inflation pressure DODGE SPRINTER 2008 2.G Service Manual

626 *Technical dataTire inflation pressure
6
\3 Tire inflation pressureObserve the information on recom-
mended tire inflation pressure in the
“Operation” section (
\2
page 361).
The following table lists the recommen-
ded cold tire inflation pressures for all
load conditions up to the maximum per-
missible weight limits (GAWR). The tire
inflation pressures listed apply to the ti-
res installed as original equipment.
iIn addition to the following table the
recommended cold tire inflation
pressures are listed on a placard lo-
cated on the driver’s door B-pillar
(\2
page 354).
Warning
G
Follow recommended tire inflation pres-
sures.
Do not underinflate tires. Underinflated
tires wear excessively and/or unevenly,
adversely affect handling and fuel econo-
my, and are more likely to fail from being
overheated.
Do not overinflate tires. Overinflated tires
can adversely affect handling and ride
comfort, wear unevenly, increase stop-
ping distance, and result in sudden defla-
tion (blowout) because they are more
likely to become punctured or damaged
by road debris, potholes etc.
nf_BA.book Page 626 Friday, January 25, 2008 3:53 PM

627 *Technical data
Tire inflation pressure
6
Set the correct tire pressure before
loading the vehicle. If the vehicle has
been loaded, check the tire pressures
and correct them if necessary.
The tires can be considered cold if the
vehicle has been parked for at least
3 hours or driven less than 1 mile
(1.6 km) at an ambient temperature of
approximately 68 °F (20 °C).
Keeping the tires properly inflated pro-
vides the best handling, tread life and
riding comfort.
Tire temperature and tire inflation pres-
sure are also increased while driving, de-
pending on the driving speed and the
tire load.Tire inflation pressure changes by ap-
proximately 1.5 psi (0.1 bar) per 18 °F
(10 °C) of air temperature change. Keep
this in mind when checking tire inflation
pressure where the temperature is dif-
ferent from the outside temperature.
For example:
If the inside temperature is 68 °F
(20 °C) and the outside temperature is
32 °F (0 °C) then the cold tire inflation
pressure should be increased by 3 psi
(0.2 bar), which equals 1.5 psi (0.1 bar)
for every 18 °F (10 °C) for this outside
temperature condition.Check tire inflation pressures more of-
ten if subject to a wide range of outdoor
temperatures, as tire inflation pressures
vary with temperature changes.
!
CAUTION
The pressure difference between the
tires on a single axle should not ex-
ceed 1.5psi (10kPa).
nf_BA.book Page 627 Friday, January 25, 2008 3:53 PM

628 *Technical dataTire inflation pressure
6
Tire
Permissible axle loads (see certification label)Front axle
Rear axle
3970 lbs
(1801 kg)
4080 lbs
(1851 kg)
4410 lbs
(2000 kg)*
5360 lbs
(2431 kg)
7060 lbs
(3202 kg)
7720 lbs
(3502 kg)
LT 215/85 R 16
115/112 N
—
55 psi (3.8 bar)
61 psi (4.2 bar)
—
55 psi (3.8 bar)
61 psi (4.2 bar)
LT 215/85 R 16
115/112 Q
—
55 psi (3.8 bar)
61 psi (4.2 bar)
—
55 psi (3.8 bar)
61 psi (4.2
bar=)
LT 245/75 R 16
120/116 L
47 psi (3.2 bar)
—
—
70 psi (4.8 bar)
—
—
LT 245/75 R 16
120/116 N
47 psi (3.2 bar)
—
—
70 psi (4.8 bar)
—
—
nf_BA.book Page 628 Friday, January 25, 2008 3:53 PM

637 Index
Numerics
12 V socket
. . . . . . . . . . . . . . . . . 297
A
ABSsee Antilock Brake SystemAcceleration skid control (ASR)
. 73
activating/deactivating . . . . . . . . 74
display message . . . . . . . . 500–501
indicator lamp . . . . . . . . . . 462–465
malfunction . . . . . . . . . . . . . . . . 465
warning lamp . . . . . . . . . . . . 73,461
Accessory weight
. . . . . . . . . . . . 393
Accident
. . . . . . . . . . . . . . . . . . . . 432
Additional turn signal lamp
. . . . 526
ADRsee Operating speed governorAir conditioning
. . . . . . . . . . . . . 215
air distribution . . . . . . . . . . . . . . 221
air vents
in the dashboard . . . . . . . . . . 215
see Rear heater . . . . . . . . . . . . . 233
Air conditioning in the rear
. . . . 225
Air conditioning, regulatedrefrigerant . . . . . . . . . . . . . . . . . 616Air pressuresee Tire inflation pressureAir ventsair distribution . . . . . . . . . . 221
,230
in the rear . . . . . . . . . . . . . . . . . 226
Airbagco-driver's . . . . . . . . . . . . . . . . . . 50driver's . . . . . . . . . . . . . . . . . . . . .50
safety notes . . . . . . . . . . . . . . . . . .46
thorax sidebag . . . . . . . . . . . . . . . .51
windowbag . . . . . . . . . . . . . . . . . .53
Airconditioningair distribution . . . . . . . . . . . . . . 215Air-conditioning systemheating . . . . . . . . . . . . . . . . . . . 219
ventilation/cooling . . . . . . . . . . 219Air-conditioning system in the rear
compartmentair cleaner . . . . . . . . . . . . . . . . . 415Air-recirculation modeair conditioning in the rear . . . . 226
heater . . . . . . . . . . . . . . . . . . . . 231
rear heating . . . . . . . . . . . . . . . . 226
Tempmatic . . . . . . . . . . . . . . . . 221
A
nf_BA.book Page 637 Friday, January 25, 2008 3:53 PM

641 Index
Checking tire pressure electronically
with the Advanced Tire Pressure
Monitoring System
(Advanced TPMS)
. . . . . . . . . . . . 373
Checking tire pressure electronically
with the Tire Pressure Monitoring
System (TPMS)
. . . . . . . . . . . . . . 367
Checks, regular
. . . . . . . . . . . . . . 312
Childrenin the vehicle . . . . . . . . . . . . . . . . 55
ISOFIX seat securing system . . . . 61
LATCH type child restraint
system . . . . . . . . . . . . . . . . . . . . . 61
restraint systems . . . . . . . . . . . . . 56Chock
. . . . . . . . . . . . . . . . . . . . . . 521
Cigarette lighter
. . . . . . . . . . . . . 295
Cleaning
. . . . . . . . . . . . . . . . 416
,424
after driving off-road or
on construction sites . . . . . . . . . 425
air cleaner element . . . . . . . . . . 415
cockpit . . . . . . . . . . . . . . . . . . . . 424
headlamps . . . . . . . . . . . . . . . . . 421
padded boss of the steering
wheel . . . . . . . . . . . . . . . . . . . . . 424
radio display . . . . . . . . . . . . . . . 424
rear view camera lens . . . . . . . . 422
rear view camera monitor . . . . . 424
rear window . . . . . . . . . . . . . . . . 421
side windows . . . . . . . . . . . . . . . 421
vehicle . . . . . . . . . . . . . . . . . . . . 418
windshield . . . . . . . . . . . . . . . . . 420
windshield wipers . . . . . . . . . . . 420
Clearance lampchanging bulbs . . . . . . . . . . . . . 535
see identification lamp . . . . . . . 533Clocksetting
vehicles with steering wheel
buttons . . . . . . . . . . . . . . . . . . 168
vehicles without steering
wheel buttons . . . . . . . . . . . . 150Cockpit
. . . . . . . . . . . . . . . . . . . . . .18
Cold tire inflation pressure
. . . . 394
COMANDsee the separate Operating
InstructionsComfort seat
. . . . . . . . . . . . . . . . 114
Constant headlamp mode
. . . . . 171
nf_BA.book Page 641 Friday, January 25, 2008 3:53 PM

648 Indexbrake pad/lining wear . . . . . . . . 470
coolant . . . . . . . . . . . . . . . . . . . . 474
engine diagnostic . . . . . . . . . . . . 477
ESP
®
. . . . . . . . . . . . . . . . . 462
,468
handbrake . . . . . . . . . . . . . . . . . 189
operating speed governor (ADR) . . 274poly-V-belt . . . . . . . . . . . . . . . . . 469
preglow . . . . . . . . . . . . . . . 186
,476
reserve warning
indicator (fuel) . . . . . . . . . . 475,476
windshield washer/headlamp
cleaning system washer fluid
level . . . . . . . . . . . . . . . . . . . . . . 482
Inflation pressuresee Tires, Inflation pressuresInformation regarding electronic
recording devices
. . . . . . . . . . . . . 16
Instrument cluster
. . . . . . . . 20
,142
lighting . . . . . . . . . . . . . . . . . . . . 144
speedometer . . . . . . . . . . . . . . . 145
tachometer . . . . . . . . . . . . . . . . 145
vehicles with steering wheel buttons
selecting the language . . . . . . 166
setting the status line . . . . . . . 167
Instrument lighting
. . . . . . . . . . . 144
Interior lightingchanging bulbs . . . . . . . . . . . . . . 537
front . . . . . . . . . . . . . . . . . . . . . . 137
rear . . . . . . . . . . . . . . . . . . . . . . 138Interior lighting, rear
. . . . . . . . . 138
Interior motion sensor
. . . . . . . . . 80
Intermittent wipe
. . . . . . . . . . . . 210
ISOFIX child seat securing
system
. . . . . . . . . . . . . . . . . . . . . . 61
TopTether . . . . . . . . . . . . . . . . . . 64
J
Jackjacking points . . . . . . . . . . . . . . 551
preparing . . . . . . . . . . . . . . . . . . 550
storage location . . . . . . . . . . . . . 515Jump-starting
. . . . . . . . . . . . . . . 581
connection point . . . . . . . . . . . . 582
Jump-starting connection
point
. . . . . . . . . . . . . . . . . . . . . . . 582
J
nf_BA.book Page 648 Friday, January 25, 2008 3:53 PM

654 IndexRear window heating
. . . . . . . . . 214
malfunction . . . . . . . . . . . . . . . . 458
Rear window wiper
. . . . . . . . . . . 212
Rear-view mirror
. . . . . . . . . . . . . 208
Recommended tire inflation
pressure
. . . . . . . . . . . . . . . . . . . . 397
Refueling
. . . . . . . . . . . . . . . . . . . 316
Remote controlauxiliary heating . . . . . . . . . . . . . 239
battery check lamp . . . . . . . . . 240
changing the batteries . . . . . . 541
central locking . . . . . . . . . . . . . . . 86
changing the batteries . . . . . . . . 539
key . . . . . . . . . . . . . . . . . . . . . . . . 86
lost . . . . . . . . . . . . . . . . . . . . . . . 448
opening the vehicle . . . . . . . . . . . 83
problems . . . . . . . . . . . . . . . . . . 445
Removing the battery cover in the
driver’s footwell
. . . . . . . . . . . . . 576
Removing/installing the floor cover-
ing in the driver’s footwell
. . . . . 575
Reserve warning indicator
(fuel)
. . . . . . . . . . . . . . . . . . . 475
,476
Residual heat mode
. . . . . . . . . . 222
problems . . . . . . . . . . . . . . . . . . 459
Restraint system
. . . . . . . . . . . . . 34
airbags . . . . . . . . . . . . . . . . . . . . . 36
belt force limiters . . . . . . . . . . . . 44
child restraint systems . . . . . . . . 56
display message . . . . . . . . . . . . 496
emergency tensioning retractor . 44
front airbags . . . . . . . . . . . . . . . . 50
malfunction . . . . . . . . . . . . . . . . 469
seat belt . . . . . . . . . . . . . . . . . . . . 36thorax sidebag . . . . . . . . . . . . . . . 51
windowbags . . . . . . . . . . . . . . . . . 53
Reverse lamp
. . . . . . . . . . . 530
,531
changing bulbs . . . . . . . . . . . . . 531
Reverse warning feature
. . . . . . 271
Rims
. . . . . . . . . . . . . . . . . . . . . . . 397
Road hazard lamp
. . . . . . . . . . . . 513
Roll-back warningsee ParktronicRoof load
. . . . . . . . . . . . . . . . . . . 630
Roof rack
. . . . . . . . . . . . . . . . . . . 285
Roof ventilator
. . . . . . . . . . . . . . 247
S
Seat
. . . . . . . . . . . . . . . . . . . 114
,116
adjusting . . . . . . . . . . . . . . 112,114
folding rear bench seat . . . . . . . 124
S
nf_BA.book Page 654 Friday, January 25, 2008 3:53 PM

658 IndexTempaticsee Air conditioningTemperaturesetting the unit
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 165Tempmaticairflow . . . . . . . . . . . . . . . . . . . . 220
air-recirculation mode . . . . . . . . 221
control panel . . . . . . . . . . . . . . . 218
defrosting . . . . . . . . . . . . . . . . . . 224
fogged-up windows . . . . . . . . . . 223
reheat function
(dehumidification) . . . . . . . . . . . 223
residual heat . . . . . . . . . . . . . . . 222
special settings . . . . . . . . . . . . . 223The first 1,500 km
. . . . . . . . . . . 302
Thorax sidebag
. . . . . . . . . . . . . . . 51
Tightening torquewheel nuts/wheel bolts . . . . . . . 554TIN
. . . . . . . . . . . . . . . . . . . . 387
,397
Tire and loading informationplacard . . . . . . . . . . . . . . . . . . . . 352
terminology . . . . . . . . . . . . . . . . 393Tire and loading information
placard
. . . . . . . . . . . . . . . . . . . . . 636
Tire Identification Numbersee TINTire inflation pressurechecking manually . . . . . . . . . . . 365
Checking tire pressure electronically
with the Advanced Tire Pressure Mon-
itoring System (Advanced TPMS)*,
(Canada only) . . . . . . . . . . . . . . . 373Checking tire pressure electronically
with the Tire Pressure Monitoring
System (TPMS) . . . . . . . . . . . . . 367
recommended tire inflation
pressure . . . . . . . . . . . . . . . . . . 361
setting the unit
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 168
Tire valves
. . . . . . . . . . . . . . . . . . 345
Tires
. . . . . . . . . . . . . . . . . . . 341
,363
Advanced Tire Pressure Monitoring
System (Advanced TPMS)*,
(Canada only) . . . . . . . . . . . . . . 373
air pressure . . . . . . . . . . . . . . . . 394
alignment and balance . . . . . . . 199
care and maintenance . . . . . . . . 347
damage . . . . . . . . . . . . . . . . . . . 348
nf_BA.book Page 658 Friday, January 25, 2008 3:53 PM

659 Index
direction of rotation, spinning . . 351
driving instructions . . . . . . . . . . 195
important guidelines . . . . . . . . . 346
inflation pressure . . . . . . . . 361
,365
information placard . . . . . . . . . . 352
inspection . . . . . . . . . . . . . . . . . 347
load limit information . . . . . . . . . 355
load rating . . . . . . . . .383
,384
,398
loading Information . . . . . . . . . . 352
loading terminology . . . . . . . . . . 393
loading the vehicle . . . . . . . . . . . 351
low tire pressure indicator . . . . . 478
maximum load . . . . . . . . . . . . . . 399
messages in the multifunction
display . . . . . . . . . . . . . . . . . . . . 478
ply composition and material
used . . . . . . . . . . . . . . . . . . . . . . 398problems under/overinflation . . 380
,
382
radial-ply tires . . . . . . . . . . . . . . 345
retreads . . . . . . . . . . . . . . . . . . . 344
rotating . . . . . . . . . . . . . . . 351
,399
seating capacity . . . . . . . . . . . . 354
service life . . . . . . . . . . . . . . . . . 349
sizes . . . . . . . . . . . . . . . . . . . . . 383
speed rating . . . . . . . 199
,386
,398
storing . . . . . . . . . . . . . . . . . . . . 350
temperature . . . . . . . . 363
,364
,627
terminology . . . . . . . . . . . . . . . . 393
TIN . . . . . . . . . . . . . . . . . . . 387,397
Tire Identification Number see TIN
Tire Pressure Monitoring System
(TPMS), (USA only) . . . . . . . . . . 367
TPMS malfunction indicator . . . 478traction . . . . . . . . . . . . . . . 198
,398
tread . . . . . . . . . . . . . . . . . . . . . 398
tread depth . . . . . . . . . . . . 349,405
Treadwear Indicator (TWI) . . . . . 196
Treadwear Indicators . . . . . . . . . 398
valves . . . . . . . . . . . . . . . . . . . . 345
vehicle maximum load on . . . . . 399
wear pattern . . . . . . . . . . . . . . . 401
winter tires . . . . . . . . . . . . . . . . 404
Tongue Weight Ratingsee TWRTopTether
. . . . . . . . . . . . . . . . . . . .64
Tow-away protection
. . . . . . . . . . .78
nf_BA.book Page 659 Friday, January 25, 2008 3:53 PM