belt DODGE CHALLENGER 2012 3.G Service Manual

STARTING PROCEDURES
Before starting your vehicle, adjust your seat, adjust the
inside and outside mirrors, fasten your seat belt, and if
present, instruct all other occupants to buckle their seat
belts.
WARNING!
•When leaving the vehicle, always remove the key
fob from the ignition and lock your vehicle.
•Never leave children alone in a vehicle, or with
access to an unlocked vehicle. Allowing children
to be in a vehicle unattended is dangerous for a
number of reasons. A child or others could be
seriously or fatally injured. Children should be
warned not to touch the parking brake, brake
pedal or the shift lever.(Continued)
WARNING! (Continued)
•Do not leave the key fob in or near the vehicle, and
do not leave a vehicle equipped with Keyless
Enter-N-Go in the ACC or ON/RUN mode. A child
could operate power windows, other controls, or
move the vehicle.
Manual Transmission – If Equipped
Apply the parking brake, place the shift lever in NEU-
TRAL and press the clutch pedal before starting vehicle.
This vehicle is equipped with a clutch interlocking igni-
tion system. It will not start unless the clutch pedal is
pressed to the floor.
Normal Starting With Integrated Key – Manual
Transmission
Normal starting of either a cold or a warm engine does
not require pumping or pressing the accelerator pedal.
Press the clutch pedal fully to the floor, and turn the
252 STARTING AND OPERATING

WARNING! (Continued)
•The battery in this vehicle has a vent hose that
should not be disconnected and should only be
replaced with a battery of the same type (vented).
CAUTION!
•It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to
the negative post. Battery posts are marked posi-
tive (+) and negative (-) and are identified on the
battery case. Cable clamps should be tight on the
terminal posts and free of corrosion.
•If a “fast charger” is used while the battery is in
the vehicle, disconnect both vehicle battery cables
before connecting the charger to the battery. Do
not use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air condi-
tioning components. Such damage is not covered by
the New Vehicle Limited Warranty.
400 MAINTAINING YOUR VEHICLE

Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with MOPARGlass Cleaner or equivalent, or any com-
mercial household-type glass cleaner. Never use an abra-
sive type cleaner. Use caution when cleaning the inside
rear window equipped with electric defrosters or the
right rear quarter window equipped with the radio
antenna. Do not use scrapers or other sharp instrument
that may scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag or micro-fiber towel. A mild
soap solution may be used, but do not use high alcohol
content or abrasive cleaners. If soap is used, wipe clean
with a clean damp rag.
2. Dry with a soft cloth.
Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use MOPAR Total Clean or
equivalent, a mild soap solution, or lukewarm water. Do
not remove the belts from the vehicle to wash them. Dry
with a soft cloth.
7
MAINTAINING YOUR VEHICLE 423

Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning The Center Console Cupholders
Clean with a damp cloth or towel using a mild detergent
with the cupholder in the center console.
NOTE:The cupholder cannot be removed.
FUSES
Integrated Power Module
The Integrated Power Module is located in the engine
compartment. This module contains fuses and relays.
Integrated Power Module
424 MAINTAINING YOUR VEHICLE

Automatic Door Locks..................... 33
Automatic Headlights .................... 139
Automatic Temperature Control (ATC) ......... 238
Automatic Transaxle Special Additives ..................... 416
Automatic Transmission .............266,416,418
Adding Fluid .................... 418,440
Autostick .......................... 273
Fluid and Filter Changes ............... 418
Fluid Change ....................... 418
Fluid Level Check .................... 417
Fluid Type ......................... 440
Special Additives ..................... 416
Autostick ............................. 273
Axle Fluid ............................. 440
Axle Lubrication (Axle Fluid) ............... 440
B-Pillar Location ........................ 301 Battery
............................... 398
Keyless Transmitter Replacement (RKE) ..... 26
Location ........................... 398
Belts, Seat ............................ 45,80
Body Mechanism Lubrication ............... 403
Brake Assist System ...................... 289
Brake Control System, Electronic ............. 287
Brake Fluid ............................ 440
Brake System ........................ 284,413
Anti-Lock (ABS) .................. 285,288
Fluid Check ..................... 414,440
Master Cylinder ..................... 414
Parking ........................... 281
Warning Light .................... 181,284
Brake, Parking .......................... 281
Brake/Transmission Interlock ............... 266
Brakes ............................. 284,413
Break-In Recommendations, New Vehicle ........ 77
10
INDEX 471

Key, Replacement........................ 17
Key, Sentry (Immobilizer) ................... 16
Keyless Enter-N-Go™ ................34,194,254
Keyless Entry System ...................... 21
Keyless Go .......................... 12,194
Keys ................................. 12
Kicker Sound System ..................... 234
Knee Bolster .......................... 54,55
Lane Change and Turn Signals .............. 142
Lap/Shoulder Belts ....................... 45
LATCH
(Lower Anchors and Tether for CHildren) .....72,73
Latches ................................ 82
Hood ............................. 137
Lead Free Gasoline ...................... 327
Leaks, Fluid ............................ 82
Life of Tires ............................ 312
Light Bulbs .......................... 82,432Lights
.............................. 82,138
Airbag .................... 61,62,67,80,178
Alarm ............................ 183
Anti-Lock ....................... 185,287
Automatic Headlights ................. 139
Brake Assist Warning .................. 294
Brake Warning .................... 181,284
Bulb Replacement ................. 432,433
Center Mounted Stop .................. 436
Courtesy/Reading ................. 143,151
Cruise ............................ 176
Daytime Running .................... 140
Dimmer Switch, Headlight ...........142,143
Electronic Stability Program (ESP) Indicator . . 294
Electronic Throttle Control Warning ....... 177
Engine Temperature Warning ............ 179
Exterior ............................ 82
Fog ............................ 141,181
Hazard Warning Flasher ............... 353
10
INDEX 479

Headlight Switch..................... 138
Headlights ...................... 138,433
Headlights On Reminder ............... 141
Headlights On With Wipers ..........139,147
High Beam ...................... 143,180
High Beam Indicator .................. 180
High Beam/Low Beam Select ............ 143
Illuminated Entry ..................... 21
Instrument Cluster ................. 138,176
Intensity Control ..................... 144
Interior ......................... 143,151
License ............................ 437
Lights On Reminder .................. 141
Low Fuel .......................... 185
Malfunction Indicator (Check Engine) ...... 185
Map Reading ..................... 143,151
Oil Pressure ........................ 180
Parade Mode (Daytime Brightness) ........ 144
Passing ............................ 143 Reading
........................ 143,151
Seat Belt Reminder ................... 180
Security Alarm (Theft Alarm) ............ 183
Service ......................... 432,433
Service Engine Soon
(Malfunction Indicator) ................ 185
Theft Alarm (Security Alarm) ............ 183
Tire Pressure Monitoring (TPMS) .......183,317
Traction Control ..................... 294
Turn Signal .................... 82,142,178
Vanity Mirror ........................ 90
Voltage ............................ 176
Warning (Instrument Cluster Description) . . . 176
Loading Vehicle ...................... 334,336
Capacities .......................... 336
Tires .............................. 301
Locks ................................. 31
Auto Unlock ......................... 33
Automatic Door ...................... 33
480 INDEX

Pets.................................. 77
Phone, Cellular .......................... 92
Phone, Hands-Free (Uconnect™) .............. 92
Placard, Tire and Loading Information ......... 301
Power Brakes ............................ 284
Deck Lid Release ..................... 40
Distribution Center (Fuses) .............. 427
Door Locks ......................... 32
Mirrors ............................ 89
Outlet (Auxiliary Electrical Outlet) ........ 163
Seats ............................. 126
Steering ........................... 280
Sunroof ........................... 161
Windows ........................... 38
Power Steering Fluid ..................... 440
Pregnant Women and Seat Belts .............. 54
Preparation for Jacking .................... 367 Pretensioners
Seat Belts ........................... 52
Programmable Electronic Features ............ 198
Programming Transmitters
(Remote Keyless Entry) .................... 21
Radial Ply Tires ......................... 308
Radiator Cap (Coolant Pressure Cap) .......... 411
Radio Operation ........................ 237
Radio Remote Controls .................... 235
Rear Cupholder ......................... 168
Rear Seat, Folding ....................... 135
Rear Window Defroster ................... 170
Rear Window Features .................... 170
Recorder, Event Data ...................... 67
Recreational Towing ...................... 348
Reformulated Gasoline .................... 328
Refrigerant ............................ 401
Release, Hood .......................... 137
10
INDEX 483

Reminder, Lights On..................... 141
Reminder, Seat Belt ....................... 53
Remote Control Starting System ....................... 27
Remote Keyless Entry (RKE) ................. 21
Remote Sound System (Radio) Controls ........ 235
Remote Starting System .................... 27
Remote Trunk Release ..................... 40
Replacement Bulbs ....................... 432
Replacement Keys ........................ 17
Replacement Parts ....................... 392
Replacement Tires ....................... 313
Reporting Safety Defects ................... 464
Restraint, Head ......................... 132
Restraints, Child ......................... 68
Restraints, Occupant ...................... 42
Rocking Vehicle When Stuck ................ 378
Rotation, Tires .......................... 316 Safety Checks Inside Vehicle
................. 80
Safety Checks Outside Vehicle ............... 82
Safety Defects, Reporting .................. 464
Safety Information, Tire ................... 296
Safety Tips ............................. 78
Safety, Exhaust Gas ....................... 79
Satellite Radio Antenna ................... 224
Schedule, Maintenance .................... 442
Seat Belt Maintenance .................... 423
Seat Belt Reminder ....................... 53
Seat Belts .......................... 42,45,80
And Pregnant Women .................. 54
Child Restraint ................. 68,69,70,75
Extender ........................... 54
Front Seat ......................... 45,46
Inspection .......................... 80
Operating Instructions .................. 46
Pretensioners ........................ 52
Rear Seat ........................... 45
484 INDEX

Reminder.......................... 180
Untwisting Procedure .................. 50
Seats ................................. 126
Adjustment ......................... 126
Head Restraints ...................... 132
Heated ............................ 129
Height Adjustment ................... 126
Power ............................ 126
Rear Folding ........................ 135
Seatback Release ..................... 135
Tilting ............................ 126
Security Alarm (Theft Alarm) ................ 18
Selection of Coolant (Antifreeze) ..........409,439
Selection of Oil ......................... 395
Sentry Key (Immobilizer) ................... 16
Sentry Key Programming ................... 18
Sentry Key Replacement ................... 17
Service Assistance ....................... 461 Service Contract
......................... 463
Service Engine Soon Light
(Malfunction Indicator) .................... 185
Service Manuals ........................ 465
Setting the Clock ..................... 204,213
Settings, Personal ........................ 198
Shift Indicator Light ...................... 263
Shift Lever Override ...................... 379
Shifting ............................... 265
Automatic Transmission ................ 265
Short Message Service (SMS) ................ 113
Shoulder Belts ........................... 45
Side Airbag ............................. 63
Side Window Demisters (Defrosters) .......... 244
Signals, Turn ...................... 82,142,178
Slippery Surfaces, Driving On ............... 277
Snow Chains (Tire Chains) ................. 314
Snow Tires ............................ 316
10
INDEX 485