brake fluid FIAT PANDA 2016 319 / 3.G User Guide
[x] Cancel search | Manufacturer: FIAT, Model Year: 2016, Model line: PANDA, Model: FIAT PANDA 2016 319 / 3.GPages: 204, PDF Size: 18.77 MB
Page 135 of 204
1.3 16V Multijet EURO 5 versions
A. Engine oil plug/filler-–B.Engine oil dipstick-–C.Engine coolant-–D.Washer fluid for windscreen/rear window-–E.Brake fluid-–F.Battery
121F1D0099
133
Page 136 of 204
1.3 16V Multijet EURO 6 versions
A. Engine oil plug/filler-–B.Engine oil dipstick-–C.Engine coolant-–D.Washer fluid for windscreen/rear window-–E.Brake fluid-–F.Battery
122F1D0141
134
SERVICING AND MAINTENANCE
Page 137 of 204
ENGINE OIL
56) 57)4)Check the oil level a few minutes (about
five) after the engine has stopped,
with the vehicle parked on level ground.
Check that the oil level is between the
MIN and MAX references on the
dipstick B. If the oil level is near or even
under the MIN mark, add oil using the
filler A to reach the MAX mark.
NOTE For the 0.9 TwinAir and 0.9
TwinAir Turbo versions, engine oil
dipstick B is integral with the cap A.
Take out the engine oil dipstick A, clean
it with a lint-free cloth and reinsert it.
Extract it again and check that the level
is between the MIN and MAX marks
on the dipstick.
Engine oil consumption
The maximum engine oil consumption
is usually 400 grams every 1000 km.
During the initial period of use the
engine oil consumption conditions
should be considered as having
stabilised after the first 5000 - 6000
km.
IMPORTANT After adding or changing
the oil, let the engine run for a few
seconds and wait a few minutes after
switching it off before checking the
level.ENGINE COOLANT166)58)The coolant level must be checked
when the engine is cold and must
range between the MIN and MAX
marks on the reservoir.
If the level is too low, unscrew reservoir
cap C and add the fluid described in
the "Technical Specifications" section.
WINDSCREEN/REAR
WINDOW WASHER FLUID
167)If the level is too low, raise reservoir cap
D (see previous pages) and add the
fluid described in the chapter "Technical
Specifications".
BRAKE FLUID
168) 169)59)Check that the fluid is at the maximum
level (the fluid level in the reservoir
must not exceed the MAX mark). If the
fluid level in the reservoir is too low,
undo reservoir cap E and add the fluid
described in the "Technical
Specifications" chapter.
DUALOGIC GEARBOX
HYDRAULIC ACTIVATION
SYSTEM OIL
5)The fluid level should only be checked
at a Fiat Dealership.BATTERY
170) 171) 172) 173)
60)6)
Battery F does not require topping up
the electrolyte with distilled water. A
periodic check carried out at a Fiat
Dealership is, however, necessary to
check efficiency.
IMPORTANT After the battery is
disconnected, the steering must be
initialised. The
warning light on the
instrument panel switches on to
indicate this. To carry out this
procedure turn the steering wheel all
the way from one end to the other
or drive in a straight line for about a
hundred metres.
IMPORTANT If the charge level remains
under 50% for a long time, the battery
is damaged by sulphation, reducing
its capacity and efficiency at start-up.
CLIMATE CONTROL
SYSTEM MAINTENANCE
In winter, the climate control system
must be turned on at least once a
month for about 10 minutes. Before
summer, have the system checked at a
Fiat Dealership.
135
Page 138 of 204
WARNING
164)Never smoke when performing
operations in the engine compartment.
Flammable gases and fumes may be
present and risk igniting.
165)Be very careful when working in the
engine compartment when the engine
is hot: you may get burnt.
166)The cooling system is pressurised. If
necessary, only replace the cap with
another original one or the operation of the
system may be adversely affected. Do
not remove the reservoir cap when the
engine is hot: risk of burns.
167)Do not travel with the washer fluid
reservoir empty: the washer operation
is essential for improving visibility. Some
commercial windscreen washer additives
are flammable. The engine compartment
contains hot components which may set it
on fire.
168)Brake fluid is poisonous and highly
corrosive. In the event of accidental
contact, immediately wash the affected
parts with water and mild soap. Then rinse
thoroughly. Call a doctor immediately if
swallowed.
169)The
symbol on the container
indicates a synthetic brake fluid, which is
different from a mineral fluid. Using a
mineral fluid will damage the special rubber
seals of the braking system beyond repair.170)Battery fluid is poisonous and
corrosive. Avoid contact with the skin and
eyes. Keep naked flames and sources
of sparks away from the battery: risk of
explosion and fire.
171)Using the battery with insufficient
fluid irreparably damages the battery and
may cause an explosion.
172)If the vehicle is left for long periods in
very cold environments, remove the battery
and store it in a warm place to prevent
freezing.
173)Always wear the proper protective
eyewear when working on the battery
or near it.
WARNING
55)Be careful not to confuse the various
types of fluids while topping up: they
are not compatible with each other!
Topping up with an unsuitable fluid could
severely damage your vehicle.
56)The oil level should never exceed the
MAX mark.
57)Do not add oil with specifications other
than those of the oil already in the engine.
58)PARAFLU
UPanti-freeze is used in
the engine cooling system. Use the same
fluid as in the cooling system when topping
up. PARAFLU
UPcannot be mixed with
any other type of fluid. If this happens, do
not start the engine and contact a Fiat
Dealership.59)Avoid allowing brake fluid, which is
extremely corrosive, to come into contact
with painted areas. Should it happen, wash
immediately with water.
60)Incorrect assembly of electrical and
electronic accessories may cause severe
damage to your vehicle. After purchasing
your vehicle, if you wish to install any
accessories (anti-theft, phone, etc.),
contact a Fiat Dealership, which
will suggest the most appropriate devices
for your vehicle, and will, most importantly,
advise you if a higher capacity battery
needs to be installed.
WARNING
4)Used engine oil and oil filters contain
substances which are harmful to the
environment. To change the oil and filters,
we advise you to contact a Fiat Dealership.
5)Used transmission fluid contains
substances that are harmful to the
environment. It is advisable to have the oil
changed by a Fiat Dealership where it
will be disposed of respecting the
environment and according to legal
requirements.
6)Batteries contain substances which are
very dangerous for the environment. For
battery replacement, contact a Fiat
Dealership.
136
SERVICING AND MAINTENANCE
Page 160 of 204
158
TECHNICAL SPECIFICATIONS
WEIGHTS
Panda/Panda Trekking EURO 5 versions
Weights (kg) 1.3 16V MultiJet 75 HP
Unladen weight (with all fluids, fuel tank 90% full and
without optional equipment):1035
Payload including the driver:
(*)480 (4-seater) / 500 (5-seater)
Maximum permitted loads
(**)
– front axle:855
– rear axle:760
– total:1515 (4-seater) / 1535 (5-seater)
Towable loads
– braked trailer:900
– non-braked trailer:400
Maximum load on roof:55
Maximum load on ball joint (braked trailer): 60
(*) If special equipment is fitted (sun roof, tow hitch, etc.) the unladen vehicle weight increases, thus reducing the specified payload in relation to the maximum
permitted loads.
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within the maximum permitted loads.
Page 161 of 204
159
Panda/Panda Trekking EURO 6 versions
Weights (kg) 0.9 TwinAir 60 HP/65 HP0.9 TwinAir Turbo 0.9 TwinAir Turbo
Natural Power
Unladen weight (with all fluids, fuel tank 90% full and
without optional equipment):955 975 / 980 1080
Payload including the driver:
(*)480 (4-seater) / 500
(5-seater)480 (4-seater) / 500
(5-seater)460 (4-seater) / 470
(5-seater)
Maximum permitted loads
(**)
– front axle: 770 855 875
– rear axle: 760 760 810
– total:1435 (4-seater) / 1455
(5-seater)1455 (4-seater) / 1460
(4-seater)
(°)/ 1475
(5-seater) / 1480 (5-seater)
(°)
1540 (4-seater) / 1550
(5-seater)
Towable loads
– braked trailer: 800 800
(°°)
– non-braked trailer: 400 400(°°)
Maximum load on roof: 55 55 55
Maximum load on ball joint (braked trailer): 60 60
(°°)
(*) If special equipment is fitted (sun roof, tow hitch, etc.) the unladen vehicle weight increases, thus reducing the specified payload in relation to the maximum
permitted loads.
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within the maximum permitted loads.
(°) Versions equipped with the "Dualogic" gearbox
(°°)IMPORTANT A trailer cannot be towed so there are no provisions for fitting a tow hook.
80 HP/85 HP
Page 162 of 204
160
TECHNICAL SPECIFICATIONS
Weights (kg) 1.2 8V 69 HP 1.2 8V 69 HP LPG 1.3 16V MultiJet 80/95HP
Unladen weight (with all fluids, fuel tank 90% full and
without optional equipment):940 980 1045
Payload including the driver:
(*)480 (4-seater) / 500
(5-seater)470480 (4-seater) (1)/
Maximum permitted loads
(**)
– front axle: 770 770 855
– rear axle: 760 760 760
– total:1420 (4-seater) / 1440
(5-seater)14501515 (4-seater) / 1535
(5-seater)
Towable loads
– braked trailer: 800
(***)900
– non-braked trailer: 400
(***)400
Maximum load on roof: 55 55
55/60
(°)
Maximum load on ball joint (braked trailer): 60(***)60
(*) If special equipment is fitted (sun roof, tow hitch, etc.) the unladen vehicle weight increases, thus reducing the specified payload in relation to the maximum
permitted loads.
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within the maximum permitted loads.
(***)IMPORTANT A trailer cannot be towed so there are no provisions for fitting a tow hook.
(°) Trekking versions
/
/
/ /
470 (4-seater) (2)/
500 (5-seater) (1)/
490 (5-seater) (2)
(1) 80HP
(2) 95HP
Page 163 of 204
161
Panda Cross and Panda 4x4 EURO 5 versions
Weights (kg) 1.3 16V MultiJet 75 HP 1.3 16V MultiJet 80 HP
Unladen weight (with all fluids, fuel tank 90% full and
without optional equipment):1115 1155
Payload including the driver:
(*)480 (4-seater) / 500 (5-seater) 440 (4-seater) / 470 (5-seater)
Maximum permitted loads
(**)
– front axle: 875 875
– rear axle: 810 810
– total: 1595 (4-seater) / 1615 (5-seater) 1530 (4-seater) / 1585 (5-seater)
Towable loads
– braked trailer: 900 800
– non-braked trailer: 400 400
Maximum load on roof: 55
60
(***)
Maximum load on ball joint (braked trailer): 60 60
(*) If special equipment is fitted (sun roof, tow hitch, etc.) the unladen vehicle weight increases, thus reducing the specified payload in relation to the maximum
permitted loads.
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within the maximum permitted loads.
(***) Load evenly distributed
Page 164 of 204
162
TECHNICAL SPECIFICATIONS
Panda Cross and Panda 4x4 EURO 6 versions
Weights (kg) 0.9 TwinAir Turbo 85 HP 0.9 TwinAir Turbo 90 HP 1.3 16V MultiJet 95 HP
Unladen weight (with all fluids, fuel tank 90% full and
without optional equipment):1050 1090
1125(°)/ 1165(°°)
Payload including the driver:(*)480 (4-seater) / 500
(5-seater)440 (4-seater) / 495
(5-seater)470 (4-seater)
(°)/ 430
(4-seater)(°°)/ 490
(5-seater)(°)/ 460
(5-seater)(°°)
Maximum permitted loads(**)
– front axle: 875 875 875
– rear axle: 810 810 810
– total:1530 (4-seater) / 1550
(5-seater)1530 (4-seater) / 1585
(5-seater)1595 (4-seater) / 1615
(5-seater)
(°)/ 1625
(5-seater)(°°)
Towable loads
– braked trailer: 800 800 900
– non-braked trailer: 400 400 400
Maximum load on roof: 55
60
(***)60(***) (°°)
Maximum load on ball joint (braked trailer): 60 60 60
(°) Panda 4x4 versions
(°°) Panda Cross versions
(*) If special equipment is fitted (sun roof, tow hitch, etc.) the unladen vehicle weight increases, thus reducing the specified payload in relation to the maximum
permitted loads.
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within the maximum permitted loads.
(***) Load evenly distributed
Page 165 of 204
163
Panda VAN EURO 5 versions
Weights (kg) 1.3 16V MultiJet 75 HP 1.3 16V MultiJet 4x4 75 HP
Unladen weight (with all fluids, fuel tank
90% full and without optional
equipment):1030 (2-seater) / 1050 (4-seater) 1100
Payload including the driver:
(*)505 (2-seater) / 400 (2-seater)(**)/ 490
(4-seater)495
Maximum permitted loads
(***)
– front axle: 855 875
– rear axle: 770 (2-seater) / 780 (4-seater) 810
– total:1535 (2-seater) / 1430 (2-seater)
(**)/ 1530
(4-seater)1595
Towable loads
– braked trailer: 900 900
– non-braked trailer: 400 400
Maximum load on roof: 60 55
Maximum load on ball joint (braked
trailer):60 60
(*) If special equipment is fitted (sun roof, tow hitch, etc.) the unladen vehicle weight increases, thus reducing the specified payload in relation to the maximum
permitted loads.
(**)Versions with reduced capacity
(***) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within the maximum permitted loads.