spare wheel CHERY TIGGO 2009 Service Repair Manual

Downloaded from www.Manualslib.com manuals search engine GENERAL INFORMATION
Description
Tires are designed and engineered for each specific vehicle. They provide the best overall performance for normal
operation. The ride and handling characteristics match the vehicle’s requirements. With proper care they will give
excellent reliability, traction, skid resistance, and tread life.
Tire Identification
•Tire type, size, load index and speed rating are encoded in the letters and numbers imprinted on the side wall
of the tire.
Spare Tire
• A full size spare tire and wheel assembly is standard equipment on this vehicle. The original tire should be
repaired or replaced at the first opportunity, then reinstalled.
Operation
Driving habits have more effect on tire life than any other factor. Careful drivers will obtain, in most cases, much
greater mileage than severe use or careless drivers. A few of the driving habits which will shorten the life of any tire
are:
•Rapid acceleration
• Severe application of brakes
• High-speed driving
• Taking turns at excessive speeds
• Striking curbs and other obstacles
• Operating vehicle with over or under inflated tire pressures
Specifications
Torque Specifications
DESCRIPTION TORQUE (N·m)
Wheel Mounting Nuts 110
Tire Specifications
TIRE SPECIFICATIONTIRE SIZE - 215TIRE SIZE - 235
Sectional Width 215235
Aspect Ratio 7060
Wheel Radius R16R16
Speed Rating 97S100H
10–48Chery Automobile Co., Ltd.

Downloaded from www.Manualslib.com manuals search engine Non-Directional Tires
The suggested method of tire rotation is shown. Other rotation methods can be used, but they will not provide all the
tire longevity benefits.
NOTE :
Only the four-tire rotation method may be used if the vehicle is equipped with a compact or temporary spare tire.1. Raise and support the vehicle.
2. Remove the wheel mounting nuts and the wheel assembly.
3. Rotate the tire to the desired location.
CAUTION:
Use caution not to damage wheel weights during tire and wheel installation.
4. Install the wheel assembly and install the wheel mounting nuts. (Tighten: Wheel mounting nuts to 110 N·m)
Directional Tires
Some vehicles may be fitted with special high-performance tires having a directional tread pattern. These tires are
designed to improve traction on wet pavement. To obtain the full benefits of this design, the tires must be installed so
that they rotate in the correct direction. This is indicated by arrows on the tire sidewalls. When being installed, extra
care is needed to ensure that this direction of rotation is maintained.
1. Remove the wheel mounting nuts and the wheel assembly.
2. Rotate the tire to the desired location.
CAUTION:
Use caution not to damage wheel weights during tire and wheel installation.
3. Install the wheel assembly and install the wheel mounting nuts. (Tighten: Wheel mounting nuts to 110 N·m)
ON-VEHICLE SERVICE
PZSM100039T
10
10–54Chery Automobile Co., Ltd.

Downloaded from www.Manualslib.com manuals search engine S
Scuff Plate, Body Interior..................... 15-14
Seat Belt Slider Track, Seat Belt System ...........14-53
Seat Belt System ........................... 14-50
Seats, Body Interior ........................ 15-104
Service Information ...........................1-1
Spare Tire Support, Body Exterior ..............15-205
Spare Tire Support, Body Exterior .................205
Spark Plug 1.6L & 1.8L & 2.0L, Ignition Control .....3-574
Spark Plug 2.4L, Ignition Control ................3-575
Spark Plug Wire 1.6L & 1.8L & 2.0L, Ignition Control .......................... 3-573
Spark Plug Wire 2.4L, Ignition Control ............3-574
Speed Control System, 2.0L Engine Controls ........3-432
Starter Motor Assembly, Starting System ............5-9
Starting System .............................5-1
Stationary Glass, Body Exterior ................15-217
Steering Column ............................ 11-8
Steering Column Shaft, Steering Column ...........11-15
Steering Column Shroud, Steering Column .........11-14
Steering Gear ............................. 11-18
Steering Gear - LHD, Steering Gear ..............11-21
Steering Gear - RHD, Steering Gear ..............11-25
Steering System ............................ 11-1
Steering Wheel, Steering Column ................11-12
Suction Line, System Plumbing .................13-45
Sun Visor, Body Interior ...................... 15-14
Sunroof Control Module, Body Exterior ...........15-230
Sunroof Glass, Body Exterior ..................15-229
Sunroof Motor, Body Exterior .................15-230
Sunroof Sun Visor, Body Exterior ...............15-229
Sunroof, Body Exterior ...................... 15-224
Symptom Diagnostic Tests, 2.4L Engine Symptom Diagnosis .............................. 3-544
System Controls ........................... 13-18
System Plumbing .......................... 13-32
T
Tail/Backup/Stop Lamp, Body Exterior ............15-194
Thermostat, Cooling System ....................6-14
Throttle Control Actuator, 2.4L Engine Controls ......3-538
Throttle Position Sensor (TPS), 2.4L Engine Controls . . 3-540
Tie Rod, Steering Gear ....................... 11-29
Timing Belt Automatic Tensioner, 2.4L Engine Mechanical
............................. 2-196
Tire Repair, Wheels and Tires ..................10-51
Tire Rotation, Wheels and Tires .................10-53
Transaxle Clutch Housing Assembly, 5-Speed Manual Transaxle ............................... 8-301
Transaxle Control Module (TCM), DP0 Automatic Transaxle ....................... 8-142
Transaxle Main Housing Assembly, 5-Speed Manual Transaxle ............................... 8-305
Transaxle, 5-Speed Manual Transaxle .............8-270
Transfer Case (4x4) ......................... 8-326
Transfer Case Unit Repair, Transfer Case (4x4) ......8-329
Transfer Case, Transfer Case (4x4) ..........8-328, 8-329
Turn Signal Lamp, Body Exterior ...............15-195
U
Unit Repair, Base Brakes ..................... 12-27
Unit Repair, Front Suspension ..................10-21
Upper Balance Shaft Timing Belt, 2.4L Engine Mechanical ............................. 2-198
Upper Balance Shaft, 2.4L Engine Mechanical .......2-204
V
Valve & Valve Guides, 1.6L & 1.8L Engine Mechanical . . 2-70
Valve & Valve Guides, 2.0L Engine Mechanical ......2-143
Valve & Valve Guides, 2.4L Engine Mechanical ......2-246
Valve Springs, 1.6L & 1.8L Engine Mechanical .......2-73
Valve Springs, 2.0L Engine Mechanical ............2-146
Valve Springs, 2.4L Engine Mechanical ............2-252
Vapor Canister 1.6L & 1.8L & 2.0L, Evaporative Emissions .............................. 3-585
Vapor Canister 2.4L, Evaporative Emissions .........3-586
Vehicle Clearance, Body Exterior ................15-154
Vehicle Fuse Box Information ..................16-37
Vehicle Ground Distribution .................... 16-27
Vehicle Harness Routing Maps, Vehicle Wiring Harness Layout .......................... 16-46
Vehicle Identification Number (VIN), Vehicle Information .............................. 1-10
Vehicle Information ...........................1-9
Vehicle Power Distribution .................... 16-12
Vehicle Service Preparation, Service Information .......1-3
Vehicle Speed Sensor, 1.6L & 1.8L Engine Controls . . . 3-221
Vehicle Wiring Harness Layout .................16-44
INDEX
AI
AI-7