troubleshooting BMW MOTORRAD K 1200 LT 2002 Rider's Manual (in English)

3
Introduction
i
Starting – Riding – Parking
First time out ................. 60-61
Important notes ............. 62-63
Side stand ..................... 64-65
Main (centre) stand ........ 66-67
Running in ..................... 68-69
Before you start ................... 70
Starting ............................... 71
Warning lights................ 72-73
Riding and changing
gear ............................... 74-75
Brake system
- general ........................ 76-77
Brake system - with
BMW Integral ABS......... 78-84
BMW Integral ABS
- troubleshooting chart ........ 85Arrive safely
Dependability .................86-87
Service worldwide ............... 88
Protecting the environment . 89
BMW rider’s equipment ....... 90
BMW motorcycle
accessories ......................... 91
Training means extra safety. 92
Concluding thoughts .......... 93
Contents
10LTbkg4.bk Seite 3 Dienstag, 27. August 2002 8:28 08

3
85
Starting – Riding – Parking
BMW Integral ABS - Troubleshooting
Warning light,
generaleWarning light,
ABSl /
brake failureMalfunctions
OFF ON Only RESIDUAL BRAKING FUNCTION
available in both circuits (
b 81)
OFF Flashes at
1HzABS not available
Pull-away test not completed (
b 82)
OFF Flashes at
4HzOnly RESIDUAL BRAKING FUNCTION
available in both circuits (
b 81)
Self-diagnosis not completed (b 82)
ON OFF Tail light/brake light defective
(Maintenance Instructions, b Chapter 2)
ON Flashes at
1HzAt least one brake circuit without
ABS (
b 84)
ON Flashes at
4HzAt least one brake circuit in RESIDUAL
BRAKING FUNCTION mode (
b 81)
Alternate flas-
hing at 1 HzAlternate flas-
hing at 1 HzFluid level in BMW Integral ABS too low.
Check the motorcycle as follows:
–Ignition OFF: is brake pressure OK at
the brake levers?
–Are the brakes acting on both wheels?
–Is the brake system leaktight, no signs
of brake fluid escaping?
The brake system is defective if the test
outcome is negative.
Alternate flas-
hing at 4 HzAlternate flas-
hing at 4 HzFluid level in the BMW Integral ABS is too
low, perform the checks listed above.
Only RESIDUAL BRAKING FUNCTION
available in at least one circuit (
b 81)
d Warning:
Do not ride the motorcycle if you
have any doubts about the
dependability of the brake sys-
tem.
10LTbkg4.bk Seite 85 Dienstag, 27. August 2002 8:28 08

94
Index
i
AABS, 80
Adjusting deflectors, 17
Adjusting windscreen, 17
Aerial, 4
Anti-lock brake system
notes, 78, 80-85
Audio system controls
passenger, 6
BBMW Integral ABS, 78-84
brake fluid level, 50
brake fluid reservoir, front, 6
brake fluid reservoir, rear, 6
troubleshooting chart, 85
warning lights, 10
Brake pads
running in, 69
Brake pads, checking, 47
Brake servo, 80
Brake system
general, 46, 47
with BMW Integral
ABS, 48, 49, 50
Brake system, checking, 46
CCases
opening/closing, 30
Cassette player/radio, 9
Catalytic converter, 63
safety instructions, 63CD changer, 7
Changing gear, 75
Checklist, 39
Clock, 10
Clock (in cockpit), 10
Clutch
fluid level, 51
Clutch lever, adjusting, 44
Cockpit
general view, 8, 9
Coolant level
checking, 59
Coolant reservoir, 5
Coolant temperature, 72
Coolant temperature gauge, 9
Cruise control
notes, 21
operation, 22, 23, 24
switch, 14
EEmergency off (kill) switch for
ignition, 15, 70
Engine oil, 40
oil filler neck, 41
Engine oil pressure
telltale light, 72
Engine speed, 74
Environmental protection, 89
A – E
10LTbkg4.bk Seite 94 Dienstag, 27. August 2002 8:28 08

97
Index
i
Seat
adjusting, 33
removing, 33
Seat heating, 7, 37
Seat opener, 5
Service worldwide, 88
Side stand, 64, 65, 70
Speedometer, 8
Spring preload, 4, 52
Starter button, 15
Starter switch, 15
Starting, 71
Stowage compartment
hand lamp, 6
TTank cap, 6
Telltale and warning lights
ABS, 10, 72
battery charge current, 11, 73
coolant temperature, 11, 73
cruise control, 10
engine oil pressure, 11, 72
fuel level, 11, 72
high-beam headlight, 11
neutral, 10
reverser, 10
turn indicator, right, 10
turn indicator,left, 10
Tightening torques
topcase, rear seat backrest, 36
Toolkit, 5
Tools, 5Topcase
opening/closing, 31
Tread depth, tyres, 53, 54
Trip meter, 8
Troubleshooting ABS, 85
Turn indicator cancel switch, 15
Turn indicator repeaters, 10
Turn indicator switch, left, 14
Turn indicator switch, right, 15
Type plate, 4
Tyres
running in, 69
tread depth, 53
tyre pressures, 54VValve caps, 54
WWarning lights
ABS, 72
battery charge current, 73
coolant temperature, 73
engine oil pressure, 72
fuel level, 72
general, 72
Warnings
braking, 76
Windscreen adjuster
switch, 14
S – Z
10LTbkg4.bk Seite 97 Dienstag, 27. August 2002 8:28 08