maintenance FORD SUPER DUTY 2003 1.G Diesel Supplement Manual

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual SUPER DUTY 2003 1.G FORD FORD https://www.carmanualsonline.info/img/11/5257/w960_5257-0.png FORD SUPER DUTY 2003 1.G Diesel Supplement Manual

Page 1 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual Introduction
2
Diesel information
4
Warning lights
8
Starting
10
Driving tips
13
General maintenance information
23
Scheduled maintenance
38
Minor troubleshooting guide
39
Capacities and specification

Page 3 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual IMPORTANT NOTICE
Ford vehicles are suitable for producing ambulances only if equipped
with theFord Ambulance Preparation Package.In addition, Ford
urges ambulance manufacturers to follow the recommend

Page 4 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual DIESEL ENGINE INFORMATION
The Diesel engine fuel system consists of:
•an engine-mounted secondary fuel filter
•frame-mounted Horizontal Fuel Conditioner Module (HFCM)
•a unit injector for each c

Page 6 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual Air filter restriction gauge
The restriction gauge, located on
the upper housing of the air cleaner
assembly, monitors the condition of
the air filter element in two ways:
First, the colored indictor

Page 8 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual WAIT TO START
With the key in the ON position, the
WAIT TO START light will illuminate
if glow plug heat is necessary as a starting aid. Wait until the light goes
off before starting. The light should

Page 11 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual 5. After the engine starts, allow it to idle for about 15 seconds. (Do not
increase engine speed until the oil pressure gauge indicates normal
pressure.)
STOPPING THE ENGINE
Turn the ignition to OFF.

Page 23 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual SCHEDULED MAINTENANCE
The scheduled maintenance services in theScheduled maintenance
guidesection are required because they are considered essential to the
life and performance of your vehicle.
Use on

Page 24 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual FUEL REQUIREMENTS
The engine is designed to use low sulfur number 1–Dor2–D Diesel fuel
only. At temperatures below -7°C (20°F), number 1–D or winter blend
number 2–D fuel is recommended. (Se

Page 25 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual Diesel fuel must not be stored in a galvanized container. The fuel will
dissolve the zinc in a galvanized container. The zinc will then remain in
solution until it is run through the engine where it w

Page 26 of 64

FORD SUPER DUTY 2003 1.G Diesel Supplement Manual 2. Locate the HFCM and place an
appropriate container under the
drain plug (see illustration).
3. Remove the drain plug, using a 6mm hex drive, by turning it
counterclockwise. Allow the HFCM to drain
Page:   1-10 11-20 21-30 next >