service schedule FORD F-150 2020 Owner's Manual

Off-road Operation
Inspect functional holes in exhaust tip to make sure they
are clean and clear of debris or foreign materials. Refer to
the Vehicle Care chapter of your owner ’s manual for more
information. (Diesel Engine).
As required
Inspect the steering and suspension ball joints and tie rods.
Lubricate any grease fittings.
Rotate the tires, inspect the tires for wear and measure
tread depth.
Every 7,000 mi (12,000 km),
six months or 300 engine
hours
Inspect the brake system pads and rotors.
Inspect the air filter restriction gauge. Replace the filter if
necessary.
Change the engine oil and filter. 1
Every 7,000 mi (12,000 km)
or 300 engine hours
Replace the engine-mounted and frame-mounted fuel
filters.
Every 30,000 mi
(48,000 km), six months or
600 engine hours
Replace the air inlet foam filter.
Every
30,000 mi
(48,000 km)
1 Reset the Intelligent Oil-Life Monitor after engine oil and filter changes. Using Biodiesel, up to and Including 20% Biodiesel (B20)
Change the engine oil and filter as indicated by the
information display, and perform the services listed in the
scheduled maintenance chart.
As required
Replace the engine-mounted and frame-mounted fuel
filters.
Every
30,000 mi
(48,000 km), six months or
300 engine hours
Exceptions
There are several exceptions to the Normal
Schedule. Axle and Transfer Case Maintenance
Axle(s) and transfer case (Four-wheel
drive vehicles) fluid changes or level
checks are not required unless a leak is
suspected or the assembly has been
submerged in water. Contact an authorized
dealer for service.
565
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 201907, Third-Printing- Scheduled Maintenance

California Fuel Filter Replacement
If you register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot Climate Oil Change Intervals
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 3,000 mi (4,800 km).
If the available API SM or SN oils are not
available, then the oil change interval is
1,800 mi (2,900 km).
Engine Air Filter Replacement
The life of the engine air filter is dependent
on exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter. Diesel Particulate Filter
Over time, a slight amount of ash builds
up in the diesel particulate filter, which is
not removed during the regeneration
process. The filter may need to be replaced
with a new or remanufactured part at
approximately 250,000 mi (400,000 km).
Actual mileage varies depending on engine
and vehicle operating conditions.
In this case, the engine control system sets
a service light (wrench icon) to inform you
to bring your vehicle to the dealer for
service. If there are any issues with the
oxidation catalyst or particulate filter
system, a service light (wrench or engine
icon) sets by the engine control system to
inform you to bring your vehicle into a
dealer for service.
SCHEDULED MAINTENANCE
RECORD
After the scheduled maintenance services
are performed, record the Repair Order #,
Distance and Engine Hours in the boxes
provided.
566
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 201907, Third-Printing- Scheduled Maintenance

Rear Occupant Alert System Audible
Warnings.......................................................170
Rear Occupant Alert System Indicators......................................................170
Rear Occupant Alert System Limitations...................................................169
Rear Occupant Alert System Precautions.................................................169
Rear Occupant Alert System
...................169
Rear Parking Aid...........................................242 Obstacle Distance Indicator.......................... 243
Rear Seat Armrest
........................................178
Rear Seats.......................................................165
Folding Up the Rear Seat Cushion ..............165
Returning the Seat to the Seating
Position.............................................................. 165
Rear View Camera.......................................247 Camera guidelines............................................ 249
Manual Zoom..................................................... 250
Obstacle Distance Indicator.......................... 250
Rear Camera Delay........................................... 250
Using the Rear View Camera System.............................................................. 248
Rear View Camera See: Rear View Camera................................... 247
Recommended Towing Weights...........302 Calculating the Maximum Loaded Trailer
Weight for Your Vehicle............................... 314
Refueling........................................................200 Refueling System Overview.......................... 200
Refueling System Warning............................. 202
Refueling Your Vehicle.................................... 200
Remote Control
..............................................60
Car Finder................................................................ 64
Integrated Keyhead Transmitter.................... 60
Intelligent Access Key.......................................... 61
Remote Start......................................................... 65
Replacing the Battery......................................... 62
Sounding a Panic Alarm.................................... 64
Remote Start
..................................................157
Automatic Settings............................................ 157
Heated and Cooled Features.......................... 157
Last Settings......................................................... 157
Removing the Tailgate..................................78
Repairing Minor Paint Damage..............388
Replacement Parts Recommendation........................................16
Collision Repairs.................................................... 16Scheduled Maintenance and Mechanical
Repairs................................................................. 16
Warranty on Replacement Parts.................... 16
Replacing a Lost Key or Remote Control............................................................66
Reporting Safety Defects (Canada Only)
..............................................................342
Reporting Safety Defects (U.S. Only)
..............................................................342
Resuming the Set Speed..........................254
Roadside Assistance...................................331 Vehicles Sold in Canada: Getting Roadside
Assistance....................................................... 332
Vehicles Sold in the United States: Getting Roadside Assistance.................................... 331
Vehicles Sold in the United States: Using Roadside Assistance.................................... 331
Roadside Emergencies
...............................331
Running-In See: Breaking-In................................................. 326
Running Out of Fuel....................................198 Adding Fuel From a Portable Fuel
Container.......................................................... 199
Filling a Portable Fuel Container.................. 198
S
Safety Canopy ™
.............................................57
Safety Precautions.......................................193
Satellite Radio
..............................................484
Satellite Radio Electronic Serial Number
(ESN)................................................................ 485
Satellite Radio Reception Factors..............485
SiriusXM Satellite Radio Service.................485
Troubleshooting................................................ 486
Scheduled Maintenance Record
...........566
Scheduled Maintenance...........................553
Seatbelt Extensions......................................48
Seatbelt Height Adjustment......................45
Seatbelt Reminder........................................46 Belt-Minder™........................................................ 46
Seatbelts...........................................................40 Principle of Operation........................................ 40
Seatbelt Warning Lamp and Indicator Chime..............................................................45
Conditions of operation..................................... 46
Seats.................................................................158
Security..............................................................82
618
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 201907, Third-Printing- Index