brake fluid CHEVROLET SUBURBAN 1997 Owner's Manual

Long Tripmighway Maintenance Schedule -- Gasoline Engines
The services shown in this schedule up to 100,000 miles
(166
000 km) should be performed after 100,000 miles
(166
000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after
150,000 miles (240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
3- The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure
to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage, transmission shift linkage, transfer case
shift linkage, parking brake cable guides, front axle
propshaft splines and brake pedal springs. Ball joints and
kinetin bushings should
not be lubricated unless
their tegperature is”1O”F
(- 12°C) or higher, or they
could be damaged.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections” in
Part C of this schedule.
* * Drive axle service (see “Recommended Fluids and
Lubricants” in the Index for proper lubricant to use):
Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
Standard Differential -- Check fluid level and add
fluid as needed at every engine oil change.
7-30 -
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
Cl Check readfront axle fluid level and add
fluid as needed. Check constant velocity
joints and axle seals for leaking.
(See footnote
**.)
0 For Two-Wheel-Drive vehicles only: Clean
and repack the front wheel bearings (or at
each brake relining, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
(See footnote
+.)
[7 Replace fuel filter. An Emission Control Service.
(See footnote?.)
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage
or looseness. Adjust
or replace as required.
This is a Noise Emission
Control Service. Applicable only to vehicles sold in
the United States.
DATE SERVICED BY ACTUAL MILEAGE
7-33
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines
52,500 Miles (87 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
0 Check readfront axle fluid level and add fluid
as needed. Check constant velocity joints and
axle seals for leaking. (See footnote
** .)
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
(See footnote
+.)
An Emission Control Service.
I DATE I ACTUALMILEAGE ISERVICED BY:I
60,000 Miles (100 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
Cl Check readfront axle fluid level and add
fluid as needed. Check constant velocity
joints and axle seals for leaking.
(See footnote
**.)
Cl For Two-Wheel-Drive vehicles only: Clean
and repack the front wheel bearings (or at
each brake relining, whichever occurs
first).
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. (See footnote
+.)
ProCarManuals.com

I Long Tripmighway Maintenance Schedule -- Gasoline Engines
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
0 Check readfront axle fluid level and add
fluid as needed. Check constant velocity
joints and axle seals for leaking.
(See footnote
**.)
El For Two-Wheel-Drive vehicles only: Clean
and repack the front wheel bearings (or at
each brake relining, whichever occurs first).
0 Replace fuel filter. An Emission Control Service.
(See footnote?.)
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace as required.
This is a Noise Emission
Control Service. Applicable
only to vehicles sold in
the United States.
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
(See footnote
+.)
7-40
ProCarManuals.com

Drive Axle Service
Check readfront axle fluid level and add as needed.
Check constant velocity joints and axle seals for leaking.
Transfer Case (Four-wheel Drive)
Inspection
Every 12 months or at oil change intervals, check front
axle and transfer case and add lubricant when necessary.
Oil the control lever pivot point and all exposed control
linkage. Check vent hose at transfer case for kinks and
proper installation. More frequent lubrication may be
required on off-road use.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment.
You may need to have
your brakes inspected more often
if your driving habits
or conditions result in frequent braking.
ProCarManuals.com

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
(Gasoline
Engine)
Engine Coolant
Hydraulic Brake
System
FLUID/LUBRICANT
Engine oil with the American
Petroleum Institute Certified For Gasoline Engines “Starburst”
symbol of the proper viscosity.
To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and GM
Goodwrench@ DEX-COOLa or
Havoline@ DEX-COOL@
(silicate-free) coolant. See
“Engine Coolant” in the Index.
Delco Supreme 11
@ Brake Fluid
(GM Part No. 12377967 or
equivalent DOT-3 brake fluid).
USAGE
Parking Brake
Cable Guides
Power Steering
System
Automatic
Transmission
Key Lock
Cylinders
~~
Chassis
Lubrication
FLUIDLUBRICANT
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB
or GC-LB.
GM Power Steering Fluid (GM
Part
No. 1052884 - 1 pint,
1050017
- 1 quart, or equivalent).
DEXRON@-111 Automatic
Transmission Fluid.
Multi-Purpose lubricant, Superlube@ (GM Part
No. 12346241
or equivalent).
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB
or GC-LB.
7-49
ProCarManuals.com

Section 9 Index
Air Bag ...................................... 1-3 1
Adding Equipment ............................ 1-37
How Does
it Restrain .......................... 1-35
How
it Works ................................ 1-33
Location
.................................... 1-33
Readiness Light ......................... 1-32. 2-65
Servicing
................................... 1-36
What Makes
it Inflate .......................... 1-34
What Will
You See After it Inflates ............... 1-35
When Should
it Inflate ......................... 1-34
Aircleaner
.................................... 6-18
Air Cleaner Filter Restriction Indicator Check
........ 7-44
Air Conditioning
................................ 3-7
Air Conditioning Refrigerants
..................... 6-72
Alignment and Balance, Tire
...................... 6-50
Aluminum Wheels, Cleaning
...................... 6-58
Antenna, Fixed
................................. 3-30
Antifreeze
..................................... 6-26
Anti-Lock Brake System Warning Light
................ 2-68, 4-7
Brakes
...................................... 4-7
Anti-Theft, Radio
.............................. 3-26
Appearance Care
............................... 6-52
Appearance Care Materials
....................... 6-60
Arbitration Program
.............................. 8-9 Armrest Storage Compartment
.................... 2-52
Ashtrays
...................................... 2-58
Audio Equipment. Adding
........................ 3-28
Audio Systems
................................. 3-11
Automatic Transmission
Check
.................................... 7-44
Fluid
....................................... 6-20
Operation
................................... 2-16
Overdrive
................................... 2-19
Park Mechanism Check
........................ 7-46
Shifting
..................................... 2-16
Axle. Front
.................................... 6-25
Axle. Locking Rear
............................. 2-20
Axle. Rear
.................................... 6-24
Auxiliary Power Outlet
.......................... 2-59
Battery
...................................... 6-36
Jump Starting
................................. 5-3
Replacement. Keyless Entry
..................... 2-7
Warnings
................................ 5-3. 5-4
BBB Auto Line
................................. 8-9
Better Business Bureau Mediation
................... 8-9
Blizzard. Driving In
............................. 4-40
9-1
ProCarManuals.com

Brake Adjustment
........................ ....... 6-35
Fluid
....................................... 6-32
Master Cylinder
.............................. 6-32
Parking
..................................... 2-25
PedalTravel
................................. 6-35
Replacing System Parts
........................ 6-35
System Warning Light
......................... 2-67
Trailer
...................................... 4- 50
Transmission Shift Interlock Check ............... 7-45
Wear
....................................... 6-34
Brakes, Anti-Lock
............................... 4-7
Braking
........................................ 4- 6
Braking in Emergencies ........................... 4-9
Break-In, New Vehicle
........................ 2- 12
Brightness Control
............................ 2-42
Bulb Replacement
.............................. 6-37
BTSICheck
................................... 7-45
Canadian Roadside Assistance
.................... 8-7
Capacities and Specifications
...................... 6-69
Carbon Monoxide
.......... 2-29,2-30,4-41,4-49, 4-50
Care
of Your Cassette Tape Player .................. 3-29
Cargo Security Shade
............................ 2-55
Cargo Tie Downs
............................... 2-56
Cassette Deck Service
........................... 7-43
Cassette Tape Player
....................... 3- 13, 3- 15
Cassette Tape Player Care ........................ 3-29
Cassette Tape Player Errors
.................. 3- 15, 3- 19
CD Player Theft-Deterrent Feature
................. 3-26
Center Passenger Position
........................ 1-38
CertificatiodTire Label ........................... 4-42
Center High-Mounted Stoplamp Bulb Replacement
.... 6-42 Chains. Safety
............................... 4-49
Changing a Flat Tire
............................. 5-22
Charging System Warning Light
................... 2-65
Check Gages Light
.............................. 2-73
Checking Your Restraint Systems
.................. 1-62
Chemical Paint Spotting
.......................... 6-59
Child Restraints
................................ 1-48
Securing in a Rear Outside Seat Position
........... 1-51
Securing in the Center Seat Position
.............. 1-54
Securing
in the Right Front Seat Position .......... 1-56
TopStrap
................................... 1-51
WheretoPut ................................ 1-50
Cigarette Lighter
............................... 2-58
Circuit Breakers and Fuses
....................... 6-63
Cleaner. Air
................................... 6-18
Cleaning
Aluminum Wheels
............................ 6-58
Exterior LampsLenses
........................ 6-57
Fabric
...................................... 6-53
Glass
....................................... 6-56
Inside
of Your Vehicle ......................... 6-53
Instrument Panel
............................. 6-56
Leather
..................................... 6-55
Outside of Your Vehicle
........................ 6-57
Special Problems
............................. 6-54
Stains
...................................... 6-54
Tires
....................................... 6-59
Vinyl
....................................... 6-55
Wheels
..................................... 6-58
Chains. Tire
................................... 6-51
Windshield and Wiper Blades
................... 6-56
Climate Control, Optional
......................... 3-3
Climate Control, Standard
......................... 3-2
Climate Control System
........................... 3-2
9-2
ProCarManuals.com

Lamps ........................................ 2-40
Cleaning Exterior
............................. 6-57
Dome
...................................... 2-43
Interior
..................................... 2-42
On Reminder
................................ 2-41
Latches, Seatback
................................ 1-6
Leaving Your Vehicle ............................. 2-5
Leaving Your Vehicle with the Engine Running
....... 2-27
Lighter
....................................... 2-58
Lights Air Bag Readiness
....................... 1.32. 2.65
Anti-Lkk Brake System Warning
............ 2.68. 4.7
Brake System Warning
......................... 2-67
Charging Warning System
...................... 2-65
Daytime Running Lamps Indicator
............... 2-72
Headlamp High-Beam Indicator
................. 2-73
Safety Belt Reminder
..................... 1 - 18, 2-64
Service Engine Soon
.......................... 2-69
Turn Signal and Lane Change Indicator
........... 2-73
Loading Your Vehicle
........................... 4-42
Loading Your Vehicle for Off-Road Driving
.......... 4- 15
Child Security ................................ 2-5
Ignition Transmission Lock Check
............... 7-46
Key Lock Cylinder Service
..................... 7-44
Lubricants and Fluids
............................ 7-49
Lubrication Service, Body
........................ 7-44
Luggagecarrier
................................ 2-57
CheckGages
................................ 2-73
Locks
......................................... 2-3
Cylinder
.................................... 7-44
Door
........................................ 2-3
PowerDoor
.................................. 2-4
Window
.................................... 2-32 Maintenance.
Normal Replacement Parts
........... 6-70
Maintenance Record
............................ 7-51
Long Tripmighway Definition
................... 7-6
Long Trip/Highway Intervals
..................... 7-6
Owner Checks and Services
..................... 7-43
Periodic Maintenance Inspections
................ 7-47
Recommended Fluids and Lubricants
............. 7-49
Scheduled Maintenance Services
.................. 7-4
Short Trip/City Definition
....................... 7-5
Short Trip/City Intervals
........................ 7-5
Maintenance. Underbody
......................... 6-59
Maintenance When Trailer Towing
................. 4-54
Malfunction Indicator Lamp
...................... 2-69
Maintenance Schedule
............................ 7-1
ManualFrontSeat
............................... 1-2
ManualMirror
................................. 2-47
Manualwindows
............................... 2-31
Methanol
...................................... 6-5
Mirrors
....................................... 2-44
Convex Outside
.............................. 2-47
Electrochromic Daymight Rearview
.............. 2-44
Inside Rearview
.............................. 2-44
Manual
..................................... 2-47
Power Remote Control
......................... 2-47
Model Reference
................................. vi
Mountain Roads ................................ 4-36
Multifunction Lever
............................. 2-33
Neutral, Automatic Transmission
.................. 2-18
New Vehicle Break-In ........................... 2-12
Nightvision
................................... 4-29
Normal Maintenance Replacement Parts
............. 6-70
MMT
......................................... 6-4
Net, Convenience
.............................. 2-54
ProCarManuals.com

Odometer ........................ ........ 2-63
Odometer. Trip
................................. 2-63
Off-Road Driving
.............................. 4-14
Off-Road Recovery
............................. 4- 1 1
Opener, Garage Door ............................ 2-48
Overdrive, Automatic Transmission
................ 2- 19
Overheating Engine
............................. 5- 11
Owner Checks and Services
....................... 7-43
Owner Publications, Ordering
................ 8- 11, 8- 12
Oil. Engine
.................................... 6-14
Paint Spotting. Chemical
. . ................. 6-59
Park Automatic Transmission
..................... 2- 17
Shifting Into ................................. 2-26
Shifting Out of
............................... 2-28
Parking AtNight
.................................... 2-11
Brake ...................................... 2-25
Brake Mechanism Check
....................... 7-46
Lots
....................................... 2-11
Over Things That Burn
........................ 2-29
With
a Trailer ................................ 4-53
Passenger Position
.............................. 1-3 1
Passing ....................................... 4-12
Periodic Maintenance Inspections
.................. 7-47
Power Auxiliary Outlet
.............................. 2-59
DoorLocks
................................... 2-4
Lumbar Adjustment
............................ 1-4 Option Fuses
.............................. 6-63
Remote
Control Mirror ........................ 2-47
Seat
......................................... 1-3
Steering
..................................... 4-9
Steering Fluid
................................ 6-30
Take-Off .................................... 4-55
Winches
.................................... 4-55
Windows
................................... 2-31
Power Lumbar Adjustment
........................ 1-4
Pregnancy, Use of Safety Belts .................... 1-30
Problems
on the Road ............................ 5-1
Protecting Exterior Bright Metal Parts ............... 6-58
PTO
......................................... 4-55
Publications, Service and Owner
.............. 8- 11, 8- 12
Radiator
..................................... 5-18
Radiator Pressure Cap
........................... 6-29
Radio Reception
................................ 3-28
Radios
........................ 3-1 1.3-13. 3.15. 3.20
Rain. Driving In
................................ 4-30
Reading Lamps
................................ 2-43
Rear Axle
....................................... 6-24
Child Security Locks
........................... 2-5
Lamp Bulb Replacement
....................... 6-43
Outside Seat Position
.......................... 1-40
Safety Belt Comfort Guides
..................... 1-45
Seat Passengers
.............................. 1-39
Window Defogger
............................ 3-10
Windshield Washer ........................... 2-36
9-7
ProCarManuals.com