ignition HONDA CR-V 2005 RD4-RD7 / 2.G Workshop Manual

Check the smaller f uses in the
under-hood f use boxes and all the
fuses in the interior fuse box by
pulling out each one with the f use
puller provided in the primary
under-hood f use box.
Check each of the large f uses in
the primary under-hood f use box
by looking through the top at the
wire inside. Removing these f uses
requires a Phillips-head
screwdriver.
If something electrical in your
vehicle stops working, check f or a
blown f use f irst. Determine f rom the
chart on pages and , or the
diagram on the f use box lid, which
f use or f uses control that device.
Check those f uses f irst, but check all
the f uses bef ore deciding that a
blown f use is the cause. Replace any
blown f uses, and check if the device
works.
Turn the ignition switch to the
LOCK (0) position. Make sure the
headlights and all other
accessories are of f .
Look f or a blown wire inside the
fuse.If itisblown,replaceitwith
one of the spare f uses of the same
rating or lower.
Remove the cover f rom the f use
box. 3.
4.
5.
1.
2. 240 241
Fuses
Checking and Replacing Fuses
238
FUSE
BLOWN BLOWN

µ
µ
µ
Î
Î
Î
´
No. Amps. Circuits Protected
No. Circuits Protected Amps.
1
2
3
4
5
15 A
10 A
10 A
10 A
Ignition Coil
Daytime running lights
ACG
Not Used
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
Power Window Relay
Moonroof
Accessory, Radio
Rear Wiper
Meter
Not Used
Daytime running lights
SRS
Remote Control Mirrors
BFRACC
Heated Seat
Fuel Pump
Turn Signal Lights
Front Wiper
Not Used
Front Right Power Window
Front Left Power Window
Rear Lef t Power Window
Rear Right Power Window
7.5 A
20 A
7.5 A
7.5 A
7.5 A
7.5 A
10 A
10 A
15 A
20 A
15 A
15 A
7.5 A
20 A
20 A
20 A
20 A
20 A
: Canadian models
Rear Accessory Power Socket
Front Accessory Power Socket
Fuse Locations
240
INTERIOR FUSE BOX

µµ
Î
Î
No. No. Circuits Protected Amps. Circuits Protected Amps.
No. Amps. Circuits Protected
: On Canadian models
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Option
Lef t Headlight
Door Lock
Right Headlight
ABS F/S
Battery
Ignition 1
Spare Fuses
20 A
30 A
15 A
20 A
15 A
15 A
15 A
15 A
10 A
30 A
20 A
40 A
40 A
Condenser Fan
Engine
Interior Light
Cooling Fan
Hazard
Small Light
Horn, Stop
DBW
Back Up
ABS Motor
Rear Defroster
Heater Motor
Power Window
40 A
20 A
20 A
20 A
30 A
100 A
50 A
1
2
3
4
20 A
7.5 A
15 A
15 A
LAF Heater
Daytime running lights
FI ECU (ECM/PCM)
IG Coil
21 257.5A 30A
Fuse Locations
T aking Care of t he Unexpect ed
241
Primary Fuse Box
Secondary Fuse Box
PRIMARY
SECONDARY
UNDER-HOOD FUSE BOXES

Thediagramsinthissectiongive
you the dimensions and capacities of
your vehicle, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.................
Identif ication Numbers . 244
................................
Specif ications .246
DOT Tire Quality Grading ......................
(U.S. Vehicles) .248
Unif orm Tire Quality ..................................
Grading .248
.................................
Treadwear .248
......................................
Traction .248
.............................
Temperature .249
.................................
Tire Labeling .250 .......................
Emissions Controls .251
.....................
The Clean Air Act .251
Crankcase Emissions Control ....................................
System .251
Evaporative Emissions Control ....................................
System .251
Onboard Ref ueling Vapor ................................
Recovery .251
...
Exhaust Emissions Controls . 252
....................
PGM-FI System .252
Ignition Timing Control ................................
System .252
Three Way Catalytic ...........................
Converter .252
....................
Replacement Parts . 252
..
Three Way Catalytic Converter . 253
..............
State Emissions Testing . 254
T echnical Inf ormat ion
T echnical Inf ormation
243

The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
quality parts may increase the
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more inf orma-
tion.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles use
various sensors to determine how
much air is going into the engine. It
then controls how much f uel to inject
under all operating conditions.
The exhaust emissions controls
include three systems: PGM-FI,
ignition timing control, and three
way catalytic converter. These three
systems work together to control the
engine’s combustion and minimize
the amount of HC, CO, and NOx that
come out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
2
2
Exhaust Emissions Controls Replacement PartsPGM-FI Syst em
Three Way Catalytic Converter
Ignit ion T iming Cont rol Syst em
Emissions Cont rols
252

CONT INUED
BatteryCharging System ...........................
Indicator .56, 233
............................
Jump Starting .229
..............................
Maintenance .217
............................
Specif ications .247
..............................
Bef ore Driving .141
....................................
Belts,Seat .8,18
...........................
Beverage Holders .91
..................................
Booster Seats .47
Brakes ...........
Anti-lock System (ABS) . 168
.............
Break-in, New Linings . 142
....................
Bulb Replacement .205
...........................................
Fluid .201
.........................................
Parking .68
.................
System Indicator . 56,235 ..........................
System Design .167
........................
Wear Indicators .167
.............................
Braking System .167
.................
Break-in, New Vehicle . 142
..
Brightness Control, Instruments . 67
..................
Brights, Headlights . 66,67
...................................
Built-in Table .91
Bulb Replacement ..........................
Back-up Lights .205
..............................
Brake Lights .205
................
Front Parking Lights . 205
........
Front Side Marker Lights . 205
.................................
Headlights .203
.........
High-mount Brake Light . 207
.........
Rear Side Marker Lights . 205
............................
Specif ications .247
....................
Turn Signal Lights . 205
..............................
Bulbs, Halogen .203
............................
Capacities Chart .246
.............
Carbon Monoxide Hazard . 50
..............................................
Cargo .150
....................................
Accessories .148
ACCESSORY (Ignition Key .......................................
Position) .72
..............
Accessory Power Sockets . 95
....................
Additives, Engine Oil . 193
.......
Adjusting the Steering Wheel . 69
...........................
Advanced Airbags .25
...............................
Airbag (SRS) .9, 21
................
Air Conditioning System . 98
.........................................
Usage .100
.......................
Air Pressure, Tires .213
.......................
Alcohol in Gasoline .142
......................................
Antif reeze .196
Anti-lock Brakes (ABS) ...............................
Indicator .57, 168
...................................
Operation .168
..............
Anti-thef t, Audio System . 136
.
Anti-thef t Steering Column Lock . 72
................................
Audio System .103
...
Automatic Seat Belt Tensioners . 19
.............
Automatic Speed Control . 138
..............
Automatic Transmission . 161
..........................
Capacity, Fluid .246
...............
Checking Fluid Level . 199....................................
D3 Mode .163
.......................................
Shif ting .161
Shif t Lever Position ...............................
Indicators .161
................
Shif t Lever Positions . 162
....................
Shif t Lock Release . 165
Index
A
B
C
INDEX
I

...............
Gas Mileage, Improving . 147
..........................................
Gasohol .142
.........................................
Gasoline .142
.....................
Low Fuel Indicator .59
...........................................
Gauge .62
................
Octane Requirement . 142
........................
Tank, Ref ueling .143
................
Gas Station Procedures . 143
Gauges ...
Engine Coolant Temperature . 62
...............................................
Fuel .62
Gearshif t Lever Positions ..........
Automatic Transmission . 161
..............
Manual Transmission . 159
........................................
Glove Box .93
Gross Vehicle Weight Rating .............................
(GVWR) .173, 246 ...
Identif ication Number, Vehicle . 244
Ignition ..............................................
Keys .70
...........................................
Switch .72
............
Timing Control System . 252
........................
Immobilizer System .71
.........
Important Safety Precautions . 6
Fluids
..........
Automatic Transmission . 199
..........................................
Brake .201
.........................................
Clutch .202
..............
Manual Transmission . 200
..........................
Power Steering .202
..................
Windshield Washer . 198
.....................
Folding Rear Seat .82, 83
..........................
Four-way Flashers .67
..............................
Front Airbags .9 ,23
Front Seat ......................................
Adjusting .78
.........................................
Heaters .86
.....................................
Airbags .9, 23
.................................................
Fuel .142
..........
Check Fuel Cap Indicator . 63
......................
Fill Door and Cap .143
.....................
Low Fuel Indicator .59
...........................................
Gauge .62
................
Octane Requirement . 142
...............................
Oxygenated .142
........................
Tank, Ref ueling .143
...............................
Fuel Economy .147
.....................
Fuses, Checking the .237 .............
Halogen Headlight Bulbs . 203
.....................................
Hatch Glass .74
..............
Hazard Warning Flashers . 67Headlights
........................................
Aiming .203
............
Daytime Running Lights . 67
..................
High Beam Indicator . 59
...........................
Reminder Tone .66
........
Replacing Halogen Bulbs . 203
...................................
Turning on .66
..............................
Head Restraints .80
...............................
Heated Mirrors .89
.....................................
Heater, Seat .86
.......................
Heating and Cooling .98
............................
High Beam Lever .67
.......................
Hood, Opening the .144
..............................................
Horn .4,64
...........................
Hydraulic Clutch .202
Index
G
H I
IV

CONT INUED
Indicators......
ABS (Anti-Lock Brake) . 57,168
Brake (Parking and Brake ............................
System) .56, 235
................
Charging System . 56,233
...........................
Check Fuel Cap .63
.............................
Cruise Control .58
DRL (Daytime Running ......................................
Lights) .59
...................................
High Beam .59
........
Key (Immobilizer System) . 57
......................................
Low Fuel .59
................
Low Oil Pressure . 56,233
.................
Passenger Airbag Of f . 30
...........................
Side Airbag Of f .57
...............................................
SRS .57
Turn Signal and Hazard ...................................
Warning .59
VSA (Vehicle Stability ..............................
Assist) .58, 170
..............................
Washer Level .60
.........
Indicators, Instrument Panel . 55
...............................
Inf ant Restraint .37
......................................
Inf ant Seats .37
............
Tether Anchorage Point . 45...................
Inf lation, Proper Tire . 212
........
Recommended Pressures . 213
...................................
Inside Mirror .88
.............................
Inspection, Tire .213
....................
Installing a Child Seat .40
............................
Instrument Panel .55
........
Instrument Panel Brightness . 67
..............
Instruments and Controls . 53
.................................
Interior Lights .95
........................................
Introduction .i
.................
Jacking up the Vehicle . 222
.......................................
Jack, Tire .220
................................
Jump Starting .229
..................................................
Keys .70
.......................
Label, Certif ication .244
.................
Lane Change, Signaling . 66
..................
Lap/Shoulder Belts . 14,18 ...........
LATCH Anchorage System . 41
Lights ....................
Bulb Replacement .203
.......................................
Indicator .55
.........................................
Parking .66
..................................
Turn Signal .66
....................................
Load Limits .151
......
LOCK (Ignition Key Position) . 72
Locks .......
Anti-thef t Steering Column . 72
..........................
Childproof Door .73
............................
Fuel Fill Door .143
....................................
Glove Box .93
.................................
Power Door .73
........................................
Tailgate .74
........................
Low Coolant Level .146
.........................
Low Fuel Indicator .59
...
Low Oil Pressure Indicator . 56,233
................................
Lower Anchors .41
...
Lubricant Specif ications Chart . 246
...........
Luggage, Storing (Cargo) . 150
...........
Luggage Net (Cargo Net) . 153
Index
L K JINDEX
V

..................................
Maintenance .183
Owner’s Maintenance ...................................
Checks .186
.................................
Record .189-191
......................
Required Indicator .60
..........................................
Saf ety .184
.............................
Schedule .187-188
.
Malf unction Indicator Lamp . 56,234
...................
Manual Transmission . 159
...............
Checking Fluid Level . 200
.......................................
Shif ting .159
........
Manual Transmission Fluid . 200
.........................
Meters, Gauges .55, 61
...................
Methanol in Gasoline . 142
..........................
Mirrors, Adjusting .88
...............
Modif ying Your Vehicle . 149
.........................................
Moonroof .88
......................
Closing Manually .236
.....................................
Operation .88
...................
Neutral Gear Position . 163
..................
New Vehicle Break-in . 142.....................
Normal Shif t Speeds .160
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 244
...
Octane Requirement, Gasoline . 142
.........................................
Odometer .62
...............................
Odometer, Trip .61
....................
Of f -Highway Driving . 179
Oil ........................
Change, How to .194
......................
Change, When to .187
......................
Checking Engine .145
..............
Pressure Indicator . 56,233
Selecting Proper Viscosity ......................................
Chart .193
...........
ON (Ignition Key Position) . 72
Onboard Ref ueling Vapor ....................................
Recovery .251
..............................
Outside Mirrors .89
....
Outside Temperature Indicator . 62
....................
Overheating, Engine .231
....
Owner’s Maintenance Checks . 186
.........................
Oxygenated Fuels .142 ..............
Panel Brightness Control . 67
........................
Park Gear Position .162
...........................................
Parking .166
.................................
Parking Brake .68
Parking Brake and Brake .................
System Indicator . 56,235
.................................
Parking Lights .66
..
Parking Over Things that Burn . 166
....
Passenger Airbag Of f Indicator . 30
.............................
PGM-FI System .252
...................................
Pollen Filter .209
..........................
Power Door Locks .73
.................
Power Socket Locations . 90
....................
Power Steering Fluid . 202
..............................
Power Windows .86
.........
Pregnancy, Using Seat Belts . 16
........................
Preparing to Drive .157
.........
Protecting Adults and Teens . 11
...
Additional Safety Precautions . 17
.....
Advice f or Pregnant Women . 16
........................
Protecting Children .32
.......................
Protecting Inf ants .37
.......
Protecting Larger Children . 46
.........
Protecting Small Children . 38
Index
O P
N M
VI

Î
................................
Side Airbags .9 ,26
...
How Your Side Airbags Work . 26
How the Side Airbag Of f ......................
Indicator Works .29
..................
Side Curtain Airbags . 9,28
How Your Side Curtain Airbags .........................................
Work .28
Side Marker Lights, Bulb ..............................
Replacement .205
...............................
Signaling Turns .66
.....................................
Snow Tires .215
................................
Sound System .103
......................................
Spare Tire .220
....................................
Spark Plugs .246
........................
Specif ications .246, 247
................................
Speed Control .138
........................
Speed Limiter .160, 164
..........
SRS, Additional Inf ormation . 21
...
Additional Safety Precautions . 31
.............................
Airbag Service .30
......
Airbag System Components . 21
How the Side Airbag Of f ......................
Indicator Works .29
..
How the SRS Indicator Works . 29
How Your Front Airbags .........................................
Work .23 ...
How Your Side Airbags Work . 26
How Your Side Curtain Airbags .........................................
Work .28
.............................
SRS Indicator .29 ,57
....
START (Ignition Key Position) . 72
.......................
Starting the Engine .158
In Cold Weather at High ..................................
Altitude .158
................
With a Dead Battery . 229
..............
State Emissions Testing . 254
........
Steam Coming f rom Engine . 231
Steering Wheel ..................................
Adjustment .69
.............
Anti-theft Column Lock . 72
.......
Steering Wheel Buttons . 135,138
...................
Stereo Sound System . 103
....................
Storing Your Vehicle .218
..........................................
Sun Visor .95
..........................
Sunglasses Holder .94
Supplemental Restraint ..................................
System .9,21
......................................
Servicing .30
.........................
SRS Indicator .29 ,57
...................
System Components . 21
..................................
Synthetic Oil .194 Table
..........................................
Built in .91
...........................................
Center .94
Tailgate .................................
Hatch Glass .74
............................
Open Indicator .59
.................................
Opening the .74
..........
Taillights, Changing Bulbs . 205
.
Taking Care of the Unexpected . 219
...........................
Tape Player .113, 129
Technical Descriptions ....
DOT Tire Quality Grading . 248
.....
Emissions Control Systems . 251
.....................
Oxygenated Fuels .142
Three Way Catalytic ...............................
Converter .253
.......................
Temperature Gauge .62
....................
Temperature, Outside . 62
..............
Tether Anchorage Points . 45
................
Thef t Protection, Radio . 136
..
Three Way Catalytic Converter . 253
..................
Tilt the Steering Wheel . 69
..........................
Time, Setting the .137
....................................
Tire Chains .216
Index
T
VIII