automatic transmission fluid Lexus GX470 2004 Audio System / LEXUS 2004 GX470 FROM SEP. 2004 PROD. OWNER'S MANUAL (OM60B57U)

For detailed information, refer to the description given in each Section\
.
PICTORIAL INDEX
xiv
Page
1Automatic transmission second start indicator light 400 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2Unengaged Parkº warning light 68
. . . . . . . . . . . . . . .
3Automatic transmission fluid temperature
warning light 69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4Low washer fluid warning light 73
. . . . . . . . . . . . . . . . .
5Automatic transmission indicator lights 392 . . . . . .
6Driver's seat belt reminder light 65
. . . . . . . . . . . . . . . .
7Turn signal indicator light 36
. . . . . . . . . . . . . . . . . . . . .
8Brake system warning light 64
. . . . . . . . . . . . . . . . . . . .
9Headlight high beam indicator light 36
. . . . . . . . . . . .
10Anti-lock brake system warning light 67
. . . . . . . . . . .
11Open door warning light 68
. . . . . . . . . . . . . . . . . . . . . . .
12Tachometer 60
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
13Headlight indicator light 33
. . . . . . . . . . . . . . . . . . . . . . .
14Cruise control indicator light 408
. . . . . . . . . . . . . . . .
15Engine oil replacement reminder light 72
. . . . . . . . . .
16Slip indicator light 420, 422, 425, 427
. . . . . . . . . . . . .
17Low engine oil pressure warning light 71
. . . . . . . . . .
18Discharge warning light 70
. . . . . . . . . . . . . . . . . . . . . . . Page
19Engine coolant temperature gauge
58
. . . . . . . . . . . . .
20Malfunction indicator lamp 66
. . . . . . . . . . . . . . . . . . . .
21Vehicle stability control system off
indicator light 422 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22Roll sensing of curtain shield airbags off
indicator light 193 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
23Kinetic dynamic suspension system
warning light 70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
24Center differential lock indicator light 400
. . . . . . . .
25Vehicle stability control system and active
traction control system warning light 70 . . . . . . . . . . .
26Downhill assist control system
indicator light 424 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
27Rear height control indicator lights 417
. . . . . . . . . . .
28Security indicator light 14, 29
. . . . . . . . . . . . . . . . . . . .
29SRS warning light 66
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
30Trip meter reset knob 61
. . . . . . . . . . . . . . . . . . . . . . . . .
31Odometer and trip meter 61
. . . . . . . . . . . . . . . . . . . . . .
32Low fuel level warning light 72
. . . . . . . . . . . . . . . . . . . .
33Low tire pressure warning light 72
. . . . . . . . . . . . . . . .
34Fuel gauge 57
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

For detailed information, refer to the description given in each Section\
.
PICTORIAL INDEX
xvi
Page
1Automatic transmission second start indicator light 400 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2Unengaged Parkº warning light 68
. . . . . . . . . . . . . . .
3Automatic transmission fluid temperature
warning light 69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4Low washer fluid warning light 73
. . . . . . . . . . . . . . . . .
5Automatic transmission indicator lights 392 . . . . . .
6Driver's seat belt reminder light 65
. . . . . . . . . . . . . . . .
7Turn signal indicator light 36
. . . . . . . . . . . . . . . . . . . . .
8Brake system warning light 64
. . . . . . . . . . . . . . . . . . . .
9Headlight high beam indicator light 36
. . . . . . . . . . . .
10Anti-lock brake system warning light 67
. . . . . . . . . . .
11Open door warning light 68
. . . . . . . . . . . . . . . . . . . . . . .
12Tachometer 60
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
13Tail light indicator light 33
. . . . . . . . . . . . . . . . . . . . . . . .
14Cruise control indicator light 408
. . . . . . . . . . . . . . . .
15Slip indicator light 420, 422, 425, 427
. . . . . . . . . . . . .
16Low engine oil pressure warning light 71
. . . . . . . . . .
17Discharge warning light 70
. . . . . . . . . . . . . . . . . . . . . . .
18Engine coolant temperature gauge 58
. . . . . . . . . . . . . Page
19Malfunction indicator lamp
66
. . . . . . . . . . . . . . . . . . . .
20Vehicle stability control system off
indicator light 422 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
21Roll sensing of curtain shield airbags off
indicator light 193 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22Kinetic dynamic suspension system
warning light 70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
23Center differential lock indicator light 400
. . . . . . . .
24Vehicle stability control system and active
traction control system warning light 70 . . . . . . . . . . .
25Downhill assist control system
indicator light 424 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
26Rear height control indicator lights 417
. . . . . . . . . . .
27Security indicator light 14, 29
. . . . . . . . . . . . . . . . . . . .
28SRS warning light 66
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
29Trip meter reset knob 61
. . . . . . . . . . . . . . . . . . . . . . . . .
30Odometer and trip meter 61
. . . . . . . . . . . . . . . . . . . . . .
31Low fuel level warning light 72
. . . . . . . . . . . . . . . . . . . .
32Low tire pressure warning light 72
. . . . . . . . . . . . . . . .
33Fuel gauge 57
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

GAUGES, METERS AND SERVICE REMINDER INDICATORS
69
(i) Automatic Transmission Fluid TemperatureWarning Light
This light warns that the automatic transmission fluid
temperature is too high. If this light comes on while you are driving, slow down and pull
off the road. Stop the vehicle at a safe place and put the
selector lever in Pº and leave the engine idling until the light
goes off. If the light goes off, you can start the vehicle again.
If the light does not go off, call a Lexus dealer or qualified repair
shop for assistance.
NOTICE
Continued driving with the warning light on may
damage the automatic transmission.

MAINTENANCE
536Brakes
In a safe place, check that the brakes do not pull to one side
when applied.
Parking brake
Check that the lever has the proper travel and that, on a safe
incline,
your vehicle is held securely with only the parking brake
applied.
Automatic transmission Parkº mechanism
Check the lock release button of the selector lever for proper
and smooth operation. On a safe incline, check that your
vehicle is held securely with the selector lever in Pº position
and all brakes released.
Vehicle exterior
Items listed below should be performed from time to time,
unless otherwise specified.
Fluid leaks
Check underneath for leaking fuel, oil, water or other fluid after
the vehicle has been parked for a while. If you smell fuel fumes
or notice any leak, have the cause found and corrected
immediately.
Doors and engine hood
Check that all side doors and back door, operate smoothly and
all latches lock securely. Make sure the engine hood
secondary latch secures the hood when the primary latch is
released.
Tire inflation pressure
Check the pressure with a gauge every two weeks,
or at least once a month and adjust as shown on the
tire pressure label. See page 578 for additional
information.
Tire surface
Check the tires carefully for cuts, damage or
excessive wear. See page 593 for additional
information.
Wheel nuts
When checking the tires, make sure to check the nuts
for looseness. Tighten them if necessary.
Tire rotation
Rotate the tires according to the maintenance
schedule. (For scheduled maintenance information,
please refer to the Owner's Manual
Supplement/Scheduled Maintenanceº.) See page 592
for additional information.

INTRODUCTION
547
NOTICE

Remember that battery and ignition cables carry high
currents or voltages. Be careful of accidentally causing a short circuit.

Before closing the engine hood, check to see that you
have not forgotten any tools, rags, etc.

Do not drive with the air cleaner removed, or excessive engine wear could result. Also backfiringcould cause a fire in the engine compartment.

Do not overfill automatic transmission fluid andpower steering fluid, or the transmission and powersteering could be damaged.

Be careful not to scratch the glass surface with thewiper frame.

INTRODUCTION
549
Checking brake fluid
Parts (if level is low):

FMVSS No. 116 DOT 3 or SAE J1703 brake fluid
Tools:

Rag or paper towel

Funnel (only for adding fluid)
Checking power steering fluid
Parts (if level is low):

Automatic transmission fluid DEXRON
II or III
Tools:

Rag or paper towel

Funnel (only for adding fluid)
Checking battery condition
Tools:

Warm water

Baking soda

Grease

Conventional wrench (for terminal clamp bolts)
Checking and replacing the blade type fuses
Parts (if replacement is necessary):

Fuse with same amperage rating as original
Checking the cartridge type fuses
Parts (if replacement is necessary):

Genuine Lexus fuse or equivalent with same amperage
rating as original
Adding washer fluid
Parts:

Water

Washer fluid containing antifreeze (for winter use)
Tools:

Funnel

CHASSIS
572Ð AUTOMATIC TRANSMISSION
Fluid capacity Drain and refill
Up to 3.0 L (3.2 qt., 2.6 lmp. qt.)
Fluid typeToyota Genuine ATF WS*
*: Change automatic transmission fluid only as necessary.
Generally, it is necessary to change automatic transmission
fluid only if your vehicle is driven under one of the Special
Operating Conditions listed in your Owner's Manual
Supplement/Scheduled Maintenanceº. When changing the
automatic transmission fluid, use only Toyota Genuine ATF
WSº (ATF JWS3324 or NWS9638) to aid in assuring optimum
transmission performance.

CHASSIS
573
NOTICE
Using automatic transmission fluid other than ToyotaGenuine ATF WSº may cause deterioration in shiftquality, locking up of your transmission accompaniedby vibration, and ultimately damage the automatictransmission of your vehicle.
Please contact your Lexus dealer for further details.
Ð BRAKES
Pedal clearance
55 mm (2.2 in.) Min. *1
Pedal free play1 Ð 6 mm (0.04 Ð 0.24 in.)
Brake pad wear limit1.0 mm (0.04 in.)
Parking brake lining wear limit1.0 mm (0.04 in.)
Parking brake adjustment5 Ð 7 clicks *2
Fluid typeSAE J1703 or FMVSS No. 116 DOT 3
*1: Minimum pedal clearance when depressed with the force of 490 N (50 kgf,\
110 lbf) with the engine running
*
2: Parking brake adjustment when pulled with the force of 196 N (20 kgf, 4\
4 lbf)

CHASSIS
574Ð CHASSIS LUBRICATION
Propeller shafts Spiders
Slide yoke
Lithium base chassis grease, NLGI No.2
Molybdenum-disulfide lithium base chassis grease, NLGI No.2 or
lithium base chassis grease, NLGI No.2
Ð STEERING
Free play
Less than 30 mm (1.2 in.)
Power steering fluidAutomatic transmission fluid DEXRONII or III
Ð TIRES AND WHEELSTire size
P265/65R17 110S
Tire inflation pressure Recommended cold tire inflation
pressure
220 kPa (2.2 kgf/cm2 or bar, 32 psi)
Wheel size17 x 7 1/2 JJ
Wheel nut torque112 N´m (11.5 kgf´m, 83 ft´lbf)
NOTE:
For complete information on tires (e.g. replacing tires or replacing wh\
eels), see Checking tire inflation pressureº
through Aluminum wheel precautionsº on pages 578 through 601.

CHASSIS
576
CHECKING POWER STEERINGFLUID
The power steering fluid reservoir is located under the
right side engine compartment cover. Before checking
the power steering fluid, remove the cover. (For details,
see Removing the engine compart coversº on page 544.)
Check the fluid level, simply look at the see-through
reservoir. If necessary, add automatic transmission fluid
DEXRON
II or III .
If the vehicle has been driven around 80 km/h (50 mph) for 20
minutes (a little more in frigid temperatures), the fluid is hot
(60 C - 80 C or 140F - 175F). You may also check the level
when the fluid is cold (about room temperature, 10 C - 30C
or 50F - 85F) if the engine has not been run for about five
hours.

1If cold O.K.2If cold add3If hot O.K.
4If hot add
Clean all dirt off the reservoir and look at the fluid level. If the
fluid is cold, the level should be in the COLDº range. Similarly,
if it is hot, the fluid level should be in the HOTº range. If the
level is at the low side of the appropriate range, add automatic
transmission fluid DEXRON
II or III to bring the level within
the range.
To remove the reservoir cap, turn it counterclockwise and lift
up. To reinstall it, turn it clockwise. After replacing the reservoir
cap, visually check the steering box case, vane pump and hose
connections for leaks or damage.