fuel reserve FIAT PANDA 2009 169 / 2.G LPG Supplement Manual
[x] Cancel search | Manufacturer: FIAT, Model Year: 2009, Model line: PANDA, Model: FIAT PANDA 2009 169 / 2.GPages: 24, PDF Size: 0.92 MB
Page 12 of 24
12
FIAT PANDA LPG
ELECTRONIC
CONTROL UNIT
The vehicle has a dedicated electronic
control unit for the LPG system; it uses
the incoming signals from the petrol in-
jection control unit and converts them in-
to signals for the injection of the LPG.
The control unit for the injectors has the
same strategy as the petrol control unit
(phased, sequential, multipoint).
LPG/PETROL SWITCH
The LPG/petrol switch fig. 7is located on
the protective fuse flap (left side of the
dashboard) and includes:
A. LPG/petrol operating mode request
button;
B. LPG gauge: 5 leds of which 4 green and
1 red to indicate the reserve. The red LED
only comes on when the last green LED
goes out.
The red LED indicates the reserve con-
dition;
ON. LPG operation mode indicator:
green LED on continuously, under the
buttonA;
OFF. petrol operation mode indicator:
yellow LED on continuously, under the
buttonA.
IMPORTANT When the ignition key is
turned to the MARposition the LEDs on
the ignition switch come on in accordance
with the following rule:
–with petrol operation mode se-
lected: yellow LED OFF activation;
–with LPG operation selected: all
LEDs on the switch are on continuously
and the green LED ONflashes.To select the type of fuel system desired
(LPG or petrol), press button A-fig. 7.
To change the type of fuel system, it is ad-
visable to operate the button with the ve-
hicle stationary and the engine running or,
whilst driving, after having released the ac-
celerator.
If the switching takes place during accel-
eration or pick-up, there may be a brief
flat spot (fall in power).
fig. 7F0Z0807m
Do not switch between the
two operating modes whilst
starting the engine.
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 12
Page 13 of 24
13
FIAT PANDA LPG
Switch from petrol to LPG
With petrol fuel supply: press the button
A-fig. 7, the switch to LPG will take place
automatically at the first significant accel-
eration.
During switching:
– the LPG gauge Bcomes on;
– the yellow LED OFF goes out (petrol
operating mode);
– the green LED ON comes on switch-
ing from intermittent to on constantly
(LPG operating mode).
There are 5 LEDs B(1 red and 4 green)
on the left of the switch that display the
amount of LPG in the tank.
When the amount of LPG remaining goes
below about 1/5 of the capacity of the
tank, only the red (reserve) LED remains
on to signal the need for refuelling.
IMPORTANT In the case of starting at
outside temperatures of below -10 °C, the
switching times from petrol to LPG in-
crease to allow the pressure regulator to
become warm enough.IMPORTANT The buzzer warns the dri-
ver that the engine is running on petrol;
therefore he must refuel with LPG before
it runs out.
THE buzzer can be deactivated by press-
ing the switching button A.
Do not switch between the
two operating modes whilst
starting the engine. Switching from LPG to petrol
With LPG supply: press the buttonA-
fig. 7.
During switching:
– the LPG gauge Bgoes out;
– the yellow LED OFF comes on con-
stantly (petrol operating mode);
– the green LED ON goes out (LPG op-
erating mode).
LPG run out
If the LPG runs out, switching to petrol
takes place automatically with:
– the yellow LED OFF on constantly;
– the green LED ON flashing;
– an acoustic warning from the switch
buzzer (fast frequency).
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 13
Page 21 of 24
21
FIAT PANDA LPG
supply pressures of pumps in the net-
work, pumps with different sup-
ply/stop specifications, tank not com-
pletely in reserve condition.
It should be remembered that when using
a fuel such as LPG the range is very vari-
able because, as well as driving and car
maintenance conditions, it also depends
on the different composition of the gas
which can vary not only seasonally but al-
so from supplier to supplier. LPG is, in ef-
fect, a composition of gas (butane and
propane) mixed in a way that may not be
standardized.
BOOT CAPACITY
Capacity with vehicle unladen (V.D.A. standards) in dm3
One-piece and split rear seat
Under rear parcel shelf with rear backrest in normal position
To waist level with rear backrest folded over
Max. to the roof with rear backrest folded over
Max. to the roof with rear backrest folded over (with sun roof)
Volume of the load carrying compartment (2-seater VAN version)
Volume of the load carrying compartment (4-seater VAN version)187
471
841
796
1000
256
CAPACITIES
Petrol
Petrol . . . . . . . . . . . . . . . . . litres 35
– including a reserve of . . . litres 5
LPG
– maximum refuelling
capacity (*) . . . . . . . litres 31/27 (▲)
(▲) VAN version
(*) The value already takes into account
the 80% filling limit of the tank and the
residual fluid necessary for the priming and
is the maximum permitted refilling. This
value may undergo slight changes
from one refilling operation to the
next due to: differences between the The trip meter indication on range is indica-
tive and refers to petrol operation only.
During LPG operation, the Instant con-
sumption and Average consumption read-
ings are not significant, whereas all other
functions remain valid.
IMPORTANT Only use LPG for mo-
tor vehicles.
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 21