maintenance schedule DODGE CARAVAN 2007 4.G User Guide

EMISSION CONTROL SYSTEM MAINTENANCE
The “Scheduled” maintenance services, listed inbold
type must be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE: Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part, which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
required service for your vehicle.
First is Schedule “B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 0° C (32° F).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 16 km (10 miles).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 32° C (90° F).
•Trailer towing. \b
466 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

•Taxi, police, or delivery service (commercial ser-
vice). \b
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE: Most vehicles are operated under the conditions
listed for Schedule B.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 467
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
•Check all lights and all other electrical items for correct
operation. At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
468 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 108, 000 111, 000 114, 000 117, 000 120, 000
(Kilometers) (180 000) (185 000) (190 000) (195 000) (200 000)
Inspect the serpentine drive belt on 3.3 liter
and 3.8 liter engines, replace if necessary. ‡ X
Change the automatic transmission fluid and
filter.
X
Replace the air conditioning filter. XX
‡ This maintenance is not required if previously replaced.

This maintenance is required only for police, taxi,
limousine type operation, or trailer towing. Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 477
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 102, 000 108, 000 114, 000 120, 000
(Kilometers) (170 000) (180 000) (190 000) (200 000)
[Months] [102] [108] [114] [120]
Inspect the serpentine drive belt on 3.3 liter and 3.8 liter
engines, replace if necessary. ‡ XX
Flush and replace the engine coolant at 120 months, if not
done at 102,000 miles. X
Replace the air conditioning filter. XX
‡ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
SCHEDULE “A” 483
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Maintenance, Airbag...................... 71
Maintenance Free Battery .................. 427
Maintenance Procedures ................... 419
Maintenance Schedule .................... 466
Light Duty Schedule “B” ................. 469
Schedule “A” ......................... 478
Schedule “B” ......................... 469
Maintenance, Sunroof ..................... 185
Malfunction Indicator Light (Check Engine) . . 218,417
Manual, Service ......................... 490
Map/Reading Lights ..................... 168
Memory Seat ........................... 99
Mini-Trip Computer ...................... 171
Mirrors ................................ 96
Automatic Dimming ..................... 96
Electric Remote ........................ 98
Exterior Folding ........................ 98
Heated .............................. 99
Outside .............................. 97 Rearview
............................. 96
Vanity ............................... 99
Modifications/Alterations, Vehicle ............. 7
Monitor, Tire Pressure System ............... 347
Mopar Parts ......................... 418,489
Multi-Function Control Lever ............... 155
Navigation Radio ........................ 257
Navigation System ....................... 257
New Vehicle Break-In Period ................ 88
Occupant Restraints ....................... 46
Octane Rating, Gasoline (Fuel) .............. 353
Odometer ............................. 219
Oil, Engine ......................... 420,462
Capacity ............................ 461
Change Interval ....................... 421
Checking ............................ 420
Disposal ............................ 423
506 INDEX

Replacement Tires....................... 343
Reporting Safety Defects ................... 489
Restraint, Head ......................... 125
Restraints, Child ....................... 75,82
Restraints, Infant ......................... 75
Rocking Vehicle When Stuck ................ 407
Roof Rack (Luggage Rack) ................. 199
Rotation, Tires .......................... 346
Safety Checks Inside Vehicle ................. 89
Safety Checks Outside Vehicle ............... 90
Safety Defects, Reporting .................. 489
Safety, Exhaust Gas ....................... 43
Safety Information, Tire ................... 327
Safety Tips ............................. 89
Satellite Radio .......................... 271
Satellite Radio Antenna ................... 274
Schedule, Maintenance .................... 466
Seat Belt Maintenance .................... 450 Seat Belt Reminder
..................... 54,55
Seat Belts .............................. 46
Adjustable Shoulder Belt .................. 52
Adjustable Upper Shoulder Anchorage ........ 52
And Pregnant Women ................... 56
Center Lap Belt ........................ 53
Child Restraint ....................... 75,77
Extender ............................. 56
Front Seat ............................ 47
Pretensioners .......................... 54
Rear Seat ............................. 47
Untwisting Procedure .................... 53
Seats ................................. 123
Adjustment .......................... 123
Bench ............................ 143,144
Easy Entry ........................... 137
Easy-Out Roller ....................... 143
Fold in Floor (Stow nGo) ................ 129
Heated ............................. 126
INDEX 509
10