1.3 multijet FIAT GRANDE PUNTO 2007 199 / 1.G Owners Manual
[x] Cancel search | Manufacturer: FIAT, Model Year: 2007, Model line: GRANDE PUNTO, Model: FIAT GRANDE PUNTO 2007 199 / 1.GPages: 242, PDF Size: 3.71 MB
Page 194 of 242
193
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●● ●
●●●●● ●
●●●●● ●
●●
●
●●●●● ●
●● ●
SERVICE SCHEDULE FOR MULTIJET ENGINES
Service coupons shall be performed every 30,000 km
Thousands of km
Check tyre conditions/wear and adjust pressure if required
Check light system operation (headlights, direction indicators,
hazard lights, boot lights, passenger compartment lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check front and rear (where provided) disk brake pad
conditions and wear
Check rear drum brake linings and wear
(1.3 Multijet versions)
Sight inspect the conditions of: bodywork, underbody protection,
pipes and hoses (exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Sight inspect accessory drive belt conditions
Replace accessory drive belt/s
Check and adjust handbrake lever stroke, if required
Check and adjust tappet clearance, if required
(1.9 Multijet versions)
189-210 Punto GDX GB 20-07-2007 9:43 Pagina 193
Page 198 of 242
197
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
1.Engine oil
2.Engine coolant
3.Windscreen washer fluid
4.Brake fluid
5.Battery
6.Diesel fuel filter. 1.Engine coolant
2.Battery
3.Windscreen washer fluid
4.Brake fluid
5.Engine oil.
fig. 2b - 1.4 T-JET version
fig. 3 - 1.3 Multijet versionsF0M0219m
F0M0146m
189-210 Punto GDX GB 20-07-2007 9:43 Pagina 197
Page 200 of 242
If the oil level is near or even below the
MINmark, add oil through the filler neck
A, until reaching the MAXmark.
Oil level shall never exceed the MAX
mark.ENGINE OIL CONSUMPTION
Max engine oil consumption is usually 400
grams every 1000 km.
When the car is new, the engine needs
to run in, therefore the engine oil con-
sumption can only be considered stabilised
after the first 5,000 ÷ 6,000 km.
IMPORTANT The oil consumption de-
pends on driving style and the conditions
under which the car is used.
IMPORTANT After adding or changing
the oil, let the engine turn over for a few
seconds and wait a few minutes after turn-
ing it off before you check the level. ENGINE OIL fig. 5, 6, 7 and 8
Check the oil level a few minutes (about
5) after the engine has stopped, with the
car parked on level ground.
The oil level shall be included between the
MINand MAXmarks on the dipstick B.
The gap between the MINand MAX
marks corresponds to about one litre of
oil.
fig. 5 - 1.2 and 1.4 8Vversions
fig. 6a - 1.4
16Vversion
F0M0149m
F0M0268mfig. 8 - 1.9 Multijet versionsF0M0151m
fig. 7 - 1.3 Multijet versionsF0M0150m
199
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
fig. 6b - 1.4 T-JET versionsF0M0319m
189-210 Punto GDX GB 20-07-2007 9:43 Pagina 199
Page 215 of 242
214
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
ENGINE CODES - BODYWORK VERSIONS
Versions Engine Body version
code 3-door 5-door
4-seat 5-seat
1.2
1.4
1.4 16V
1.4 T-JET
1.3 Multijet 75HP
1.3 Multijet 90HP
1.9 Multijet
1.9 Multijet Sport
(
❒) Version with 5-speed gearbox
(
❍) Version with 6-speed gearbox
(*) Version with DPF
199A4000
350A1000
199A6000
198A4000
199A2000
199A3000
939A1000
199A5000199BXA1A 01
199BXB1A 03
199BXG1B 14
199BXMIA 26
199BXC1A 05
199BXD1A 12 (
❒)
199BXD1B 07 (
❍)
199BXD1B 07B (*)
199BXE1B 09
199BXE1B 09B (*)
– 199AXA1A 00D
199AXB1A 02D
199AXG1B 13
199AXMIA 25
199AXC1A 04
199AXD1A 11 (
❒)
199AXD1B 06 (
❍)
199AXD1B 06D (*)
199AXE1B 08
199AXE1B 08G (*)
199AXF1B 10 199AXA1A 00E
199AXB1A 02E
199AXG1B 13B
199AXMIA 25B
199AXC1A 04C
199AXD1A 11B (
❒)
199AXD1B 06C (
❍)
199AXD1B 06E (*)
199AXE1B 08E
199AXE1B 08H (*)
199AXF1B 10C
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 214
Page 217 of 242
216
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.3 Multijet
75 HP
199A2000
Diesel
4 in line
69.6 x 82
1248
17.6
55
75
4000
190
19.4
1750
–
Diesel fuel
for motor
vehicles
(Specification
EN590)1.3 Multijet
90 HP
199A3000
Diesel
4 in line
69.6 x 82
1248
17.6
66
90
4000
200
20.4
1750
–
Diesel fuel
for motor
vehicles
(Specification
EN590)1.9 Multijet
939A1000
Diesel
4 in line
82 x 90.4
1910
18
88
120
4000
280
28.5
2000
–
Diesel fuel
for motor
vehicles
(Specification
EN590)1.9 Multijet
Sport
199A5000
Diesel
4
in line
82 x 90.4
1910
18
96
130
4000
280
28.5
2000
–
Diesel fuel
for motor
vehicles
(Specification
EN590)
GENERAL
Engine code
Cycle
Number and layout of cylinders
Piston bore and stroke mm
Total displacement cm3
Compression ratio
Maximum power (EEC) kW
HP
corresponding ratio rpm
Maximum torque (EEC) Nm
kgm
corresponding ratio rpm
Spark plugs
Fuel
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 216
Page 218 of 242
217
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Modifications or repairs to the fuel feed system that are not carried out properly or do not take the system’s
technical specifications into account can cause malfunctions leading to the risk of fire.
WARNING
TRANSMISSION
1.2 1.4 1.3 Multijet 75HP 1.3 Multijet 90HP1.4 16V -1.9 Multijet
Gearbox
Clutch
DriveSelf-adjusting pedal without idle stroke
Front Five forward gears and reverse with synchromesh for
forward gear engagementSix forward gears and
reverse with
synchromesh for
forward gear
engagement Five or six forward
gears and reverse with
synchromesh for
forward gear
engagement
IGNITION
1.2 - 1.4 - 1.4 16V1.4 T-JET1.3 Multijet - 1.9 Multijet
Fuel feed Multipoint electronic Multipoint sequential Multijet direct
injection phased electronic injection “Common Rail”injection
with turbosupercharger
and intercooler
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 217
Page 219 of 242
218
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
SUSPENSIONS
1.2 - 1.4 - 1.4 16V- 1.3 Multijet - 1.9 Multijet
Front
Rear
BRAKES
1.2 1.4 - 1.4 16V1.3 Multijet 1.9 Multijet
Service brakes:
– front
– rear
Parking brake
IMPORTANT Water, ice and antifreeze salt on roads may deposit on the brake discs thus reducing braking efficiency
at first braking.
Mc Pherson independent wheels
twisting axle with interconnected wheels
rack and pinion with electric power steeringcontrolled by hand lever, it works on rear brakesdrum or disc (on certain versions) disc (self-ventilating for versions where provided)
STEERING
1.2 1.4 1.4 16V1.3 Multijet 1.3 Multijet 1.9 Multijet75HP 90HP
Type
Minimum steering
cycle m 10,1 10,1 10,5 10,1 10,9 10,9
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 218
Page 222 of 242
221
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
175/65 R15 84T (M+S)
185/65 R15 88T (M+S)
175/65 R15 84T (M+S)
185/65 R15 88T (M+S)
185/65 R15 88T (M+S)
195/65 R16 87H (M+S)
185/65 R15 88T (M+S)
195/65 R16 87H (M+S)
175/65 R15 84T (M+S)
185/65 R15 88T (M+S)
185/65 R15 88T (M+S)
195/55 R16 87H (M+S)
185/65 R15 88H (M+S)
195/55 R16 87H (M+S) 175/65 R15 84T
185/65 R15 88T
175/65 R15 84T
185/65 R15 88T
185/65 R15 88T
195/55 R16 87H
205/45 R17 88V
185/65 R15 88H
195/55 R16 87H
205/45 R17 88V
175/65 R15 84T
185/65 R15 88T
185/65 R15 88T
195/55 R16 87H
205/45 R17 88V
185/65 R15 88H
195/55 R16 87H
205/45 R17 88V6J X 15'' - ET 43
6J X 15'' - ET 43
6J X 15'' - ET 43
6J X 15'' - ET 43
6J X 15'' - ET 43
6J X 15'' - ET 43
6J X 15'' - ET 43175/65 R15 84T
185/65 R15 88T
175/65 R15 84T
185/65 R15 88T
185/65 R15 88T
185/65 R15 88T
175/65 R15 84T
185/65 R15 88T
185/65 R15 88T
185/65 R15 88H 6J X 15'' - ET 43
6J X 15'' - ET 43
6J X 15'' - ET 43
6J X 16'' - ET 45
6,5J X 17'' - ET 46
6J X 15'' - ET 43
6J X 16'' - ET 45
6,5J X 17'' - ET 46
6J X 15'' - ET 43
6J X 15'' - ET 43
6J X 16'' - ET 45
6,5J X 17'' - ET 46
6J X 15'' - ET 43
6J X 16'' - ET 45
6,5J X 17'' - ET 46
Version Rims (*) Tyres Spare wheelStandard tyre Snow tyre Rim (*) Tyre
1.2
1.4
1.4 16V
1.4 T-JET 120 HP
1.3 Multijet 75 HP
1.3 Multijet 90 HP
1.9 Multijet
(*) Spacing of studs 100 mm and studs M12 x 1.5 use only wheels specified for this car.
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 221
Page 223 of 242
222
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
2.2 2.1
2.2 2.2
2.2 2.0
2.2 2.2
––
––
––
––
––
––2.2 2.1
2.2 2.2
2.2 2.0
2.2 2.2
––
––
––
––
––
––2.4 2.1
2.5 2.2
2,3 2.1
2.3 2.3
––
––
––
––
––
––––
––
2.3 2.1
2.3 2.3
––
––
2.3 2.1
2.4 2.4
2.4 2.2
2.5 2.4––
––
––
––
2.4 2.2
2,4 2.2
2.4 2.2
2.6 2.4
2.6 2.3
2.8 2.5 ––
––
2.2 2.0
2.2 2.2
––
––
2.2 2.0
2.2 2.2
2.4 2.2
2.4 2.4––
––
––
––
2.2 2.0
2.2 2.2
2.2 2,0
2.2 2.2
2.4 2,2
2.4 2.4
COLD TYRE INFLATION PRESSURE (bar)
Versions 1.2 1.4 1.4
16V1.4 T-JET 1.3 Multijet 1.3 Multijet 1.9 Multijet
75 HP 90 HP
Front Rear Front Rear Front Rear Front Rear Front Rear Front Rear Front Rear
175/65 R15 84T
Medium load
Full load
185/65 R15 88T
Medium load
Full load
185/65 R15 88H
Medium load
Full load
195/55 R16 87H
Medium load
Full load
205/45 R17 88V
Medium load
Full load
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm. Recheck pressure value with cold tyres.
With snow tyres, add +0.2 bar to the inflation pressure value prescribed for standard tyres.
When running at speed higher than 160 km/h, inflate tyres at full load inflation values.
With T.P.M.S. system, pressure value shall be + 0.1 bar than prescribed value.
T.P.M.S. system not available for tyre 175/65 R15 84T
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 222
Page 224 of 242
223
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
DIMENSIONS
Dimensions are expressed in mm and re-
fer to the vehicle fitted with standard
tyres.
The height refers to the vehicle unladen.
Boot volume
Unladen boot volume
(V.D.A. standards) ...................... 275 dm
3
Boot volume with rear
seat folded .................................... 638 dm3
F0M0369m
fig. 5
Versions A B C D E F G H3 - 5 door
1.2 -1.4 - 1.4
16V
1.3 Multijet4030 875 2510 645 1490 1473 1687 1466
1.9 Multijet
IMPORTANT Track measurements may vary according to rim/tyre size.
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 223