gearbox PEUGEOT 207 2010 User Guide

!
131
Only use products recommended by
PEUGEOT or products of equivalent
quality and specifi cations.
In order to optimise the operation
of units as important as the braking
system, PEUGEOT selects and of-
fers very specifi c products.
To avoid damaging the electrical
units, the use of a high pressure
washer in the engine compartment
is strictly prohibited .
2 Tronic gearbox
The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the Warranty and
Maintenance Record for de-
tails of the level checking in-
tervals for this component. Brake disc and drum wear
For any information relating
to checking of the brake disc
and/or drum wear, contact a
PEUGEOT dealer.
Manual gearbox
The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the Warranty and
Maintenance Record for de-
tails of the level checking in-
tervals for this component. Brake pads
Brake wear depends on the
style of driving, particularly in
the case of vehicles used in
town, over short distances. It
may be necessary to have the
condition of the brakes checked, even
between vehicle services.
Unless there is a leak on the circuit, a
drop in the brake fl uid level indicates
that the brake pads are worn.
Parking brake
If the parking brake travel is
too long or if you notice a loss
of effectiveness of this sys-
tem, the parking brake must
be adjusted, even between
two services.
This system must be checked by a
PEUGEOT dealer.
Automatic gearbox
The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the Warranty and
Maintenance Record for de-
tails of the checking intervals
for this component.

10
159
* Not available on SW and SW Outdoor. MODELS:
ENGINES AND GEARBOXES

PETROL ENGINES 1.4 litre 75 hp 1.4 litre 16V
90 hp * 1.4 litre VTi 16V 95 hp
Cubic capacity (cc) 1 360 1 360 1 397
Bore x stroke (mm) 75 x 77 75 x 77 75 x 77
Maximum power: EU standard (kW) 54 65 70
Maximum power engine speed (rpm) 5 400 5 250 6 000
Maximum torque: EU standard (Nm) 118 133 136
Maximum torque engine speed (rpm) 3 300 3 250 4 000
Fuel Unleaded Unleaded Unleaded
Catalytic converter Yes Yes Yes

GEARBOXES Manual
(5-speed) 2 Tronic
(5-speed) Manual
(5-speed)

OIL CAPACITIES (in litres)

Engine (with fi lter replacement) 3.25 3.25 4.25
Gearbox - Final drive 1.9 - 1.9

10
160
TECHNICAL DATA

MODELS:
ENGINES AND GEARBOXES

PETROL ENGINES 1.6 litre VTi 16V 120 hp 1.6 litre THP 16V 150 hp *
Cubic capacity (cc) 1 598 1 598
Bore x stroke (mm) 77 x 85.8 77 x 85.8
Maximum power: EU standard (kW) 88 115
Maximum power engine speed (rpm) 6 000 5 800
Maximum torque: EU standard (Nm) 160 240
Maximum torque engine speed (rpm) 4 250 1 400
Fuel Unleaded Unleaded
Catalytic converter Yes Yes

GEARBOXES Manual
(5-speed) Auto
(4-speed) Manual
(6-speed)

OIL CAPACITIES (in litres)

Engine (with fi lter replacement) 4.25 4.25 4.25
Gearbox - Final drive 1.9 - 1.9
* Not available on SW and SW Outdoor.
PEUGEOT recommends the use of RON 98 unleaded petrol for opt imum engine performance.

10
167

MODELS:
ENGINES AND GEARBOXES

DIESEL ENGINES
1.4 litre Turbo HDI
70 hp *
1.6 litre Turbo HDI
90 hp
1.6 litre Turbo HDI
90 hp 99g *
1.6 litre Turbo HDI
110 hp
Cubic capacity (cc) 1 398 1 560 1 560 1 560
Bore x stroke (mm) 73.7 x 82 75 x 88.3 75 x 88.3 75 x 88.3
Maximum power: EU standard (kW) 50 66 68 66 82
Maximum power engine speed (rpm) 4 000 4 000 4 000 4 000
Maximum torque: EU standard (Nm) 160 215 230 215 270
Maximum torque engine speed (rpm) 2 000 1 750 1 750 1 750
Fuel Diesel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes Yes
Particle emission fi lter No Yes No Yes No Yes

GEARBOXES Manual
(5-speed) Manual
(5-speed) Manual
(5-speed) Manual
(6-speed)

OIL CAPACITIES (in litres)

Engine (with fi lter replacement) 3.75 3.25 3.25 3.25
Gearbox - Final drive 1.9 1.9 1.9 1.9
* Not available on SW and SW Outdoor.

10
161
The GTW and towed load values indicated apply up to a maximum altitude of 1 000 metres; the towed load mentioned must
be reduced by 10 % for each additional 1 000 metres of alti tude.
The speed of a towing vehicle must not exceed 60 mph (100 k m/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the pe rformance of the vehicle in order to protect the engine; when
the ambient temperature is higher than 37 °C, limit the we ight towed.
SALOON WEIGHTS AND TOWED LOADS (in kg)

Petrol engines
1.4 litre 75 hp 1.4 litre 16V 90 hp

Gearboxes
Manual "2 Tronic"
- Kerb weight 1 300 - 1 288 - 1 232 1 241 - 1 231
- Payload 320 - 292 - 338 409 - 399
- Gross vehicle weight (GVW) 1 620 - 1 580 - 1 570 1 650 - 1 630
- Gross train weight (GTW)
on a 12 % gradient 2 400 2 580
- Braked trailer (within GTW limit)

on a 10 % or 12 % gradient 780 - 820 - 830 930 - 95 0

on an 8 % gradient 830 - 870 950 - 970
- Braked trailer *** (with load transfer within GTW limit) 950 1 150
- Unbraked trailer 600 - 600 - 590 600
- Recommended nose weight 38 - 38 - 46 46
*** The weight of the braked trailer may be in creased, within the GTW limit, on condition that th e GVW of the towing vehicle is reduced
by the same amount; warning, towing using a lightly loaded towing vehicle may adversely affect its road holding performance.

10
162
TECHNICAL DATA
SALOON WEIGHTS AND TOWED LOADS (in kg)

Petrol engines
1.4 litre VTi 16V 95 hp

Gearboxes
Manual
- Kerb weight 1 253 - 1 240
- Payload 387 - 400
- Gross vehicle weight (GVW) 1 640
- Gross train weight (GTW)
on a 12 % gradient 2 580
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 940
on an 8 % gradient -
- Braked trailer *** (with load transfer within GTW limit) 1 150
- Unbraked trailer 600
- Recommended nose weight 46
The GTW and towed load values indicated apply up to a maximum altitude of 1 000 metres; the towed load mentioned must
be reduced by 10 % for each additional 1 000 metres of alti tude.
The speed of a towing vehicle must not exceed 60 mph (100 k m/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the pe rformance of the vehicle in order to protect the engine; when
the ambient temperature is higher than 37 °C, limit the we ight towed.
*** The weight of the braked trailer may be in
creased, within the GTW limit, on condition that th e GVW of the towing vehicle is reduced
by the same amount; warning, towing using a lightly loaded towing vehicle may adversely affect its road holding performance.

10
163

SALOON WEIGHTS AND TOWED LOADS (in kg)

Petrol engines
1.6 litre VTi 16V 120 hp
1.6 litre THP 16V
150 hp

Gearboxes
Manual Auto. Manual
- Kerb weight 1 275 1 321 - 1 312 1 370 - 1 356
- Payload 375 - 365 374 - 366 340 - 344
- Gross vehicle weight (GVW) 1 650 - 1 640 1 695 - 1 678 1 710 - 1 700
- Gross train weight (GTW)
on a 12 % gradient 2 600 2 645 - 2 638 2 640
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 950 - 960 950 - 960 930
on an 8 % gradient 1 000 - 1 010 1 000 - 1 010 1 000
- Braked trailer *** (with load transfer within GTW limit) 1 150 1 150 1 150
- Unbraked trailer 600 600 600
- Recommended nose weight 46 46 46
The GTW and towed load values indicated apply up to a maximum altitude of 1 000 metres; the towed load mentioned must
be reduced by 10 % for each additional 1 000 metres of alti tude.
The speed of a towing vehicle must not exceed 60 mph (100 k m/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the pe rformance of the vehicle in order to protect the engine; when
the ambient temperature is higher than 37 °C, limit the we ight towed.
*** The weight of the braked trailer may be in
creased, within the GTW limit, on condition that th e GVW of the towing vehicle is reduced
by the same amount; warning, towing using a lightly loaded towing vehicle may adversely affect its road holding performance.

10
168
TECHNICAL DATA
SALOON WEIGHTS AND TOWED LOADS (in kg)

Diesel engines
1.4 litre Turbo
HDI 70 hp
1.6 litre Turbo
HDI 90 hp
1.6
litre Turbo HDI
90 hp 99g
1.6 litre Turbo
HDI 110 hp

Gearboxes
Manual Manual Manual Manual
- Kerb weight
1 261 - 1 251 - 1 269 1 280 - 1 272 - 1 290 1 260 - 1 279 1 328 - 1 319 - 1 358
- Payload 399 - 369 - 341 420 - 408 - 340 445 - 450 382 - 391 - 323
- Gross vehicle weight (GVW)
1 660 - 1 620 - 1 610 1 700 - 1 680 - 1 630 1 630 - 1 654 1 710 - 1 710 - 1 681
- Gross train weight (GTW)
on a 12 % gradient 2 600 2 650 1 630 - 1 65 4 2 690
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 940 - 980 - 990 950 - 970 - 1 020
980
on an 8 % gradient 940 - 980 980 - 1 000
1 030
- Braked trailer ** (with load transfer within GTW limit) 1 150 1 150 1 150 1 150
- Unbraked trailer 600 600 600 600
- Recommended nose weight 46 46 46 46
The GTW and towed load values indicated apply up to a maximum altitude of 1 000 metres; the towed load mentioned must
be reduced by 10 % for each additional 1 000 metres of alti tude.
The speed of a towing vehicle must not exceed 60 mph (100 k m/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the pe rformance of the vehicle in order to protect the engine; when
the ambient temperature is higher than 37 °C, limit the we ight towed.
** The weight of the braked trailer may be inc
reased, within the GTW limit, on condition that the GVW of the towing vehicle is reduced
by the same amount; warning, towing using a lightly loaded towing vehicle may adversely affect its roadholding performance.

10
164
TECHNICAL DATA
SW WEIGHTS AND TOWED LOADS (in kg)

Petrol engines
1.4 litre 75 hp 1.4 litre VTi 16V 95 hp

Gearboxes
Manual Manual
- Kerb weight 1 271 1 290
- Payload 371 401
- Gross vehicle weight (GVW) 1 642 1 691
- Gross train weight (GTW)
on a 12 % gradient 2 422 2 591
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 780 900
on an 8 % gradient 800 900
- Braked trailer *** (with load transfer within GTW limit) 1 045 1 150
- Unbraked trailer 600 600
- Recommended nose weight 42 46
The GTW and towed load values indicated apply up to a maximum altitude of 1 000 metres; the towed load mentioned must
be reduced by 10 % for each additional 1 000 metres of alti tude.
The speed of a towing vehicle must not exceed 60 mph (100 k m/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the pe rformance of the vehicle in order to protect the engine; when
the ambient temperature is higher than 37 °C, limit the we ight towed.
*** The weight of the braked trailer may be in
creased, within the GTW limit, on condition that th e GVW of the towing vehicle is reduced
by the same amount; warning, towing using a lightly loaded towing vehicle may adversely affect its road holding performance.

10
165

SW WEIGHTS AND TOWED LOADS (in kg)

Petrol engines
1.6 litre VTi 16V 120 hp

Gearboxes
Manual Auto.
- Kerb weight 1 302 1 335
- Payload 403 402
- Gross vehicle weight (GVW) 1 705 1 737
- Gross train weight (GTW)
on a 12 % gradient 2 605 2 687
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 900 950
on an 8 % gradient 950 950
- Braked trailer *** (with load transfer within GTW limit) 1 150 1 150
- Unbraked trailer 600 600
- Recommended nose weight 46 46
The GTW and towed load values indicated apply up to a maximum altitude of 1 000 metres; the towed load mentioned must
be reduced by 10 % for each additional 1 000 metres of alti tude.
The speed of a towing vehicle must not exceed 60 mph (100 k m/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the pe rformance of the vehicle in order to protect the engine; when
the ambient temperature is higher than 37 °C, limit the we ight towed.
*** The weight of the braked trailer may be in
creased, within the GTW limit, on condition that th e GVW of the towing vehicle is reduced
by the same amount; warning, towing using a lightly loaded towing vehicle may adversely affect its road holding performance.