power steering fluid CHRYSLER PACIFICA 2007 1.G Warranty Booklet
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2007, Model line: PACIFICA, Model: CHRYSLER PACIFICA 2007 1.GPages: 132, PDF Size: 0.91 MB
Page 32 of 132
MAINTENANCE Scheduled maintenance must be completed to provide the best vehicle
performance and reliability. The limited warranties in the warranty booklet DO NOT COVER repairs required due to improper maintenance. We strongly suggest you keep track of scheduled maintenance and keep receipts or other documents. Use only recommended Mopar Lubricants and genuine Mopar® Parts. In the event that a condition arises between maintenance intervals, please contact your retailer. avoid prolonged periods of idling.
noTe:
WHere TiMe (MonTHs) and MeTrage are indiCa Ted, folloW THe inTerval
THa T oCCUrs firsT.
aT ea CH sT op for f U el
•
Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
•
Check the windshield washer solvent and add if required.
onCe a M on TH
•
Check the tire pressure and look for unusual
wear or damage.
•
Inspect the battery and clean and tighten the
terminals as required.
•
Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and add as needed.
•
Check all the lights and all other electrical items
for correct operation.
•
Check rubber seals on each side of the radiator
for proper fit.
•
Check and clean wiper blades. Replace if required.
VISUAL INSPECTIONS – INSPECT FOR SIGNS OF COMPONENT DETERIORATION AND PHYSICAL DAMAGE.
There are two maintenance schedules contained in your Owner’s Manual. Schedule “B” best
describes operating cond itions in Canada and
is the reco mmended service schedule. For
your convenience, the scheduled maintenance intervals outlined in this booklet follow the Severe Service Schedule as described in your Owner’s Manual. Schedule “B” is for vehicles that are operated under one or more of the following conditions: day or night tempera
tures are below 0°C (32°F); stop and go
driving; extensive engine idling; driving in dusty conditions; short trips of less than 16.2
km (10 mi.); more than 50% of your driving is at sustained high speeds during hot weather, above 32°C (90°F); trailer towing; taxi, police, or
delivery service (commercial service); off road
or desert driving; if equipped for and operating
with E 85 (ethanol) fuel. Schedule “A” is for
vehicles that are not operated under any of the conditions listed under Schedule “B.”The performance of all scheduled service work is required to maintain your vehicle in good operating condition. DaimlerChrysler Canada Inc. reserves the right to deny warranty coverage if the vehicle has not been properly maintained. While we do not insist that such
work be performed by factory authorized
retailers, we strongly recommend that an authorized Chrysler, Jeep® or Dodge Retailer perform this work.
i
n Trod UCTion
Page 41 of 132
2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
Odometer Reading
Date
25,000 km Maintenance Service Schedule “B”
25,000 km
Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
Inspect the engine air cleaner filter, replace if necessary (Sebring and PT Cruiser only).*
Replace the engine air cleaner filter (Pacifica and Minivan only).
Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
Inspect the make-up air filter, replace if necessary (PT Cruiser only).*
Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
INSPECT THE FOLLOWING:
Inspect the brake hoses.
Inspect the CV joints and front and rear suspension components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Check the manual transmission fluid level (if equipped) (Sebring only).
Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions
warranty.
Page 42 of 132
2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No.
Change engine oil and engine oil filter (or every 3 months,
whichever occurs first).
Inspect the engine air cleaner filter, replace if necessary
(Sebring and PT Cruiser only).*
Replace the engine air cleaner filter (Pacifica and Minivan
only).
Inspect and adjust the power steering pump belt tension
(Caravan 2.4L engine only).
Change the All-Wheel Drive (AWD) power transfer unit
fluid (Pacifica only).
Inspect the make-up air filter, replace if necessary
(PT Cruiser only).*
Inspect the generator belt on 2.4L engines, replace if
necessary (Caravan only).
INSPECT THE FOLLOWING:
Inspect the brake hoses.
Inspect the CV joints and front and rear suspension
components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Check the manual transmission fluid level (if equipped)
(Sebring only).
Check the manual transaxle fluid level and fill plug
condition (PT Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to
maintain the emissions warranty.
Maintenance Service Schedule “B”
25,000 km
Page 51 of 132
2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
Odometer Reading
Date
50,000 km Maintenance Service Schedule “B”
50,000 km
Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
Replace the engine air cleaner filter (All models).*
Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L engines only).
Replace the spark plugs (2.4L Sebring only).
Inspect the PCV valve and replace if necessary (PT Cruiser, Pacifica and Minivan only).*
‡
Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
Replace the make-up air filter (PT Cruiser only).
Adjust the generator drive belt tension (PT Cruiser only).
Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
Check spare tire for proper pressure and correct stowage.
Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the brake hoses.
Inspect the CV joints and front and rear suspension components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
Check the manual transmission fluid level (if equipped) (Sebring only).
Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions warranty.‡This maintenance is not required if previously replaced.
Page 52 of 132
2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No. Change engine oil and engine oil filter (or every 3 months,
whichever occurs first).
Replace the engine air cleaner filter (All models).*
Inspect and adjust the power steering pump belt tension (Caravan
2.4L engine only).
Replace the spark plugs and ignition cables (PT Cruiser and Caravan
2.4L engines only).
Replace the spark plugs (2.4L Sebring only).
Inspect the PCV valve and replace if necessary (PT Cruiser, Pacifica
and Minivan only).*‡ Change the All-Wheel Drive (AWD) power transfer unit fluid
(Pacifica only).
Replace the make-up air filter (PT Cruiser only).
Adjust the generator drive belt tension (PT Cruiser only).
Inspect the generator belt on 2.4L engines, replace if necessary
(Caravan only).
Check spare tire for proper pressure and correct stowage.
Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:
Inspect the brake hoses.
Inspect the CV joints and front and rear suspension components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and
Minivan only).
Check the manual transmission fluid level (if equipped) (Sebring only).
Check the manual transaxle fluid level and fill plug condition (PT
Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to
maintain the emissions warranty.
‡This maintenance is not required if previously replaced.
Maintenance Service Schedule “B”
50,000 km
Page 61 of 132
2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
Odometer Reading
Date
75,000 km Maintenance Service Schedule “B”
75,000 km
Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
Inspect the engine air cleaner filter, replace if necessary (Sebring and PT Cruiser only).*
Replace the engine air cleaner filter (Pacifica and Minivan only).
Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
Inspect the make-up air filter, replace as necessary (PT Cruiser only).*
Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
INSPECT THE FOLLOWING:
Inspect the front and rear brake linings and rotors (Pacifica and Minivan only).
Inspect the brake hoses.
Inspect the CV joints and front and rear suspension components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Check the manual transmission fluid level (if equipped) (Sebring only).
Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions
warranty.
Page 62 of 132
2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No. Change engine oil and engine oil filter (or every 3 months,
whichever occurs first).
Inspect the engine air cleaner filter, replace if necessary (Sebring
and PT Cruiser only).*
Replace the engine air cleaner filter (Pacifica and Minivan only).
Inspect and adjust the power steering pump belt tension (Caravan
2.4L engine only).
Change the All-Wheel Drive (AWD) power transfer unit fluid
(Pacifica only).
Inspect the make-up air filter, replace if necessary (PT Cruiser
only).*
Inspect the generator belt on 2.4L engines, replace if necessary
(Caravan only).
INSPECT THE FOLLOWING:
Inspect the front and rear brake linings and rotors (Pacifica and
Minivan only).
Inspect the brake hoses.
Inspect the CV joints and front and rear suspension components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Check the manual transmission fluid level (if equipped) (Sebring
only).
Check the manual transaxle fluid level and fill plug condition (PT
Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to
maintain the emissions warranty.
Maintenance Service Schedule “B”
75,000 km
Page 71 of 132
2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
Odometer Reading
Date
100,000 km
Maintenance Service Schedule “B”
100,000 km
Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
Replace the engine air cleaner filter (All models).*
Replace the air conditioning filter (Pacifica and Minivan only).
Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L engines only).
Replace the spark plugs (2.4L Sebring only).
Inspect the PCV valve and replace if necessary (Pacifica and Minivan only).*
‡ Replace the make-up air filter (PT Cruiser only).
Inspect the serpentine drive belt, replace if necessary (Town & Country/Caravan 3.3L and 3.8L engines and
Pacifica only).
‡ Adjust the generator drive belt tension (PT Cruiser only).
Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
Change the automatic transaxle fluid and filter (All models).
† Flush and replace engine coolant at 60 months or 170,000 kilometres, whichever comes first (All models).
Check spare tire for proper pressure and correct stowage.
Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the front and rear brake linings and rotors (PT Cruiser only).
Inspect the brake hoses.
Inspect the CV joints and front and rear suspension components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
Check the manual transmission fluid level (if equipped) (Sebring only).
Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions warranty.†This maintenance is required only for police, taxi, limousine type operation, or trailer towing.‡This maintenance is not required if previously replaced.
Page 72 of 132
2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No.
Maintenance Service Schedule “B”
100,000 km Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
Replace the engine air cleaner filter (All models).*
Replace the air conditioning filter (Pacifica and Minivan only).
Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine
only).
Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L
engines only).
Replace the spark plugs (2.4L Sebring only).
Inspect the PCV valve and replace if necessary (Pacifica and Minivan only).*
‡ Replace the make-up air filter (PT Cruiser only).
Inspect the serpentine drive belt, replace if necessary (Town & Country/Caravan
3.3L and 3.8L engines and Pacifica only).
‡ Adjust the generator drive belt tension (PT Cruiser only).
Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
Change the automatic transaxle fluid and filter (All models).
† Flush and replace engine coolant at 60 months or 170,000 kilometres,
whichever comes first (All models).
Check spare tire for proper pressure and correct stowage.
Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the front and rear brake linings and rotors (PT Cruiser only).
Inspect the brake hoses.
Inspect the CV joints and front and rear suspension components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
Check the manual transmission fluid level (if equipped) (Sebring only).
Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the
emissions warranty.
†This maintenance is required only for police, taxi, limousine type operation, or trailer towing.‡This maintenance is not required if previously replaced.
Page 81 of 132
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
Odometer Reading
Date
125,000 km Maintenance Service Schedule “B”
125,000 km
Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
Inspect the engine air cleaner filter, replace if necessary (Sebring and PT Cruiser
only).*
Replace the engine air cleaner filter (Pacifica and Minivan only).
Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
Inspect the make-up air filter, replace if necessary (PT Cruiser only).*
Inspect the serpentine drive belt, replace if necessary (Town & Country/Caravan 3.3L
and 3.8L engines and Pacifica only).
‡
Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
INSPECT THE FOLLOWING:
Inspect the brake hoses.
Inspect the CV joints and front and rear suspension components.
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
Check the manual transmission fluid level (if equipped) (Sebring only).
Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
Check the automatic transaxle fluid level (PT Cruiser only).
Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions
warranty.
‡This maintenance is not required if previously replaced.