washer fluid CHEVROLET VOLT 2020 User Guide

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556250) - 2020 - CRC - 2/11/20
294 Vehicle Care
Clean rubber blades using a lint-free
cloth or paper towel soaked with
windshield washer fluid or a mild
detergent. Wash the windshield
thoroughly when cleaning the
blades. Bugs, road grime, sap, and
a buildup of vehicle wash/wax
treatments may cause wiper
streaking.
Replace the wiper blades if they are
worn or damaged. Damage can be
caused by extreme dusty
conditions, sand, salt, heat, sun,
snow, and ice.
Weatherstrips
Apply weatherstrip lubricant on
weatherstrips to make them last
longer, seal better, and not stick or
squeak. Lubricate weatherstrips at
least once a year. Hot, dry climates
may require more frequent
application. Black marks from
rubber material on painted surfaces
can be removed by rubbing with a
clean cloth.
Tires
Use a stiff brush with tire cleaner to
clean the tires.
Caution
Using petroleum-based tire
dressing products on the vehicle
may damage the paint finish and/
or tires. When applying a tire
dressing, always wipe off any
overspray from all painted
surfaces on the vehicle.
Wheels and Wheel Trim
Use a soft, clean cloth with mild
soap and water to clean the wheels.
After rinsing thoroughly with clean
water, dry with a soft, clean towel.
A wax may then be applied.
Caution
Chrome wheels and chrome
wheel trim may be damaged if the
vehicle is not washed after driving
on roads that have been sprayed
with magnesium chloride or
calcium chloride. These are used
on roads for conditions such as(Continued)
Caution (Continued)
dust and ice. Always wash the
chrome with soap and water after
exposure.
Caution
To avoid surface damage on
wheels and wheel trim, do not
use strong soaps, chemicals,
abrasive polishes, cleaners,
or brushes. Use only GM
approved cleaners. Do not drive
the vehicle through an automatic
car wash that uses silicon carbide
tire/wheel cleaning brushes.
Damage could occur and the
repairs would not be covered by
the vehicle warranty.
Brake System
Visually inspect brake lines and
hoses for proper hook-up, binding,
leaks, cracks, chafing, etc. Inspect
disc brake pads for wear and rotors

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556250) - 2020 - CRC - 2/11/20
Service and Maintenance 301
The Tire Rotation and Required
Services are the responsibility of the
vehicle owner. It is recommended to
have your dealer perform these
services every 12 000 km/7,500 mi.
Proper vehicle maintenance helps to
keep the vehicle in good working
condition.
The Additional Required Services
are for vehicles that:
.Carry passengers and cargo
within recommended limits on
the Tire and Loading Information
label. See Vehicle Load Limits
0 178.
. Are driven on reasonable road
surfaces within legal driving
limits.
Refer to the information in the
Maintenance Schedule Additional
Required Services chart.
{Warning
Performing maintenance work can
be dangerous and can cause
serious injury. Perform
maintenance work only if the
required information, proper tools,
and equipment are available.
If they are not, see your dealer to
have a trained technician do the
work. See Doing Your Own
Service Work 0234.
Maintenance
Schedule
Owner Checks and Services
Once a Month
.
Check the tire inflation
pressures. See Tire Pressure
0 263.
. Inspect the tires for wear. See
Tire Inspection 0269.
. Check the windshield washer
fluid level. See Washer Fluid
0 239.
Air Conditioning Desiccant
(Replace Every Seven Years)
The air conditioning system requires
maintenance every seven years.
This service requires replacement of
the desiccant to help the longevity
and efficient operation of the air
conditioning system. This service
can be complex. See your dealer.

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556250) - 2020 - CRC - 2/11/20
302 Service and Maintenance
Tire Rotation and Required
Services Every 12 000 km/
7,500 mi
Rotate the tires, if recommended for
the vehicle, and perform the
following services. SeeTire
Rotation 0269.
. Check coolant level. See
Cooling System 0238.
. Check windshield washer fluid
level. See Washer Fluid 0239.
. Check tire inflation pressures.
See Tire Pressure 0263.
. Inspect tire wear. See Tire
Inspection 0269.
. Visually check for fluid leaks.
. Inspect brake system. See
Exterior Care 0291.
. Visually inspect steering,
suspension, and chassis
components for damage,
including cracks or tears in the
rubber boots, loose or missing
parts, or signs of wear at least
once a year. See Exterior Care
0 291. .
Inspect power steering for
proper attachment, connections,
binding, leaks, cracks,
chafing, etc.
. Visually inspect halfshafts and
drive shafts for excessive wear,
lubricant leaks, and/or damage
including: tube dents or cracks,
constant velocity joint or
universal joint looseness,
cracked or missing boots, loose
or missing boot clamps, center
bearing excessive looseness,
loose or missing fasteners, and
axle seal leaks.
. Check restraint system
components. See Safety System
Check 045.
. Lubricate body components. See
Exterior Care 0291. .
Check accelerator pedal for
damage, high effort, or binding.
Replace if needed.
. Visually inspect gas strut for
signs of wear, cracks, or other
damage. Check the hold open
ability of the strut. If the hold
open ability is low, service the
gas strut. See Gas Strut(s)
0 246.
. Check tire sealant expiration
date, if equipped. See Tire
Sealant and Compressor Kit
0 277.

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556250) - 2020 - CRC - 2/11/20
Service and Maintenance 305
Fluids
Proper fluid levels and approved
fluids protect the vehicle’s systems
and components. See
Recommended Fluids and
Lubricants0307 for GM approved
fluids.
. Keep the windshield washer fluid
reservoir filled.
. Instrument cluster lights may
come on to indicate that fluids
may be low and need to be
filled.
Hoses
Hoses transport fluids and should
be regularly inspected to ensure
that there are no cracks or leaks.
With a multi-point inspection, your
dealer can inspect the hoses and
advise if replacement is needed. Lamps
Properly working headlamps,
taillamps, and brake lamps are
important to see and be seen on
the road.
.
Signs that the headlamps need
attention include dimming, failure
to light, cracking, or damage.
The brake lamps need to be
checked periodically to ensure
that they light when braking.
. With a multi-point inspection,
your dealer can check the lamps
and note any concerns.
Shocks and Struts
Shocks and struts help aid in control
for a smoother ride.
. Signs of wear may include
steering wheel vibration, bounce/
sway while braking, longer
stopping distance, or uneven
tire wear. .
As part of the multi-point
inspection, trained dealer
technicians can visually inspect
the shocks and struts for signs
of leaking, blown seals,
or damage, and can advise
when service is needed.
Tires
Tires need to be properly inflated,
rotated, and balanced. Maintaining
the tires can save money and
reduce the risk of tire failure.
. Signs that the tires need to be
replaced include three or more
visible treadwear indicators; cord
or fabric showing through the
rubber; cracks or cuts in the
tread or sidewall; or a bulge or
split in the tire.

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556250) - 2020 - CRC - 2/11/20
Service and Maintenance 307
Recommended Fluids, Lubricants, and Parts
Recommended Fluids and Lubricants
UsageFluid/Lubricant
Electric Drive Unit See your dealer.
Hydraulic Brake System DOT 3 Hydraulic Brake Fluid (GM Part No. 19353126, in Canada 19353127).
Key Lock Cylinders, Hood and Liftgate Hinges Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, in
Canada 10953474).
Vehicle Coolant Circuits Use Only Premix DEX-COOL Coolant (GM Part No. 12378390, in Canada 10953456). SeeCooling System0238.
Weatherstrip Conditioning Weatherstrip lubricant (GM Part No. 3634770, in Canada 10953518) or equivalent.
Windshield Washer Automotive windshield washer fluid that meets regional freeze protection requirements.

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556250) - 2020 - CRC - 2/11/20
338 Index
DriverTeen . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Driver Assistance Systems . . . . . 199
Driver Efficiency Gauge . . . . . . . . . 98
Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . 118
Driver Selected Operating
Modes . . . . . . . . . . . . . . . . . . . . . . . . 186
Driving Assistance Systems . . . . . . . . . . 203
Defensive . . . . . . . . . . . . . . . . . . . . . 173
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 173
Hill and Mountain Roads . . . . . . 176
If the Vehicle is Stuck . . . . . . . . . 178
Loss of Control . . . . . . . . . . . . . . . 175
Off-Road Recovery . . . . . . . . . . . 175
One-Pedal . . . . . . . . . . . . . . . . . . . . 190
Vehicle Load Limits . . . . . . . . . . . 178
Wet Roads . . . . . . . . . . . . . . . . . . . 176
Winter . . . . . . . . . . . . . . . . . . . . . . . . 177
Driving for Better Energy
Efficiency . . . . . . . . . . . . . . . . . . . . . 171
E
Electric Drive Unit . . . . . . . . . . . . . . 187
Electric Parking Brake . . . . . . . . . . 192 Electric Parking Brake Light . . . . 102
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 230
Electrical Requirements for Battery Charging . . . . . . . . . . . . . . 229
Electrical System Fuses and Circuit Breakers . . . 250
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 255
Overload . . . . . . . . . . . . . . . . . . . . . 250
Emergency
OnStar . . . . . . . . . . . . . . . . . . . . . . . 327
Energy Efficiency Driving . . . . . . . . . . . . . . . . . . . . . . . . 171
Energy Information . . . . . . . . . . . . . 115
Engine Cooling System . . . . . . . . . . . . . . . 238
Entry Lighting . . . . . . . . . . . . . . . . . . . 134
Event Data Recorders . . . . . . . . . . 324
Exit Lighting . . . . . . . . . . . . . . . . . . . . 134
Extended Parking . . . . . . . . . . . . . . . 186
Extender, Seat Belt . . . . . . . . . . . . . . 45
Exterior Lamp Controls . . . . . . . . . 128
Exterior Lamps Off Reminder . . . 130
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 134
F
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 130
Flashers, Hazard Warning . . . . . . 131
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 276
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 298
FluidBrakes . . . . . . . . . . . . . . . . . . . . . . . . 241
Washer . . . . . . . . . . . . . . . . . . . . . . . 239
Folding Mirrors . . . . . . . . . . . . . . . . . . 24
Forward Collision Alert (FCA) System . . . . . . . . . . . . . . . . . 204
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 322
Front Pedestrian Braking
(FPB) System . . . . . . . . . . . . . . . . . 207
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 34
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 35
Fuses
Fuses and Circuit Breakers . . . 250
Instrument Panel FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 255
Underhood Compartment . . . . . 251
G
Gas Strut(s) . . . . . . . . . . . . . . . . . . . . 246
Gauges Battery . . . . . . . . . . . . . . . . . . . . . . . . . 98

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556250) - 2020 - CRC - 2/11/20
342 Index
PrivacyVehicle Data Recording . . . . . . . 324
Program Courtesy Transportation . . . . . . 318
Programmable Charging . . . . . . . . 107
Proposition 65 Warning,
California . . . . . . . . . . . .233, 242, 284,
Back Cover
Propulsion Power Messages . . . 120
Publication Ordering Information . . . . . . . . . . . . . . . . . . . . 321
R
Radio Frequency Statement . . . . 322
RadiosAM-FM Radio . . . . . . . . . . . . . . . . . 140
Satellite . . . . . . . . . . . . . . . . . . . . . . . 141
Reading Lamps . . . . . . . . . . . . . . . . . 133
Ready Indicator . . . . . . . . . . . . . . . . . 106
Rear Camera Mirror . . . . . . . . . . . . . 25
Rear Seat Armrest . . . . . . . . . . . . . . . 38
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 37 Heated . . . . . . . . . . . . . . . . . . . . . . . . . 39
Rear Vision Camera (RVC) . . . . . 200
Rear Window Washer/Wiper . . . . . 88
Rearview Mirrors . . . . . . . . . . . . . . . . 25 Automatic Dimming . . . . . . . . . . . . . 25 Reclining Seatbacks . . . . . . . . . . . . . 34
Recommended Fluids and
Lubricants . . . . . . . . . . . . . . . . . . . . . 307
Records Maintenance . . . . . . . . . . . . . . . . . . 309
Recreational Vehicle Towing . . . . 289
Regenerative Braking . . . . . . . . . . . 194
Reimbursement Program, GM Mobility . . . . . . . . . . . . . . . . . . . 316
Remote Keyless Entry (RKE) System . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Remote Start . . . . . . . . . . . . . . . . . . . . 15
Replacement Parts Airbags . . . . . . . . . . . . . . . . . . . . . . . . . 59
Maintenance . . . . . . . . . . . . . . . . . . 308
Replacing Airbag System . . . . . . . . 59
Replacing LATCH System
Parts after a Crash . . . . . . . . . . . . . 75
Replacing Seat Belt System Parts after a Crash . . . . . . . . . . . . . 46
Reporting Safety Defects
Canadian Government . . . . . . . . 323
General Motors . . . . . . . . . . . . . . . 323
U.S. Government . . . . . . . . . . . . . 322
Requirements
Electrical Battery Charging . . . 229
Restraints Where to Put . . . . . . . . . . . . . . . . . . . 65 Retained Accessory
Power (RAP) . . . . . . . . . . . . . . . . . . 184
Roads Driving, Wet . . . . . . . . . . . . . . . . . . 176
Roadside Assistance Program . . . . . . . . . . . . . . . . . . . . . . . 316
Rotation, Tires . . . . . . . . . . . . . . . . . . 269
S
Safety Defects Reporting
Canadian Government . . . . . . . . 323
General Motors . . . . . . . . . . . . . . . 323
U.S. Government . . . . . . . . . . . . . 322
Safety Locks . . . . . . . . . . . . . . . . . . . . . 20
Safety Signal Pedestrian . . . . . . . . . . . . . . . . . . . . . . 86
Safety System Check . . . . . . . . . . . . 45
Satellite Radio . . . . . . . . . . . . . . . . . . 141
Scheduling Appointments . . . . . . . 318
Sealant Kit, Tire . . . . . . . . . . . . . . . . 277
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . 39
Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Extender . . . . . . . . . . . . . . . . . . . . . . . . 45
How to Wear Seat BeltsProperly . . . . . . . . . . . . . . . . . . . . . . . 40
Lap-Shoulder Belt . . . . . . . . . . . . . . 42
Reminders . . . . . . . . . . . . . . . . . . . . . . 99
Replacing after a Crash . . . . . . . . 46

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556250) - 2020 - CRC - 2/11/20
Index 345
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Voltage Devices and Wiring . . . . 249
W
WarningBrake System Light . . . . . . . . . . . 102
Caution and Danger . . . . . . . . . . . . . 2
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . . 94
Warnings Hazard Flashers . . . . . . . . . . . . . . 131
Washer Fluid . . . . . . . . . . . . . . . . . . . 239
Wheels
Alignment and Tire Balance . . 275
Different Size . . . . . . . . . . . . . . . . . 273
Replacement . . . . . . . . . . . . . . . . . 275
When It Is Time for New
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . 270
When to Charge . . . . . . . . . . . . . . . . 213
Where to Put the Restraint . . . . . . 65
Windows . . . . . . . . . . . . . . . . . . . . . . . . 28 Power . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Windshield Replacement . . . . . . . . . . . . . . . . . 246
Wiper/Washer . . . . . . . . . . . . . . . . . . 87
Winter
Driving . . . . . . . . . . . . . . . . . . . . . . . . 177
Winter Tires . . . . . . . . . . . . . . . . . . . . 258 Wiper Blade Replacement . . . . . . 244
Wipers
Rear Washer . . . . . . . . . . . . . . . . . . . 88
Wireless Charging . . . . . . . . . . . . . . . 91
Wiring, High Voltage Devices . . . 249