warning CHEVROLET TRACKER 1997 Owner's Manual

Front Axle
When to Check and Change Lubricant
Refer to the Maintenance Schedule to determine how
often to check the lubricant and when to change it. See
“Periodic Maintenance Inspections” and “Scheduled
Maintenance Services” in the Index.
How to Check Lubricant
If the differential is at operating temperature (warm),
add enough lubricant to raise the level to the bottom of
the filler plug
hole.
If the differential is cold, add enough lubricant to raise
the level to 1/2 inch
(I 2 mm) below the filler plug hole.
What to Use
Refer to the Maintenance Schedule to determine what
kind
of lubricant to use. See “Recommended Fluids and
Lubricants”
in the Index.
Engine Coolant
The following explains your cooling system and how to
add coolant when it is low. If you have a problem with
engine overheating, see “Engine Overheating” in
the Index.
If the level is below the bottom of the filler plug hole,
you’ll need to add some lubricant.
A 50/50 mixture of water and the proper coolant will:
0 Give freezing protection down to -33°F (-36°C).
0 Give boiling protection up to 258°F (125°C).
0 Protect against rust and corrosion.
0 Help keep the proper engine temperature.
Let the warning lights and gages work as
they should.
6-23
I
ProCarManuals.com

What to Use
Use a mixture of one-half clean water (preferably
distilled) and one-half coolant that meets
GM
Specification 1825-M, which won’t damage aluminum
parts. You can also use a recycled coolant conforming to
GM Specification 1825-M with a complete coolant flush
and refill. If you use this mixture, you don’t need to add
anything else.
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mix will. Your vehicle’s coolant warning
system is set for the proper coolant mix. With
plain water or the wrong mix, your engine could
get too hot but you wouldn’t get the overheat
warning. Your engine could catch fire and you
or
others could be burned. Use a 50/50 mix of clean
water and the proper coolant.
I
NOTICE:
If you use an improper coolant mix, your engine
could overheat and be badly damaged. The
repair cost wouldn’t be covered by your
warranty.
Too much water in the mix can freeze
and crack the engine, radiator, heater core and
other parts.
If you have to add coolant more than four times a year,
have your dealer check your cooling system.
I NOTICE:
If you use the proper coolant, you don’t have to
add extra inhibitors or additives which claim to
improve the system. These can be harmful.
6-24
ProCarManuals.com

Brake Wear
NOTICE:
0
0 Using the wrong fluid can badly damage
brake system parts. For example, just
a few
drops of mineral-based oil, such as engine
oil, in your brake system can damage brake
system parts
so badly that they’ll have to be
replaced. Don’t let someone put in the
wrong kind
of fluid.
If you spill brake fluid on your vehicle’s
painted surfaces, the paint finish can be
damaged. Be careful not to spill brake fluid
on your vehicle.
If you do, wash it off
immediately. See “Appearance Care” in
the Index. Your Geo has
front disc brakes and rear drum brakes.
Disc brake pads have built-in wear indicators that make a
high-pitched warning sound when the brake pads are worn and new pads are needed. The sound may come and go or
be heard
all the time your vehicle is moving (except when
you are pushing on the brake
pedal firmly).
I
The brake wear warning sound means that soon
your brakes won’t work well. That could lead to
an accident. When
you hear the brake wear
warning sound, have your vehicle serviced.
I NOTICE:
Continuing to drive with worn-out brake pads
could result in costly brake repair.
I
6-31
ProCarManuals.com

Uniform Tire Quality Grading
The following information relates to the system
developed by the United States National Highway
Traffic Safety Administration, which grades tires by
treadwear, traction and temperature performance.
(This applies only to vehicles sold in the United States.)
The grades are molded on the sidewalls of most
passenger car tires. The Uniform Tire Quality Grading
system does not apply to deep tread, winter-type snow
tires, space-saver or temporary use spare tires, tires with
nominal rim diameters of
10 to 12 inches (25 to 30 cm),
or to some limited-production tires.
While the tires available on General Motors passenger
cars and light trucks may vary with respect to these
grades, they must also conform to Federal safety
requirements and additional General Motors Tire
Performance Criteria (TPC) standards.
Treadwear
The treadwear grade is a comparative rating based on
the wear rate of the tire when tested under controlled
conditions on
a specified government test course. For
example, a tire graded
150 would wear one and a half
( 1 1/2) times as well on the government course as a tire
graded
100. The relative performance of tires depends
upon the actual conditions of their use, however, and
may depart significantly from the norm due to variations
in driving habits, service practices and differences in
road characteristics and climate.
Traction -- A, B, C
The traction grades, from highest to lowest, are A, B, and
C, and they represent the tire’s ability to stop on wet
pavement as measured under controlled conditions on
specified government test surfaces of asphalt and concrete.
A tire marked C may have poor traction performance.
Warning: The traction grade assigned to this tire
is based
on braking (straight ahead) traction tests and does not
include cornering (turning) traction.
6-45
ProCarManuals.com

Temperature -9 A, B, C
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of
heat and its ability to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material
of the tire to degenerate and reduce tire life,
and excessive temperature can lead to sudden tire
failure. The grade
C corresponds to a level of
performance which all passenger car tires must meet
under the Federal Motor Vehicle Safety Standard
No. 109. Grades B and A represent higher levels of
performance on the laboratory test wheel than the
minimum required by law.
Warning: The temperature grade for this tire is
established for a tire that is properly inflated and not
overloaded. Excessive speed, underinflation, or
excessive loading, either separately or in combination,
can cause heat buildup and possible tire failure.
Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully at the factory to give you the longest
tire life
and best overall performance. Scheduled
wheel alignment and wheel balancing are not
needed. However, if you notice unusual tire wear or
your vehicle pulling one way or the other, the alignment
may need to be reset. If you notice your vehicle
vibrating when driving on a smooth road, your wheels
may need
to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked, or badly
rusted or corroded. If wheel nuts keep coming loose,
the wheel, wheel bolts and wheel nuts should be
replaced. If the wheel leaks air, replace it (except some
aluminum wheels, which can sometimes be repaired).
See your Geo dealer if any of these conditions exist.
Your dealer will know the kind
of wheel you need.
Each new wheel should have the same load-carrying
capacity, diameter, width, offset and be mounted the same way as the one it replaces.
If you need to replace any of your wheels, wheel
bolts or wheel nuts, replace them only with new
GM
original equipment parts. This way, you will be sure
to have the right wheel, wheel bolts and wheel nuts for
your Geo model.
6-46
ProCarManuals.com

Tire Chains
NOTICE:
Use tire chains only where legal and only when
you must. Use only
SAE Class “S” type chains
that are the proper size for your tires. Install them
on the tires
of the drive axle (fourwheel-drive
vehicles can use chains on both axles).
Tighten them as tightly as possible with the ends
securely fastened. Drive slowly and follow the
chain manufacturer’s instructions.
If you can
hear the chains contacting your vehicle, stop
and retighten them.
If the contact continues,
slow down until it stops. Driving too fast or
spinning the wheels with chains on will
damage your vehicle.
Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into flame if you strike a
match or get them on
a hot part of the vehicle. Some are
dangerous if you breathe their fumes in a closed space.
When you
use anything from a container to clean your
Geo, be sure to follow the manufacturer’s warnings and
instructions. And always open your doors or windows
when you’re cleaning the inside.
Never use these to clean your vehicle:
0 Gasoline
0 Benzene
0 Naphtha
0 Carbon Tetrachloride
Acetone
0 Paint Thinner
Turpentine
0 Lacquer Thinner
0 Nail Polish Remover
They can all be hazardous
-- some more than
others
-- and they can all damage your vehicle, too.
6-48
ProCarManuals.com

c
Fuse Usage
1
2
3
4
5
Dome Lamp, Sidemarker Lamps, Parking
Lamps, License Plate Lamp, Instrument
Panel Illumination
Stoplamps,
Horn
Hazard Lamps
Fuse
6
7
8
9
10
11
12
13
14
Usage
Door Lock (Option)
Lighter, Radio
Ignition System, Warning and Indicator
Lights, Gages, Four-wheel Drive System
(Option)
Turn Signal Flasher, Back-up Lamps
Wipermasher
Rear Defogger
Heater
Empty
Empty
Please note, fuses for the air bags are located
next to the
instrument panel fuse block.
6-60
ProCarManuals.com

Gem Section 9 Index
Adding Equipment to the Outside of Your Vehicle ..... 6-3
AirBag
....................................... 1-25
Adding Equipment
............................ 1-3 1
How Does it Restrain
.......................... 1-29
How it Works
................................ 1-27
Location
.................................... 1-27
Readiness Light
......................... 1-26. 2-63
Servicing ................................... 1-30
What Makes it Inflate
.......................... 1-28
What Will
You See After it Inflates ............... 1-29
When Should it Inflate
......................... 1-28
Aircleaner
.................................... 6-14
Air Conditioning
................................ 3-3
Air Conditioning Refrigerants
..................... 6-64
Alignment and Balance. Tire
...................... 6-46
Aluminum Wheels. Cleaning
...................... 6-55
Antenna
...................................... 3-19
Antifreeze
..................................... 6-23
Anti-Lock Brake System Active Light
................. 2-66. 4-9
Brake System Warning Light
................ 2-65. 4-7
Brakes
...................................... 4-7
Appearance Care
............................... 6-48
Appearance Care Materials
....................... 6-57 Arbitration
Program
.............................. 8-9
Ashtrays ...................................... 2-43
Audio Systems
.................................. 3-6
Automatic
Overdrive
................................... 2-14
Overdrive Off Switch
.......................... 2-14
Automatic Transmission
.......................... 2-9
Check
...................................... 7-50
Fluid
....................................... 6-16
Operation
................................... 2-10
Park Mechanism Check ........................ 7-52
Shifting
..................................... 2-10
Starting Your Engine
........................... 2-9
Axle. Front .................................... 6-23
Axle. Rear
.................................... 6-21
Battery
...................................... 6-33
Jump Starting
................................. 5-3
Warnings
................................ 5-3, 5-5
BBB Auto Line
................................. 8-9
Better Business Bureau Mediation ................... 8-9
Blizzard ...................................... 4-42
9-1
ProCarManuals.com

Brake Adjustment
.................................. 6-32
Fluid
....................................... 6-29
Master Cylinder
.............................. 6-29
Parking
..................................... 2-21
PedalTravel
................................. 6-32
Replacing System
Parts ........................ 6-32
System Warning Light
......................... 2-64
Trailer
...................................... 4-53
Transmission Shift Interlock
.................... 2-25
Transmission Shift Interlock Check
............... 7-5 1
Wear
....................................... 6-31
Brakes, Anti-Lock
............................... 4-7
Braking
........................................ 4-6
Braking
in Emergencies ........................... 4-9
Break-In, New Vehicle
........................... 2-7
Brightness Control
.............................. 2-38
BTSI
......................................... 2-25
BTSICheck
................................... 7-51
Bulb Replacement
.............................. 6-33
Canadian Roadside Assistance
.................... 8-7
Canvas Top Lowering and Raising
......................... 2-50
Preparing for Storage
.......................... 2-56
Removing and Installing
....................... 2-55
Capacities and Specifications
...................... 6-62
Carbon Monoxide
..................... 2-5,2-27, 4-43
Cassette Deck Service
........................... 7-49
Cassette Tape Player
........................ 3-8, 3-11
Cassette Tape Player Care
........................ 3- 1 8
CD Player Theft-Deterrent Feature ................. 3 - 15 Center
High-Mounted Stoplamp Bulb Replacement
.... 6-39
Certification Label
.............................. 4-47
Chains. Safety
................................. 4-53
Chains. Tire
................................... 6-48
Changing a Flat Tire
............................. 5-23
Charging System Light
.......................... 2-63
Checking Your Restraint Systems
.................. 1-45
Chemical Paint Spotting
.......................... 6-56
Child Restraints
........................... 1-35. 1-36
Securing in a Rear Seat Position
................. 1-37
Securing in the Right Front Seat Position
.......... 1-39
TopStrap
................................... 1-37
WheretoPut
................................ 1-36
Circuit Breakers and Fuses
....................... 6-59
Cleaner. Air
................................... 6-14
Cleaning Aluminum Wheels
............................ 6-55
Canvas Top and Plastic Window
................. 6-54
Exterior LampsLenses
........................ 6-53
Fabric
...................................... 6-49
Glass Surfaces
............................... 6-52
Inside of Your Ceo
............................ 6-49
Instrument Panel
............................. 6-51
Outside of Your Geo .......................... 6-53
Stains
...................................... 6-50
Tires
....................................... 6-55
Vinyl
....................................... 6-51
Wheels
..................................... 6-55
Cigarette Lighter
............................... 2-43
Special Problems
............................. 6-50
Windshield and Wiper Blades
................... 6-52
Climate Control System
........................... 3-2
9-2
ProCarManuals.com

Fetbric C1eani;ag; ............................... 45-49
Fifth &ar91kfgmd Tkmxqaimion ................... 2-15
Fillitrg YOW 'Jk& ................................ 6-5:
Filter. Air ..................................... 6-15
Finish Care .................................... 6-53
Finish Damage ................................. 6-56
First Gear. Manual Transmission ................... 2-14
Flashers. Hazard Warning ... ..................... 5-2
Flash-to-Pass Feature ........................... 2-32
Flat Tire. Changing ............................. 5-23
Fluid Capacities ................................ 6-63
Fluid Level Check .............................. 7-50
Fluids and Lubricants ............................ 7-55
Foreign Countries. Fuel ........................... 6-5
Fourth Gear. Manual Transmission ................. 2-15
Four-wheel Drive .................... 2-17.2-20. 6-22
French Language Manual 11
Front Axle .................................... 6-23
Front Seat Side Pockets .......................... 2-42
Front Sidemarker Lamp Bulb Replacement ........... 6-36
Front Turn Signal Lamp Bulb Replacement .......... 6-35
.. ...........................
FrontTowing .................................. 5-10
Fuel .......................................... 6-3
Canada ...................................... 6-3
DoorLock ................................... 6-6
Filling Your Tank .............................. 6-5
Gage ....................................... 2-72
In Foreign Countries ........................... 6-5
Fuses and Circuit Breakers ....................... 6-59
Gag&%
Enghe C.OP~UI% Temgmat~~e .................... 2-66
Fuel ....................................... 2-72
GABR ....................................... 447
Gear Pasidom. Automatic TmmmiSsion ............. 2-10
ProCarManuals.com