power steering CHRYSLER PACIFICA 2006 1.G User Guide

WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid type.
Front & Rear Suspension Ball Joints
The suspension ball joints are permanently sealed. No
regular maintenance is required for these components.
Steering Shaft Seal
The steering shaft seal, at the point where the shaft passes
through the bulkhead, is lubricated when it is installed. If
the seal becomes noisy when the steering shaft is turned,
it should be lubricated with a multi-purpose grease.
Mopar multi-purpose lubricant is recommended.
Steering Linkage
The tie rod end ball joints are permanently lubricated and
do not require periodic maintenance.
Drive Shaft Universal Joints
Your vehicle has constant velocity universal joints. Peri-
odic lubrication of these joints is not required. However,
the joint boots should be inspected for external leakage or
damage when other maintenance is performed. If leakage
or damage is evident, the universal joint boot and grease
should be replaced immediately.
MAINTAINING YOUR VEHICLE 355
7

Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not come in contact with any
heat source or moving component which may cause heat
damage or mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
Brakes
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the Mainte-
nance Schedules.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake And Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
364 MAINTAINING YOUR VEHICLE

Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE: Often, fluid such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to facilitate the assembly of hoses to couplings.
Therefore, oil wetness at the hose-coupling area is not
necessarily an indication of leakage. Actual dripping of
hot fluid when systems are under pressure (during
vehicle operation), should be noted before a hose is
replaced based on leakage.
NOTE: Inspection of brake hoses should be performed
whenever the brake system is serviced and at every
engine oil change. Inspect hydraulic brake hoses for
surface cracking, scuffing, or worn spots. If there is any
evidence of cracking, scuffing, or worn spots, the hose should be replaced immediately! Eventual deterioration
of the hose can take place resulting in a possibility of a
burst failure.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Master Cylinder — Brake Fluid Level Check
The fluid level in the master cylinder should be checked
when performing underhood services, or immediately if
the brake system warning light indicates system failure.
Clean the top of the master cylinder area before removing
the cap. Add fluid to bring the level up to the top of the
“FULL” mark on the side of the master cylinder reservoir.
MAINTAINING YOUR VEHICLE 365
7

Chassis
Component Fluids, Lubricants and Genuine Parts
Automatic Transmission Mopar ATF+4 Automatic Transmission Fluid.
AWD Power Transfer Unit Mopar Gear Lubricant 75W-90 or equivalent.
AWD Overrunning Clutch Mopar ATF+4 Automatic Transmission Fluid.
AWD Rear Carrier Mopar Gear Lubricant 75W-90 or equivalent.
Brake Master Cylinder Mopar DOT 3 and SAE J1703 should be used. If DOT 3 brake fluid is not
available, then DOT 4 or DOT 4+ is acceptable. Use only recommended
brake fluids.
Power Steering Reservoir Mopar ATF+4 Automatic Transmission Fluid.
388 MAINTAINING YOUR VEHICLE

Air Conditioning.................... 253,354
Automatic Transaxle .................... 369
Engine Oil ........................ 348,387
Engine Oil Disposal .................... 348
Flashers Hazard Warning ....................... 318
Turn Signal ..................... 169,384,385
Floor Console .......................... 155
Fluid Capacities ......................... 386
Fluid Leaks ............................. 73
Fluid Level Checks Automatic Transmission ................. 368
Brake ............................ 365,388
Power Steering ..................... 354,388
Fluids ................................ 387
Fluids, Lubricants and Genuine Parts .......... 387
Fog Light Service ........................ 384
Fog Lights ....................... 129,174,384
Folding Rear Seat ........................ 116 Freeing A Stuck Vehicle
................... 330
Fuel ................................. 296
Adding ............................. 300
Additives ............................ 298
Clean Air ............................ 297
Filler Cap (Gas Cap) .................... 300
Gasoline ............................ 296
Gauge .............................. 169
Hoses .............................. 367
Octane Rating ...................... 296,387
Requirements ...................... 296,386
Tank Capacity ........................ 386
Fuel System Caution ..................... 298
Fueling ............................... 300
Fuses ................................ 377
Garage Door Opener (HomeLink ) ........... 142
Gas Cap (Fuel Filler Cap) ...............300,341
Gasoline, Clean Air ...................... 297
INDEX 427
10

Security Alarm (Theft Alarm)................ 26
Selection of Coolant (Antifreeze) ..........359,387
Sentry Key (Immobilizer) ................... 12
Sentry Key Programming ................... 14
Service Assistance ....................... 414
Service Contract ......................... 416
Service Engine Soon Light (Malfunction Indicator) . 173
Service Manuals ........................ 418
Setting the Clock ........................ 186
Shoulder Belts ........................... 35
Signals, Turn ..................... 169,384,385
Slippery Surfaces, Driving On ............... 329
Snow Chains (Tire Chains) ................. 294
Snow Tires ............................ 295
Spare Tire ....................... 286,287,322
Spark Plugs ............................ 349
Speed Control (Cruise Control) .............. 138
Speedometer ........................... 169
Starting ............................... 258 Engine Fails to Start
.................... 259
Starting and Operating .................... 258
Starting Procedures ...................... 258
Steering Linkage ............................. 355
Power ........................... 271,354
Shaft Seal ............................ 355
Tilt Column .......................... 133
Steering Wheel Mounted Sound System Controls ............................. 229
Storage ............................ 155,380
Storage, Vehicle ...................... 252,380
Storing Your Vehicle ...................... 380
Sun Roof .............................. 149
Sun Visor Extension ....................... 83
Sunglasses Storage ....................... 142
Sunroof Maintenance ..................... 151
Supplemental Restraint System - Airbag ........ 45
Synthetic Engine Oil ...................... 348
INDEX 435
10