belt GMC SIERRA 2016 Repair Manual

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Vehicle Care 451
Caution
Do not attach a device with a
suction cup to the display. This
may cause damage and would
not be covered by the vehicle
warranty.
Instrument Panel, Leather,
Vinyl, Other Plastic Surfaces,
Low Gloss Paint Surfaces and
Natural Open Pore Wood
Surfaces
Use a soft microfiber cloth
dampened with water to remove
dust and loose dirt. For a more
thorough cleaning, use a soft
microfiber cloth dampened with a
mild soap solution.
Caution
Soaking or saturating leather,
especially perforated leather, as
well as other interior surfaces,
may cause permanent damage.(Continued)
Caution (Continued)
Wipe excess moisture from these
surfaces after cleaning and allow
them to dry naturally. Never use
heat, steam, or spot removers. Do
not use cleaners that contain
silicone or wax-based products.
Cleaners containing these
solvents can permanently change
the appearance and feel of
leather or soft trim, and are not
recommended.
Do not use cleaners that increase
gloss, especially on the instrument
panel. Reflected glare can decrease
visibility through the windshield
under certain conditions.
Caution
Use of air fresheners may cause
permanent damage to plastics
and painted surfaces. If an air
freshener comes in contact with
any plastic or painted surface in (Continued)
Caution (Continued)
the vehicle, blot immediately and
clean with a soft cloth dampened
with a mild soap solution.
Damage caused by air fresheners
would not be covered by the
vehicle warranty.
Care of Safety Belts
Keep belts clean and dry.
{Warning
Do not bleach or dye safety belt
webbing. It may severely weaken
the webbing. In a crash, they
might not be able to provide
adequate protection. Clean and
rinse safety belt webbing only
with mild soap and lukewarm
water. Allow the webbing to dry.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Service and Maintenance 457
Maintenance Schedule
Additional Required
Services - Normal12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi
60 000 km/37,500 mi
72 000 km/45,000 mi
84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi
120 000 km/75,000 mi
132 000 km/82,500 mi
144 000 km/90,000 mi
156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi
204 000 km/127,500 mi
216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Rotate tires and perform Required Services.
Check engine oil level and oil life percentage.
Change engine oil and filter, if needed.@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace passenger compartment air filter. (1)@ @@@@@
Inspect evaporative control system. (2)@ @@
Replace engine air cleaner filter. (3)@@@
Replace spark plugs. Inspect spark plug wires.@
For GVW under 8600 lbs, change transfer case
fluid, if equipped with 4WD. (4)@
For GVW over 8600 lbs, change transfer case
fluid, if equipped with 4WD. (4)@@@
Drain and fill engine cooling system. (5)@
Visually inspect accessory drive belts. (6)@
Replace brake fluid. (7)
Footnotes—Maintenance
Schedule Additional Required
Services —Normal
(1) Or every two years, whichever
comes first. More frequent
replacement may be needed if the
vehicle is driven in areas with heavy traffic, poor air quality, areas with
high dust levels or are sensitive to
environmental allergens. Filter
replacement may also be needed if
you notice reduced airflow, windows
fogging up, or odors. Your local GM
Service location can help you
determine when it is the right time to
replace your filter.
(2)
Check all fuel and vapor lines
and hoses for proper hook-up,
routing, and condition.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Service and Maintenance 459
Maintenance Schedule
Additional Required
Services - Severe12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi
60 000 km/37,500 mi
72 000 km/45,000 mi
84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi
120 000 km/75,000 mi
132 000 km/82,500 mi
144 000 km/90,000 mi
156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi
204 000 km/127,500 mi
216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Rotate tires and perform Required Services.
Check engine oil level and oil life percentage.
Change engine oil and filter, if needed.@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace passenger compartment air filter. (1)@ @@@@@
Inspect evaporative control system. (2)@ @@
Replace engine air cleaner filter. (3)@@@
Replace spark plugs. Inspect spark plug wires.@
Change automatic transmission fluid and filter.@@@
For GVW under 8600 lbs, change transfer case
fluid, if equipped with 4WD. (4)@@@
For GVW over 8600 lbs, change transfer case
fluid, if equipped with 4WD. (4)@@@@@@
Drain and fill engine cooling system. (5)@
Visually inspect accessory drive belts. (6)@
Replace brake fluid. (7)
Footnotes—Maintenance
Schedule Additional Required
Services —Severe
(1) Or every two years, whichever
comes first. More frequent
replacement may be needed if the vehicle is driven in areas with heavy
traffic, poor air quality, areas with
high dust levels or are sensitive to
environmental allergens. Filter
replacement may also be needed if
you notice reduced airflow, windows
fogging up, or odors. Your local GMService location can help you
determine when it is the right time to
replace your filter.
(2)
Check all fuel and vapor lines
and hoses for proper hook-up,
routing, and condition.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Service and Maintenance 461
.To avoid break-down or failure to
start the vehicle, maintain a
battery with full cranking power.
. Trained dealer technicians have
the diagnostic equipment to test
the battery and ensure that the
connections and cables are
corrosion-free.
Belts
. Belts may need replacing if they
squeak or show signs of
cracking or splitting.
. Trained dealer technicians have
access to tools and equipment
to inspect the belts and
recommend adjustment or
replacement when necessary.
Brakes
Brakes stop the vehicle and are
crucial to safe driving.
. Signs of brake wear may include
chirping, grinding, or squealing
noises, or difficulty stopping. .
Trained dealer technicians have
access to tools and equipment
to inspect the brakes and
recommend quality parts
engineered for the vehicle.
Fluids
Proper fluid levels and approved
fluids protect the vehicle’s systems
and components. See
Recommended Fluids and
Lubricants 0463 for GM approved
fluids.
. Engine oil and windshield
washer fluid levels should be
checked at every fuel fill.
. Instrument cluster lights may
come on to indicate that fluids
may be low and need to be
filled.
Hoses
Hoses transport fluids and should
be regularly inspected to ensure
that there are no cracks or leaks.
With a multi-point inspection, your
dealer can inspect the hoses and
advise if replacement is needed. Lamps
Properly working headlamps,
taillamps, and brake lamps are
important to see and be seen on
the road.
.
Signs that the headlamps need
attention include dimming, failure
to light, cracking, or damage.
The brake lamps need to be
checked periodically to ensure
that they light when braking.
. With a multi-point inspection,
your dealer can check the lamps
and note any concerns.
Shocks and Struts
Shocks and struts help aid in control
for a smoother ride.
. Signs of wear may include
steering wheel vibration, bounce/
sway while braking, longer
stopping distance, or uneven
tire wear.
. As part of the multi-point
inspection, trained dealer
technicians can visually inspect
the shocks and struts for signs

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Technical Data 467
Technical Data
Vehicle Identification
Vehicle IdentificationNumber (VIN) . . . . . . . . . . . . . . . 467
Service Parts Identification Label . . . . . . . . . . . . . . . . . . . . . . . . 467
Vehicle Data
Capacities andSpecifications . . . . . . . . . . . . . . . 468
Engine Drive Belt Routing . . . . 471
Vehicle Identification
Vehicle Identification
Number (VIN)
This legal identifier is in the front
corner of the instrument panel, on
the left side of the vehicle. It can be
seen through the windshield from
outside. The VIN also appears on
the Vehicle Certification and Service
Parts labels and certificates of title
and registration.
Engine Identification
The eighth character in the VIN is
the engine code. This code
identifies the vehicle's engine,
specifications, and replacement
parts. See “Engine Specifications”
under Capacities and Specifications
0 468 for the vehicle's engine code.
Service Parts
Identification Label
This label, on the inside of the glove
box, has the following information:
.
Vehicle Identification
Number (VIN).
. Model designation.
. Paint information.
. Production options and special
equipment.
Do not remove this label from the
vehicle.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Technical Data 471
Engine Drive Belt Routing
V6 Engines
5.3L and 6.2L V8 Engines
6.0L V8 Engines
If the vehicle has a diesel engine,
see the Duramax diesel
supplement.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
484 Customer Information
Vehicle Data
Recording and
Privacy
The vehicle has a number of
computers that record information
about the vehicle’s performance and
how it is driven. For example, the
vehicle uses computer modules to
monitor and control engine and
transmission performance, to
monitor the conditions for airbag
deployment and deploy them in a
crash, and, if equipped, to provide
antilock braking to help the driver
control the vehicle. These modules
may store data to help the dealer
technician service the vehicle.
Some modules may also store data
about how the vehicle is operated,
such as rate of fuel consumption or
average speed. These modules may
retain personal preferences, such as
radio presets, seat positions, and
temperature settings.
Event Data Recorders
This vehicle is equipped with an
event data recorder (EDR). The
main purpose of an EDR is to
record, in certain crash or near
crash-like situations, such as an air
bag deployment or hitting a road
obstacle, data that will assist in
understanding how a vehicle’s
systems performed. The EDR is
designed to record data related to
vehicle dynamics and safety
systems for a short period of time,
typically 30 seconds or less. The
EDR in this vehicle is designed to
record such data as:
.How various systems in your
vehicle were operating;
. Whether or not the driver and
passenger safety belts were
buckled/fastened;
. How far (if at all) the driver was
depressing the accelerator and/
or brake pedal; and,
. How fast the vehicle was
traveling. These data can help provide a
better understanding of the
circumstances in which crashes and
injuries occur.
Note
EDR data are recorded by your
vehicle only if a non-trivial crash
situation occurs; no data are
recorded by the EDR under normal
driving conditions and no personal
data (e.g., name, gender, age, and
crash location) are recorded.
However, other parties, such as law
enforcement, could combine the
EDR data with the type of
personally identifying data routinely
acquired during a crash
investigation.
To read data recorded by an EDR,
special equipment is required, and
access to the vehicle or the EDR is
needed. In addition to the vehicle
manufacturer, other parties, such as
law enforcement, that have the
special equipment, can read the
information if they have access to
the vehicle or the EDR.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Index 499
D
Damage Repair, Collision . . . . . . . 479
Danger, Warning, and Caution . . . . 3
Data Recorders, Event . . . . . . . . . 484
Daytime RunningLamps (DRL) . . . . . . . . . . . . . . . . . . 177
Defensive Driving . . . . . . . . . . . . . . . 258
Delayed Locking . . . . . . . . . . . . . . . . . 39
Diagnostics OnStar
®. . . . . . . . . . . . . . . . . . . . . . 490
Distracted Driving . . . . . . . . . . . . . . . 257
Dome Lamps . . . . . . . . . . . . . . . . . . . 181
Door Ajar Messages . . . . . . . . . . . . . . . 154
Delayed Locking . . . . . . . . . . . . . . . . 39
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Power Locks . . . . . . . . . . . . . . . . . . . . 39
Drive Belt Routing, Engine . . . . . . 471
Driver Assistance Systems . . . . . 309
Driver Information Center (DIC) . . . . . . . . . . . . . 148, 150
Driving Assistance Systems . . . . . . . . . . 312
Characteristics andTowing Tips . . . . . . . . . . . . . . . . . 322
Defensive . . . . . . . . . . . . . . . . . . . . . 258
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 258
For Better Fuel Economy . . . . . . . 30 Driving (cont'd)
Hill and Mountain Roads . . . . . . 266
If the Vehicle is Stuck . . . . . . . . . 268
Loss of Control . . . . . . . . . . . . . . . 260
Off-Road . . . . . . . . . . . . . . . . . . . . . 261
Off-Road Recovery . . . . . . . . . . . 260
Vehicle Load Limits . . . . . . . . . . . 269
Wet Roads . . . . . . . . . . . . . . . . . . . 265
Winter . . . . . . . . . . . . . . . . . . . . . . . . 267
Dual Automatic Climate Control System . . . . . . . . . . . . . . . . 250
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 319
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 349
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 392
Fuses . . . . . . . . . . . . . . . . . . . . . . . . 392
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . 395, 397
Overload . . . . . . . . . . . . . . . . . . . . . 391
Emergency
OnStar
®. . . . . . . . . . . . . . . . . . . . . . 487
Engine Air Cleaner/Filter . . . . . . . . . . . . . 370
Check and Service EngineSoon Light . . . . . . . . . . . . . . . . . . 141 Engine (cont'd)
Compartment Overview . . . . . . . 358
Coolant . . . . . . . . . . . . . . . . . . . . . . . 373
Coolant Heater . . . . . . . . . . . . . . . 281
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . 135
Cooling System . . . . . . . . . . . . . . . 371
Cooling System Messages . . . 154
Drive Belt Routing . . . . . . . . . . . . 471
Exhaust . . . . . . . . . . . . . . . . . . . . . . 285
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 377
Oil Life System . . . . . . . . . . . . . . . 366
Oil Messages . . . . . . . . . . . . . . . . . 155
Oil Pressure Gauge . . . . . . . . . . 134
Overheated Protection Operating Mode . . . . . . . . . . . . . 377
Overheating . . . . . . . . . . . . . . . . . . 375
Power Messages . . . . . . . . . . . . . 155
Running While Parked . . . . . . . . 286
Starting . . . . . . . . . . . . . . . . . . . . . . . 279
Entry Lighting . . . . . . . . . . . . . . . . . . . 182
Equipment, Towing . . . . . . . . . . . . . 339
Event Data Recorders . . . . . . . . . . 484
Exit Lighting . . . . . . . . . . . . . . . . . . . . 182
Extender, Safety Belt . . . . . . . . . . . . 70
Exterior Lamp Controls . . . . . . . . . 174
Exterior Lamps Off Reminder . . . 176

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Index 501
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 388
Hazard Warning Flashers . . . . . . . 178
Head Restraints . . . . . . . . . . . . . . . . . 56
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 388
Automatic . . . . . . . . . . . . . . . . . . . . . 177
Bulb Replacement . . . . . . . . . . . . 388
Daytime RunningLamps (DRL) . . . . . . . . . . . . . . . . 177
Flash-to-Pass . . . . . . . . . . . . . . . . . 177
High Intensity Discharge (HID) Lighting . . . . . . . . . . . . . . . 388
High-Beam On Light . . . . . . . . . . 147
High/Low Beam Changer . . . . . 176
Lamps On Reminder . . . . . . . . . 147
Heated Steering Wheel . . . . . . . . . . . . . . . 123
Heated and Ventilated Front
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Heated Mirrors . . . . . . . . . . . . . . . . . . . 48
Heater Engine Coolant . . . . . . . . . . . . . . . 281
Heating and Air
Conditioning . . . . . . . . . . . . . . 246, 248
High Voltage Devices and Wiring . . . . . . . . . . . . . . . . . . . . . . . . . 391
High-Beam On Light . . . . . . . . . . . . 147 High-Speed Operation . . . . . . . . . . 409
Hill and Mountain Roads . . . . . . . . 266
Hill Descent Control (HDC) . . . . . 305
Hill Descent Control Light . . . . . . . 144
Hill Start Assist (HSA) . . . . . . . . . . 302
Home Page . . . . . . . . . . . . . . . . 190, 192
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 357
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
How to Wear Safety Belts
Properly . . . . . . . . . . . . . . . . . . . . . . . . 66
I
Idle SystemFast . . . . . . . . . . . . . . . . . . . . . . . . . . 280
Ignition Positions . . . . . . . . . . . . . . . 278
Ignition Transmission Lock Check . . . . . . . . . . . . . . . . . . . . . . . . . 387
Immobilizer . . . . . . . . . . . . . . . . . . . . . . 44
Indicator Vehicle Ahead . . . . . . . . . . . . . . . . 145
Infants and Young Children,
Restraints . . . . . . . . . . . . . . . . . . . . . . 88
Infotainment . . . . . . . . . . . . . . . . . . . . 185
Infotainment System . . . . . . . . . . . . 485
Instrument Cluster . . . . . . . . . . . . . . 130
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . .117
Interior Rearview Mirrors . . . . . . . . . 49 Internet Radio
Pandora . . . . . . . . . . . . . . . . . . . . . . 199
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jack Auxiliary . . . . . . . . . . . . . . . . . . . . . . 209
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 434
K
Key and Lock Messages . . . . . . . . 156
Keyless EntryRemote (RKE) System . . . . . . . . . 35
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
L
Labeling, Tire Sidewall . . . . . . . . . . 401
Lamps Auxiliary RoofMounted Lamp . . . . . . . . . . . . . . 180
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . 181
Daytime Running (DRL) . . . . . . 177
Dome . . . . . . . . . . . . . . . . . . . . . . . . . 181
Exterior Controls . . . . . . . . . . . . . . 174
Exterior Lamps Off Reminder . . . . . . . . . . . . . . . . . . . 176
Malfunction Indicator . . . . . . . . . 141
Messages . . . . . . . . . . . . . . . . . . . . 156
On Reminder . . . . . . . . . . . . . . . . . 147

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
502 Index
Lamps (cont'd)Reading . . . . . . . . . . . . . . . . . . . . . . 181
Lane Departure Warning (LDW) . . . . . . . . . . . . . . . . 314
Lane Departure Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . . 144
Lane Keep Assist (LKA) . . . . . . . . 315
Lane Keep Assist Light . . . . . . . . . 144
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . . 70
Lap-Shoulder Belt . . . . . . . . . . . . . . . 66
LATCH System Replacing Parts after aCrash . . . . . . . . . . . . . . . . . . . . . . . 104
LATCH, Lower Anchors and
Tethers for Children . . . . . . . . . . . . 94
LED Lighting . . . . . . . . . . . . . . . . . . . . 389
Light Hill Decent Control . . . . . . . . . . . 144
Lighting Entry . . . . . . . . . . . . . . . . . . . . . . . . . 182
Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Illumination Control . . . . . . . . . . . 180
LED . . . . . . . . . . . . . . . . . . . . . . . . . . 389
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . 144 Airbag On-Off . . . . . . . . . . . . . . . . . 138
Airbag Readiness . . . . . . . . . . . . . 137
Antilock Brake System(ABS) Warning . . . . . . . . . . . . . . 143 Lights (cont'd)
Brake System Warning . . . . . . . 142
Charging System . . . . . . . . . . . . . 140
Cruise Control . . . . . . . . . . . . . . . . 148
Flash-to-Pass . . . . . . . . . . . . . . . . . 177
Four-Wheel-Drive . . . . . . . . . . . . . 143
Front Fog Lamp . . . . . . . . . . . . . . 147
High-Beam On . . . . . . . . . . . . . . . . 147
High/Low Beam Changer . . . . . 176
Lane Departure Warning . . . . . . 144
Low Fuel Warning . . . . . . . . . . . . 146
Safety Belt Reminders . . . . . . . . 137
Security . . . . . . . . . . . . . . . . . . . . . . 147
StabiliTrak
®OFF . . . . . . . . . . . . . 145
Tire Pressure . . . . . . . . . . . . . . . . . 146
Tow/Haul Mode . . . . . . . . . . . . . . . 144
Traction Control System (TCS)/StabiliTrak
®. . . . . . . . . . 146
Traction Off . . . . . . . . . . . . . . . . . . . 145
Locking Rear Axle . . . . . . . . . . . . . . 305
Locks Automatic Door . . . . . . . . . . . . . . . . . 39
Delayed Locking . . . . . . . . . . . . . . . . 39
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Lockout Protection . . . . . . . . . . . . . . 40
Power Door . . . . . . . . . . . . . . . . . . . . . 39
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Loss of Control . . . . . . . . . . . . . . . . . 260 Low Fuel Warning Light . . . . . . . . . 146
Low-Profile Tires . . . . . . . . . . . . . . . . 401
Lower Anchors and Tethers
for Children (LATCH
System) . . . . . . . . . . . . . . . . . . . . . . . . 94
Lumbar Adjustment . . . . . . . . . . . . . . 58 Front Seats . . . . . . . . . . . . . . . . . . . . . 58
M
Maintenance
Records . . . . . . . . . . . . . . . . . . . . . . 466
Maintenance and Care
Additional . . . . . . . . . . . . . . . . . . . . . 460
Maintenance Schedule . . . . . . . . . 454 Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 463
Transfer Case . . . . . . . . . . . . . . . . 293
Malfunction Indicator Lamp . . . . . 141
Manual Mode . . . . . . . . . . . . . . . . . . . 289
Memory Features . . . . . . . . . . . . . . . . 13
Memory Seats . . . . . . . . . . . . . . . . . . . 60
Messages Airbag System . . . . . . . . . . . . . . . . 158
Battery Voltage andCharging . . . . . . . . . . . . . . . . . . . . 153
Brake System . . . . . . . . . . . . . . . . 154
Compass . . . . . . . . . . . . . . . . . . . . . 154
Door Ajar . . . . . . . . . . . . . . . . . . . . . 154
Engine Cooling System . . . . . . . 154