clutch SATURN SKY 2007 User Guide

Page 268 of 384

Brakes
Brake Fluid
Your brake master
cylinder reservoir is
lled with DOT-3 brake
uid. SeeEngine
Compartment Overview
on page 242for the
location of the reservoir.
There are only two reasons why the brake uid
level in the reservoir might go down. The rst
is that the brake uid goes down to an acceptable
level during normal brake lining wear. When
new linings are put in, the uid level goes back
up. The other reason is that uid is leaking out of
the brake and/or clutch hydraulic system. If it
is, you should have your brake and/or clutch
system xed, since a leak means that sooner or
later your brakes and/or clutch will not work
well, or will not work at all.So, it is not a good idea to top off your brake/clutch
uid. Adding uid will not correct a leak. If you
add uid when your brake linings are worn, then
you will have too much uid when you get
new brake linings. You should add or remove
uid, as necessary, only when work is done on
the brake/clutch hydraulic system.
{CAUTION:
If your vehicle has too much brake uid, it
can spill on the engine. The uid will burn
if the engine is hot enough. You or others
could be burned, and your vehicle could
be damaged. Add brake uid only when
work is done on the brake and/or clutch
hydraulic system.
When your brake uid falls to a low level, your
brake warning light will come on. SeeBrake
System Warning Light on page 134.
268
ProCarManuals.com

Page 269 of 384

What to Add
When you do need brake uid, use only DOT-3
brake uid. Use new brake uid from a sealed
container only. SeeRecommended Fluids
and Lubricants on page 345.
Always clean the brake uid reservoir cap and
the area around the cap before removing it. This
will help keep dirt from entering the reservoir.
{CAUTION:
With the wrong kind of uid in the
brake/clutch system, the brakes/clutch
may not work well, or they may not even
work at all. This could cause a crash.
Always use the proper brake uid.Notice:
Using the wrong uid can badly damage
brake/clutch system parts. For example,
just a few drops of mineral-based oil,
such as engine oil, in the brake/clutch
hydraulic system can damage brake/clutch
system parts so badly that they will
have to be replaced. Do not let someone
put in the wrong kind of uid.
If you spill brake uid on your vehicle’s
painted surfaces, the paint nish can
be damaged. Be careful not to spill brake
uid on your vehicle. If you do, wash it
off immediately. SeeWashing Your Vehicle
on page 318.
269
ProCarManuals.com

Page 327 of 384

Fuses Usage
6 Amplier
7 Cluster
8 Ignition Switch, PassKey III+
9 Stoplamp
10Climate Control System,
PassKey III+
11 Empty
12 Spare
13 Airbag
14 Spare
15 Wiper
16Climate Control System,
Automatic Occupant Sensing
Module, Clutch Switch, Crank
Relay, Instrument Panel Cluster
17 Empty
18 EmptyFuses Usage
19Electric Power Steering,
Steering Wheel Controls
20 Spare
21 Spare
22 Empty
23 Radio
24 Sensing and Diagnostic Module
25Engine Control Module,
Transmission Control Module
26 Door Locks
27 Interior Lamps
28 Steering Wheel Control Backlighting
29 Power Windows
30 Climate Control System
31 Empty
32 Retained Accessory Power
327
ProCarManuals.com

Page 329 of 384

Fuses Usage
10 Trunk
11 Trunk
12 Empty
13 Fuel Pump
14 Rear Defogger Relay
15 Air Conditioning Clutch Relay
16 Empty
17 Empty
18 Trunk Release Relay
19 Fuel Pump Relay
20 Empty
21 Mirrors
22 Air Conditioning
23 Empty
24Cooling Fan 2 Relay (LE5);
Empty (LNF)
25 Fuse Puller
26 Powertrain Relay
27 EmptyFuses Usage
28Back-up Lamps Relay
(Automatic Transmission);
Empty (Manual Transmission)
29 Data Link Connector
30 Outlet
31Back-up Lamps
(Automatic Transmission);
Empty (Manual Transmission)
32 Empty (LE5); Vacuum Pump (LNF)
33 Emissions
34 Crank Relay
35 Empty
36 Empty
37 Power Seat
38Empty (LE5); Vacuum Pump
Relay (LNF)
39 Empty
40 Cooling Fan 1 (LE5); Empty (LNF)
41Empty (LE5); Turbo, Cam
Phaser (LNF)
42 Engine Control Module
329
ProCarManuals.com

Page 342 of 384

At Least Once a Year
Starter Switch Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough
room around the vehicle.
2. Firmly apply both the parking brake and the
regular brake. SeeParking Brake on page 86.
Do not use the accelerator pedal, and be
ready to turn off the engine immediately if
it starts.3. On automatic transmission vehicles,
try to start the engine in each gear. The
vehicle should start only in PARK (P) or
NEUTRAL (N). If the vehicle starts in
any other position, contact your Saturn
retailer for service.
On manual transmission vehicles, put the shift
lever in NEUTRAL, push the clutch pedal
down halfway, and try to start the engine.
The vehicle should start only when the clutch
pedal is pushed down all the way to the
oor. If the vehicle starts when the clutch pedal
is not pushed all the way down, contact your
Saturn retailer for service.
342
ProCarManuals.com

Page 345 of 384

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number, or specication may be obtained
from your retailer.
Usage Fluid/Lubricant
Engine Oil
(2.4L L4
engine)Engine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. GM Goodwrench
®
oil meets all the requirements for
your vehicle. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on page 245.
Usage Fluid/Lubricant
Engine Oil
(2.0L L4
engine)The engine requires a special
engine oil meeting GM Standard
GM4718M. Oils meeting this
standard may be identied with the
American Petroleum Institute (API)
Certied for Gasoline Engines
starburst symbol. However, not all
synthetic API oils with the starburst
symbol will meet this GM standard.
You should look for and use only
an oil that meets GM Standard
GM4718M. GM Goodwrench
®oil
meets all the requirements for your
vehicle. For the proper viscosity,
seeEngine Oil on page 245.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 255.
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Hydraulic
Clutch SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184,
in Canada 89021186).
345
ProCarManuals.com

Page 373 of 384

Care of
Safety Belts............................................. 318
Your CD Player........................................ 190
Your CDs ................................................. 190
CD, MP3 ..................................................... 179
Center Console Storage Area...................... 100
Chains, Tire................................................. 303
Charging System Light................................ 133
Check
Engine Light............................................ 138
Checking Things Under the Hood................ 240
Chemical Paint Spotting.............................. 322
Child Restraints
Child Restraint Systems............................. 34
Infants and Young Children........................ 30
Lower Anchors and Tethers for Children..... 38
Older Children........................................... 28
Securing a Child Restraint in the
Passenger Seat Position......................... 38
Cigarette Lighter.......................................... 122
Cleaning
Aluminum or Chrome-Plated Wheels........ 320
Convertible Top........................................ 320Cleaning (cont.)
Exterior Lamps/Lenses............................. 319
Fabric/Carpet........................................... 316
Finish Care.............................................. 319
Inside of Your Vehicle .............................. 315
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 317
Leather.................................................... 317
Tires........................................................ 321
Underbody Maintenance........................... 322
Washing Your Vehicle .............................. 318
Weatherstrips........................................... 318
Windshield and Wiper Blades................... 319
Climate Control System............................... 122
Outlet Adjustment..................................... 126
Clutch, Hydraulic......................................... 254
Collision Damage Repair............................. 364
Content Theft-Deterrent................................. 73
Control of a Vehicle..................................... 196
Convertible Top........................................... 100
Coolant
Engine Temperature Warning Light........... 137
Surge Tank Pressure Cap........................ 258
373
ProCarManuals.com

Page 377 of 384

Hood
Checking Things Under............................ 240
Release................................................... 241
Horn............................................................ 110
How to Use This Manual................................ 4
How to Wear Safety Belts Properly............... 18
Hydraulic Clutch.......................................... 254
I
Ignition Positions........................................... 78
Infants and Young Children, Restraints.......... 30
Ination - Tire Pressure............................... 292
Inator Kit, Tire........................................... 304
Instrument Panel
Overview.................................................. 108
Instrument Panel (I/P)
Brightness................................................ 120
Cluster..................................................... 128
J
Jump Starting.............................................. 272
K
Keyless Entry System................................... 62
Keys............................................................. 60
L
Labeling, Tire Sidewall................................. 287
Lamps
Battery Run-Down Protection................... 121
Fog .......................................................... 120
Mirror Reading......................................... 120
LATCH System
Child Restraints......................................... 38
Latches, Seatback......................................... 12
License Plate Lamps................................... 282
Light
Airbag Readiness..................................... 130
Anti-Lock Brake System Warning............. 135
Brake System Warning............................. 134
Charging System..................................... 133
Electronic Stability Control........................ 136
Engine Coolant Temperature Warning....... 137
Fog Lamp................................................ 142
377
ProCarManuals.com

Page:   < prev 1-10 11-20