................................. 2-42
Leaving
Your Vehicle with the Engine Running ....... 2-26
Lighter ....................................... 2-45
9-5
ProCarManuals.com

Lights Air Bag Readiness
....................... 1.27. 2.5 1
Anti-Lock Brake System Warning ............ 2.53. 4.7
Brake System Warning
......................... 2-52
Daytime Running Lamps Indicator ............... 2-54
Interior
..................................... 2-40
Safety Belt Reminder
..................... 1 . 11. 2.50
Service Engine Soon
.......................... 2-54
Loading Your Vehicle
........................... 4-27
Door
........................................ 2-4
Ignition Transmission Lock Check
............... 7-47
PowerDoor
.................................. 2-5
Rear Door Security
............................. 2-5
Sliding Door Child Security
...................... 2-5
Loss of Control
................................ 4- 13
Lubricants and Fluids
............................ 7-51
Lubrication Service. Body
........................ 7-46
Locks
......................................... 2-4
Maintenance. Normal Replacement
parts ........... 6-67
Maintenance Record
............................ 7-53
Maintenance Schedule
............................ 7- 1
Long Tripmighway Definition ................... 7-6
Long TripiHighway Intervals
..................... 7-7
Owner Checks and Services
..................... 7-45
Periodic Maintenance Inspections
................ 7-49
Recommended Fluids and Lubricants
............. 7-5 1
Scheduled Maintenance Services .................. 7-4 Short
Trip/City Definition
....................... 7-5
Short Trip/City Intervals ........................ 7-5
Maintenance. Underbody ......................... 6-56
Maintenance When Trailer Towing
................. 4-37
Malfunction Indicator Lamp ...................... 2-54
Manual Front Seat
............................... 1-2
Mirrors
....................................... 2-43
Convex Outside
.............................. 2-44
Inside Daymight Rearview
..................... 2-43
Power Remote Control
......................... 2-43
Visor Vanity
................................. 2-46
MMT
......................................... 6-4
Model Reference
................................. vi
MountainRoads
................................ 4-22
Multifunction Lever
............................. 2-33
Neutral. Automatic Transmission ................. 2-21
New Vehicle Break-In ........................... 2-16
Nightvision
................................... 4-15
Noise Control System
........................... 6-11
Odometer
.................................... 2-49
Odometer. Trip
................................. 2-49
Off-Road Recovery
............................. 4-11
Oil. Engine
.................................... 6-12
Overheating Engine
............................. 5-12
Owner Checks and Services
....................... 7-45
Owner Publications. Ordering
..................... 8-11
9-6
ProCarManuals.com