torque TOYOTA GT86 2020 Warranties & Maintenance Guides (in English)

13Your Warranties in Detail
WARRANTY
NEW VEHICLE LIMITED WARRANTY
WHAT IS COVERED
AND HOW LONG
Basic Warranty
This warranty covers repairs and
adjustments needed to correct defects
in materials or workmanship of any
part supplied by Toyota, subject to the
exceptions indicated under “What
Is Not Covered” on pages 14–15.
Coverage is for 36 months or 36,000 miles,
whichever occurs rst, with the exception of
wheel alignment and wheel balancing, which
are covered for 12 months or 12,000 miles,
whichever occurs rst.
Powertrain Warranty
This warranty covers repairs needed to
correct defects in materials or workmanship
of any component listed below and in the
next column and supplied by Toyota, subject
to the exceptions indicated under “What Is
Not Covered” on pages 14–15.
Coverage is for 60 months or 60,000 miles,
whichever occurs rst.
Engine
Cylinder block and head and all internal
parts, timing gears and gaskets, timing
chain/belt and cover, ywheel, valve
covers, oil pan, oil pump, engine mounts,
turbocharger housing and all internal parts,
supercharger housing and all internal
parts, engine control computer, water
pump, fuel pump, seals and gaskets.
Transmission and Transaxle
Case and all internal parts, torque

converter, clutch cover, transmission
mounts, transfer case and all internal
parts, engine control computer, seals
and gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts,
axle shafts, drive shafts, constant velocity
joints, front hub and bearings, seals
and gaskets.
Rear-Wheel-Drive System
A xle housing and all internal parts,
propeller shafts, U-joints, axle shafts,
drive shafts, bearings, supports, seals
and gaskets.
Restraint Systems Warranty
This warranty covers repairs needed to
correct defects in materials or workmanship
of any seatbelt or air bag system supplied by
Toyota, subject to the exceptions indicated
under “What Is Not Covered” on pages 14–15.
Coverage is for 60 months or 60,000 miles,
whichever occurs rst.
For vehicles sold and registered in the
state of Kansas, the warranty for seatbelts
and related components is 10 years,
regardless of mileage.

37Maintenance Log
MAINTENANCE
SCHEDULED MAINTENANCE
Driving on dirt
or dusty roads
Driving on dirt
or dusty roads
Automatic transmission uid
Brake uid
Brake lines and hoses
Brake pads and discs
Cabin air lter Bolts and nuts
on chassis
Normal Normal Normal
Normal Severe
Severe SevereMiles (000)
Month
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
When operating in high humidity areas or in mountainous areas, replace e\
very 15,000 miles or
15 month, whichever occurs rst.
When operating in areas where road salts or other corrosive materials ar\
e used; if living in coastal areas,
inspect every 7,500 miles or 7.5 months, whichever occurs rst.
Note: Driving in heavy trafc, on dirt roads or in urban, dusty or de\
sert areas may shorten the life of the cabin air lter.
Replacement may be needed if you notice reduced airow from the air c\
onditioner and heater or if the windows fog
easily when you use the “fresh” mode. Consult your dealer if any o\
f these conditions occur.After the described period, continue to follow the described maintenance\
at the recommended intervals. I = Inspect; R = Replace, Change, Rotate Tires or Lubricate; T = Tighten\
to Specied Torque
Maintenance Item
I IIRII
I I
I II
I
I
I
I II I
R R
R R
R
R
R R
R
Repeated short driving distance; driving on rough and/or muddy roads; dr\
iving in areas where
road salts or other corrosive materials are used; if living in coastal a\
reas, inspect every
7,500 miles or 7.5 months, whichever occurs rst.
T T T T T T T T T T T T
Maintenance Interval (Miles or Number of Months, Whichever Occurs First\
)

38Maintenance Log
MAINTENANCE
SCHEDULED MAINTENANCE
Driving on dirt
or dusty roads
Inspect
Clutch uid and system operations
Drive shaft boots
Engine oil and oil lter
Engine coolant
Engine air lter Drive belt
Normal
Normal
Normal Severe Severe
ReplaceMiles (000)
Month
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
Driving on dirt
or dusty roads
Repeated short driving distance; driving on rough and/or muddy roads;
if driving in extremely cold weather; in areas where road salts or other\
corrosive materials are used;
if living in coastal areas, inspect every 7,500 miles or 7.5 months, whi\
chever occurs rst.
Repeated short distance driving; driving in extremely cold weather, repl\
ace every 3,750 miles
or 3.75 months, whichever occurs rst.
Note: When the vehicle is used in extremely dusty conditions, the air \
lter cleaner element should be replaced more often.Note: See the“Explanation of Maintenance Items” section in the bac\
k of this guide for more information.
Maintenance Item
I IIIII
I
I I
I
First replace at 135,000 miles or 132 months, then replace at every 75,0\
00 miles or 72 months,
whichever occurs rst.
R RR
III RIII RIII RRRRRRRRRRRR
R
I
IIII
I
II
After the described period, continue to follow the described maintenance\
at the recommended intervals.
I = Inspect; R = Replace, Change, Rotate Tires or Lubricate; T = Tighten\
to Specied Torque
Maintenance Interval (Miles or Number of Months, Whichever Occurs First\
)

39Maintenance Log
MAINTENANCE
SCHEDULED MAINTENANCE
Exhaust pipes and mountings
Fuel lines and
connections,
fuel tank
vapor vent system hoses
and fuel tank
band
Fuel lter
Fuel tank cap gasket
Manual transmission oil
Parking brake lining
and drums
Rear differential oil
Spark plugs Driver’s oor mat proper installation
Normal Normal
Severe Normal
SevereMiles (000)
Month
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
Maintenance Item
IIIIII
I II
I
II
I II
R
R
I
I I
When operating in areas where road salts or other corrosive materials ar\
e used; if living in coastal areas,
inspect every 7,500 miles or 7.5 months, whichever occurs rst.
When operating in areas where road salts or other corrosive materials ar\
e used; if living in coastal areas,
inspect every 7,500 miles or 7.5 months, whichever occurs rst.
Note: When operating the vehicle in extremely cold or hot weather condit\
ions, contamination of the lter may occur andlter replacement should be performed more often.
I
I
I
I
I
I I
I I
IIIIIIIII
After the described period, continue to follow the described maintenance\
at the recommended intervals.
I = Inspect; R = Replace, Change, Rotate Tires or Lubricate; T = Tighten\
to Specied Torque
Maintenance Interval (Miles or Number of Months, Whichever Occurs First\
)

40Maintenance Log
MAINTENANCE
SCHEDULED MAINTENANCE
NormalMiles (000)
Month
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
Driving on dirt
or dusty roads Driving on dirt
or dusty roads
Severe Severe
When operating on rough and/or muddy roads; driving in extremely cold we\
ather; in areas where road
salts or other corrosive materials are used; if living in coastal areas,\
inspect every 7,500 miles
or 7.5 months, whichever occurs rst.
When operating on rough and/or muddy roads; driving in extremely cold we\
ather; in areas where road
salts or other corrosive materials are used; if living in coastal areas,\
inspect every 7,500 miles
or 7.5 months, whichever occurs rst.
Steering gear
Suspension ball joints
and dust covers
Normal
Tire rotation
Wiper bladesMaintenance Item
After the described period, continue to follow the described maintenance\
at the recommended intervals.I = Inspect; R = Replace, Change, Rotate Tires or Lubricate; T = Tighten\
to Specied Torque
Maintenance Interval (Miles or Number of Months, Whichever Occurs First\
)

43Maintenance Log
MAINTENANCE
EXPLANATION OF MAINTENANCE ITEMS
Engine Oil and Oil Filter
Replace the oil lter and drain and rell
the engine oil at specied intervals. For
recommended oil grade and viscosity,
refer to the Owner’s Manual.
Exhaust Pipes and Mountings
Visually inspect the exhaust pipes, mufer
and hangers for cracks, deterioration and
damage. Start the engine and listen
carefully for any exhaust gas leakage.
Tighten connections or replace parts
as necessary.
Fuel Lines and Connections,
Fuel Tank Vapor Vent System
Hoses and Fuel Tank Band
Visually inspect for corrosion, damage,
cracks, and loose or leaking connections.
Tighten connections or replace parts
as necessary.
Fuel Tank Cap Gasket
Visually inspect for cracks, deterioration
and damage and replace if necessary.
Nuts and Bolts on Chassis
and Body
Retighten the seat-mounting bolts and
front /rear suspension member retaining
bolts to specied torque.
Spark Plugs
Replace at specied intervals. Install new
plugs of the same type as originally
equipped. A qualied technician should
perform this operation.
Steering Gear
Inspect for signs of leakage. If you
discover any leakage, have it repaired
immediately by a qualied technician.
Steering Linkage and Boots
With the vehicle stopped, check for
excessive freeplay in the steering wheel.
Inspect the linkage for bending and
damage and the dust boots for
deterioration, cracks and damage. Replace
any damaged parts. A qualied technician
should perform these operations.
Tire Rotation
Tires should be rotated according to the
instructions in the Owner’s Manual. When
rotating tires, check for damage and
uneven wear. Replace if necessary.