oil filter DODGE NITRO 2008 1.G Owners Manual

MAINTAINING YOUR VEHICLE
CONTENTS
mEngine Compartment ± 3.7L...............348
mEngine Compartment ± 4.0L...............349
mOnboard Diagnostic System Ð OBD II........350
NLoose Fuel Filler Cap Message............351
mEmissions Inspection And Maintenance
Programs............................351
mReplacement Parts......................353
mDealer Service.........................353
mMaintenance Procedures..................354NEngine Oil..........................354
NDrive Belts Ð Check Condition And Tension . . 358
NSpark Plugs.........................358
NCatalytic Converter....................359
NCrankcase Emission Control System........361
NFuel Filter..........................361
NEngine Air Cleaner Filter................361
NMaintenance-Free Battery................362
NAir Conditioner Maintenance.............362
7

SAE 10W-30engine oil is preferred. SAE 5W-30 engine oil
is allowed during cold weather only to improve cold
weather starting.
Lubricants which do not have both, the engine oil certi-
fication mark and the correct SAE viscosity grade num-
ber should not be used.
Materials Added To Engine Oils
The manufacturerstrongly recommendsagainst the ad-
dition of any additives (other than leak detection dyes) to
engine oil. Engine oil is an engineered product and it's
performance may be impaired by supplemental addi-
tives.
Disposing of Used Engine Oil
Care should be taken in disposing of used engine oil from
your vehicle. Used oil, indiscriminately discarded, can
present a problem to the environment. Contact your
authorized dealer, service station, or governmental
agency for advice on how and where used oil can be
safely discarded in your area.
Engine Oil Filter
The engine oil filter should be replaced at every engine
oil change.
NOTE:For best access to the oil filter, a drive on hoist
should be used instead of a chassis hoist (3.7L Only).
MAINTAINING YOUR VEHICLE 357
7

Engine Oil Filter Selection
All of the manufacturer's engines have a full-flow type
disposable oil filter. Use a filter of this type for replace-
ment. The quality of replacement filters varies consider-
ably. Only high quality filters should be used to assure
most efficient service. Mopartengine oil filters are high
quality oil filters and are recommended.
Drive Belts Ð Check Condition and Tension
Belt tension is controlled by means of an automatic
tensioner. No belt tension adjustments are required.
However, belt and belt tensioner condition should be
inspected at the specified intervals, and replaced if re-
quired. See your authorized dealer for service
At the mileage indicated in the appropriate ªMainte-
nance Scheduleº, all belts and tensioner should be
checked for condition. Improper belt tension can cause
belt slippage and failure.Belts should be inspected for evidence of cuts, cracks,
glazing, or frayed cords and replaced if there is indication
of damage which could result in belt failure. Low gen-
erator belt tension can cause battery failure.
Also check belt routing to make sure there is no interfer-
ence between the belts and other engine components.
Spark Plugs
Spark plugs must fire properly to assure engine perfor-
mance and emission control. New plugs should be in-
stalled at the mileage specified in the appropriate main-
tenance chart. The entire set should be replaced if there is
any malfunction due to a faulty spark plug.
Refer to the ªVehicle Emission Control Informationº label
in the engine compartment for spark plug information.
358 MAINTAINING YOUR VEHICLE

FLUID CAPACITIES
U.S. Metric
Fuel (Approximate)19.5 Gallons 73.8 Liters
Engine Oil with Filter
3.7 Liter Engine (SAE 5W-20, API Certified Engine Oil) 5 Qts 4.7 Liters
4.0 Liter Engine (SAE 10W-30, API Certified Engine Oil) 6 Qts 5.7 Liters
Cooling System *
3.7 Liter Engine (MopartAntifreeze/Engine Coolant 5 Year/
100,000 Mile Formula)14 Qts 13 Liters
4.0 Liter Engine (MopartAntifreeze/Engine Coolant 5 Year/
100,000 Mile Formula)14 Qts 13 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
394 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS AND GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MopartAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology) or equivalent.
Engine Oil (3.7L Engine) Use API Certified SAE 5W-20 engine oil, meeting material standard MS-6395
or equivalent.
Engine Oil (4.0L Engine) Use API Certified SAE 10W-30 engine oil, refer to oil viscosity chart for cor-
rect SAE grade meeting DaimlerChrysler Material Standard MS-6395.
Engine Oil Filter MopartEngine Oil Filter, P/N 5281090 or equivalent.
Spark Plugs 3.7 Liter ZFR6F-11G (Gap 0.043º)
Spark Plugs 4.0 Liter ZFR5LP-13G (Gap 0.050º)
Fuel Selection (3.7L Engines) 87 Octane, (R+M)/2 Method
Fuel Selection (4.0L Engines) 87 Octane, (R+M)/2 Method Acceptable, 89 Octane, (R+M)/2 Method Pre-
ferred
MAINTAINING YOUR VEHICLE 395
7

Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and other electrical items for correct
operation.At Each Oil Change
²Change the engine oil filter.
²Inspect the brake hoses and lines.
²Check the manual transmission fluid level.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
400 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Required Maintenance Intervals
Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change the engine oil and engine oil filter. 6,000 10 000 6
Rotate tires. 6,000 10 000 6
If using your vehicle for any of the following: Dusty
or off-road conditions. Inspect the engine air cleaner
filter, replace if necessary.12,000 20 000 12
Inspect the brake linings, replace if necessary. 12,000 20 000 12
Inspect the front & rear axle fluid, change if using
your vehicle for police, taxi, fleet, off-road or frequent
trailer towing.18,000 30 000 18
Inspect exhaust system. Perform the first inspection at
12,000 miles (20 000 km) or 12 months.24,000 40 000 24
Inspect the front suspension, tie rod ends and boot
seals, replace if necessary.24,000 40 000 24
Replace the engine air cleaner filter.30,000 50 000 30
MAINTENANCE SCHEDULES 401
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Electronic Roll Mitigation................ 133
Electronic Stability Program............... 134
Traction Control System................. 132
Electronic Roll Mitigation (ERM)............. 133
Electronic Speed Control (Cruise Control)...... 128
Electronic Stability Program (ESP).........134,170
Electronic Vehicle Information Center (EVIC).... 184
Emergency, In Case of
Hazard Warning Flasher................. 334
Jacking............................. 336
Overheating.......................... 335
Towing............................. 343
Emission Control System Maintenance......351,398
Engine
Air Cleaner.......................... 361
Block Heater......................... 248
Break-In Recommendations................ 76
Compartment......................348,349
Compartment Identification............348,349Coolant (Antifreeze).................... 395
Exhaust Gas Caution..................76,309
Fails to Start.......................... 246
Flooded, Starting...................... 246
Fuel Requirements..................306,394
Jump Starting......................... 341
Oil ...........................354,394,395
Oil Disposal.......................... 357
Oil Filter............................ 357
Oil Selection.......................... 394
Overheating.......................... 335
Starting............................. 245
Temperature Gauge..................... 168
Engine Oil Viscosity...................... 356
Engine Oil Viscosity Chart................. 356
Enhanced Accident Response Feature.......... 62
Entry System, Illuminated.................. 19
Event Data Recorder...................... 64
Exhaust Gas Caution...................76,309
420 INDEX

Exhaust System......................... 366
Exterior Finish Care...................... 378
Fabric Care.........................379,380
Filters
Air Cleaner.......................... 361
Engine Fuel.......................... 361
Engine Oil........................357,395
Finish Care............................ 378
Flashers
Hazard Warning....................... 334
Turn Signal..................171,390,391,392
Flooded Engine Starting................... 246
Floor Console.......................... 152
Fluid, Brake........................... 396
Fluid Capacities......................... 394
Fluid Leaks............................. 78
Fluid Level Checks...................... 377
Automatic Transmission................. 374Engine Oil........................... 354
Manual Transmission................... 375
Power Steering........................ 363
Fluids, Lubricants and Genuine Parts.......... 395
Fog Light Service........................ 391
Fog Lights..........................124,391
Folding Rear Seat........................ 118
Four Wheel Drive....................... 265
Operation........................... 265
Systems............................. 265
Four Wheel Drive Operation................ 265
Four-Way Hazard Flasher.................. 334
Front Axle (Differential)................... 377
Fuel................................. 306
Filler Cap (Gas Cap).................... 310
Filter............................... 361
Gasoline............................ 306
Gauge.............................. 168
Materials Added....................... 308
INDEX 421
10

Vanity............................... 86
Modifications/Alterations, Vehicle............. 8
Monitor, Tire Pressure System............... 296
Mopar Parts.........................353,409
Multi-Function Control Lever............... 123
Navigation Radio........................ 225
Navigation System....................... 225
New Vehicle Break-In Period................ 76
Occupant Restraints....................... 39
Octane Rating, Gasoline (Fuel).............. 306
Odometer
Trip ................................ 179
Off-Pavement Driving (Off-Road)............ 268
Off-Road Driving (Off-Pavement)............ 268
Oil, Engine.........................354,395
Capacity............................ 394
Dipstick............................. 354Filter............................357,395
Identification Logo..................... 356
Materials Added to..................... 357
Recommendation...................356,394
Viscosity..........................356,394
Onboard Diagnostic System..............350,351
Opener, Garage Door (HomeLinkt) ........... 137
Outside Rearview Mirrors.................. 84
Overdrive.......................175,257,263
Overdrive OFF Switch.................257,263
Overheating, Engine...................169,335
Owner's Manual (Operator Manual).......... 410
Paint Care............................. 377
Paint Damage.......................... 377
Panic Alarm............................ 23
Parking Brake.......................... 272
Parking On Hill......................... 272
Passing Light........................... 124
426 INDEX