MITSUBISHI GALANT 1989 Service Repair Manual

36-6PARKING BRAKES - Parking Brake Cable
Identification mark
14A0441
SERVICE POINTS OF INSTALLATIONWXDAE
8. INSTALLATION OF PARKING BRAKE CABLE Check the parking brake cables for an identification mark
and install as appropriate on the left and right sides.
Item Identifica-
tion mark Left
Yellow
Green None
Red*
Blue*
1 Right 1 Orange BrownIWhiteI I
Yellow green* I
Green*
NOTE*: Vehicles with automatic seat belt
4. INSTALLATION OF CABLE END
(1) Connect the cable end to the brake shoe assembly.
(2) Install the brake shoe assembly.
(3) Turn the brake shoe adjuster to adjust the outside diameter of brake shoe to the specified value.
NOTE
Adjusting the outside diameter of brake shoe to thespecified value will facilitate adjustment of the shoe
clearance. .‘,,

I.**i:,1;q ,.’
TSB Revision

ALPHABETICAL INDEX1
A
ABS
Checking by the ABS Warnrng Light................
. 35-68-l
Troubleshooting ...........................
35-l 5-l
ABS POWER RELAY, Chec
k 35-74-l
ACCELERATOR CABLE
Inspection and Adjustment <Auto-cruise control>
13-398-l
Inspection and Adjustment <Engine control> ........ 13-329-l
ACCELERATOR SWITCH, Inspection and Adjustment 13-329-I
A/C COMPRESSOR CLUTCH RELAY
On-vehicle Inspection <DOHC>
.............
. 13-285-l
On-vehrcle
Inspection
<SOHC-8VALVE>.........
. 13-83-t
On-vehicle Inspection
<SOHC-lGVALVE>......
. 13-176-l
ACTIVE-ECS ON-BOARD DIAGNOSTIC, Check......

. 338-88-I
ACTIVE-ECS RELAY.......................

. 338-141
-I
ACTIVE-ECS SENSOR....

.
...... ............ 338-138-I
ACTIVE-ECS SYSTEM
Checking by Using Alarm Light
.................
. 338-87-I
Operation Check ........................... 338-90-I
AERO PARTS..

.
........................... 51-18-l
AIR CLEANER...............................

. 15-9-I
AIR CLEANER ELEMENT
Inspection and Replacement
....................
. 15-6-l
Maintenance .......................... 00-39-l
AIR COMPRESSOR..........................

. 338-125-I
AIR CONDITIONING SWITCH
Emission control
...........................
.
17-21 -I
Heater, Air
Conditionrng
and Ventilation .............. 55-29-l
On-vehicle Inspection <DOHC> ................. 13-285-l
On-vehicle Inspection
<SOHC-BVALVE>...........
. 13-83-l
On-vehicle Inspection

<SOHC-76VALVE>..........
. 13-176-l
AIR TUBE..............

.
....................... 338-133-I
ALARM LIGHT, Check. ......................... 338-87-I
ALARM SYSTEM, Theft ..........................
54-165-11
ALIGNMENT
Front Wheel, Adjustment .......................
. 33A-5-l
Rear
Wheel, inspection <AWD>..................
. 34-23-l
Rear Wheel, Inspection
<FWD>....................
. 34-5-l
ANTENNA ......................................
54-153-11
ANTI-LOCK BRAKING SYSTEM, Troubleshooting .........
.
35-15-1
ARM
Lower
<Actrve-ECS>......................
. 338-103-I
Lower <Front
Suspension>......................
.
33A-10-I
Lower <Rear Suspension-AWD>
................... 34-28-l
Torsion
<Active-ECS>................
.
338-l 19-l
Torsion <Rear
Suspension-FWD>
...................34-l 5-lTrailing <Rear Suspension-AWD>
................. 34-31-l
Upper <Rear Suspension-AWD>
.................. 34-28-l
AUDIO
SYSTEM................

.
.................
54-l 12-11
AUTO-CRUISE CONTROL. ..........................
. 13-408-I
AUTO-CRUISE CONTROL INDIVIDUAL PARTS, inspection..

. 13-401-I
AUTO-CRUISE CONTROL SYSTEM...................

. 13-332-l
AUTO-CRUISE CONTROL SYSTEM, Inspection..........

. 13-397-l
AUTOMATIC TRANSAXLE, Maintenance ................. 00-43-I
AXLE
Rear, Maintenance
...............................
. 00-45-I
Torsion
<Active-ECS>........................
.
338-l 19-l
Torsion <FWD>.....

.
......................... 34-15-l
AXLE HUB
Rear
<FWD-Rear
Disc Brakes> ...................... 27-8-l
Rear CFWD-Rear
Drum Brakes> ................... 27-6-l
AXLE SHAFT <AWD>..............................

.
27-17-1
B
BACKLASH. Total, Rear Axle, Check <AWD>............
. 27-15-l
BALL JOINT
Rotation Starting Torque Check ...................... 378-8-I
Tie Rod End, Staning Torque Check .................. 37A-15-l
Tie Rod End, Variation Check ....................... 37A-15-l
BALL JOINT SEALS, Maintenance ..................... 00-45-I
BAR
Stabilizer <Active-ECS>....................

. 338-106-I
Stabilizer
<Front Suspension> ...................
. 33A-13-l
Stabilizer <Rear
Suspension-AWD>...............
. 34-37-l
BAROMETRIC PRESSURE SENSOR
On-vehicle Inspection <DOHC>
................
. 13-266-l
On-vehicle Inspection
<SOHC-BVALVE> 13-53-l
On-vehicle Inspection
<SOHC-lGVALVE>..........
. 13-154-l
BASIC IDLE SPEED
Adjustment <DOHC>
...........................
. 13-245-l
Adjustment
<SOHC-8VALVE>..................... 13-33-l
Adjustment
<SOHC-lGVALVE>...................
. 13-133-l
BATTERY.........................................

.
54-2-11
BATTERY, Flat Remedy.
.............................
. 35-75-l
BEARING
Wheel, Adjustment <Active-ECS>................

. 338-87-I
Wheel, Adjustment <Front Suspension> ............. 33A-5-l
BELT
Drive, Compressor, Adjustment
....................
. 55-17-l
Drive (For Water Pump and Generator), Maintenance ..... 00-41-I
Drive, Tension Adjustment <DOHC> ................. 11-61-I
Drive, Tension Adjustment <SOHC> ................. 11-12-l
Seat..........................................

. 52-39-l
Timing <DOHC> ...................... ......... 11-80-I
Timing<SOHC>................................

. 11-34-l
Timing, Maintenance ............................... 00-40-I
Timing, Tension Adjustment <SOHC> ................ 11-10-I
BLEEDING
Clutch
..........................................
. 21-6-l
4ws...........................................

. 370-4-I
Service Brakes. .................................. 35-57-l
Steering ........................................ 37A-22-l
BLOWER..........................................

. 55-32-l
BOOSTER
Brake
.........................................
. 35-85-l
Brake, Operating Inspection ......................... 35-54-l
BOOST METER, On-vehicle Inspection <DOHC-Turbo> ... 13-311-l
BOOTS, Drive Shaft, Maintenance ....................... 00-45-I
BRAKE
Disc, Front
......................................
. 35-94-l
Disc, Rear.....................................

.
35-l 14-l
BRAKE BOOSTER
...................................
. 35-85-l
BRAKE BOOSTER, Operating Inspection .................. 35-54-l
BRAKE DISC
Front, Run-out Check.
.............................
. 35-63-l
Front, Run-out Correction ........................... 35-64-l
Front, Thickness Check ............................. 35-65-l
Rear, Run-out Check ............................... 35-66-l
Rear, Run-out Correction. ........................... 35-66-l
Rear, Thickness Check............................

. 35-66-l
BRAKE DRUM, tnside
Diameter, Check ................... 35-67-l
BRAKE FLUID LEVEL SENSOR, Check...................

. 35-54-l
BRAKE FLUID PRESSURE SWITCH
AWD-ABS (Up to 1991 Models)
....................
.
35-133-l
AWD-ABS
(Up to 1991 models), Check ...............
. 35-75-l
BRAKE HOSES, Maintenance ........................... 06-45-t
BRAKELINE
........................................
35-87-l

2ALPHABETICAL INDEX
BRAKE LINING ThicknessCheck

.., ..,............
Drum, Rear, Maintenanc
e
BRAKE LINING AND BRAKE DRUM, Connection Check..
BRAKE PAD
Drsc, Front, Check and Replacemen
t
Disc, Rear, Check and Replacement BRAKEPEDAL..
BRAKE PEDAL, Inspection and Adjustment
BUMPER..... 35-67-l
00-44-l
35-67-l
35-59-l
35-65-l
35-76-l
35-53-l
51-7-I
C
CABLEAccelerator, Inspection and Adjustment
<Auto-cruise Control> 13-398-l
Accelerator, Inspection and Adjustment <Engrne
Control> 13-329-I
High
Tensron, Spark Test <SOHC-8VALVE>........
.
16-42-11Parking Brake................................

.
36-5-l
Spark
Plug, Tes
t
........................
16-42-11Speedometer, Replacement <A/T> ...............
.
23-93-l
Speedometer, Replacement
<M/T-AWD>.........
.
22-19-I
Speedometer, Replacement
<M/T-FWD>............
.
22-5-l
CAMSHAFTDOH

C
...................
1 l-68-lSOHC.................................

.
11-19-I
CAMSHAFT OIL SEALS
DOHC
...................................
.
11-68-I
SOHC........................................

.
11-19-I
CAMSHAFT POSITION SENSOR
On-vehrcle Inspection <DOHC>
..................
.
13-277-l
On-vehicle Inspection
<SOHC-8VALVE>............
.
13-69-l
On-vehicle Inspection
<SOHC-lGVALVE>........
.
13-165-I
CANISTER,
Evaporatjve Emission.................

.
17-21-l
CATALYTIC CONVERTER............................

.
17-24-l
CENTERMEMBER...................

.
....... 32-8-l
CENTRAL DOOR LOCKING SYSTEM..................

.
42-101-I
CHARGE AIR COOLER...............................

.
15-l

2-l
CHARGING..................
.
..... 55-17-I
CHARGING SYSTEM....................

.
...........
16-2-11CHARGING SYSTEM, Inspection.......................
.
16-5-11CHECK VALVE, Operation Check......................

.
35-54-l
CIGARETTE LIGHTER..........................

.
54-106-11
CLOCK........................................
.
54-109-11CLOSED THROTTLE POSITION SWITCHAdjustment <SOHC-l
GVALVE>
.................. 13-136-I
Frxed SAS, Adjustment <DOHC>
..................
.
13-250-I
On-vehicle inspection <DOHC> .................. 13-274-l
On-vehicle Inspection
<SOHC-8VALVE>............
.
13-61-I
On-vehicle Inspection

<SOHC-lGVALVE>.........
. 13-160-I
CLUTCH CONTROL.................................

.
21-10-I
CLUTCH MASTER CYLINDER.........................

.
21-12-l
CLUTCH PEDAL.....................................

.
21-7-l
CLUTCH PEDAL, Inspection and Adjustment ................
21-5-1CLUTCH RELAY, A/C Compressor, On-vehicle Inspection
<DOHC
>
....................................... 13-285-l
CLUTCH RELEASE CYLINDER.........................
21-13-lCOIL
Ignition, On-vehicle
Inspectron <DOHC> 13-302-I
Ignition, On-vehicle
InspectIon
<SOHC-8VALVE>......
. 13-96-l
Ignition. On-vehicle Inspection
<SOHC-16VALVE> 13-186-l
COLUMN SWITCH............................

.
54-100-11COMBINATION LIGHT, Rear.
.........................
.
54-95-11COMPRESSION PRESSURE
Check <DOHC>
...............................
.
1
i-59-1Check <SOHC>
..................................
11-8-l
COMPRESSOR...................................
.
55-38-l
COMPRESSOR, Air.......

.
........................ 338-125-I
COMPRESSOR DRIVE BELT, Adjustment, ................. 55-17-l
COMPRESSOR NOISE, Adjustment ...................... 55-23-l
CONDENSER, ............ .......................... 55-48-l
CONDENSER FAN MOTOR...........................

.
55-48-l
CONSOLE, Floor....................................

.
52-29-l
CONTROL
Engine
........................................
.
13-328-l
Transaxle <A/T> ............................... 23-94-l
Transaxle
<M/T-AWD>..........................
.
22-19-I
Transaxle
<M/T-FWD>...........................
.
22-6-l
CONTROL SYSTEM
Evaporative Emission
.............................
.
17-15-l
Intake Charge Pressure, Inspection.
....................
15-7-lMixture (MFI
)
.............................. 17-29-l
Purge, Inspection <Non-Turbo> .................... 17-17-l
Purge, Inspection <Turbo> ....................... 17-18-l
CONTROL UNIT
ABS
........................................
.
35-134-l
Active-ECS ................................... 338-140-I
EPS.....................................

.
...37A-59-lCONTROL VALVE <4WS>..........................

.
378-12-I
COOLANT
Engine, Concentration Test ..........................
14-8-lEngine, Leak Check ................................
.
14-8-l
Engine, Maintenance. ............................ 00-44-I
Engine, Replacement ...........
................... 14-8-lCRANKCASE VENTILATION SYSTEM, inspection..........

.
17-14-l
CRANKSHAFT POSITION SENSOR
On-vehicle Inspection <DOHC>
..................
.
13-280-I
On-vehicle Inspection
<SOHC-8VALVE>............
.
13-73-l
On-vehicle Inspection
<SOHC-lGVALVE> 13-167-l
CROSSMEMBER....................................

.
32-8-l
CURB IDLE SPEED
Inspection <DOHC>
.......
.
.................... 13-245-l
Inspection
<SOHC-8VALVE> 13-32-l
Inspection
<SOHC-lGVALVE>....................
.
13-133-l
CYLINDER
Master
.........................................
.
35-81 -IPower
.........................................
.
378-9-I
Wheel,RearBrake...............................

. 35-111-l
Wheel, Rear, Maintenance .......................... 00-44-I
CYLINDER HEAD GASKET
DOHC
.......................................
.
11-73-l
SOHC.................: ......................... 11-25-l
D
DASH POT, Inspection and Adjustment <DOHC>
1 l-58-lDEFOGGER, Rear Window 64-156-11
DEFOGGER RELA
Y
.54-163-11DEFOGGER SWITCH, Rear Window. 54-163-11
DEFOGGER TIMER 54-164-11
DELAY VALVE, Check <FWD-ABS>
35-74-l
DIAPHRAGM, Rolling, Check 33B-89-l
DIFFERENTIAL CARRIER
<AWD> 27-26-l
DISC
Brake, Front, Run-out Check
35-63-l
Brake, Front, Run-out Correction 35-64-l
Brake, Front.
Thichness Check 35-65-l
Brake, Rear, Run-out Check 35-66-l
Brake, Rear, Run-out Correction 35-66-l
Brake, Rear,
Thichness Chec
k
35-66-l

ALPHABETICAL INDEX3
DISC BRAKEFront
......................................
.
35-94-I
Rear......................................

.
35-114-l
DlSC BRAKE PADS. Marntenance.......................

.
00-44-j
DWHARGlNG
SYSTEM ......................... 55-26-l
DISJRIBUTOR..............................

.
16-55-11
DOoR
........................................
42-74-lDOOR. Fit Adjustment
..............................
. 42-51-l
DOOR DRIP LINE WEATHERSTRIP
Front.......

.
........................... 42-112-j
Rear.....................................

.
42-114-IDOOR GLASS
Adjustment
...............................
42-52-f
Front..................................
.
42-80-l
Rear ........... 42-83-I
DOOR HANDLE
Front
...........
.
........ ............ 42-96-l
Rear.
.................. ................. 42-99-l
DOOR INSIDE HANDLE, Play Check.....................

.
42-52-l
DOOR LATCH
Front
.........
.
............... ........ 42-96-l
Rear.................................

. 42-99-l
DOOR MIRROR...............................

.
51-33-1
DOOR
MOULDING
Front
....................................
.
42-112-l
Rear......................................

.
42-114-l
DOOR REGULATOR
Front
......................................
.
42-80-I
Rear...............

.
.................... 42-83-l
DOOR RUNCHANNEL..........................

.
42-l 10-l
DOOR TRIM
Front
......................................
.
42-76-l
Rear.......................................

.
42-78-i
DOOR WATERPROOF FILM
Fron

t
.................................... 42-76-l
Rear........................................

.
42-78-l
DRIVE BELT
Compressor, Adjustment
....................
.
55-17-l
Tension Adjustment <DOHC> ..................... 11-61-l
Tension Adjustment <SOHC> ...................... 11-12-I
Water Pump and Generator, Maintenance ..............
00-41 -IDRIVE SHAFTFront Axle
.....................................
. 26-12-l
Rear
Axle

<AVVD>............................
. 27-20-I
DRIVE SHAFT BOOTS, Maintenance....................

.
00-45-j
DRIVE SHAFT OIL SEALSReplacement <A/T>
...........................
.
23-92-I
Replacement
<M/T-AWD>.......................
.
22-18-l
Replacement
<M/T-FWD>........................
.
22-4-l
DRUMBrake, inside Diameter, Check
......................
.
35-67-j
Brake,
Rear..............................
.
..... 35-108-l
DRUM BRAKE, Rear
................................
.
35-108-1
DRUM BRAKE LININGS, Rear, Maintenance
..............
.
06-44-j
DRYER........................................

.
33B-127-l
E
EGR SOLENOID <California>Emission Control
.................................
.
17-28-j
On-vehicle
Inspection <DOHC> ................. 13-307-j
On-vehicle
Inspection

<SOHC-6VALVE>..I........
.
13-101-t
On-vehicle
Inspection

<SOHC-lGVALVE>..........
.
13-191-l
EGR SYSTEM

speccon
<California>..........................
.
17-25-j inspection

<Federal>...........................
.
17-25-1
EGR TEMPERATURE SENSOR <California>
Emission Control
................................
.
17-28-l
On-vehicle Inspection <DOHC> .................. 13-288-l
On-vehicle Inspection

<SOHC-8VALVE> 13-85-l
On-vehicle
Inspection
<SOHC-lGVALVE>..........
.
13-177-l
EGRVALVE........................................

.
17-27-f
EGR VALVE CONTROL VACUUM
.......................
.
17-26-l
ELECTRONIC CONTROL UNIT <ABS>
35-134-jELEMENT
Air Cleaner. Inspection
and Replacement ................ 15-6-l
Air Cleaner, Maintenance ........................... go-39-j
END PLAY
Hub.
Inspection
<Active-ECS>................
.
33B-86-l
Hub. Inspection
<Front Axle> ...................
.
26-5-l
Rear. Wheel Bearing, Adjustment
<FWD>...........
.
27-3-l
Rear Wheel Bearing. Check
<AWD>...............
.
27-15-i
ENGINE
DOHC
.......................................
.
11-63-l
SOHC.......................................

.
11-14-1
ENGINE CONTROL................................

.
13-328-l
ENGINE CONTROL MODULE POWER GROUND
On-vehicle Inspectron <DOHC>
..................
.
13-257-l
On-vehicle Inspection
<SOHC-8VALVE>............
.
13-45-l
On-vehicle Inspection
<SOHC-lGVALVE>..........
.
13-146-1
ENGINE CONTROL MODULE TERMINAL VOLTAGE
On-vehicle Inspection <DOHC> ..................
.
13-315-I
On-vehicle Inspection
<SOHC-8VALVE>........... 13-105-I
On-vehicle Inspection

<SOHC-lGVALVE>..........
.
13-192-l
ENGINE COOLANT
Concentration Test
....
.
............................
14-8-l LeakCheck
....................................... 14-8-l
Maintenance ..................................... 00-44-I
Replacement ..............................
,......
.
14-8-I
ENGINE COOLANT TEMPERATURE GAUGE UNIT.........

. 14-31-l
ENGINE COOLANT TEMPERATURE SENSOR
Cooling
........................................
. 14-31-I
Emission Control .................................. 17-21-l
On-vehicle Inspection <DOHC> ................... 13-268-l
On-vehicle Inspection
<SOHC-8VALVE>............
.
13-55-j
On-vehicle Inspection
<SOHC-lGVALVE>..........
.
13-155-l
ENGINE COOLANT TEMPERATURE SWITCH
Cooling........................................
. 14-31-I
Heater, Air Conditioning and Ventilation ......... 55-57-l
ENGINE MOUNTING..................................

.
32-4-l
ENGINE OILCheck <DOHC>
................................
.
11-57-j
Check<SOHC>.................................

. 11-7-l
Maintenance .....................................
00-41-1
ENGINE OIL FILTER, Maintenance ......................
.
60-41-j
ENGINE RPLL
STOPPER..............................
.
32-6-j
EPS CONTROL UNIT................................

.
37A-59-l
EPS MODE SELECTOR SWITCH.......................

.
37A-59-j
EpS SOLENOID, Check
..............................
.
37A-19-j
EVAPORATIVE EMISSION CANISTER...................

.
77-21-j
EVAPORATIVE EMISSION CONTROL SYSTEM............

.
17-15-l
EVAPORATIVE EMISSION PURGE SOLENOIDEmission Control
.................................
.
17-21-1
On-vehicle
Inspection <DOHC> ..................
, 13-307-I
On-vehicle
Inspection

<SOHC-8VALVE>............
.
13-99-1
On-v&i&
inspection
<SOHC-l GVALVE>
........... 13-189-j
EVAPORATOR....

.
................................ 55-34-f
EXHAUST GAS RECIRCULATION (EGR) SYSTEM..........

.
17-22-I
EXHAUST MANIFOLD
DOHC-Non-Turbo................................
.
15-30-1

4ALPHABETICAL INDEX
DOHC-Turbo.................................
. 15-31-f
SOHC-8VALVE..................................

.
15-27-t
SOHC-1 GVALVE............................

.
15-28-l
EXHAUST PIPEDOH

C
......................... 15-33-I
SOHC.....................................

.
15-32-l
EXHAUST SYSTEM, Maintenance ..................... 00-45-I
F
FAN MOTOR
Condenser
.............................
.
55-48-l
Radiator...................

.
......... 14-12-I
FEEDER CABLE ..........................
54-l 55-11FENDER................................
.
42-61-t
FILLER DOOR, Fuel Tank.........................

.
42-60-I
FILLER TUBE CAP, Fuel Tank, Inspection...............

.
17-21 -I
FILTER
Engine 011. Maintenance ....................
. 00-41-I
Fuel <DOHC> ........................... 13-327-l
Fuel
<SOHC-8VALVE>....
.
...................
13-I 15-lFuel <SOHC-lGVALVE>........................
.
13-195
FITTINGS, Handling................................
. 55-22-l
FIXED SAS
Adjustment <DOHC>
........................
.
13-250-I
Adjustment
<SOHC-lGVALVE>...................
.
13-138-I
FLAT BATTERY, Remedy............................

.
35-75-l
FLOOR CONSOLE................................

.
52-29-l
FLUID
Power Steering, Level Check
...................
. 37A-21-l
Power Steering, Replacement ................. 37A-21-l
Transaxle, Replacement ..................... 23-82-l
FLUID LEVEL, Transaxle, Inspection .................. 23-82-l
FOG LIGHT................

.
......................
54-94-11FOG LIGHT SWITCH................................
.
54-99-114WS, Function Check
..........................
. 37B-6-l
FRONT BRAKE DISC
Run-out Check
...................................
. 35-63-I
Run-out Correction ........................... 35-64-l
Thickness Check .............................. 35-65-l
FRONT DISC BRAKE.................................

. 35-94-l
FRONT DISC BRAKE PAD, Check and Replacement ......... 35-59-l
FRONT DOOR DRIP LINE WEATHERSTRIP 42-112-I
FRONT DOOR GLASS...............................

. 42-80-l
FRONT DOOR HANDLE.........................

. 42-96-l
FRONT DOOR LATCH...

.
......... .......... 42-96-l
FRONT DOOR
MOULDING
........................... 42-112-I
FRONT DOOR REGULATOR........................

. 42-80-I
FRONT DOOR TRIM.................................

. 42-76-l
FRONT DOOR WATERPROOF FILM....................

. 42-76-l
FRONT GRILLE..................................

. 51-12-l
FRONT SEAT,...................................

. 52-35-l
FRONT WHEEL ALIGNMENT Adjustment
<Active-ECS>.....................
. 338-86-I
Adjustment <Front Suspension> .................... 33A-5-l
FUEL FILTER
DOHC
.......................................
. 13-327-I
SOHC-8VALVE
.................................
13-l 15-l SOHC-IGVALVE
................................ 13-195-I
FUEL HOSES, Maintenance ............................
00-39-1
FUEL LINE
DOHC-AWD ..................................
.
13-326-l
DOHC-FWD....................................

.
13-324-l
SOHC-8VALVE
................................. 13-113-l
SOHC-1 ~VALVE............................

.
13-l 95-IFUEL PRESSURE
On-vehicle Inspection <DOHC>
On-vehicle Inspection
<SOHC-8VALVE>
On-vehicle Inspection <SOHC-lGVALVE>
FUEL PRESSURE SOLENOID <Turbo>,
On-vehicle Inspection <DOHC
>
FUEL PUMP
On-vehicle Inspection <DOHC>
On-vehicle Inspection
<SOHC-8VALVE>
On-vehicle Inspection <SOHC-lGVALVE>
FUEL SYSTEM, Maintenanc

e
FUEL TANK
DOHC-AWD .,.......
DOHC-FW

D
SOHC-8VALVE
SOHC-16VALVE
FUEL TANK FILLER DOO

R
FUEL TANK FILLER TUBE CAP, Inspection
FUEL TANK PRESSURE CONTROL VALVE. 13-312-l
13-102-I
,.....13-I
92-l
13-307-I
......
13-258-l
....... 13-46-l
...... 13-147-l
....... 00-39-l
......
13-322-l
...... 13-318-l
..... 13-109-I
...... 13-195-I
....... 42-60-I
....... 17-21-I
....... 17-21-l
G
GARNISHES
51-13-l
GASKET
Cylinder Head <DOHC> 1 l-73-l
Cylinder Head <SOHC> 1 l-25-l
GAUGE UNIT, Engine Coolant Temperature
14-31-l
GEAR BOX, Power Steering 37A-32-l
GEAR OIL, Level Check
<AWD> 27-15-l
GENERATOR
16-g-11
GLASS
Door, Adjustmen
t
42-52-l
Door, Front 42-80-I
Door, Rear 42-83-l
Quarter Window 42-70-I
Window.............
.._......_...... 42-63-i
Window,Rear
42-72-i
GRILLE,Front
_. _. _.
51-12-l
G-SENSOR
Service Brakes <AWD-ABS>
35-132-l
Output Voltage, Check 336-96-l
H
HANDLE
Door, Front
..........................
.
Door,Rear
...........................
Door Inside, Play Check. ..................
HAZARD SWITCH.........................
.
HEADLIGHTS............................

.
HEADLINING.............................

.
HEATED OXYGEN SENSOR, On-vehicle Inspection<DOHC

>
...............................
HEATER CONTROL.......................
.
HEATER UNIT............................

.
HEIGHT SENSOR.........................

.
HIGH MOUNTED STOP LIGHT...............

.
42-96-1 42-99-l
42-52-l
54-98-11
54-92-11
52-31-l
13-290-I
55-25-l
55-30-I
338-l
35-l
54-96-11HIGH PRESSURE SWITCH (HIGH-PRESSURE TANK SIDE),Actuation Pressure Check. 338-94-I
16-42-11
42-55-l
42-50-I
54-l 03-11
54-105-11
HIGH TENSION CABLE, Spark Test <SOHC-8VALVE>
HOOD .__...._..._......__._...................
HOOD, Alignment Adjustment .
HOR

N
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . HORNRELAY

._.._._....___.........__.._._..___
HOSE
Brake, Maintenance
.
00-45-I

ALPHABETICAL INDEX5
Fuel, Maintenance.
.
Power Steering
Transaxle
011 Cooler
Vacuum
..,...,..,.......
Water <DOHC (Non-Turbo)
>
Water <DOHC (Turbo)>
Water <SOHC>
HUB
End Play inspection <Active-ECS>
End Play, Inspection <Front Axle>
Front Axl
e
Rear Axle
<FWD-Rear Disc Brakes>
Rear Axle

<FWD-Rear Drum Brakes
>
HYDRAULIC UNIT
HYDRAULIC UNIT, Inspection
I 00-39-I
37A-58-I
23-l
00-l
17-4-I
14-26-I
14-28-l
14-23-l
338-86-I
26-5-l
26-l-l
27-8-l
27-6-1
35-121-l
35-70-t
IAC VALVE POSITION SENSOR, On-vehicle Inspection<SOHC-16VALVE>........................

.
13-162-l
IDLE AIR CONTROL MOTOR
DC Motor,
On-vehicle
Inspection <SOHC-l GVALVE>
13-184-I
Stepper Motor, On-vehicle Inspection <DOHC> ....... 13-298-l
IDLE SPEED
Basic, Adjustment <DOHC>
.....................
.
13-245-l
Basic, Adjustment
<SOHC-8VALVE>...............
.
13-33-l
Basrc. Adjustment <SOHC-lGVALVE>...........

.
13-133-l
Curb, Inspection <DOHC> ................
...... 13-245-I
Curb, Inspection
<SOHC-8VALVE>..
.
...
...........
.
13-32-I
Curb, Inspection
<SOHC-lGVALVE>.............
.
13-133-I
IDLE SPEED CONTROL MOTOR (DC Motor),
On-vehrcle Inspectron <SOHC-8VALVE>.............
.
13-93-l
IDLE SPEED CONTROL MOTOR POSITION SENSOR,On-vehicle Inspection <SOHC-8VALVE>..............

.
13-64-I
IDLE-UP OPERATION, Check ....................... 55-24-l
IGNITION COIL
On-vehtcle
Inspection <DOHC> ................. 13-302-I
On-vehicle
Inspectron <SOHC-8VALVE>.........
.
13-96-l
On-vehicle
Inspection
<SOHC-lGVALVE>.......
.
13-186-I
IGNITION POWER TRANSISTOR
On-vehrcle
Inspection <DOHC> ................ 13-302-I
On-vehicle Inspection
<SOHC-8VALVE>............. 13-96-l
On-vehicle
inspection <SOHC-lGVALVE>.........
.
13-186-l
IGNITION SWITCH
Chassis Electrical.
...........................
.
.....
54-6-11
On-vehicle Inspection <DOHC> ..................
.
13-284-l
On-vehicle Inspection <SOHC-8VALVE.
A/T>....
... 13-78-l
On-vehicle Inspection <SOHC-8VALVE.
M/T>........ 13-77-l
On-vehicle Inspection <SOHC-16VALVE.
A/T>....... 13-172-l
On-vehicle inspection <SOHC-l
GVALVE. M/T> ......
.
13-171 -IIGNITION SYSTEM...........................

.
16-32-11.....

.
IGNITION TIMING Adjustment <DOHC> ...........................
16-40-11
Adjustment <SOHC>16-39-11.......
.
....................
INDICATOR...........................
.
.......... 33B-140-l
INDIVIDUAL PARTS, Auto-cruise Control, Inspection .......
13-401 -I
INFLATION PRESSURE, Tire, Check......................
.
31-4-l
INJECTORS
On-vehicle Inspection <DOHC>
..................
.
13-295-I
On-vehicle Inspection
<SOHC-8VALVE>...........
.
13-90-I
On-vehicle Inspection <SOHC-l GVALVE>
........... 13-l
81-l
INSTRUMENT PANEL ................................. 52-22-l
INTAKE AIR TEMPERATURE SENSOR
Emission Control
..............................
.
17-21 -I
On-vehicle inspection <DOHC>
.................
.
13-263-l
On-vehicle Inspection
<SOHC-8VALVE>............
.
13-51-IOn-vehicle Inspection
<SOHC-lGVALVE>
INTAKE CHARGE PRESSURE CONTROL SYSTEM,Inspection . . . . . . . . . . . . . . .
INTAKE MANIFOLD
DOHC
,.. . . . . . . . . . . ,,... SOHC-WALVE
SOHC-l
GVALVE
K
KEY INTERLOCK MECHANISM, Check

.
KICKDOWN SERVO, Adjustment
KNOCK SENSOR, On-vehicle Inspection<DOHC-Turbo and DOHC (1992 From models)>
KNUCKL
E
L
LASH ADJUSTERS
Check <DOHC

>
Check <SOHC>
LATCHDoor, Fron
t
Door, Rear
LATERAL ROD
Active-EC
S
Rear Suspesion
<FWD>
LEAK, Refrrgerant. Repair Procedure
LEVELFluid, Transaxle, Inspection
Oil, Transfer, Inspection.
LEVERParking Brak
e
Parking Brake, Stroke Check
Selector, Operation Check.
Shift
<AWD>
Shift <FWD>
LIDTrunk ._, . . . . . . . . . . . . .
Trunk, Adjustmen
t
LIGHT
......
......
......
.....
......
......
.....
......
......
......
......
......
......
......
......
......
......
......
......
......
.......
........
.......
........
........
........
........
........
........
........
........
........
........
........
........
........
........
Alarm, Chec

k
Rear Combination
Stop, High Mounted
LIGHTING SYSTEM
LINEBrake
Fuel <DOHC-AWD>
Fuel <DOHC-FWD>
Fuel <SOHC-8VALVE>
Fuel <SOHC-lGVALVE>
Refrigerant
.
Vapor
<DOHC-AWD>
Vapor <DOHC-FWD>
Vapor <SOHC-8VALVE>
Vapor <SOHC-l GVALVE>
LINE PRESSURE, Adjustment
LININGBrake, Thickness Check.
Rear Drum Brake, Maintenance
LOOSE PANE
L
LOWER ARMActive-KS
Front Suspensio

n
Rear Suspesion
<AWD>
........
...............
.......
........
........
........
........
........
........
........
........
.........
.........
.........
.........
.........
........ 13-152-I
15-7-l
15-21 -I
15-14-I
15-18-I
23-83-1
23-86-i
13-287-l
26-6-l
11-57-1
1 l-7-l
42-96-l
42-99-l
338-l 17-l
34-14-I
’
55-21-I
23-82-l
23-82-l
36-4-l
36-2-l
23-83-l
22-19-l
22-9-l
42-57-l
42-50-I
338-87-I
54-95-11
54-96-11
54-38-11
35-87-I
13-326-I
13-324-I
13-113-I
13-I
95-l
55-54-l
13-326-I
13-324-l
13-I 13-l
13-195-1
23-88-l
35-67-l
00-44-I
42-62-i
338-l
03-l
33A-10-I
34-28-l

6ALPHABETICAL INDEX
LOW PRESSURE SWITCH (LOW-PRESSURE TANK SIDE)
Actuation Pressure Check
.
M
MAIN MUFFLER
DOH
C
SOHC
MANIFOLD
Exhaust <DOHC-Non-Turbo>
Exhaust <DOHC-Turbo
>
Exhaust
<SOHC-8VALVE>
Exhaust <SOHC-lGVALVE>
Intake <DOHC
>
Intake
<SOHC-8VALVE>
Intake <SOHC-lGVALVE>1
Vacuum Inspection <DOHC>
Vacuum Inspection <SOHC>
MANUAL TRANSAXLE
AWD
FW
D
Maintenance
MASTER CYLINDER
Clutch
Service Brakes.
METER, Boost, On-vehrcle
Inspectron <DOHC-Turbo>
METERS AND GAUGES
MIRROR, Door
MIRROR SWITCH. Remote Controlled
MIXTURE CONTROL [MFI) SYSTEM : : : : : :
MODE SELECTOR SWITCH EPS
MOTOR 15-30-I
15-31 -I
15-27-l
15-28-l
15-21-l
15-14-l
15-18-l
11-60-I
11-9-l
22-l 5-l
22-2-i
00-42-l
21-12-l
35-81 -I
13-311-I
54-8-11
51-33-l
51-34-l
17-29-l
37A-59-l
Idle Arr Control (DC Motor), On-vehicle Inspection<SOHC-lGVALVE>
Idle Air Control (Stepper Motor), On-vehicle Inspection
<DOHC
>
Idle Speed Control (DC Motor),
6n-vehicle
Inspection<SOHC-8VALVE>
Starte
r
MOULDING
Door. Front
Door. Rear
Exterio
r
MOUNTING 42-112-l
42-1 14-l
51-15-l
Engine.
,,,.....
Transaxl
e
MUFFLER
Main <DOHC>
Main <SOHC

> 32-4-l
32-5-l
15-33-l
15-32-I
N
NOISE. Compressor, Adjustmen

t
NORMAL VEHICLE HEIGHT, Check and Adjustment
OIL 55-23-l
338-88-I
0
Engine. Check <DOHC>
Engine. Check <SOHC>
1 : : 1 : 1
Engine, Maintenance.
.
Transaxle. Replacement
<AWD>
Transaxle. Replacement <FWD>
Transfer. Replacemen
t
OIL COOLER HOSES, Transaxle
OIL FILTER, Engine, Maintenance. 11-57-l
11-7-l
00-41-I
22-18-l
22-4-l
23-82-l
23-l
00-l
00-41 -I338-95-I
15-33-l
15-32-l
13-l
84-l
13-298-l
13-93-l
16-19-f
OIL LEVEL
Gear, Check <AWD>............................
.
27-l 5-f
Transaxle, Inspection <AWD>....................

. 22-17-l
Transaxle, Inspection
<FWD>......................
. 22-4-l
Transfer, Inspection ............................... 23-82-l
OIL LINE, Rear. .............. ..................... 378-13-I
OIL PAN
DOHC.....................................
. 11-71-l
SOHC......

.
.................................. 11-23-l
OIL PRESSURE SWITCH, Power Steering. Check ........... 37A-24-l
OIL PUMP Power Steering ................................. 37A-48-l
Power Steering, Pressure Test ...................... 37A-23-l
Rear..........

.
...
......................... 378-15-I
...
Rear, Discharge Flow Volume Check .................. 378-6-I “s
OIL SCREEN.
DOHC.....................................

.
11-71-l
SOHC.
......................................
.
1 l-23-l
OIL SEALS Camshaft <DOHC> .......................... 11-68-I
Camshaft <SOHC>
........................... 11-19-l
Drive Shaft. Replacement <A/T> .................... 23-92-l
Drive Shaft, Replacement
<AWD>................
. 22-18-l
Drive Shaft, Replacement
<FWD>...................
. 22-4-l
Transfer, Replacement
<AWD>...................
. 22-19-l
OUTPUT VOLTAGE,
G sensor, Check ..................
. 33B-96-l
OXYGEN SENSOR
On-vehicle
inspectron
<SOHC-8VALVE>............
.
13-87-l
On-vehicle Inspection <SOHC-lGVALVE>.........

. 13-179-l
P
PAD
Disc Brake. Front, Check and Replacement ............
. 35-59-l
Disc Brake. Maintenance. ........................... 00-44-i
Disc Brake. Rear, Check and Replacement
’.............
. 35-65-l
PANEL. Loose ....................................... 42-62-l
PARKING BRAKE CABLE..............................

. 36-5-l
PARKING BRAKE LEVER...............................

. 36-4-l
PARKING BRAKE LEVER, Stroke Check...................

. 36-2-l
PARKING BRAKE SWITCH, Check.......................

. 36-3-l
PARK/NEUTRAL POSITION SWITCH
Adjustment ..................................... 23-84-l
On-vehrcle
Inspection <DOHC, A/T> ................ 13-284-l
On-vehicle Inspection <SOHC-8VALVE.
A/T>......... 13-78-l
On-vehicle Inspection <SOHC-16VALVE.
A/T>....... 13-172-l
PCV VALVE, Inspection
................................ 17-14-l
PEDAL
Brake
..........................................
. 35-76-l
Brake, Inspection
and Adjustment
.................... 35-53-l
Clutch.........................................

. 21-7-l
Clutch. Inspection
and Adjustment
..................... 21-5-l
PERFORMANCE TEST...............................

. 55-21-l
PIPE
Exhaust <DOHC>................................15-33-1
Exhaust <SOHC>\-...............................

. 15-32-l
Water <DOHC (Non-Turbo)>
....................... 14-26-l
Water
<DOHC (Turbo)> ..........................
. 14-28-l
Water
<SOHC>................................
. 14-23-l
PLAY
End. Hub, Inspection
<Active-ECS>................. 338-86-I
End. Hub. Inspection <Front Axle>..............
. 26-6-l
End, Rear Wheel Bearing, Check
<AWD> 27-15-1End, Wheel Bearing, Adjustment <FWD>.............
. 27-3-l

ALPHABETICAL INDEX
PLUGSpark, Maintenance. 00-40-I
Spark, Test..
16-42-11
POSITIVE CRANKCASE VENTILATION SYSTEM 17-13-l
POSITIVE CRANKCASE VENTILATION (PCV) VALVE,Inspection
17-14-I
POWER AMPLIFIER
54-151-11POWER CYLINDE
R
378-9-I
POWER GROUND
Engine Control Module, On-vehicle
Inspection
<DOHC> 13-257-l
Engrne Control Module, On-vehicle Inspection<SOHC-8VALVE>..........

.
13-45-l
Engine Control Module, On-vehicle Inspection
<SOHC-lGVALVE>....................
.
13-146-I
POWER RELAY
ABS. Check
................................
.
35-74-l
Air
Conditionrng and Ventrlation. Check ........
.
55-24-l
POWER STEERING, Stationary Steering Effort Check......

.
37A-18-l
POWER STEERING FLUID
Level Check
.................................
.
37A-21-l
Replacement .................................... 37A-21-I
POWER STEERING GEAR 80X....................

.
37A-32-l
POWER STEERING HOSES...........

.
........ 37A-58-l
POWER STEERING OIL PUMP......................

.
37A-48-l
POWER STEERING OIL PUMP, Pressure Test...........

.
37A-23-l
POWER STEERING PRESSURE SWITCH
Check
........................................
.
37A-24-l
On-vehicle Inspection <DOHC> ................ 13-284-l
On-vehicle Inspection
<SOHC-8VALVE>..........
.
13-81 -IOn-vehicle Inspection <SOHC-lGVALVE>.........

.
13-175-l
POWER SUPPLY
On-vehicle Inspectron <DOHC>
.................
.
13-255-l
On-vehicle Inspection
<SOHC-8VALVE>............
.
13-42-I
On-vehrcle Inspection <SOHC-lGVALVE>..........

.
13-143-l
POWER TRANSISTOR
Ignition, On-vehicle Inspection <DOHC>
............
.
13-302-I
Ignition, On-vehicle Inspection
<SOHC-8VALVE>......
.
13-96-l
Ignition, On-vehicle Inspection
<SOHC-lGVALVE> 13-186-I
POWER WINDOW..................................

.
42-86-l
PRESSURECompression, Check <DOHC>
....................
.
11-59-i
Compression, Check <SOHC> ...................
1 l-8-lFuel, On-vehicle Inspection <DOHC> .............
.
13-312-I
Fuel, On-vehicle Inspection

<SOHC-8VALVE>.......
.
13-102-I
Fuel, On-vehicle Inspection
<SOHC-lGVALVE>......
.
13-192-l
Inflation,Tire,
Check
............................ 31-4-I
Line, Adjustment .................................. 23-88-l
Reducing, Adjustment ........................
23-91 -IPRESSURE SWITCH
Brake Fluid <AWD-ABS, Up to 1991 Models>
....
.
35-133-I
Brake Fluid, Check AWD-ABS: Up to 1991 Models> ..... 35-75-l
PROPELLER SHAFT.................................

.
25-4-l
PROPORTIONING VALVE, Function Test................

.
35-56-l
PUMP
Fuel, On-vehicle Inspection <DOHC> .............. 13-258-l
Fuel, On-vehicle Inspection
<SOHC-8VALVE>........
.
13-46-l
Fuel, On-vehicle Inspection
<SOHC-lGVALVE>......
.
13-147-l
OiLRear
....................................... 37B-15-l
Water <DOHC>
................................ 14-20-I
Water <SOHC> ................................
14-I 5-1PURGE CONTROL SYSTEM
Inspection <Non-Turbo>
.........................
.
17-17-I
Inspection <Turbo> .............................. 17-18-I
PURGE CONTROL VALVE <Turbo> .................... 17-20-I
PURGE PORT VACUUM............................

.
17-19-I
Q
QUARTER WINDOW GLASS......................
.
42-70-I
R
RADIATOR.........................................

.
14-9-lRADIATOR CAP, Pressure Test
.......................
.
14-8-lRADIATOR FAN MOTOR
............................
.
14-12-lRADIO AND TAPE PLAYER
..........................
.
54-149-11REAR AXLE
Maintenance
.............................
.
00-45-I
Total Backlash Check
<AWD>....................
.
27-15-I
REAR AXLE HUB
FWD-Rear Disc Brakes
.............................
.
27-8-l
FWD-Rear Drum Brakes ........................... 27-6-l
REAR BRAKE DISC
Run-out Check.
.................................
.
35-66-l
Run-out Correction .............................. 35-66-l
Thickness Check ............................... 35-66-l
REAR BRAKE WHEEL CYLINDER......................

.
35-l 1 l-lREAR COMBINATION LIGHT
..........................
.
54-95-IREAR DISC BRAKE.................................

.
35-l 14-lREAR DISC BRAKE PAD, Check and Replacement
.........
. 35-65-l
REAR DOOR DRIP LINE WEATHERSTRIP.............

.
42-l 14-lREAR DOOR GLASS.........................

.
42-83-l
REAR DOOR HANDLE............................

.
42-99-l
REAR DOOR LATCH................................

.
42-99-l
REAR DOOR
MOULDING
........................42-l 14-l
REAR DOOR REGULATOR..........................
.
42-83-l
REAR DOOR TRIM................................

.
42-78-l
REAR DOOR WATERPROOF FILM......................

.
42-78-l
REAR DRUM BRAKE...............................

.
35-108-I
REAR DRUM BRAKE LININGS, Maintenance ............... 00-44-I
REAR HUB, Rotary-sliding Resistance (Torque)
Adjustment
<FWD>................................
.
27-5-l
REAR OIL LINE..................................

.
378-13-I
REAR OIL PUMP
Discharge Flow Volume Check .................... 378-6-I
4WS
........................................... 378-15-I
REAR SEAT......................................

.
52-37-l
REAR SUSPENSION
Active-ECS
...................................
.
338-l 14-lAWD
..........................................
.
34-24-l
FWD..........................................

.
34-6-l
REAR WHEEL ALIGNMENT Inspection
<AWD>.............................
.
34-23-l
Inspection
<FWD>...............................
.
34-5-l
REAR WHEEL BEARING
End Play Check <AWD>.........................

.
27-15-I
‘Rotation Sliding Resistance Check
<AWD>..........
.
27-16-I
REAR WHEEL CYLINDERS, Maintenance, 00-44-I
REAR WINDOW
DEFFOGER..........................
.
54-156-11REAR WINDOW DEFOGGER SWITCH..................

.
54-163-11REAR WINDOW GLASS..............................

.
42-72-l
REDUCING PRESSURE, Adjustment. ..................... 23-91-l
REFRIGERANT, Leak Repair Procedure.................

.
55-21-l
REFRIGERANT LINE..................................
55-54-l
REGULATOR
Door, Front
.....................................
.
42-80-I
Door, Rear ....................................... 42-83-l
RELAY
A/C Compressor Clutch, On-vehicle Inspection<SOHC-8VALVE>..............................

.
13-83-lA/C Compressor Clutch, On-vehicle Inspection<SOHC-lGVALVE>.............................
13-176-I

8ALPHABETICAL INDEX
ACTIVE-KS
.............................
.
338-l
41-1
Defogger ................................
.54-163-11
Horn
,
...............
54-105-11
Lightrng System............................
.
54-97-l)
Power, Check .............................. 55-24-l
RELEASE CYLINDER, Clutch.......................

.
21-13-l
REMOTE CONTROLLED MIRROR SWITCH..............

.
51-34-l
RESERVE TANK ............... 338-122-I
RESISTANCE
Rotary-sliding. Rear Hub, Adjustment <FWD>.....

. 27-5-l
fiotation
Sliding, Rear Wheel Bearing, Check
<AWD>..
.
27-16-l
RESISTOR
Heater, Arr Conditioning and Ventilation
............
. 55-28-l
On-vehicle
Inspection <DOHC-Turbo> ............ 13-298-t
RHEOSTAT.....

.
.........................
54-99-11
ROD
Lateral <Active-ECS>......................
.
338-l 17-l
Lateral <Rear Suspesion-FWD>..............

. 34-14-l
ROLLING DIAPHRAGM, Check .................. 338-89-I
ROLL STOPPER, Engine...........................

. 32-6-l
ROTARY-SLIDING RESISTANCE (TORQUE), Rear Hub,Adjustment <FWD>............................

. 27-5-l
ROTATION SLIDING RESISTANCE, Rear Wheel Bearing,Check<AWD>....................................

. 27-16-l
RUNCHANNEL. Door
.............................
.
42-l 10-l
RUN-OUT
Front Brake Disc, Correction ...................
. 35-64-l
Rear Brake Disc, Check ......................... 35-66-l
Rear Brake Disc, Correction ...................... 35-66-i
WheeLCheck
................................. 31-4-I
S
SAFETY PRECAUTIONS
SEALS 55-12-l
Ball Joint, Maintenance
Steering Linkage, Maintenance
SEAT
Fron
t
.._........
Rear...

.
SEAT BELT
SELECTOR LEVER, Operation Check
SENSOR
........ 00-45-I
...... 00-45-I
........
52-35-l
....... 52-37-l
.... 52-39-l
........ 23-83-l
ACTIVE-ECS Barometric Pressure, On-vehicle Inspection
<DOHC> . . . . . . . . . . . . . . . . . . . . . . . . 33B-138-i
13-266-l
Barometric Pressure, On-vehicle inspection
<SOHC-8VALVE> 13-53-l
Barometric Pressure, On-vehicle Inspection
<SOHC-lGVALVE>_. 13-154-l
Brake Fluld Level, Chec
k
35-54-l
Camshaft Position, On-vehicle inspection <DOHC> 13-277-l
Camshaft Position, On-vehicle Inspectron
<SOHC-8VALVE>
13-69-l
Camshaft Position, On-vehicle Inspection <SOHC-l GVALVE>
13-l
65-l
Crankshaft Position, On-vehicle Inspection <DOHC> 13-280-I
Crankshaft Position, On-vehicle Inspection
<SOHC-8VALVE> 13-73-l
Crankshaft Position, On-vehicle Inspection <SOHC-l GVALVE>
13-167-I
EGR Temperature California 17-28-l
EGR Temperature California, On-vehicle Inspection
<DOHC> 13-288-l
EGR Temperature California, On-vehicle Inspection<SOHC-8VALVE>
13-85-l
EGR Temperature California, On-vehicle Inspection
<SOHC-lGVALVE> 13-177-l Engine Coolant Temperature <Cooling> 14-31-l
Engine Coolant Temperature <Emission Control> 17-21-l
Engine Coolant Temperature, On-vehicle Inspection <DOHC> . 13-268-l
Engine Coolant Temperature, On-vehicle
Inspection
<SOHC-8VALVE> 13-55-l
Engine Coolant Temperature, On-vehicle Inspection
<SOHC-l GVALVE>
13-l 55-l
G <AWD-ABS> 35-132-l
Heated Oxygen, On-vehicle Inspection <DOHC> 13-290-I
Height 338-135-I
IAC Valve Position, On-vehicle Inspection<SOHC-lGVALVE>
13-162-l
idle Speed Control Motor Position, On-vehicle Inspection
<SOHC-BVALVE> 13-64-l
Intake Air Temperature 17-21-l
Intake Air Temperature, On-vehicle Inspection <DOHC> 13-263-l
Intake Air Temperature, On-vehicle Inspection
<SOHC8VALVE> 13-51-l
Intake Air Temperature, On-vehicle Inspection <SOHC-l GVALVE>

13-l 52-l
Knock, On-vehicle Inspection <DOHC-Turbo and DOHC
(1992 From models)>
Oxygen, On-vehicle Inspection

<SOHC-8VALVE>
Oxygen, On-vehicle Inspection <SOHC-lGVALVE>
Throttle Position, Adjustment <A/T
>
Throttle Position, Adjustment <DOHC>
Throttle
Position, Adjustment <SOHC-8VALVE>
Throttle Position, Adjustment <SOHC-lGVALVE>
Throttle Position, On-vehicle Inspection <DOHC>
13-287-1 13-87-l
13-179-l
23-92-l
13-248-l
13-35-l
13-136-I
13-270-I
Throttle Position, On-vehicle Inspection
<SOHC-8VALVE> 13-57-1
Throttle Position, On-vehicle Inspection<SOHC-lGVALVE>...........................
. 13-157-l
Vehicle Speed, On-vehicle Inspection <DOHC> ....... 13-284-l
Vehicle Speed, On-vehicle Inspection
<SOHC-8VALVE>..............................
. 13-80-I
Vehicle Speed, On-vehicle Inspection <SOHC-l GVALVE>
.............................
13-l 73-l
Volume Air Flow, Emission Control ...................
.
17-21
-I
Volume Air Flow, On-vehicle Inspection <DOHC> ....
. 13-261-l
Volume Air Flow, On-vehicle Inspection
<SOHC-8VALVE>..............................
. 13-49-l
Volume Air Flow, On-vehicle Inspection
<SOHC-lGVALVE>............................
. 13-150-I
Wheel Speed
<ABS>...........................
. 35-126-l
Wheel Speed, Output Voltage Measurement ............ 35-69-l
SERVO, Kickdown. Adjustment
.......................... 23-86-l
SHAFT
Axle <AWD>..................................

. 27-17-I
Drive........................................

. 26-12-I
Drive
<AWD>.................................
. 27-20-I
Propeller.......................................

. 25-4-l
Steering.......................................

. 37A-25-l
SHIFT LEVER
AWD
.........................................
. 22-19-l
FWD
22-9-l
............................................
SHIFT LOCK MECHANISM, Check......................
. 23-84-l
SHOCK ABSORBER
Active-ECS
...................................
. 338-110-l
RearSuspension<AWD>........................

. 34-35-l
Rear Suspension
<FWD>........................
.
34-l 1-ISOLENOID VALVE
Active-ECS
.................................
.
..33B-127- I
EGR <California>
...............................
. 17-28-l
EGR <California>, On-vehicle Inspection <DOHC> 13-307-I
EGR <California>, On-vehicle Inspection
<SOHC-8VALVE>.............................. 13-101-I

ALPHABETICAL INDEX
EGR <California>, On-vehicle Inspection<SOHC-l GVALVE>13-191 -IEPS. Chec

k
37A-19-I
Evaporative Emission Purge
17-21 -IEvaporative Emission Purge, On-vehicle Inspection <DOHC> 13-307-I
Evaporative Emission Purge, On-vehicle Inspection
<SOHC8VALVE> 13-99-l
Evaporative Emission Purge, On-vehicle Inspection
<SOHC-lGVALVE> 13-189-l
Fuel Pressure <Turbo>, On-vehicle Inspection
<DOHC
>
13-307-I
Turbocharger Waste Gate, Inspectron
15-8-l
Turbocharger Waste Gate, On-vehicle Inspection <DOHC-Turbo> 13-309-I
00-40-I
16-42-11
16-42-11
54-151-I
35-126-l
35-69-l
23-93-l
22-19-l
22-5-l
SPARK PLUG
Maintenanc
e
........
Test .........................
SPARK PLUG CABLE, Test........
.
SPEAKER.......................

.
SPEED SENSOR
Wheel<ABS>.,..........

.
Wheel, Output Voltage Measurement
SPEEDOMETER CABLE
Replacement <A/T> ..........
.
Replacement
<M/T-AWD>.....
.
Replacement
<M/T-FWD>...
.
STABILIZER BAR
Active-ECS
.........
.
Front
Suspensron...........
.
Rear Suspension
<AWD>.....
.
STARTER MOTOR..................

.
STARTING SYSTEM................

.
STEERING GEAR BOX, Power.........

.
STEERING LINKAGE SEALS, Maintenance
STEERING SHAFT.................
.
STEERING WHEEL..............

.
STEERING WHEEL
AngleCheck.....................

. 37A-15-l
Centering ...................... 37A-16-l
Free Play Check. ............... 37A-15-l
Return to Center Check ............. 37A-19-l
STOP LIGHT, High Mounted ...........
54-96-l
I
STOPPER, Roll. Engine
................
. 32-6-i
STRUT
Active-ECS
338-97-I
.......
Front Suspension. ........................... 33A-6-l
...
SUNROOFBody
..........................
.
.......... 42-116-l
Fit Adjustment ................................ 42-53-l
SUPERCHARGING PRESSURE, Turbocharger, Inspection.....

.
15-7-l
SUSPENSIONRear <Active-ECS>.....................

.
33B-114-l
Rear<AWD>.................................

.
34-24-l
Rear<FWD>................................

.
34-6-i
SWITCHAccelerator, Inspection and Adjustment
..............
.
13-329-l
Air Conditioning <Emission Control> ................. 17-21-l33B-106-l
33A-13-l
34-37-l
16-19-1116-14-I
37A-32-l
00-45-I
37A-25-1
37A-25-I
Air Conditioning <Heater, Air Conditioning and Ventilation> 55-29-l
Air Conditioning, On-vehicle Inspection <DOHC> 13-285-l
Air Conditioning, On-vehicle Inspection
<SOHC-8VALVE> 13-83-l
Air Conditioning, On-vehicle Inspection <SOHC-l GVALVE>
13-176-l
Brake Fluid Pressure
<AWD-ABS:Up to 1991 Models> 35-l 33-1
Brake Fluid Pressure, Check <AWD-ABS:Up to 1991 Models> 35-75-l
Closed Throttle Position, Adjustment <DOHC>
13-250-l
Closed Throttle Position, Adjustment
<SOHC-lGVALVE> 13-136-l
Closed Throttle Position, On-vehicle Inspection <DOHC> 13-274-l
Closed Throttle Position, On-vehicle Inspection
<SOHC-8VALVE>
13-61-l
Closed Throttle Position, On-vehicle Inspection
<SOHC-lGVALVE> 13-160-I
Column
.54-100-11Engine Coolant Temperature <Cooling> 14-31-l
Engine Coolant Temperature <Heater, Air Conditioning and ventilation>
FogLight...
Hazar
d
., .._.
High-Pressure (High-Pressure Tank Side),Actuation Pressure Chec

k
Ignrtion, Chasscs Electrical
Ignition, On-vehicle Inspection <DOHC-A/T>
Ignition, On-vehicle Inspection <DOHC-M/T>
Ignition, On-vehicle Inspection <SOHC-8VALVE.
A/T> 55-57-l
54-99-11
54-98-11
33B-94-l
54-6-11
13-284-i
13-284-l
13-78-l
Ignitron. On-vehicle Inspection
<SOHC-8VALVE.
M/T> 13-77-1
Ignition, On-vehicle
Inspection
<SOHC-l GVALVE. A/T
>
: 13-I 72-l
Ignition. On-vehicle Inspection
<SOHC-16VALVE.
M/T> 13-171-l
Ignition. Power Supply, On-vehicle Inspection <DOHC> 13-255-l
Low-Pressure (Low-Pressure Tank Side),
Actuation Pressure Check
Parking
Brake. Check.
.
Park/Neutral
Posrtion, Adjustment <A/T>
Park/Neutral
Posrtion, On-vehicle Inspection
<DOHC-A/T
>
Park/Neutral Position, On-vehicle Inspection <SOHC-8VALVE.
A/T> 338-95-I
36-3-l
23-84-l
13-284-I
13-78-l
Park/Neutral Position, On-vehicle Inspection
<SOHC-lGVALVE,A/T> _. 13-172-l
Power Steering Pressure, Check, Steering 37A-24-l
Power Steering Pressure, On-vehicle Inspection <DOHC> 13-284-l
Power Steering Pressure, On-vehicle Inspection
<SOHC-8VALVE>Power Steering Pressure, On-vehicle Inspection<SOHC-lGVALVE>
Rear Window Defogge
r
Remote Controlled Mirror 13-81-l
13-175-l
54-163-11
51-34-l
T
TANK
Fuel <DOHC-AWD>..........................

.
13-322-l
Fuel
<DOHC-FWD>............................
.
13-318-I
Reserve ....................................... 338-122-I
TENSIONDrive Belt Adjustment <DOHC

>
11-61-1
Drive Belt Adjustment <SOHC>
11-12-I
Timing Belt Adjustment <SOHC> 11-10-I
TERMINAL VOLTAGE
Engine Control Module, On-vehicle Inspection
<DOHC
>
.................. 13-315-l
.. ....... ..........
Engine Control Module, On-vehicle Inspection
<SOHC8VALVE>.................
.
13-l 05-i..
.........
.
Engine Control Module, On-vehicle Inspection
<SOHC-lGVALVE>
TEST PROCEDURE
S
THEFT ALARM SYSTEM THERMAL VACUUM VALVE <Federal> 13-192-l
55-13-l
54-165-11
17-27-l