transmission FORD FUSION/HYBRID 2018 Owners Manual

which case a tire of the same brand, size, load, speed and tread type will
be used. In some circumstances, Ford may authorize another brand
and/or model to substitute for the original brand and model, even if still
available.
Normal tire wear or damage is not reimbursable. See page 14 for details
of what is not covered.
Extended warranty coverage periods are available for certain
vehicle parts and conditions. Specifically,
(1) Your vehicle’s Powertrain components are covered for five years or
60,000 miles, whichever occurs first. The extended coverage applies to
theEngine: all internal lubricated parts, cylinder block, cylinder heads,
electrical fuel pump, powertrain control module, engine mounts,
flywheel, injection pump, manifold (exhaust and intake), manifold bolts,
oil pan, oil pump, seals and gaskets, engine thermostat, engine
thermostat housing, timing chain cover, timing chain (gears or belt),
turbocharger/supercharger unit, valve covers, water pump;
Transmission: all internal parts, clutch cover, seals and gaskets, torque
converter, transfer case (including all internal parts), transmission case,
transmission mounts; single-speed gearbox (for The Focus Electric);
Front-Wheel Drive: axle shafts, front bearings seals and gaskets,
universal and constant velocity joints; Rear-Wheel Drive:axle shafts,
bearings (front and rear), center support bearing, drive axle housing
(including all internal parts), drive shaft, retainers, supports, seals and
gaskets, universal and constant velocity joints. Four-wheel/All-Wheel
Drive: axle shafts, bearings (front and rear), center support bearing,
drive shafts, final drive housing (including all internal parts),
hubs-automatic front locking (four-wheel drive), locking rings
(four-wheel drive), seals and gaskets, universal and constant velocity
joints.
(2) Your vehicle’s safety belts and air bag Supplemental Restraint System
(SRS) are covered for an extended Safety Restraint Coverage Period,
which lasts for five years or 60,000 miles, whichever occurs first.
10

(3) Your vehicle’s body sheet metal panels are covered for an extended
Corrosion Coverage Period, which lasts for five years, regardless of miles
driven. The extended warranty coverage only applies if a body sheet
metal panel becomes perforated due to corrosion during normal use due
to a manufacturing defect in factory-supplied materials or factory
workmanship. If aluminum body panels have corrosion or rust damage,
and the damage is not the result of abnormal usage, vehicle accident,
customer actions and/or extreme environmental conditions, the corrosion
or rust damage repairs are covered for 5 years, unlimited miles. For
damage caused by airborne material (environmental fallout) where there
is no factory-related defect involved and therefore no warranty our
policy is to provide free repair of paint damage due to the airborne
material for 12 months or 12,000 miles, whichever occurs first.
(4)
Your vehicle’s unique hybrid / electric components are covered during
the Hybrid / Electric Unique Component Coverage, which lasts for eight
years or 100,000 miles, whichever occurs first.
•The following hybrid parts are covered during this extended coverage
period: high-voltage battery, hybrid continuously variable transmission,
Inverter System Controller (ISC), DC/DC converter, high-voltage
battery connector, battery pack fan assembly, service disconnect,
charger fan, Battery Energy Control Module (BECM), and the PHEV
onboard charger.
• The following plug-in-vehicle unique parts (if equipped) are covered
during this extended coverage period: high-voltage battery packs,
high-voltage charger, DC/DC convertor, electronic drive module
assembly (includes electric motor and gearbox), transmission range
sensor.
Note: Lithium-Ion Battery Gradual Capacity Loss
The Lithium-ion battery (EV battery) will experience gradual
capacity loss with time and use (similar to all lithium-ion batteries),
which is considered normal wear and tear. Loss of battery capacity
due to or resulting from gradual capacity loss is NOT covered under
the New Vehicle Limited Warranty. See your Owner’s Manual for
important tips on how to maximize the life and capacity of the
Lithium-ion battery.
11

•Fuel Filler Door Sensor (Plug-in Hybrid vehicles only)
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• High Voltage Battery
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Inverter System Controller (Plug-in Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System
• Motor Electronics Coolant Pump (Plug-in Hybrid vehicles only)
• PCV System and Oil Filler Cap
• PHEV Onboard Charger
• Powertrain Control Module (PCM)/Engine Control Module (ECM)*
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in Hybrid vehicles only)
• Vacuum Distribution System
* Includes hardware and emission related software changes only
20

•Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in Hybrid vehicles only)
• Vacuum Distribution System
* Includes hardware and emission related software changes only
28

COVERAGE FOR 2018 MODEL VEHICLES (GVWR OF 14,000 LBS. OR LESS)UNDER LONG TERM DEFECTS WARRANTY
(Coverage for up to 7 years/70,000 miles, whichever first cccurs)
Part Name2.0L Fusion Hybrid
2.0L C-max Hybrid
Power Steering Wiring Assembly X
Catalytic Converter X X
Cam Timing Assembly X X
Variable Camshaft Timing Assembly X X
Transmission Range Sensor / Detent Assembly X
Exhaust Gasket X
Hybrid Powertrain Control Module X X
Inverter System Controller X X
Coolant Pump Motor X
Fuel Tank X X
Battery Energy Control Module X X
On-board Battery Charger (1) X
High Voltage Traction Battery X X
Instrument Cluster (3) X X
Powertrain Control Wiring Harness X
Powertrain Control Module (PCM)/Electronic Engine Control Unit (ECU) X X
Main Body Wiring Harness (4) X X
Battery Cable (4) X
Main Wiring Assembly (4) X X
Fuel Sender Wiring Assembly (4) X
Main Jumper Wiring Assembly (4) X X
Electric Coolant Heater Assembly (4) X X
(1) for Plug-in Hybrid vehicles only
(2) for Full Hybrids Only
(3)
for Service Engine Soon/Malfunction Indicator Lamp (MIL) functionality concerns only
(4) for MIL illumination only
29