check engine FORD FUSION (AMERICAS) 2015 2.G Owner's Guide
[x] Cancel search | Manufacturer: FORD, Model Year: 2015, Model line: FUSION (AMERICAS), Model: FORD FUSION (AMERICAS) 2015 2.GPages: 488, PDF Size: 5.66 MB
Page 317 of 488
VEHICLE IDENTIFICATION
NUMBER
The vehicle identification number is
located on the left-hand side of the
instrument panel.
Please note that in the graphic, XXXX is
representative of your vehicle identification
number.
The Vehicle Identification Number contains
the following information:
World manufacturer identifier
A
Brake system, Gross Vehicle
Weight Rating, Restraint Devices
and their locations
B Make, vehicle line, series, body
type
C
Engine type
D
Check digit
E
Model year
F
Assembly plant
G
Production sequence number
H
VEHICLE CERTIFICATION
LABEL The National Highway Traffic Safety
Administration Regulations require that a
Safety Compliance Certification Label be
affixed to a vehicle and prescribe where
the Safety Compliance Certification Label
may be located. The Safety Compliance
Certification Label shall be affixed to either
the door hinge pillar, the door latch post,
or the edge of the door near the door latch,
next to the driver's seating position.
314
Fusion/Mondeo (CC7), enUSA Capacities and SpecificationsE142476 E142477 E167469
Page 322 of 488
Ford part number /
Ford specification
Ford part name or
equivalent
Capacity
Item
WSH-M1C231-A
1 Ford recommends using Motorcraft (Ford) DOT 4 Low Viscosity (LV) High Performance
Brake Fluid, or equivalent meeting WSS-M6C65-A2. Use of any fluid other than the
recommended fluid may cause degraded brake performance and not meet the Ford
performance standards. Keep brake fluid clean and dry. Contamination with dirt, water,
petroleum products or other materials may result in brake system damage and possible
failure.
2 Approximate dry fill capacity. Actual amount may vary during fluid changes.
3 Automatic transmissions that require Motorcraft MERCON LV transmission fluid should
only use Motorcraft MERCON LV transmission fluid.
Use of any fluid other than the recommended fluid may cause transmission damage.
Change the automatic transmission fluid and filter at the correct service interval. See
Scheduled Maintenance (page 458).
4 See your authorized dealer for fluid level checking or filling.
5 Use of synthetic or synthetic blend motor oil is not mandatory. Only use fluid that meets
Ford specifications. Motor oils of the recommended viscosity grade that meet API SN
requirements and display the API Certification Mark for gasoline engines are also
acceptable. Do not use oil labeled with API SN service category unless the label also
displays the API certification mark.
6 Do not use oils labeled as API SN unless the label also displays the API certification mark.
These oils do not meet the requirements of your vehicle's engine and emissions system.
7 Do not use supplemental engine oil additives in your engine. They are unnecessary and
could lead to engine damage not covered by your Ford warranty.
8 Add the coolant type originally equipped in your vehicle.
319
Fusion/Mondeo (CC7), enUSA Capacities and Specifications
Page 462 of 488
When the oil change message appears in
the information display, it is time for an oil
change. Make sure you perform the oil
change within two weeks or 500 miles
(800 kilometers) of the message
appearing. Make sure you reset the
Intelligent Oil-Life Monitor after each oil
change. See Information Messages
(page 103).
If your information display resets
prematurely or becomes inoperative, you
should perform the oil change interval at
six months or 5000 miles (8000
kilometers) from your last oil change.
Never exceed one year or 10000 miles
(16000 kilometers) between oil change
intervals.
Your vehicle is very sophisticated and built
with multiple, complex, performance
systems. Every manufacturer develops
these systems using different
specifications and performance features.
That is why it is important to rely upon your
dealership to properly diagnose and repair
your vehicle.
Ford Motor Company has recommended
maintenance intervals for various parts
and component systems based upon
engineering testing. Ford Motor Company
relies upon this testing to determine the
most appropriate mileage for replacement
of oils and fluids to protect your vehicle at
the lowest overall cost to you and
recommends against maintenance
schedules that deviate from the scheduled
maintenance information.
We strongly recommend the use of only
genuine Ford, Motorcraft or
Ford-authorized re-manufactured
replacement parts engineered for your
vehicle. Additives and Chemicals
This owner's manual and the Ford
Workshop Manual list the recommended
additives and chemicals for your vehicle.
We do not recommend using chemicals or
additives not approved by us as part of
your vehicle
’s normal maintenance. Please
consult your warranty information.
Oils, Fluids and Flushing
In many cases, fluid discoloration is a
normal operating characteristic and, by
itself, does not necessarily indicate a
concern or that the fluid needs to be
changed. However, a qualified expert, such
as the factory-trained technicians at your
dealership, should inspect discolored fluids
that also show signs of overheating or
foreign material contamination
immediately.
Make sure to change your vehicle ’s oils and
fluids at the specified intervals or in
conjunction with a repair. Flushing is a
viable way to change fluid for many vehicle
sub-systems during scheduled
maintenance. It is critical that systems are
flushed only with new fluid that is the same
as that required to fill and operate the
system or using a Ford-approved flushing
chemical.
Owner Checks and Services
Make sure you perform the following basic
maintenance checks and inspections every
month or at six-month intervals.
459
Fusion/Mondeo (CC7), enUSA Scheduled Maintenance
Page 463 of 488
Check every month
Engine oil level.
Function of all interior and exterior lights.
Tires (including spare) for wear and proper pressure. Windshield washer fluid level. Check every six months
Battery connections. Clean if necessary.
Body and door drain holes for obstructions. Clean if necessary. Cooling system fluid level and coolant strength.
Door weatherstrips for wear. Lubricate if necessary.
Hinges, latches and outside locks for proper operation. Lubricate if necessary. Parking brake for proper operation.
Safety belts and seat latches for wear and function.
Safety warning lamps (brake, ABS, airbag and safety belt) for operation.
Washer spray and wiper operation. Clean or replace blades as necessary.
Multi-Point Inspection
In order to keep your vehicle running right,
it is important to have the systems on your
vehicle checked regularly. This can help
identify potential issues and prevent major
problems. We recommend having the
following multi-point inspection performed
at every scheduled maintenance interval
to help make sure your vehicle keeps
running great.
460
Fusion/Mondeo (CC7), enUSA Scheduled Maintenance
Page 464 of 488
Multi-Point inspection
Hazard warning system operation
Accessory drive belt(s)
Horn operation
Battery performance
Radiator, cooler, heater and air conditioninghoses
Engine air filter
Suspension components for leaks ordamage
Exhaust system
Steering and linkage
Exterior lamps operation
Tires (including spare) for wear and properpressure**
Fluid levels *
; fill if necessary
Windshield for cracks, chips or pits
For oil and fluid leaks
Washer spray and wiper operation
Half-shaft dust boots
* Brake, coolant recovery reservoir, automatic transmission and window washer
** If your vehicle is equipped with a temporary mobility kit, check the tire sealant expiration
Use By date on the canister. Replace as needed.
Be sure to ask your dealership service
advisor or technician about the multi-point
vehicle inspection. It is a comprehensive
way to perform a thorough inspection of
your vehicle. Your checklist gives you
immediate feedback on the overall
condition of your vehicle.
NORMAL SCHEDULED
MAINTENANCE
Intelligent Oil-Life Monitor®
Your vehicle is equipped with an Intelligent
Oil-Life Monitor that determines when you
should change the engine oil based on how
your vehicle is used. By using several
important factors in its calculations, the
monitor helps reduce the cost of owning
your vehicle and reduces environmental
waste at the same time. This means you do not have to remember
to change the oil on a mileage-based
schedule. Your vehicle lets you know when
an oil change is due by displaying ENGINE
OIL CHANGE DUE or OIL CHANGE
REQUIRED in the information display.
The following table provides examples of
vehicle use and its impact on oil change
intervals. It is a guideline only. Actual oil
change intervals depend on several factors
and generally decrease with severity of
use.
461
Fusion/Mondeo (CC7), enUSA Scheduled Maintenance
Page 466 of 488
At every oil change interval as indicated by the information display
*
Inspect the tires, tire wear and measure the tread depth.
Inspect the wheels and related components for abnormal noise, wear, looseness or
drag.
* Do not exceed one year or 10000 miles (16000 kilometers) between service intervals.
** Reset the Intelligent Oil-Life Monitor after engine oil and filter changes. See Engine
Oil Check (page 251). Other maintenance items
1
Replace cabin air filter.
Every 20000 miles (32000
km)
Replace engine air filter.
Every 30000 miles (48000
km)
Change engine coolant.2
At 100000 miles (160000
km)
Replace spark plugs.
Every 100000 miles
(160000 km) Inspect accessory drive belt(s). 3
Change automatic transmission fluid.
Every 150000 miles
(240000 km) Change manual transmission fluid.
Replace accessory drive belt(s).
4
Replace timing belt (1.6L engine).
1 Perform these maintenance items within 3000 miles (4800 kilometers) of the last
engine oil and filter change. Do not exceed the designated distance for the interval.
2 Initial replacement at six years or 100000 miles (160000 kilometers), then every three
years or 50000 miles (80000 kilometers).
3 After initial inspection, inspect every other oil change until replaced.
4 If not replaced within the last 100000 miles (160000 kilometers).
463
Fusion/Mondeo (CC7), enUSA Scheduled Maintenance
Page 468 of 488
Extensive idling or low-speed driving for long distances, as in heavy commercial use
(such as delivery, taxi, patrol car or livery)
Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Sched-
uled Maintenance chart.
As required
Replace cabin air filter.
Inspect frequently, service
as required
Replace engine air filter.
Change automatic transmission fluid.
Every 30000 miles (48000
km)
Replace spark plugs.
Every 60000 miles (96000
km) Operating in dusty or sandy conditions (such as unpaved or dusty roads)
Replace cabin air filter.
Inspect frequently, service
as required
Replace engine air filter.
Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.
Every 5000 miles (8000
km)
Rotate tires, inspect tires for wear and measure tread
depth.
Change engine oil and filter.*
Every 5000 miles (8000
km) or six months
Perform multi-point inspection.
Change automatic transmission fluid.
Every 30000 miles (48000
km)
Change manual transmission fluid.
Every 50000 miles (80000
km)
* Reset your Intelligent Oil-Life Monitor after engine oil and filter changes. See Engine
Oil Check (page 251). Exclusive use of E85 (flex fuel vehicles only)
If ran exclusively on E85, fill the fuel tank full with regular
unleaded fuel.
Every oil change
465
Fusion/Mondeo (CC7), enUSA Scheduled Maintenance
Page 479 of 488
Bonnet Lock
See: Opening and Closing the Hood..........246
Booster Seats..................................................22
Types of Booster Seats...................................... 22
Brake and Clutch Fluid Check.................255
Brakes.................................................................171 General Information............................................ 171
Breaking-In......................................................221
Bulb Specification Chart...........................263
C
Cabin Air Filter................................................126
California Proposition 65..............................11
Capacities and Specifications.................312 Technical Specifications.................................. 316
Car Wash See: Cleaning the Exterior.............................. 266
Center Console
..............................................143
Changing a Bulb............................................261 Replacing a Reverse Lamp Bulb.................. 262
Replacing the Headlamp Bulbs.................... 261
Replacing the License Plate Lamp Bulb.................................................................... 263
Replacing the Tail, Brake, High-Mount Brake Lamp, and Turn Signal Lamp
Bulbs................................................................... 261
Changing a Fuse...........................................245 Fuses...................................................................... 245
Changing a Road Wheel...........................304 Dissimilar Spare Wheel and Tire Assembly
Information..................................................... 304
Stowing the flat tire (Type 1)........................ 309
Stowing the flat tire (Type 2)....................... 309
Tire Change Procedure.................................... 305
Type 1..................................................................... 306
Type 2..................................................................... 307
Changing the 12V Battery.........................255
Changing the Engine Air Filter................265 2.5L Engine........................................................... 265
EcoBoost Engines............................................. 265
Changing the Wiper Blades......................257
Checking MyKey System Status...............55
Checking the Wiper Blades......................257
Child Restraint and Safety Belt Maintenance.................................................34
Child Safety
.......................................................13
General Information............................................. 13Child Safety Locks
..........................................25
Left-Hand Side...................................................... 26
Right-Hand Side................................................... 26
Child Seat Positioning..................................24
Cleaning Leather Seats
.............................269
Cleaning Products.......................................266
Cleaning the Alloy Wheels
.......................270
Cleaning the Engine....................................267
Cleaning the Exterior..................................266 Cleaning Plastic Exterior Parts...................... 267
Exterior Chrome................................................. 266
Stripes or Graphics (if equipped)...............266
Underbody............................................................ 267
Cleaning the Instrument Panel and Instrument Cluster Lens........................268
Cleaning the Interior...................................268
Cleaning the Windows and Wiper Blades...........................................................268
Clearing All MyKeys.......................................53
Climate............................................................426 Climate Control Voice Commands.............429
Climate Control
...............................................117
Climate Controlled Seats..........................135
Cooled Seats........................................................ 136
Collision Warning System........................204 PRINCIPLE OF OPERATION.......................... 204
Coolant Check See: Engine Coolant Check............................ 252
Crash Sensors and Airbag Indicator........43
Creating a MyKey............................................53 Programming/Changing Configurable
Settings............................................................... 53
Cruise Control
.................................................69
Principle of Operation....................................... 187
Type 1........................................................................\
69
Type 2....................................................................... 69
Cruise control See: Using Cruise Control................................ 187
Customer Assistance
.................................229
D
Data Recording
..................................................9
Event Data Recording........................................... 9
Service Data Recording........................................ 9
476
Fusion/Mondeo (CC7), enUSA Index
Page 480 of 488
Daytime Running Lamps..............................77
Type 1 - Conventional
(Non-Configurable)........................................ 77
Type 2 - Configurable.......................................... 77
Digital Radio..................................................329
HD Radio Reception and Station
Troubleshooting............................................ 330
Direction Indicators........................................79
Driver Alert
......................................................194
PRINCIPLE OF OPERATION........................... 194
USING DRIVER ALERT..................................... 194
Driver and Passenger Airbags....................37 Children and Airbags........................................... 37
Proper Driver and Front Passenger Seating Adjustment........................................................ 37
Driver and Passenger Knee Airbags
.........41
Driving Aids.....................................................194
Driving Hints
....................................................221
Driving Through Water................................221
DRL See: Daytime Running Lamps.......................... 77
E
Economical Driving......................................221
Electric Parking Brake..................................172 Applying the electric parking brake..............172
Applying the electric parking brake when
the vehicle is moving..................................... 172
Battery With No Charge.................................... 174
Parking on a hill (vehicles with a manual transmission) .................................................. 172
Releasing the electric parking brake............173
Emission Control System
..........................158
On-Board Diagnostics (OBD-II)................... 159
Readiness for Inspection/Maintenance (I/M) Testing................................................... 159
End User License Agreement
..................441
SYNC End User License Agreement
(EULA)............................................................... 441
Engine Block Heater
....................................148
Using the Engine Block Heater...................... 149Engine Coolant Check................................252
Adding Engine Coolant.................................... 252
Checking the Engine Coolant........................ 252
Recycled Engine Coolant................................ 253
Severe Climates................................................. 253
What You Should Know About Fail-Safe Cooling.............................................................. 254
Engine Immobilizer See: Passive Anti-Theft System..................... 65
Engine Oil Check
...........................................251
Adding Engine Oil............................................... 251
Engine Oil Dipstick - 1.5L EcoBoost™.................................................250
Engine Oil Dipstick - 1.6L EcoBoost™..................................................251
Engine Oil Dipstick - 2.0L EcoBoost™/ 2.5L..................................................................251
Engine Specifications..................................312 Drivebelt Routing................................................ 312
Entertainment..............................................394 A/V Inputs............................................................. 410
AM/FM Radio...................................................... 396
Bluetooth Audio................................................ 409
Browsing Device Content............................... 394
CD........................................................................\
... 405
SD Card Slot and USB Port........................... 406
SIRIUS® Satellite Radio (If Activated)........................................................ 401
Supported Media Players, Formats and Metadata Information................................ 409
EPB See: Electric Parking Brake.............................. 172
Essential Towing Checks............................217 Before Towing a Trailer..................................... 218
Hitches.................................................................... 217
Launching or Retrieving a Boat or Personal Watercraft (PWC)......................................... 218
Safety Chains........................................................ 217
Trailer Brakes......................................................... 217
Trailer Lamps........................................................ 217
When Towing a Trailer...................................... 218
Event Data Recording See: Data Recording.............................................. 9
Export Unique Options
..................................12
Extended Service Plan (ESP).................456 SERVICE PLANS (CANADA ONLY).............457
SERVICE PLANS (U.S. Only)........................ 456
477
Fusion/Mondeo (CC7), enUSA Index
Page 481 of 488
Exterior Mirrors................................................82
Auto-Dimming Feature...................................... 82
Blind Spot Monitor.............................................. 83
Fold-Away Exterior Mirrors............................... 82
Heated Exterior Mirrors...................................... 82
Integrated Blind Spot Mirrors.......................... 83
Memory Mirrors..................................................... 82
Power Exterior Mirrors........................................ 82
Signal Indicator Mirrors...................................... 83
F
Fastening the Safety Belts.........................28
Rear Inflatable Safety Belt............................... 30
Safety Belt Extension Assembly...................... 31
Safety Belt Locking Modes............................... 29
Using Safety Belts During Pregnancy...........28
Flat Tire Inflation See: Temporary Mobility Kit........................... 273
Floor Mats
.......................................................222
Fog Lamps - Front See: Front Fog Lamps......................................... 78
Ford Credit
..........................................................11
(U.S. Only)................................................................. 11
Front Fog Lamps............................................78
Front Passenger Sensing System
............38
Fuel and Refueling.......................................152
Fuel Consumption
........................................157
Calculating Fuel Economy.............................. 158
Filling the Tank..................................................... 157
Fuel Filter........................................................255
Fuel Quality
.....................................................153
Choosing the Right Fuel (Flex Fuel
Vehicles)........................................................... 153
Choosing the Right Fuel (Gasoline Vehicles)........................................................... 153
Octane Recommendations............................ 153
Fuel Shutoff
...................................................225
Fuses................................................................235
Fuse Specification Chart...........................235 Passenger Compartment Fuse
Panel.................................................................. 242
Power Distribution Box.................................... 235
G
Garage Door Opener See: Universal Garage Door Opener............137 Gauges...............................................................86
Engine Coolant Temperature Gauge............87
Fuel Gauge.............................................................. 87
Information Display............................................. 86
Left Information Display................................... 88
Type 1 and 2............................................................ 86
Type 3....................................................................... 88
General Information on Radio Frequencies...................................................45
Intelligent Access................................................. 45
General Maintenance Information
.......458
Multi-Point Inspection.................................... 460
Owner Checks and Services......................... 459
Protecting Your Investment.......................... 458
Why Maintain Your Vehicle?......................... 458
Why Maintain Your Vehicle at Your Dealership?..................................................... 458
Getting Assistance Outside the U.S. and Canada..........................................................232
Getting the Services You Need
...............229
Away From Home.............................................. 229
Global Opening and Closing......................82 Closing the Windows.......................................... 82
Opening the Windows........................................ 82
H
Hazard Warning Flashers..........................225
Headlamp Exit Delay....................................76
Head Restraints
.............................................128
Adjusting the Head Restraint......................... 129
Tilting Head Restraints .................................... 129
Heated Seats
..................................................135
Heated Steering Wheel................................70
Heated Windows and Mirrors..................126 Heated Exterior Mirror....................................... 126
Heated Rear Window........................................ 126
Heating See: Climate Control........................................... 117
Hill Start Assist..............................................174 Using Hill Start Assist........................................ 174
478
Fusion/Mondeo (CC7), enUSA Index