warning light CHEVROLET CAVALIER 1997 3.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine Brakes
Brake Fluid
Your brake master cylinder
reservoir is here.
It is filled
with
DOT-3 brake fluid.
There are only two reasons why the brake fluid level in
the reservoir might go down. The first
is that the brake
fluid goes down to an acceptable level during normal
brake lining wear. When new linings
are put in, the fluid
level goes back up. The other reason is that fluid is
leaking out
of the brake system. If it is, you should have
your brake system fixed, since a leak means that sooner
or later your brakes won’t work well, or won’t work
at all.
So, it isn’t a good idea to “top off’ your brake fluid.
Adding brake fluid won’t correct a leak. If you add fluid
when your linings are worn, then you’ll have
too much
fluid when
you get new brake linings. You should add
(or remove) brake fluid, as necessary, only when work is
done on the b: * ‘lyd ; system. ..
A CAUTION:
have too much brake fluid, it can spill
on the engine. The fluid will burn if the engine
is hot enough. You or others could be burned,
and your vehicle could be damaged. Add brake
fluid only when work is done on the brake
hydraulic system.
When your brake fluid falls to a low level, your brake
warning light will come on. See “Brake System Warning
Light” in the Index.

Downloaded from www.Manualslib.com manuals search engine Brake Wear
Your Chevrolet has front disc brakes and rear drum brakes.
Disc brake pads have built-in wear indicators that make a high-pitched waming sound when the brake pads are worn
and new pads are needed. The sound may come and go or
be heard all the time your vehicle is moving (except when
you are pushing on the brake pedal fiiy).
The brake wear warning sound means that soon
your brakes won’t work well. That could lead to
an accident. When you hear the brake wear
warning sound, have your vehicle serviced.
NOTICE:
~ ~~~
Continuing to drive with worn-out brake pads
could result in costly brake repair.
Some driving conditions or climates may cause a brake
squeal when the brakes are first applied or lightly
applied. This does not mean something is wrong with
your brakes.
See “CaliperKnuckle Maintenance Inspection”
in
Section 7 of this manual under Part C “Periodic
Maintenance Inspections.”
Properly torqued wheel nuts are necessary to help
prevent brake pulsation. When tires are rotated, inspect
brake pads for wear and evenly torque wheel nuts in the
proper sequence to
GM specifications.
Your rear drum brakes don’t have wear indicators, but if
you ever hear a rear brake rubbing noise, have the rear
brake linings inspected. Also, the rear brake drums should be removed and inspected each time the tires
are removed for rotation or changing. When you
have the front brake pads replaced, have the rear brakes
inspected, too.
Brake linings should always be replaced as complete
axle sets.
See “Brake System Inspection” in Section
7
of this manual under Part C “Periodic
Maintenance Inspections.’’

Downloaded from www.Manualslib.com manuals search engine Uniform Tire Quality Grading
The following information relates to the system
developed by the United States National Highway
Traffic Safety Administration, which grades tires by
treadwear, traction and temperature performance. (This
applies only
to vehicles sold in the United States.) The
grades are molded on the sidewalls of most passenger
car tires. The Uniform Tire Quality Grading system
does not apply
to deep tread, winter-type snow tires,
space-saver or temporary use spare tires, tires with
nominal rim diameters
of 10 to 12 inches (25 to 30 cm),
or to some limited-production tires.
While the tires available on General Motors passenger
cars and light trucks may vary with respect to these
grades, they must also conform to Federal safety
requirements and additional General Motors Tire
Performance Criteria
(TPC) standards.
Treadwear
The treadwear grade is a comparative rating based on
the wear rate of the tire when tested under controlled
conditions on a specified government test course. For
example, a tire graded 150 would wear one and a half
(1 1/2) times as well on the government course as a tire
graded 100. The relative performance of tires depends
upon the actual conditions
of their use, however, and
may depart significantly from the norm due to variations
in driving habits, service practices and differences in
road characteristics and climate.
Traction -- A, B, C
The traction grades, from highest to lowest, are A, B, and
C, and they represent the tire’s ability to stop on wet
pavement as measured under controlled conditions on specified government test surfaces
of asphalt and concrete.
A tire marked C may have poor traction performance.
Warning: The traction grade assigned to this tire is based
on braking (straightahead) traction tests and does not
include cornering (turning) traction.
- 6-45

Downloaded from www.Manualslib.com manuals search engine Fuse
WIPER
ERLS
AIR BAG
EXT LAMP
PWR ACC
HVAC
RADIO
ALARM
CRUISE
L HDLP
CIG
Usage
Windshield Wipers,
Windshield Washers
Automatic Transaxle, Brake
Transaxle Shift Interlock, A/C
Compressor, Cruise Control,
Multiport Fuel Injection
Supplemental Inflatable
Restraint System
Exterior Lamps, Instrument
Panel Lights
Power Door Locks, Convertible
Top (Convertible Model)
Heater and A/C Control,
Anti-lock Brake System,
Engine Cooling Fan
Radio, Remote Keyless Entry
Alarm Module
- Interior Lamps,
Warning Chimes
Cruise Control
Left Headlamp Cigarette Lighter,
Horn, Interior
Lamps, Diagnostic Connector
Fuse
INST LPS
STOP HAZ
PWR WIN- DOW
PCM/IGN
INT LAMP
FOG LAMP
IGN
R HDLP
Usage
Instrument Panel Lights,
Warning Chimes
Exterior Lamps, Anti-Lock
Brake System, Cruise Control,
Turn Signals
Power Windows, Power Sunroof,
Convertible Top Controls
(Convertible Model)
(Circuit Breaker)
Powertrain Control Module
Alarm Module: Illuminated Entry,
Warning Chimes, Overhead
Lamps, Mapmeading Lamps,
Glove Box Lamp, Trunk Lamp,
Radio, Power Mirrors, Remote
Keyless Entry
Fog Lamps
(2-24 Only)
Engine Ignition
Right Headlamp
6-61

Downloaded from www.Manualslib.com manuals search engine 0 Section 9 Index
Adapter Kit. CD ............................... 3- 17
AirBag
....................................... 1-22
How Does it Restrain
.......................... 1-26
How it Works ................................ 1-24
Location
.................................... 1-24
Readiness Light
......................... 1-23. 2-68
Servicing
................................... 1-27
What Makes it Inflate
.......................... 1-25
What Will
You See After it Inflates ............... 1-26
When Should it Inflate
......................... 1-25
Aircleaner
.................................... 6-17
Air Conditioning
................................ 3-5
Air Conditioning Refrigerants ..................... 6-64
Alignment and Balance. Tire
...................... 6-46
Aluminum Wheels. Cleaning
...................... 6-55
Antenna. Fixed
................................. 3-25
Anti-Lock
Brake System Warning Light
................ 2-70. 4-7
Brakes
...................................... 4-7
Anti-Theft. Radio
.............................. 3-2 1
Appearance Care
............................... 6-48
Appearance Care Materials ....................... 6-57
Arbitration Program
.............................. 8-9 Ashtrays
...................................... 2-50
Audio Equipment. Adding
........................ 3-23
Audio Systems
.................................. 3-8
Auto-Down Window ............................ 2-32
Automatic Overdrive
............................ 2-22
Automatic Transaxle Check
...................................... 7-42
Fluid
.................................. 6-18. 6-21
GearPositions
............................... 2-19
Operation
................................... 2-18
Shifting ..................................... 2-18
Park Mechanism Check
........................ 7-45
Starting Your Engine
.......................... 2-14
Back-up Lamps Bulb Replacement
............... 6-38
Battery
....................................... 6-35
Charging System Light ........................ 2-69
Jump Starting
................................. 5-3
Replacement. Keyless Entry ..................... 2-8
Saver
...................................... 2-45
Warnings
.................................... 5-3
BBB Auto Line ................................. 8-9
Better Business Bureau Mediation ................... 8-9
Blizzard
...................................... 4-26

Downloaded from www.Manualslib.com manuals search engine Brake Adjustment
.................................. 6-34
Fluid
....................................... 6-31
Master Cylinder
.............................. 6-3 1
Parking
..................................... 2-26
PedalTravel
................................. 6-34
Replacing System
Parts ........................ 6-34
System Warning Light
......................... 2-69
Trailer
...................................... 4-40
Transaxle Shift Interlock Check
.................. 7-44
Wear
....................................... 6-33
Brakes, Anti-Lock
............................... 4-7
Braking
........................................ 4-6
Braking in Emergencies
.......................... 4- 10
Break-In, New Vehicle
.......................... 2-12
Brightness Control
.............................. 2-44
BTSICheck
................................... 7-44
Bulb Replacement
.............................. 6-35
Back-up Lamps
.............................. 6-38
Center High-Mounted Stoplamp
................. 6-39
Dome Lamp
................................. 6-39
RearTurnSignal
............................. 6-37
Taillamp
.................................... 6-37
Bypass Switch
................................. 2-60
Canadian Roadside Assistance
.................... 8-7
Capacities and Specifications
...................... 6-63
Carbon Monoxide
............... 2.27.2.28.4.30. 4.39 Cassette Deck Service
........................... 7-41
Cassette Tape Player
....................... 3- 10. 3.13
Care
....................................... 3-24
CD Adapter Kit
................................ 3-17
CDCare
...................................... 3-25
CD Player
..................................... 3-17
Theft-Deterrent Feature
........................ 3-21
Center Console Storage Area
...................... 2-48
Center High-Mounted Stoplamp Bulb Replacement
.... 6-39
Center Rear Passenger Position
.................... 1-33
Certification Label
.............................. 4-34
Chains. Safety
................................. 4-40
Chains. Tire
................................... 6-48
Changing a Flat Tire
............................. 5-23
Check Engine Light
............................. 2-73
Check Gages Light
.............................. 2-77
Checking Your Restraint Systems
.................. 1-48
Chemical Paint Spotting
.......................... 6-56
Child Restraints
................................ 1-37
Securing in a Rear Outside Seat Position
........... 1-39
Securing
in the Center Rear Seat Position .......... 1-41
Securing
in the Passenger Seat Position ........... 1-42
Securing in the Right Front Seat Position
.......... 1-42
TopStrap
................................... 1-38
WheretoPut
................................ 1-37
Circuit Breakers and Fuses
....................... 6-59
Cleaner. Air
................................... 6-17
Cigarette Lighter
............................... 2-50

Downloaded from www.Manualslib.com manuals search engine Driving City
........................................ 4-21
Defensive
.................................... 4-2
Drunken
..................................... 4-2
Freeway
.................................... 4-22
InaBlizzard
................................. 4-28
In Foreign Countries
........................... 6-5
In the Rain
.................................. 4- 18
Night
...................................... 4-16
OnCurves
.................................. 4-10
On Grades While Towing a Trailer
............... 4-42
On Hill and Mountain Roads
.................... 4-24
OnSnowandIce
............................. 4-27
Throughwater
............................... 4-20
WetRoads
.................................. 4-18
Winter
...................................... 4-26
With a Trailer
................................ 4-40
DrunkenDriving
................................ 4-2
Easy Entry Seat ................................ 1-6
Electrical Equipment. Adding ...... 2-15.2-16.3-23. 6-58
Electrical System
............................... 6-58
Engine
.................................. 6-10. 6-11
Coolant
..................................... 6-25
Coolant Heater
............................... 2- 17
Coolant Level Check
.......................... 7-41
Coolant Temperature Gage
..................... 2-72
Exhaust
..................................... 2-30
Fuse Block
.................................. 6-62
Identification
................................ 6-58
OilLevelCheck
.............................. 7-41
Overheating
................................. 5-14
Running While Parked
......................... 2-31 Specifications
................................ 6-64
Starting Your
...................... 2.14.2.15. 2.16
Engineoil
.................................... 6-12
Adding
..................................... 6-13
Additives
................................... 6-16
Checking
................................... 6-13
Used
....................................... 6-16
What
To Use ................................. 6-14
When to Change
.............................. 6-16
Enhanced Traction System Operation
................ 4-9
Enhanced Traction System Active Light
......... 2.72. 4.9
Enhanced Traction System Warning Light
....... 2.71. 4.9
Ethanol
........................................ 6-5
ETS Active Light ........................... 2.72. 4.9
ETS Warning Light
......................... 2.71. 4.9
Exhaust. Engine
................................ 2-30
Fabric Cleaning
............................... 6-49
Fifth Gear. Manual Transaxle
..................... 2-24
Filling Your Tank ................................ 6-6
Filter. Air
..................................... 6-17
Finishcare
.................................... 6-53
Finish Damage
................................. 6-56
First Gear. Automatic Transaxle
.............. 2.21. 2.23
First Gear. Manual Transaxle
...................... 2-24
Flashers. Hazard Warning
......................... 5-2
Flat Tire. Changing
............................. 5-23
Fluids and Lubricants
............................ 7-48
FOgLmps
.................................... 2-43
Foreign Countries. Fuel
........................... 6-5
Fourth Gear. Manual Transaxle .................... 2-24
French Language Manual
11 1. ...........................
Front Reading Lamps ............................ 2-45

Downloaded from www.Manualslib.com manuals search engine Jack. Tire .................................... 5-25
Jump Starting
................................... 5-3
Key Lock Cylinders Service
..................... 7-43
Key Release Button
............................. 2-14
Keyless Entry System
............................ 2-6
Keys
.......................................... 2-2
Labels
....................................... 4-33
Certification
................................. 4-34
Service Parts Identification
..................... 6-58
Tire-Loading Information ...................... 4-33
Vehicle Identification Number
................... 6-58
Lamps
........................................ 2-41
Exterior
.................................... 2-41
Fog
........................................ 2-43
FrontReading
................................ 2-45
Interior
..................................... 2-44
Map
....................................... 2-45
OnReminder
................................ 2-42
Latches. Seatback
................................ 1-5
Leaving Your Vehicle
............................. 2-6
Leaving Your Vehicle with the Engine Running
....... 2-28
Lighter
....................................... 2-50
Lights Air Bag Readiness
..... i ................. 1-23. 2-68
Anti-Lock Brake System Warning
............ 2.70. 4.7
Brake System Warning
......................... 2-69
Charging System
............................. 2-69
CheckEngine
................................ 2-73
Enhanced Traction System Active
............ 2.72. 4.9
Enhanced Traction System Warning Light
..... 2.71. 4.9
CheckGages
................................ 2-77
ETS Active .............................. 2.72. 4.9
ETS Warning
............................ 2.71. 4.9
Interior
..................................... 2-44
Low Coolant Warning
......................... 2-73
Oil Pressure Warning
.......................... 2-76
Passlock
TM Warning ........................... 2-77
Safety Belt Reminder
...................... 1.8. 2.68
Loading Your Vehicle
........................... 4-33
Locks Cylinders
................................... 7-43
Door
........................................ 2-4
Key Lock Cylinder Service
..................... 7-43
Power Door
.................................. 2-5
Rear Door Security ............................. 2-5
Steering Column Lock Check
................... 7-44
Trunk
...................................... 2-10
Low Coolant Warning Light
...................... 2-73
Lowering the Convertible Top Manually
............. 2-59
Lowering Your Convertible Top
................... 2-52
Lubricants and Fluids
............................ 7-48
Lubrication Service. Body
........................ 7-43
Maintenance.
NO~Z~I Replacement parts ........... 6-64
Maintenance Record
............................ 7-50
Maintenance Schedule
............................ 7-1
Long Trip/Highway Definition
................... 7-6
Long TripMighway Intervals
..................... 7-6
Owner Checks and Services
..................... 7-41
Periodic Maintenance Inspections
................ 7-46
Recommended Fluids and Lubricants
............. 7-48
Scheduled Maintenance Services
.................. 7-3
Short TripKity Definition
....................... 7-5
Short TripKity Intervals
........................ 7-5
Up-Shift
............................... 2.25. 2.77

Downloaded from www.Manualslib.com manuals search engine Maintenance. Underbody ......................... 6-56
Maintenance When Trailer Towing
................. 4-43
Malfunction Indicator Lamp
...................... 2-73
Manual Front Seat
............................... 1-2
Manual Lumbar Support
.......................... 1-3
Manual Remote Control Mirror .................... 2-47
Manual Transaxle Check
...................................... 7-42
Fluid
....................................... 6-22
Gear Positions
............................... 2-23
Operation
................................... 2-23
Shifting
..................................... 2-23
Starting Your Engine
.......................... 2-14
Methanol
...................................... 6-5
Mirrors
....................................... 2-46
Convex Outside
.............................. 2-48
Inside Daymight Rearview
..................... 2-46
Manual Remote Control
........................ 2-47
Power Remote Control
......................... 2-47
MountainRoads
................................ 4-24
Multifunction Lever
............................. 2-33
Neutral. Automatic Transaxle
.................... 2-20
Neutral. Manual Transaxle
........................ 2-24
New Vehicle “Break-In”
......................... 2-12
Nightvision
................................... 4-17
Odometer
.................................... 2-66
Odometer. Trip
................................. 2-66
Off-Road Recovery
............................. 4- 12
Oil. Engine
.................................... 6-12
Oil Pressure Warning Light
....................... 2-76
Overdrive. Automatic Transaxle
................... 2-22 Overheating Engine
............................. 5-14
Owner Checks and Services
....................... 7-41
Owner Publications. Ordering
..................... 8-12
Paint Spotting. Chemical
........................ 6-56
Park
Automatic -:ansaxle
.......................... 2-19
Shifting Into
................................. 2-27
Shifting Out of
............................... 2-29
Parking AtNight
.................................... 2-11
Brake
...................................... 2-26
Brake Mechanism Check
....................... 7-45
Lots
....................................... 2-11
Over Things That Burn
........................ 2-30
With a Trailer
................................ 4-42
Your Vehicle. Manual Transaxle
................. 2-29
Passenger Position
.................... 1-22. 1-28. 1-33
Passing
....................................... 4-13
With a Trailer ................................ 4-40
Passlock
” .................................... 2-11
Periodic Maintenance Inspections
.................. 7-46
Power
DoorLocks
................................... 2-5
Option Fuses
................................ 6-59
Remote Control Mirror
........................ 2-47
Steering
............................... 4.10. 6.29
Windows
................................... 2-32
Pregnancy. Use of Safety Belts
.................... 1-21
Problems on the Road
............................ 5-1
Publications. Service and Owner
................... 8-12
Passlock”
Warning Light
........................ 2-77
Steering Fluid
................................ 6-29
9-7

Downloaded from www.Manualslib.com manuals search engine TrunkLock .................................... 2-10
TTYUsers
..................................... 8-4
Turn Signal and Lane Change Signals
............... 2-34
Turn SignalMultifunction Lever
................... 2-33
Turn Signals When Towing a Trailer
................ 4-41
Underbody Flushing Service
..................... 7-45
Underbody Maintenance
......................... 6-56
Up-Shift Light
............................ 2.25. 2.77
Vehicle Control
...................................... 4-6
Damage Warnings vi1
Dimensions
................................. 6-65
Identification Number
......................... 6-58
Loading
.................................... 4-33
Storage
..................................... 6-35
Ventilation System
............................... 3-6
Visors. Sun
.................................... 2-50
Warning Devices
............................... 5-3
Warning Lights. Gages and Indicators
............... 2-67
Washer Fluid. Windshield
........................ 6-30
.. ..............................
Washing Your Vehicle ...........................
Weatherstrips ..................................
Wheel
Alignment
..................................
Replacement .................................
Used Replacement ............................
Wrench .....................................
Windows .....................................
Auto-Down .................................
Power ......................................
Windshield Washer .............................
Fluid .................................. 2-37.
Fluid Level Check
............................
Windshield Wiper ..............................
Bladecheck .................................
Blade Replacement ...........................
Fuse .......................................
Winter Driving .................................
Wiring. Headlamp ..............................
WreckerTowing ................................
Wrench. Wheel .................................
Nut Torque ............................. 5-31.
6-53 6-53
6-46
6-63
6-46
6-47
5-25
2-32 2-32
2-32
2-37
6-30
7-41 2-35
6-40
6-59
4-26
6-59
.5-8
5-25 7-42
9-11
~~