Seat FIAT QUBO 2010 1.G Service Manual

PROTECTED DEVICE - fig. 162 FUSE AMPS
Heated rear window, mirror defrosters F20 30
Fuel pump F21 15
Fog lights F30 15
SpareF08 -
Cigar lighter/Passenger compartment socket/Heated seats F85 30
+15 reverse lights/air flow meter/water in fuel sensor/relay coils T02, T05,
T14, T17 and T19F87 7.5
159
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

PROTECTED DEVICE - fig. 164 FUSE AMPS
SpareF92 -
SpareF93 -
Cigar lighter/Passenger compartment power socket F94 15
SpareF95 -
Cigar lighter/Passenger compartment power socket F96 15
Front seat heater (driver) F97 10
Front seat heater (passenger) F98 10
162
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

units and the relay/fuse box on the left side of the
engine compartment (as you look from behind
the wheel). Have this operation performed at a
specialist garage.
IMPORTANT The washing should take place with the
engine cold and the ignition key in the STOP
position. After the wash, make sure that the various
protective devices (e.g. rubber caps and guards)
have not been removed or damaged.
Front headlights
IMPORTANT Never use aromatic substances (e.g.
petrol) or ketenes (e.g. acetone) for cleaning the
plastic lenses of the front headlights.INTERIORS
Check regularly that water is not trapped under the
mats (from dripping off shoes, umbrellas, etc.) which
could cause the metal to rust.
WARNING
Never use flammable products, such as
pet
roleum ether or modified petrol,
to clean the inside of the vehicle.The
electrostatic charges which are generated by
rubbing during the cleaning operation may
cause a fire.
WARNING
Do not keep aerosol cans in the vehicle:
t
hese could explode. Aerosol cans must
not be exposed to temperatures of more than
50°C.When the vehicle is exposed to sunlight ,
the temperature inside can greatly exceed
this value.
SEATS AND FABRIC PARTS
Remove dust with a soft brush or a vacuum cleaner.
It is advisable to use a damp brush on velvet
upholstery.
Rub the seats with a sponge and a solution of water
and mild soap.
186
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

CHASSIS MARKING
This is printed on the passenger compartment floor,
near the right front seat.
Slide the hatch A fig. 178 forward to access.
The marking includes:
❒type of vehicle;
❒chassis manufacture number.BODY PAINTWORK IDENTIFICATION
PLATE
This plate is applied inside the bonnet and shows the
following data fig. 179:
APaint manufacturer.
BColour name.
CFiat colour code.
DRespray and touch up code.
ENGINE MARKING
This is printed onto the cylinder block and shows the
type and production serial number.
fig. 178F0T0084fig. 179F0T0012
189
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

ENGINE CODES - BODYWORK
VERSIONS
Version Engine code
1.3 Multijet199A2000
The following body version code and key are an
example that may be applied to all body version
codes.
Example:
225BXB1AAX
Key :
225Model
BBody
XBEngine
1Traction
ATransmission
AXVersionBODY
AQubo M1 (5 seat)
CQubo N1 (4 seats)
ENGINES
XA1.4 petrol Euro 4
XB1.3 Multijet 75 HP Euro 4
XCMethane
XD1.3 Multijet 75 HP Euro 5
XE1.3 Multijet 95 HP Euro 5
XF1.4 petrol Euro 5
DRIVE
1Front
TRANSMISSION
AMechanical gearbox
1Comfort/Dualogic gearbox
190
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

WEIGHTS
Weights (kg)1.3 Multijet 75 HP Euro 4 class 1
(o)
N1
"Minimum"
versions (4
seats)N1 "Maximum" versions (4 seats) M1 versions
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1205 1300 1200
Payload
(*)including the driver:550 455 510
Payload
(*)excluding the driver:475 - 440
Maximum permitted loads
(**)
- front axle: 950 950 950
- rear axle: 950 950 950
- total: 1755 1755 1710
Towable loads
- trailer with brakes: 600 600 600
- trailer without brakes: 400 400 400
(o)For versions/markets, where provided
(*)N1 CATEGORY: for the full optional versions (110 kg) the payload is gradually reduced to 500 kg.
(**)Loads not to be exceeded. The user is responsible for arranging goods in the boot and/or on the load carrying platform within the
maximum permitted loads.
201
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

Weights (kg)1.3 Multijet 75 HP Euro 4 class 1
(o)
N1
"Minimum"
versions (4
seats)N1 "Maximum" versions (4 seats) M1 versions
Maximum load on the roof (with roof
rack bars)
(***)70 70 70
Maximum load on ball joint (trailer
with brake):60 60 60
(o)For versions/markets, where provided
(***)Including weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NoteTrekking versions have the same capacities as the other versions.
CATEGORY M1: optional equipment is included in the capacity.
202
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

Weights (kg)1.3 Multijet 75 HP Euro 4 class 2
N1 "Minimum"
versions (4 seats)N1 "Maximum" versions (4 seats)
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1235 1355
Payload
(*)including the driver:565 445
Payload
(*)excluding the driver:490 370
Maximum permitted loads
(**)
- front axle: 950 950
- rear axle: 960 960
- total: 1800 1800
Towable loads
- trailer with brakes: 600 600
- trailer without brakes: 400 400
Maximum load on the roof (with roof
rack bars)
(***)100 100
Maximum load on ball joint (trailer
with brake):60 60
(*)N1 CATEGORY: for the full optional versions (120 kg) the payload is gradually reduced to 445 kg.
(**)Loads not to be exceeded. The user is responsible for arranging goods in the boot and/or on the load carrying platform within the
maximum permitted loads.
(***)Including weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NoteTrekking versions have the same capacities as the other versions.
203
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

ARRANGEMENTS FOR DEALING WITH THE VEHICLE AT THE END OF ITS
LIFE
Fiat has been committed for many years to safeguarding the environment through the constant improvement
of its production processes and manufacturing products that are increasingly "eco-compatible". To give
customers the best possible service in terms of respecting environmental laws and in response to European
Directive 2000/53/EC governing vehicles at the end of their life, Fiat is offering its customers the opportunity
of handing over their vehicle* at the end of its life without incurring any additional costs.
The European Directive sets out that when the vehicle is handed over the last keeper or owner should not
incur any expenses as a result of it having a zero or negative market value. In all European Union countries,
until 1st January 2007, only vehicles registered after 1st July 2002 were collected free of charge, while since
2007 collection has been free of charge irrespective of the year of registration as long as the vehicle contains
its basic components (in particular, the engine and bodywork) and has no additional waste.
To hand your vehicle over at the end of its life without extra cost, go to one of our Dealerships or
Fiat-authorised collection and scrapping centres. These centres have been carefully chosen to offer high
quality service for the collection, treatment and recycling of unused vehicles with respect to the environment.
You can find further information on these collection and scrapping centres either from a Fiat or Fiat
Commercial Vehicle Dealership or by calling the freephone number 00800 3428 0000 or by going on the Fiat
website.
(*) Vehicle for transporting passengers with a maximum of nine seats and a total permitted weight of 3.5 t
211
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

Index
ABS fault warning light ............ 123
ABS (fault warning light) .......... 123
ABS ................................................ 75
Air bag fault warning light ........ 121
Air bag (fault warning light) ..... 121
Airbags (general warnings) ...... 108
Air cleaner ................................... 177
Alarm fault warning light .......... 127
Alarm ............................................. 9
Alarm (warning light) ................ 127
Arrangements for dealing
with the vehicle at the end
of its life ..................................... 211
Ashtray .......................................... 56
ASR
– On/off message..................... 130
ASR system .................................. 78
– On/off message..................... 130
Battery
– Replacement .......................... 178
Battery (low charge warning
light) ............................................ 122
Battery (recharging) .................. 163Body
– Advice for preserving the
bodywork ............................... 184
– Protection from
atmospheric elements......... 184
– Vehicle body and
underbody guarantee .......... 184
Body paintwork
identification plate ................... 189
Bodywork versions.................... 190
Bonnet
– Closing ..................................... 71
– Opening ................................... 70
Boot ............................................... 62
Boot light ............................... 52-153
Brake Assist ................................. 76
Brake fluid/handbrake
warning light.............................. 120
Brake fluid.................................... 175
Brake fluid (warning light)........ 120
Brake lights (changing a
bulb) ............................................ 149
Brake pad wear warning
light ............................................. 129
Brake pad wear (warning
light) ............................................ 129
Brakes
– characteristics ....................... 193Brakes (pad wear warning
light) ............................................ 129
Break-in attempt warning
light ............................................. 127
Bulb types .................................... 144
Bump starting ............................. 132
Capacities.................................... 204
Carrying children safely
– Child seat compliance ......... 100
– Child seats .............................. 96
– Safety rules ............................ 101
Ceiling lights................................. 49
Ceiling light with movable
lens (changing a bulb).............. 151
Central and side vents ............... 38
Changing a bulb.................. 143-144
Changing an exterior
bulb .................... 146-147-148-150
Changing an interior bulb ........ 151
Changing a tyre .................. 132-133
Changing battery - key with
remote control.......................... 8
Chassis marking.......................... 189
Checking fluid levels.................. 171
Cigar lighter ................................. 55
Clutch ........................................... 192
CO
2emissions ........................... 209
222
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX