radiator cap DODGE JOURNEY 2016 1.G Owners Manual

CAUTION!
Driving with a hot cooling system could damage
your vehicle. If the temperature gauge reads “H,”
safely pull over and stop the vehicle. Idle the vehicle
with the A/C turned off until the pointer drops back
into the normal range. If the pointer remains on the
“H,” and you hear continuous chimes, turn the en-
gine OFF immediately, and call for service.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
2.4L Engine — If Equipped
On hot days the engine oil temperature may become too
hot during sustained high-speed driving or if towing a
trailer up long grades. If this happens, a HOTOIL mes-
sage will flash in the odometer and the vehicle speed will
be reduced to 48 mph (77 km/h) maximum until the
engine oil temperature is reduced.
NOTE:The maximum vehicle speed is reduced to
48 mph (77 km/h), you may reduce vehicle speed further
as needed. Once the engine oil temperature is reduced,
you may continue to drive normally
WHEEL AND TIRE TORQUE SPECIFICATIONS
Proper lug nut/bolt torque is very important to ensure
that the wheel is properly mounted to the vehicle. Any
time a wheel has been removed and reinstalled on the
vehicle the lug nuts/bolts should be torqued using a
properly calibrated torque wrench.
530 WHAT TO DO IN EMERGENCIES

WARNING!
•Take care to avoid the radiator cooling fan when-
ever the hood is raised. It can start anytime the
ignition switch is ON. You can be injured by
moving fan blades.
• Remove any metal jewelry such as rings, watch
bands and bracelets that could make an inadvertent
electrical contact. You could be seriously injured.
• Batteries contain sulfuric acid that can burn your
skin or eyes and generate hydrogen gas which is
flammable and explosive. Keep open flames or
sparks away from the battery.
1. Set the parking brake, shift the automatic transmission into PARK and turn the ignition to LOCK.
2. Turn off the heater, radio, and all unnecessary electri- cal accessories.
Remote Battery Posts
1 — Remote Positive (+) Post (Covered With Protective Cap)
2 — Remote Negative (-) Post
6
WHAT TO DO IN EMERGENCIES 547

4. Install the wiper blade pivot pin into the wiper bladeholder at the end of the wiper arm, and firmly press
the wiper blade until it snaps into place.
5. Lower the wiper blade and snap the pivot cap into place.
Adding Washer Fluid
The windshield washer and the rear window washer
share the same fluid reservoir. The fluid reservoir is
located in the engine compartment. Be sure to check the
fluid level in the reservoir at regular intervals. Fill the
reservoir with windshield washer solvent (not radiator
antifreeze) and operate the system for a few seconds to
flush out the residual water.
When refilling the washer fluid reservoir, apply some
washer fluid to a cloth or towel and wipe the wiper
blades clean. This will help blade performance. To prevent freeze-up of your windshield washer system
in cold weather, select a solution or mixture that meets or
exceeds the temperature range of your climate. This
rating information can be found on most washer fluid
containers.
The fluid reservoir will hold nearly 1 gal (4 l) of washer
fluid when the message “LoWASH” appears in the
instrument cluster.
WARNING!
Commercially available windshield washer solvents
are flammable. They could ignite and burn you. Care
must be exercised when filling or working around
the washer solution.
576 MAINTAINING YOUR VEHICLE

To minimize the possibility of catalytic converter dam-
age:
•Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
• Do not try to start the engine by pushing or towing the
vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.Cooling System
WARNING!
• When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the LOCK position. The fan is tempera-
ture controlled and can start at any time the igni-
tion switch is in the ON position.
• You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had
time to cool. Never try to open a cooling system
pressure cap when the radiator is hot.
Coolant Checks
Check the engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
7
MAINTAINING YOUR VEHICLE 579

Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words “DO NOT OPEN HOT” on the
cooling system pressure cap are a safety precaution.
Never add engine coolant (antifreeze) when the
engine is overheated. Do not loosen or remove the
cap to cool an overheated engine. Heat causes
pressure to build up in the cooling system. To
prevent scalding or injury, do not remove the
(Continued)
WARNING! (Continued)
pressure cap while the system is hot or under
pressure.
• Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
7
MAINTAINING YOUR VEHICLE 583

Coolant Level
2.4L Engine —The coolant bottle provides a quick visual
method for determining that the coolant level is ad-
equate. With the engine idling and warm to normal
operating temperature, the level of the coolant in the
bottle should be between the “ADD” and “FULL” lines,
shown on the bottle.
3.6L Engine — The level of the coolant in the pressurized
coolant bottle should be between the “COLD” and
“FULL” range on the bottle when the engine is cold.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing engine coolant (anti-
freeze). Advise your service attendant of this. As long as
the engine operating temperature is satisfactory, the
coolant bottle need only be checked once a month. When additional engine coolant (antifreeze) is needed to main-
tain the proper level, it should be added to the coolant
bottle. Do not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle.
584 MAINTAINING YOUR VEHICLE

Body Mechanism Lubrication.................573
B-Pillar Location ......................... .470
Brake Assist System ...................... .453
Brake Control System, Electronic ..............450
Brake Fluid ............................ .618
Brake, Parking .......................... .446
Brakes ................................ .449
Brake System ........................ .449, 585
Fluid Check ....................... .586, 618
Master Cylinder ....................... .586
Parking ............................. .446
Warning Light ........................ .304
Brake/Transmission Interlock .................431
Brightness, Interior Lights ...................230
Bulb Replacement ..................... .606, 608
Bulbs, Light ..........................111,606
Camera, Rear ........................... .250
Capacities, Fluid ......................... .614Caps, Filler
Fuel ................................ .505
Oil (Engine) ....................... .559, 567
Power Steering ........................ .445
Radiator (Coolant Pressure) ................583
Carbon Monoxide Warning ...............108, 502
Cargo Area Cover ........................ .286
Cargo Area Features ...................... .282
Cargo Compartment ...................... .282
Light ............................... .282
Luggage Carrier ....................... .290
Cargo Load Floor ........................ .283
Cargo Management System ..................283
Rollaway Tonneau Cover ..................286
Tri-Fold Load Floor ..................... .283
Cargo Tie-Downs ........................ .284
Cargo (Vehicle Loading) .................283, 508
Car

Washes ............................ .593
Certification Label ........................ .508
640 INDEX

Chains, Tire............................ .488
Changing A Flat Tire ...................... .532
Chart, Tire Sizing ........................ .465
Check Engine Light (Malfunction Indicator Light) . .562
Checking Your Vehicle For Safety ..............107
Checks, Safety .......................... .107
Child Restraint ............................78
Child Restraints Booster Seats ...........................86
Child Restraints .........................78
Child Seat Installation .................99, 101
How To Stow An Unused ALR Seat Belt ........97
Infants And Child Restraints ................81
Install A LATCH-Compatible Child Restraint ....96
Installing Child Restraints Using The Vehicle
Seat Belt ..............................98
Locating The LATCH Anchorages ............93
Lower Anchors And Tethers For Children .......89
Older Children And Child Restraints ..........82Seating Positions
........................88
Using The Top Tether Anchorage ............103
Child Safety Locks .........................33
Clean Air Gasoline ....................... .498
Cleaning Wheels .............................. .595
Coin Holder ............................ .277
Cold Weather Operation ....................427
Compact Disc (CD) Maintenance ..............387
Compact Spare Tire ....................... .482
Computer, Trip/Travel ..................... .334
Connector UCI................................ .385
Universal Consumer Interface (UCI) ..........385
Conserving Fuel ......................... .332
Console, Floor .......................... .277
Console, Overhead ....................... .252
Contract, Service ......................... .631
Coolant Pressure Cap (Radiator Cap) ...........583
10
INDEX 641

Cooling System.......................... .579
Adding Coolant (Antifreeze) ...............581
Coolant Capacity ...................... .614
Coolant Level ..................... .579, 584
Disposal Of Used Coolant .................583
Drain, Flush, And Refill ...................580
Inspection ........................... .584
Points To Remember .....................584
Pressure Cap ......................... .583
Radiator Cap ......................... .583
Selection Of Coolant (Antifreeze) ......580, 614, 616
Corrosion Protection ...................... .592
Cruise Light ............................ .325
Cupholders ......................... .274, 599
Customer Assistance ...................... .629
Data Recorder, Event .......................77
Daytime Brightness, Interior Lights .............231
Daytime Running Lights ....................226 Dealer Service
........................... .563
Defroster, Rear Window .....................290
Defroster, Windshield ..................... .109
Delay (Intermittent) Wipers ..................232
Diagnostic System, Onboard .................561
Dimmer Switch, Headlight ...................229
Dipsticks Automatic Transmission ...............588, 590
Oil (Engine) .......................... .565
Power Steering ........................ .445
Disabled Vehicle Towing ....................552
Disposal Antifreeze (Engine Coolant) ................583
Door Ajar .......................... .312, 313
Door Ajar Light ...................... .312, 313
Door Locks Door Locks ............................30
KeyFob...............................30
Remote ...............................30
642 INDEX

Distribution Center (Fuses)................602
Door Locks ............................31
Inverter ............................. .272
Mirrors ............................. .121
Outlet (Auxiliary Electrical Outlet) ...........268
Seats ............................... .199
Steering .......................... .444, 445
Sunroof ............................. .264
Transfer Unit ......................... .592
Windows ..............................41
Power Seats Down .............................. .200
Forward ............................. .200
Rearward ............................ .200
Up ................................ .200
Power Steering Fluid ...................... .618
Power Transfer Unit ....................592, 618
Pregnant Women And Seat Belts ...............57
Preparation For Jacking .....................534 Pretensioners
Seat Belts ..............................57
Programming Transmitters (Remote Keyless Entry) . .21
Radial Ply Tires ......................... .478
Radiator Cap (Coolant Pressure Cap) ...........583
Radio Frequency General Information ............15, 18, 26, 29, 40
Radio Operation ......................... .387
Radio Remote Controls .....................385
Rear Air Conditioning ...................397, 411
Rear Axle (Differential) .....................591
Rear Camera ........................... .250
Rear Cupholder ......................... .274
Rear Drive Assembly ...................... .591
Rear Liftgate .............................44
Rear ParkSense System .....................242
Rear Seat, Folding .....................213, 220
Rear Window Defroster .....................290
652 INDEX