gearbox Citroen C4 PICASSO 2013 1.G Service Manual

292
Practical information
Type 2 fuse tables
Fuse N°RatingFunctions
F
33 A START/STOP button.
F6A 15 A Touch screen tablet, audio and navi
gation system, CD player,USB ports and auxiliary sockets.
F8 5
A Alarm.
F
93 A Steering mounted controls.
F1
95 A Instrument panel.
F2
43 A Rain and sunshine sensor.
F25 5
A Airbags.
F33 3
A Memorisation of driving position.
F3
45 A Electric power steering.
F13 10 A
Fr
ont 12V socket.
F1410 A
Boot 12V socket.
F1
63 A Map reading lamps in row 1 cour tesy lamps.
F27 5
A Electronic gearbox gear selector.
F3
020 A Rear wiper.
F3
83 A Manual headlamp adjustment control.

295
7
Practical information




12 V battery
The battery is located under the bonnet.
For access to the (+) terminal: )release the bonnet using the interior lever,
then the exterior safety catch, )raise the bonnet and secure it with its stay, )lift the plastic cover for access to the (+)
terminal.
Access to the battery

Procedure for star ting the engine using another battery or charging a discharged battery.
The presence of this label, in particular with the Stop & Start system, indicatesthe use of a 12 V lead-acid battery withspecial technology and specification;the involvement of a CITROËN dealer or a qualified workshop is essential when replacing or disconnecting the battery.

After refitting the battery, the Stop & Start system will only be active after acontinuous period of immobilisation of thevehicle, a period which depends on theclimatic conditions and the state of chargeof the battery (up to about 8 hours).
When your vehicle's battery is discharged, the engine can be star ted using a slave battery (external or on another vehicle) and jump leadcables.
Starting using another
batter
y
) Connect the red cable to the positive
terminal (+) of the flat battery A, then to the
positive terminal (+) of the slave battery B.) Connect one end of the green or blackcable to the negative terminal (-) of the slave battery B
(or ear th point on the other
vehicle).) Connect the other end of the green or black cable to the ear th point Con the broken
down vehicle (or on the engine mounting). ) Start the engine of the vehicle with the good battery and leave it running for a few minutes.


First check that the slave battery has a nominal voltage of 12 V and a capacity at least equal to that of the discharged battery. Do not try to star t the engine byconnecting a battery charger.
Do not disconnect the (+) terminal when the engine is running.
Before doing any work
Immobilise the vehicle: apply the parking brake, put the gearbox in neutral, then switch off the ignition.Check that all electrical equipment isswitched off.

297
7
Practical information
The batteries contain harmful substancessuch as sulphuric acid and lead. They
must be disposed of in accordance with regulations and must not, in anycircumstances, be discarded with household waste. Take used remote control batteries and vehicle batteries to a special collection point.

Protect your eyes and face before handling the battery.
All operations on the battery must becarried out in a well ventilated area andaway from naked flames and sourcesof sparks, so as to avoid the risk of explosion or fire.
Do not try to charge a frozen battery;the battery must first be thawed out to avoid the risk of explosion. If the batteryhas been frozen, before charging have it checked by a CITROËN dealer or aqualified workshop who will check that the internal components have not beendamaged and the casing is not cracked, which could cause a leak of toxic and corrosive acid.
Do not reverse the polarity and use onlya 12 V charger.
Do not disconnect the terminals whilethe engine is running. Do not charge the batteries withoutdisconnecting the terminals first.
Wash your hands afterwards.
It is advisable to disconnect the battery if the vehicle is to be left unused for more than one month.
Do not push the vehicle to star t the engine if you have an electronicgearbox or automatic gearbox.










Charging the battery using
a battery charger
)Disconnect the battery from the vehicle.)Follow the instructions for use provided by
the manufacturer of the charger.)Connect the battery starting with thenegative terminal (-).)Check that the terminals and connectorsare clean. If they are covered with sulphate (whitish or greenish deposit), remove themand clean them.



The Stop & Start battery does not haveto be disconnected for charging.

300
Practical information





Towing the vehicle
The towing eye is installed in the boot under
the floor.
To gain access to it:)open the boot, )lift the floor and remove it,)remove the towing eye from its housing.

General recommendations
Observe the legislation in force in your country. Ensure that the weight of the towing vehicle is higher than that of the towed vehicle. The person at the wheel of the towed vehicle must have a valid driving licence.When towing a vehicle with all four wheels on the ground, always use an approved towing bar; rope and straps are prohibited. When towing a vehicle with the engine off, there is no longer any power assistance for braking or steering. In the following cases, you must always call on a professional recovery service: - vehicle broken down on a motor way or fast road, - 4 wheel drive vehicle, - when it is not possible to put the gearbox into neutral, unlock the steering, or release theparking brake, - towing with only two wheels on the ground, - where there is no approved towing bar available...
Procedure
for having your vehicle towed or for towing another vehicle using the towing eye.
Access to the tools

301
7
Practical information

To w i ng another vehicle
)
On the rear bumper, unclip the cover bypressing at the bottom. )
Screw the towing eye in fully. )
Install the towing bar. )
Switch on the hazard warning lamps on
both vehicles.)
Move off gently, drive slowly and for a shor t distance.
)On the front bumper, unclip the cover bypressing on the left. )Screw the towing eye in fully. )Install the towing bar.


To w i ng your vehicle
)Place the gear lever in neutral(position N
on an electronic or automatic gearbox). Failure to observe this instructioncould result in damage to certain components (braking, transmission...) and the absenceof braking assistance the next time the engine is star ted.
)
Unlock the steering by turning the keyin the ignition one notch and release the
parking brake.
) Switch on the hazard warning lamps onboth vehicles.
)
Move off gently, drive slowly and for a shor tdistance.

322
Checks
Brake wear depends on the styleof driving, par ticularly in the case of vehicles used in town, over shor t
distances. It may be necessary to
have the condition of the brakes checked, even between vehicle services.
Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake
pads are worn.















Brake pads
For information on checking brake
disc wear, contact a CITROËN dealer
or a qualified workshop.


Brake disc wear















Only use products recommended by CITROËN or products of equivalent quality and specification.

In order to optimise the operation of units as important as those in the braking system, CITROËN selects and offers very specific products.
After washing the vehicle, dampness,or in wintry conditions, ice can form on the brake discs and pads: braking efficiency may be reduced. Make lightbrake applications to dry and defrost the brakes.

Electric parking brake


For more information, refer to the "Electric parking brake - Operating faults" section. This s
ystem does not require any routine servicing. However, in theevent of a problem, have the systemchecked by a CITROËN dealer or a qualified workshop.
Manual gearbox

The gearbox does not require anymaintenance (no oil change).
Refer to the maintenance and
warranty guide for the details of
the level checking inter val for thiscomponent.
6-speed electronic gearbox
The gearbox does not require anymaintenance (no oil change).
Refer to the maintenance and
warranty guide for details of the checking interval for this component.
Automatic gearbox

The gearbox does not require anymaintenance (no oil change).
Refer to the maintenance and
warranty guide for details of the levelchecking interval for this component.
To avoid damaging the electrical units, the use of a high pressure washer in the engine compar tment is strictlyprohibited.

9
323
Technical data
Petrol enginesVTi 120THP155
Gearboxes
Manual(5-speed)


Manual(6-speed)
Model codes:3D... 3E... 3A...5FS0/1
5FV8 - 8/1

Cubic capacity (cc)
1 598

1 598

Bore x stroke (mm)
77 x 85.8
77 x 85.8

Max power * : EU standard (kW)
88
115

Max power en
gine speed (rpm) 6 000
6 000

Max torque: EU standard
(Nm)

160240

Max torque en
gine speed (rpm) 4 2501 400

F
uel Unleaded Unleaded
Catal
ytic converter yes
yes
Oil capacities (in litres)

Engine (with filter replacement)
4.25

4.25


* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).















Petrol engines and gearboxes
3D...:CITROËN C4 Picasso (5-seat).3A...:CITROËN Grand C4 Picasso (7- s e at).3E...:
CITROËN Grand C4 Picasso (5-seat).

324
Technical data
* The kerb weight is equal to the unladen weight + driver (75 kg). **

The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
Petrol enginesVTi 120THP155
Gearboxes
Manual(5-speed)
Manual (6-speed)

Model codes:3D... 3E... 3A ... 5FS0/1 3D... 3E... 3A ...5FV8 - 8/1


-
Unladen weight1 252 - 1 276 - 1 278

1 296 - 1 311 - 1 313



- Kerb wei
ght *


1 327 - 1 351 - 1 353

1 371 - 1 386 - 1 388



- Gross vehicle wei
ght (GV W)

1 900 - 2 060 - 2 1101 940 - 2 100 - 2 150



- Gross train weight (GT W)

on a 12 % gradient2 900 - 2 860 - 2 860 3 360 - 3 350 - 3 350



- Braked trailer
(within GTW limit) on a 10 % or 12 % gradient
1 000 - 800 - 750
1 420 - 1 250 - 1 200



- Braked trailer
**
(with load transfer within the GTW limit)

1 200 - 1 100 - 1 050

1 620 - 1 550 - 1 500



- Unbraked trailer
660 - 675 - 675 685 - 690 - 690



- Recommended nose weight
70 - 70 - 70
70 - 70 - 70














Petrol weights and towed loads (in kg)
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit th
e towed load.

9
325
Technical data
Diesel enginesHDi 90e-HDi 90 Airdream
Gearboxes

Manual(5-speed)


Electronic gearbox system(6-speed)
Model codes:3D... 3E... 3A...
9HP0/1 9HP8/2PS
Cubic capacity (cc) 1 560

Bore x stroke
(mm)

75 x 88.3

Max power * : EU standard (kW)
68

Max power engine speed (rpm)
4 000
Max torque: EU standard
(Nm)

230

Max torque engine speed (rpm) 1 750

F
uel

Diesel

Catalytic converter
yes

Particle emission filter
yes
Oil capacities (in litres)

Engine (with filter replacement) 3.75

.../S: e-HDi model fitted with Stop & Star t.3D...:CITROËN C4 Picasso (5-seat).














Diesel engines and gearboxes


* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).
3E...:CITROËN Grand C4 Picasso (5-seat). 3A...:CITROËN Grand C4 Picasso (7-seat).

326
Technical data
* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).











Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Star t.3D...:CITROËN C4 Picasso (5-seat). 3E...:
CITROËN Grand C4 Picasso (5-seat). 3A...:
CITROËN Grand C4 Picasso (7-seat).
Diesel enginesHDi 115e- HDi 115 Airdream
GearboxesManual (6-speed)


Manual(6-speed)Electronic gearbox system(6-speed)

Model codes:3D... 3E... 3A...9HC8/1
9HC8/1S
9HC8/1PS - 8/2PS


Cubic capacity (cc)
1 5601 560

Bore x stroke
(mm)75 x 88.3

75 x 88.3

Max power * : EU standard (kW)
8585
Max power engine speed
(rpm) 3 6003 600
Max torque: EU standard
(Nm)
270270 - 285

Max torque en
gine speed (rpm) 1 7501 750

F
uel
Diesel
Diesel

Catalytic conver ter yes yes

Particle emission filter no
yes
Oil capacities (in litres)

Engine (with filter replacement) 3.75
3.75