belt DODGE DURANGO 2009 2.G Service Manual

STARTING PROCEDURES
Before starting your vehicle, adjust your seat, adjust the
inside and outside mirrors, fasten your seat belt, and if
present, instruct all other occupants to buckle their seat
belts.
WARNING!
•Never leave children alone in a vehicle. Leaving
unattended children in a vehicle is dangerous for a
number of reasons. A child or others could be
seriously or fatally injured. Do not leave the key in
the ignition. A child could operate power win-
dows, other controls, or move the vehicle.
•Do not leave animals or children inside parked
vehicles in hot weather; interior heat buildup may
cause serious injury or death.
Normal Starting
The shift lever must be in the NEUTRAL or PARK
position before you can start the engine. Apply the brakes
before shifting into any driving gear.
NOTE:Normal starting of either a cold or a warm
engine is obtained without pumping or depressing the
accelerator pedal.
Tip Start Feature
Do notpress the accelerator. Turn the ignition switch to
the START position and release it as soon as the starter
engages. The starter motor will continue to run, and it
will disengage automatically when the engine is running.
If the engine fails to start, the starter will disengage
automatically in 10 seconds. If this occurs, turn the
ignition switch to the LOCK position, wait 10 to 15 sec-
onds, then repeat the normal starting procedure.
STARTING AND OPERATING 289
5

WARNING!
Do not permit vehicles to touch each other as this
could establish a ground connection and personal
injury could result.
5. Connect the other cable, first to the negative terminal
of the booster battery and then to the engine of the
vehicle with the discharged battery. Make sure you have
a good contact on the engine.
WARNING!
•Do not connect the cable to the negative post of the
discharge battery. The resulting electrical spark
could cause the battery to explode.
(Continued)
WARNING! (Continued)
•During cold weather when temperatures are be-
low freezing point, electrolyte in a discharged
battery may freeze. Do not attempt jump-starting
because the battery could rupture or explode. The
battery temperature must be brought up above
freezing point before attempting a jump-start.
6. Start the engine in the vehicle which has the booster
battery, let the engine idle a few minutes, then start the
engine in the vehicle with the discharged battery.
7. When removing the jumper cables, reverse the above
sequence exactly. Be careful of the moving belts and fan.
WHAT TO DO IN EMERGENCIES 389
6

WARNING! (Continued)
•Battery posts, terminals and related accessories
contain lead and lead compounds. Wash hands
after handling.
CAUTION!
•It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to
the negative post. Battery posts are marked (+)
positive and negative (-) and identified on the
battery case.
•If a “fast charger” is used while battery is in
vehicle, disconnect both vehicle battery cables
before connecting the charger to battery. Do not
use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Section 3 of the Warranty Information book for
further warranty information.
(Continued)
MAINTAINING YOUR VEHICLE 405
7

Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with any commercial household-type glass cleaner.
Never use an abrasive type cleaner. Use caution when
cleaning inside rear windows equipped with electric
defrosters or windshields equipped with a windshield
wiper de-icer. Do not use scrapers or other sharp instru-
ments which may scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage will also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the
vehicle to wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
MAINTAINING YOUR VEHICLE 425
7

120,000 Miles (200,000 km) or 120 Months Maintenance Service Schedule
❏Change the engine oil and engine oil filter.
❏Rotate tires.
❏Replace the engine air cleaner filter.
❏Replace the ignition cables (3.7L Engine).
❏Replace the top row of spark plugs (4.7L Engine). **
❏Replace the spark plugs (3.7L and 5.7L Engine).
❏Inspect the brake linings; replace if necessary.
❏Inspect the CV joints.
❏Inspect the transfer case fluid.
❏Inspect exhaust system.
❏Inspect the front suspension, tie rod ends and boot seals; replace if necessary.
❏Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
❏Change the automatic transmission fluid and filter.
❏Replace accessory drive belt(s).
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
MAINTENANCE SCHEDULES 459
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Axle Fluid............................. 445
Axle Lubrication (Axle Fluid)............... 420
Battery.......................395,396,397,404
Charging............................ 388
Emergency Starting..................... 388
Gas Caution.......................... 388
Keyless Transmitter Replacement (RKE)....... 25
Saving Feature (Protection)............... 147
Belts, Seat............................40,74
Body Mechanism Lubrication............... 406
B-Pillar Location........................ 325
Brake Assist System...................... 313
Brake Control System, Electronic............. 312
Brake Fluid............................ 445
Brake System........................... 416
Anti-Lock (ABS)....................309,312
Fluid Check.......................... 416
Master Cylinder....................... 416Parking............................. 308
Warning Light.....................205,210
Brake/Transmission Interlock............... 293
Break-In Recommendations, New Vehicle........ 71
Bulb Replacement....................... 435
Bulbs, Light..........................74,434
Calibration, Compass..................... 174
Camera, Rear........................... 163
Capacities, Fluid........................ 443
Caps, Filler
Fuel............................... 355
Oil (Engine).......................... 402
Power Steering........................ 307
Radiator (Coolant Pressure)............... 413
Car Washes............................ 421
Carbon Monoxide Warning...............73,351
Cargo Management System................. 191
Cargo Organizer....................... 191
INDEX 475
10

Extender, Seat Belt........................ 50
Exterior Lights.......................... 74
Filters
Air Cleaner.......................... 403
Engine Oil........................403,444
Engine Oil Disposal.................... 403
Flashers
Hazard Warning....................... 378
Turn Signal...................74,149,203,437
Flat Tire Stowage.....................380,387
Flexible Fuel Vehicles
Cruising Range....................... 355
Engine Oil........................... 354
Fuel Requirements..................352,353
Replacement Parts..................... 355
Starting............................. 354
Flooded Engine Starting................... 290
Floor Console.......................189,190Fluid, Brake.........................416,445
Fluid Capacities......................... 443
Fluid Leaks............................. 75
Fluid Level Checks
Automatic Transmission................. 417
Brake.............................. 416
Engine Oil........................... 401
Power Steering........................ 307
Transfer Case......................... 419
Fluids, Lubricants and Genuine Parts.......... 444
Fog Lights..........................148,442
Folding Rear Seat.....................128,132
Four Wheel Drive....................... 298
Operation........................... 298
Four-Way Hazard Flasher.................. 378
Freeing A Stuck Vehicle................... 390
Front Axle (Differential)................... 420
Fuel................................. 347
Filler Cap (Gas Cap).................355,357
INDEX 479
10

Key, Programming........................ 17
Key, Replacement........................ 16
Key, Sentry (Immobilizer)................... 15
Keyless Entry System...................... 20
Keys................................. 12
Knee Bolster............................ 51
Lane Change and Turn Signals.........149,203,437
Lap/Shoulder Belts....................... 40
LATCH (Lower Anchors and Tether for
CHildren).............................. 65
Latches................................ 75
Leaks, Fluid............................ 75
Life of Tires............................ 335
Liftgate................................ 35
Light Bulbs............................. 74
Lights..............................74,143
Airbag..........................60,74,214
Anti-Lock Warning..................... 205Back-Up............................ 437
Brake Warning........................ 210
Bulb Replacement...................434,435
Center Mounted Stop................... 441
Courtesy/Reading..................... 165
Cruise.............................. 215
Daytime Running...................... 148
Dome.............................. 166
Electronic Stability Program (ESP)
Indicator......................... 211,316
Exterior.............................. 74
Fog ..........................148,208,442
Hazard Warning Flasher................. 378
High Beam.......................... 150
High Beam/Low Beam Select............. 150
Instrument Cluster..................... 203
Interior..........................146,165
License............................. 440
Lights On Reminder.................... 148
482 INDEX

Low Fuel............................ 203
Malfunction Indicator (Check Engine)........ 212
Passing............................. 150
Reading............................. 166
Seat Belt Reminder..................... 204
Service............................. 434
Tire Pressure Monitoring (TPMS)........... 212
Traction Control....................... 316
Turn Signal......................74,149,437
Voltage............................. 205
Warning (Instrument Cluster Description)..... 203
Loading Vehicle......................... 358
Tires ............................... 325
Locks................................. 28
Automatic Door........................ 29
Child Protection........................ 32
Door................................ 28
Keys................................ 12
Power Door........................... 29Steering Wheel......................... 14
Lower Anchors and Tether for CHildren
(LATCH).............................. 65
Lubrication, Body....................... 406
Lug Nuts............................. 386
Luggage Carrier......................... 195
Lumbar Support........................ 122
Maintenance Free Battery.................. 404
Maintenance Procedures................... 401
Maintenance Schedule.................... 448
Malfunction Indicator Light (Check Engine) . . 212,399
Manual, Service......................... 469
Manual Transmission
Lubricant Selection..................... 445
Map/Reading Lights..................165,166
Memory Seat........................... 136
Mirrors................................ 82
Automatic Dimming...................82,85
INDEX 483
10

Owner’s Manual (Operator Manual).........5,469
Panic Alarm............................ 24
Park Sense System, Rear................... 158
Parking Brake.......................... 308
Parking On Hill......................... 308
Passing Light........................... 150
Pedals, Adjustable....................... 154
Personal Settings........................ 170
Pets.................................. 71
Pets, Transporting........................ 71
Phone, Cellular.......................... 86
Phone, Hands-Free (uconnect)............... 86
Placard, Tire and Loading Information......... 325
Power
Distribution Center (Fuses).......395,396,397,429
Door Locks.........................20,29
Lift Gate............................. 36
Mirrors.............................. 83Outlet (Auxiliary Electrical Outlet).......184,187
Steering..........................306,307
Steering Filler Cap................395,396,397
Sunroof............................. 182
Windows............................. 33
Power Steering Fluid..................... 445
Pregnant Women and Seat Belts.............. 50
Preparation for Jacking.................... 382
Pretensioners
Seat Belts............................ 48
Programmable Electronic Features............ 170
Programming Transmitters
(Remote Keyless Entry).................... 25
Radial Ply Tires......................... 332
Radiator Cap (Coolant Pressure Cap)....... 411,413
Radio Operation........................ 268
Radio, Satellite (uconnect gps)............260,265
Rear Axle (Differential).................... 420
INDEX 485
10