check oil Citroen DS3 2014 1.G Owner's Manual

15
DS3_en_Chap00c_eco-conduite_ed01-2014
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind   resistance   (roof  
b

ars,   roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations on
maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   recommended   in   the   maintenance   and   warranty   guide.
With
  a   Blue   HDi   Diesel   engine,   if   the   SCR   system   is   faulty   your   vehicle  
b

ecomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified   workshop  
w

ithout   delay   to   have   the   emissions   of   nitrous   oxides   brought   back   to  
t

he   legal   level.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first   1   800   miles  
(3
  000   kilometres)   that   you   will   see   the   fuel   consumption   settle   down   to  
a

  consistent   average.
Eco-driving

27
DS3_en_Chap01_controle-de-marche_ed01-2014
Warning lamps
When the engine is running or the vehicle is being   driven,   the   illumination   of   one   of   the  
f

ollowing   warning   lamps   indicates   a   fault   which  
r

equires   action   on   the   part   of   the   driver.Any
  fault   resulting   in   the   illumination   of   a   warning   lamp   must   be   investigated   further   by  r
eading   the   associated   message   in   the   multifunction   screen.
If
  you   encounter   any   problems,   do   not   hesitate   to   contact   a   CITROËN   dealer   or   a   qualified  
w

orkshop.
Warning lamp is on
cau

seAction / Observations
STOP fixed,
  alone   or
 a

ssociated with
another
 w

arning
 lam
p,
 a

ccompanied   by   an
 a

udible   signal   and   a
 m

essage   on   the   screen.Illumination
  of   the   warning   lamp   is  
a

ssociated   with   a   serious   braking  
s

ystem   or   engine   coolant   temperature  
pro

blem.Stop
  as   soon   as   it   is   safe   to   do   so   as   the   engine   may  
c

ut   out   when   driving.
Park,
  switch   off   the   ignition   and   call   a   CITROËN   dealer  
o

r   a   qualified   workshop.
Service temporarily. Minor
  problems   have   occurred   for  
w

hich   there   is   no   specific   warning  
lam

p.Identify
  the   problem   by   reading   the   message   shown   in  
t

he   screen,   such   as,   for   example:
-
 
t
he   engine   oil   level,
-

t
he screenwash level,
-
 
t
he   remote   control   battery,
-
 
s
aturation   of   the   particle   emission   filter   on   Diesel  
v

ehicles   (see   the   "Checks   -   Particle   emissions  
f

ilter"   section).
For any other faults, contact a CITR
oË

N dealer or a
qualified
 w

orkshop.
fixed. Major
  problems   have   occurred   for  
w

hich   there   is   no   specific   warning  
lam

p.Identify
  the   problem   by   reading   the   message   shown  
i

n the screen and contact a CITR
oË
N dealer or a
qualified
 w

orkshop.
Monitoring

39
DS3_en_Chap01_controle-de-marche_ed01-2014
on vehicles fitted with an electric oil level
indicator,  information   on   the   oil   level   is  
d

isplayed   in   the   instrument   panel   for   a   few  
s

econds   when   the   ignition   is   switched   on,   after  
t

he   service   information.
Engine oil level indicator*
The level shown will only be correct
if  the   vehicle   is   on   level   ground   and  
t

he   engine   has   been   off   for   more   than  
3

0 minutes.
Oil level correct
Oil level low
This is indicated by the flashing of " O I L" ,
a ccompanied   by   illumination   of   the   service  
w

arning   lamp,   an   audible   signal   and   a  
m

essage.
If
  the   low   oil   level   is   confirmed   by   a   check   using  
t

he   dipstick,   the   level   must   be   topped   up   to  
p

revent   damage   to   the   engine.
Refer
  to   the   "Checking   levels"   section.
Oil level indicator fault
This is signaled by the flashing of "OIL- -".
C ontact a CITRoË N dealer or a qualified
workshop.
In the event of a fault with the electric oil level
indicator,
  the   engine   oil   level   is   no   longer  
mon

itored.
While
  the   system   is   faulty,   you   should   check  
t

he   engine   oil   level   using   the   manual   dipstick  
l

ocated   under   the   bonnet.
Refer
  to   the   "Checking   levels"   section.
*
  Depending   on   version.
Monitoring

205
DS3_en_Chap10_info-pratiques_ed01-2014
F Place the switch in the "O"   position.
F  R emove   the   kit.
F
 
D
rive   immediately   for   approximately  
t

hree   miles   (five   kilometres),   at   reduced  
s

peed   (between   15   and   35   mph   (20   and  
6

0 km/h)),   to   plug   the   puncture.
F
 
S
top   to   check   the   repair   and   the   tyre  
p

ressure   using   the   kit.
checking / adjusting tyre pressures
You can also use the compressor, without injecting   sealant,   to   check   and   if   necessary  
a

djust   the   tyre   pressures
F
 
R
emove   the   valve   cap   from   the   tyre   and  
p

lace   it   in   a   clean   area.
F

U
ncoil the pipe stowed under the
compressor.
F
 
S
crew   the   pipe   onto   the   valve   and   tighten  
f

i r m l y. F
 C heck   that   the   compressor   switch   is   at  
t

he "O "
  position.
F

U
ncoil fully the electric cable, stowed under
the
  compressor.
F
 
C
onnect   the   compressor's   plug   to   the  
v

ehicle's   12   V   socket.
F
 
S
witch   on   the   ignition.
Practical information

249
DS3_en_Chap11_verifications_ed01-2014
Petrol engines
1. Screenwash  fluid   reservoir.
2. C oolant   header   tank.
3.
 A

ir   filter.
4.
 B

rake   fluid   reservoir.
5.
 B

attery.
6.
 F

usebox.
7.
 E

ngine   oil   dipstick.
8.
 E

ngine   oil   filler   cap.
checks

251
DS3_en_Chap11_verifications_ed01-2014
Checking levels
Check all of these levels regularly, in line with the maintenance and warranty guide. Top them up if necessary, unless other wise indicated.
I f   a   level   drops   significantly,   have   the   corresponding   system   checked   by   a   CITROËN   dealer   or   a   qualified   workshop.
Engine oil level
It is normal to top up the oil level between two   services   (or   oil   changes).   CITROËN  
r

ecommends   that   you   check   the   level,   and   top  
u

p   if   necessary,   every   3   000   miles   (5   000   kms).
The
  check   is   carried   out   either   when  
t

he   ignition   is   switched   on   using   the  
o

il   level   indicator   in   the   instrument  
p

anel for vehicles with an electric oil
level   gauge,   or   using   the   dipstick.
To   ensure   that   the   reading   is   correct,  
y

our   vehicle   must   be   parked   on   a   level  
s

ur face   with   the   engine   having   been   off  
f

or   more   than   30   minutes.
Take   care   when   working   under   the  
b

onnet,   as   certain   areas   of   the   engine  
m

ay   be   extremely   hot   (risk   of   burns)  
a

nd   the   cooling   fan   could   start   at   any  
t

ime   (even   with   the   ignition   off).
checking using the dipstick
A = MA X
B   =   MIN If you find that the level is above the A
  mark   or  
belo

w the B   mark,   do not star t the engine
.
-
I
f the level is above the MAX
 
mark   (risk  
o

f   damage   to   the   engine),   contact   a  
C

ITROËN   dealer   or   a   qualified   workshop.
-
I
f the level is below the MIN
 
mark,   you  
m

ust   top   up   the   engine   oil.
Refer
 
to
 
the
 
"Petrol   engine"   or   "Diesel   engine"  
s

ection
 
for
 
the   location   of   the   dipstick   in   the  
e

ngine
 
compartment   of   your   vehicle.
F
 
T

ake
 
the
  dipstick   by   its   coloured   grip   and  
r

emove
 
it   completely.
F
 
W

ipe
 
the
  end   of   the   dipstick   using   a   clean  
n

on-fluffy   cloth.
F
 
R

efit
 
the
  dipstick   and   push   fully   down,   then  
p

ull
 
it
 
out   again   to   make   the   visual   check:  
t

he
 
correct   level   is   between   the   marks   A
and B .
Oil grade
Before topping-up the oil or changing the oil, c
heck   that   the   oil   is   the   correct   grade   for   your  
e

ngine   and   conforms   to   the   manufacturer's  
r

ecommendations.
checks

DS3_en_Chap11_verifications_ed01-2014
Brake fluid level
Changing the fluid
Refer to the maintenance and warranty guide for   details   of   the   interval   for   this   operation.
Fluid specification
The brake fluid must conform to the manufacturer's r ecommendations.
The
  brake   fluid   level   should   be   close  
t

o   the   "MA X"   mark.   If   it   is   not,   check  
t

he   brake   pad   wear.
After
 
topping
 
up
 
the
 
oil,
 
the
 
check
 
when
 
s

witching
 
on
 
the
 
ignition
 
with
 
the
 
oil
 
level
 
i

ndicator
 
in
 
the
 
instrument
 
panel
 
is
 
not
 
valid
 
d

uring
 
the
 
30
 
minutes
 
after
 
topping
 
up.
Topping up the engine oil level
Refer to the "Petrol engine" or "Diesel engine" s ection for the location of the oil filler cap in the
engine
  compartment   of   your   vehicle.
F

U
nscrew the oil filler cap to reveal the filler
aperture.
F
 
A
dd   oil   in   small   quantities,   avoiding   any  
s

pills   on   engine   components   (risk   of   fire).
F
 
W
ait   a   few   minutes   before   checking   the  
l

evel   again   using   the   dipstick.
F
 
A
dd   more   oil   if   necessary.
F
 
A
fter   checking   the   level,   carefully   refit   the  
o

il   filler   cap   and   the   dipstick   in   its   tube.
Engine oil change
Refer to the maintenance and warranty guide for   details   of   the   interval   for   this   operation.
In
  order   to   maintain   the   reliability   of   the   engine  
a

nd   emission   control   system,   never   use  
a

dditives   in   the   engine   oil.

255
DS3_en_Chap11_verifications_ed01-2014
Checks
12 V batteryAir filter and passenger compartment filter
Oil filterParticle filter (
di
esel)
Unless other wise indicated, check these components in accordance with the maintenance and warranty guide and according to your engine.
O ther wise,   have   them   checked   by   a   CITROËN   dealer   or   a   qualified   workshop.
The battery does not require any maintenance.
H owever,   check   that   the   terminals   are   clean a

nd   correctly   tightened,   particularly   in   summer
 a

nd   winter.Refer to the maintenance and warranty   guide   for   details   of   the  
r

eplacement   intervals   for   these  
c

omponents.
Replace
  the   oil   filter   each   time   the  
e

ngine   oil   is   changed.
Refer
  to   the   maintenance   and  
w

arranty   guide   for   details   of   the  
r

eplacement   interval   for   this  
c

omponent.
The presence of this label, in particular with
the
 
Stop
 
&
 
Start
 
system,
 
indicates
 
the
 
use
 
of
 
a s

pecific 12 V lead-acid battery with special
technology
 
and
 
specification.
 
The
 
involvement
 
o

f
 
a
 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
workshop
 
i

s
 
essential
 
when
 
replacing
 
or
 
disconnecting
 
t

he
 
battery. The start of saturation of the
particle filter is indicated by the
temporary
  illumination   of   this   warning   lamp  
a

ccompanied   by   a   message   in   the   multifunction  
sc

reen.
As
  soon   as   the   traffic   conditions   permit,  
r

egenerate   the   filter   by   driving   at   a   speed   of   at  
l

east   40   mph   (60   km/h)   until   the   warning   lamp  
g

oes   off.
If
  the   warning   lamp   stays   on,   this   indicates   a  
l

ow   additive   level.
on a n

ew vehicle, the first particle
filter
  regeneration   operations   may   be  
a

ccompanied   by   a   "burning"   smell,  
w

hich   is   per fectly   normal.
Following
  prolonged   operation   of   the  
v

ehicle at very low speed or at idle,
you
  may,   in   exceptional   circumstances,  
n

otice   the   emission   of   water   vapour   at  
t

he   exhaust   on   acceleration.   This   does  
n

ot affect the behaviour of the vehicle
or
  the   environment.
When
 
carrying
 
out
 
work
 
on
 
the
 
battery,
 
refer
 
t

o the "12 V battery" section for details of the
precautions
 
to
 
be
 
taken
 
before
 
disconnecting
 
t

he
 
battery
 
and
 
following
 
its
 
reconnection.
Depending on the environment (e.g. dusty a tmosphere)   and   the   use   of   the   vehicle   (e.g.   city d

riving),
 r
eplace them twice as often if necessar y .
A
  clogged   passenger   compartment   filter   may   have
 a

n   adverse   effect   on   the   per formance   of   the   air
 c

onditioning   system   and   generate   undesirable
 o

dours.
checks

DS3_en_Chap11_verifications_ed01-2014
Manual gearbox
Automatic gearboxBrake pads
Brake wear depends on the style o
f   driving,   particularly   in   the   case o

f vehicles used in town, over short
distances.
  It   may   be   necessary   to   have
 t

he   condition   of   the   brakes   checked,
 e

ven   between   vehicle   services.
The
 
gearbox
 
does
 
not
 
require
 
any
 m
aintenance
 
(no
 
oil
 
change).
Refer
 
to
 
the
 
maintenance
 
and
 
w

arranty
 
guide
 
for
 
the
 
checking
 
i

nterval
 
for
 
this
 
component.
Only
  use   products   recommended   by  
C

ITR
oË
N or products of equivalent
quality
 an

d
 sp
ecification.
In
  order   to   optimise   the   operation   of  
u

nits   as   important   as   those   in   the  
b

raking   system,   CITROËN   selects   and  
o

ffers   very   specific   products.
The
 
gearbox
 
does
 
not
 
require
 
any
 
m

aintenance
 
(no
 
oil
 
change).
Refer
 
to
 
the
 
maintenance
 
and
 
w

arranty
 
guide
 
for
 
details
 
of
 
the
 
level
 
c

hecking
 
interval
 
for
 
this
 
component.
Electronic gearbox
The gearbox does not require any m aintenance   (no   oil   change).
Refer
  to   the   maintenance   and  
w

arranty   guide   for   details   of   the  
c

hecking   interval   for   this   component. For
  information   on   checking   brake  
d

isc wear, contact a CITR
oË
N dealer
or
  a   qualified   workshop.
Brake disc wearParking brake
If excessive travel or a loss of e
ffectiveness   of   this   system   is  
n

oticed,   the   parking   brake   must   be  
c

hecked,   even   between   two   services.
Unless
 
there
 
is
 
a
 
leak
 
in
 
the
 
circuit,
 
a
 
drop
 
in
 
t

he
 
brake
 
fluid
 
level
 
indicates
 
that
 
the
 
brake
 
p

ads
 
are
 
worn. Checking
 
this   system   must   be   done   by   a  
C

ITROËN   dealer   or   a   qualified   workshop.
After
 
washing
 
the
 
vehicle,
 
dampness,
 
o

r
 
in
 
wintry
 
conditions,
 
ice
 
can
 
form
 
o

n
 
the
 
brake
 
discs
 
and
 
pads:
 
braking
 
e

fficiency
 
may
 
be
 
reduced.
 
Make
 
light
 
b

rake
 
applications
 
to
 
dry
 
and
 
defrost
 
t

he
 
brakes.

361
DS3_en_Chap14_index-recherche_ed01-2014
Technical data - Maintenance
Running out of Diesel 193a
dblu e® additive and SCR
system   (BlueHDi   Diesel)  1 94-201
Checking
  levels  
2
51-254
-

oil
-
 
b

rake   fluid
-


coolant
-

s

creenwash fluid
-

additive (Diesel with particle emissions filter)Checking components 2 55 -256
- battery
-
 
a
ir   filter   /   passenger   compartment   filter
-

o
il filter
-
 
p
article   emissions   filter   (Diesel)
-
 
b
rake   pads/discs
Changing
 bu

lbs
 2
15-223
-
front
-
rear
-


interior
bat
tery

231-233
Energy   economy   mode  
2
34
Engine
 c
ompartment
 
f
uses
2
24, 227-230
bo

nnet

247-248
Under-bonnet
  layout,   petrol  
2
49
Under-bonnet layout, Diesel
2

50
Petrol
  engines  
2
60 -262
LPG
  engine  
2
66
Diesel
 e

ngines
 26
8-269Petrol
  weights  
2
63 -265
LPG   weights  
2
67
Diesel   weights  
2
70 -271
Dimensions
 2
72-273
Identification
 ma

rkings
 2
74
Visual search