Hood HONDA CIVIC 1999 6.G Workshop Manual

\
Hatchback
FUSEs2 IltOn||.gTO? LT1laSBe PowerDbtribution,page 1G13.
S€e Powor
BRAKE SWITCHClos€d with brakepedal depressed.PHOTO 6A
UNDER.HOODFUSE/RELAYBOX
**TT**TI
BRAKE SWITCH I-I-TClosed w{h brake | | |
ffid"o'""""0 tld
*-."11
rr.l
.l I
ll-r I
*"*rtrl
"""^,"rf,
\,,r=Male-Female
termanals reversedlor '99-'00 models
c607
c60s
vtEw I
HIGH MOUNTBRAKE LIGHT
c608
@
".i.I
>-ra
BLK
2
BLK
\
+ g?o'1"'
110-17

Dash and Console Lights
!'-I- ---1UNDER-HooD
| / FUSE '18 | FUSETRELAY| ) xeroucrr lBox
I t.* | Pl1o to .
L-L---J9 Y C3s2wHr I etoroa See power
arr- Distribution.
wnr I - PagelGl2
86 l,COMBINATIONI r---F--'t Head qhr I LtcHT
| | lswrtch- l"syllgl| | HEADa )OFF r .:::::.'| | "'oo)-o" ; 1,;;7-a"'
I L---95-.t IL----g--------JB1 Y , sEcuRtw SYSTEM".oo"l [_ _______---j coNNEcroR (opT|oN)
;f nED/ca 3 \f [email protected]*----FED/GRN II C4227 A PHofose vlEw 16-^---:-- --.l UNDER-DASH
I f;.*--,Tl 333J'"#1nn''"n"n iFiifiiiLA.vINSTAUXENTuGHTs ' PHoro 58t* . , 1
Vehicles pre-wiredfor accessorysecunry.sysrem
",o ".* ! i[o',,Bu' ".o ".* ! !;91o,u, poj;T;o6} coNNEcroR
O
"ro ".* !
"." Jlfr ;1+.,:.,,
"'o "'*
|
"'o ".."
|
"'o "'.*
|
"'"'"''*
| F$S^ff".t-;t;'t
['jl' ,, | "'-'x----lgr- -:'-l:t:!y!-
*,,,""::,:";illttS,iii',""0","'=ss.oomode's I if----tg;-;'"t1*-:.1ll r I I Poshior !! Indicrtor !it HErren t neAren I l.*. 94!r$f.._ ltndtcErol ll circu! . .l!
I ;ffiF' I ;ffiF' n=uu, ! i9d#"iufftl*;1#ff"'"I :l:-i!"' oo f ';dio-'" PU'H ll
r-z-----',-.--j";."..J:lqtT I il ! !i8noHt"
iI _:: i
-7-----1 r-4(.-1 neo l----1
,.-1.-E !!A ilfr. !
JL-r--J
.i:i9:'::i Bnl,r'i @ ^.i i @,o,1
"'"*
| @^.,l
-____ffi-:s;J
,LjrY##Y_i
$ffi_l
-l
i"l
i
ilffl
1l-
I l\Y','! ! \7(i , A "o.u "t'A3Y ' E1l"f I
114

Power Door Locks
- All Models Without Keyless Entry
G551
[t.dE-l=
- ---- --:[
l'!fi:i- ".",.1
l'! l-------- r I
li I I
*"I!'k------#-r*.*rq;,pft?is,,,flr::fi
| : I I c"u,',", i c"",o"" i 21 i cs03 security'
I i"x[v*fl
i$k------+-----=#f;ffi svseni
I i t I ou*."jJ*"'l '** '"*J"l ^,,**0, #'#[""j,% i
I i ! I &H'E5o I ,ig^* d$n* |
.e&.s8usA usA ; 'o'"rto it,Ii
lrr!
-"ll'**n*ru;X,*#",XHm,
i
lil I
| :.--!---i
| .L-J iiriioflil", iffffliii F$fl,H"- itJ !F$$,i$", iI l-T;1-li"3g5"= iioriibl-r'-" 1 iffi !
I lunr.ocx I rccK IswrrcH : Lunl----i L!flJI l"'*^1 *-l- - i sreREo RADro srEREo RADro
t --t , ,--- ",r*- :
UNDER.HOODFUSE/RELAYBOXi--r?Grs;-'ir oooF Locx I
L__{g:":l9 Y C3sl
'n',o"n I iE?Loo'
I see PowerIl Distribution.I ^r^a llr-i,
"*,:TI
Bdt6rynpur
Unlock LockGround input input
130
'='99-'00 models

rl
lt,
I vevneo
I veuneo.1I YEUFED
UNDER-HOODFUSE/RELAYBOXi-iffiri
""',;Xftf*',I.'
c557
vtEw 62
c654
FRONT
;l
I
see Power iDistribution. I**t"t:.""."
I
------*-,7
OE
n"r,n"n I
il.",":['
".,"-fifiT""' I
-:iii[::f
PASSENGER'SDOOR LOCKACTUATOR
c554
c557
. VIEW 62
cs56
vtEw61WHT/REO
POWERDOORLOCKCONTROLUNIT
GRN/OBN
tu
GFI{/OBN:
GRN/OFN
ALUAViIT
DOORKEY
4
BLUAVHT
c556PHOfO93vtEw 61
BLU/NED
c634
92YEURED
DRIVER'SDOORLOCKACTUATORDOORLOCKKNOB
DRIVER'SDOOR LOCKswlTcH
WHT/FED
1
I
BLK
22
BLK
I-
c556
vtEw61BLK
YEUFEO=__- , YEUFEO
c5zo : sPHO|O 99 ,VIEW 5 - YEUFEO
C674 ' 1PHO|O95
PHOTO 95 I WHI/REO
C674PHOTO9sI WHT/FEDc570PHOTO ggvtEw 5 . _ryHi/!E9
ACTUATOR .-.:PHO|O 95FED
c664 2PHA|A9S wxf/FED
c571 2
VIEW6 WHT/BEO
Driver'sdoor Batt€ryunlock input input
Unlock Lockanput input
Unlock/loc*ouIpur
Ground
Unlock/lockLock outputinput
[-:I
l_l
t fl!@Klocx
eLxlrat-{ 3'i#i:T:'
!- cssr
Il r
S€s Ground
130-3

Power Door Locks (cont'd)
Keyless Receiver Unit Input Test
The following tests are pertormed with A (Main) and B (Keyless) disconnected from the audio unit.
TerminalNo.WireColorTest ConditlonTest: Desired RasultPossible Cause it resull is not obtained
4WHT/BLUUnder all conditionsCheck for vollage to ground:
There should bs batteryvoltage.
aBlown No. 47 (7.5A) tuse in the
under-hood fuss/relay box
An open in the wireo
5YEUREDlgnition switch ACC (l)Check lor voltage to ground:
Th€re should be battery
voltage.
aBlown No. 28 (10A) fuse in the
underdash fusg/relay box
An open in the wirea
TerminalNo.WireColorTest CondiiionTest: Desired ResultPossible Cause if rssult i3 not obtalned
BLU/RED
lgnition key insertedinto the ignition key
switch
Check for voltage to ground:
There should bs 1 V or less.aPoor ground (G401, G402)
Faulty ignition key switch
An open in the wire
Short in the wire
a
a
algnition key r€moved
trom the ignition key
switch
Check lor voltage to ground:
There should be 4 V or more.
3BLUI/ELUnder all conditions
Check for continuity betweenthe audio unit 16P connectorNo- 3 terminal and power doorlock control unit 12P connsctorNo. 6 terminal: There should
be continuity.
I An open in the wire
6BLK/YELlgnition switch ON (ll)Check for voltage to ground:
Thers should be batteryvollage.
. Blown No. 14 (7.5A) fuse in the
under-dash fuse/relay box
. An open in the wire
8LT GRN/BLKCeiljng light switch in"middle position"Connect to ground: The ceilinglight should come on.
aBlown No. 43 (7.5A) fuse in the
undsr-hood fuse/relay box
Blown ceiling light bulb
Faulty ceiling light
An open in the wire
a
a
o
14LT GRN/REDEach door oponed,one at a timeCheck for continuity to ground:
There should be continuity.
aFaulty door switch
An open in lhe wirea
tcBLKUnder all conditionsCheck for continuity to ground:
There should b€ continuity.
aPoor ground (G401, G402)
An open in the wirea
16GRYUnder all conditionsConn€ct to ground:
Horn should sound.
. Blown No.52 (15A) fuse in the
under-hood tuse/relay box
. Faulty horn
. Faulty horn relay
. An open in the wire
130-6

Power Door Locks (cont'd)
Keyless Entry Does Not Work In Any
Mode
NOTE: Before beginning, verify that all the
transmitters are programmed to the vehicle.
1 . Does the radio work properly?
Yes - Go to step 9.
No - Go to the neld step.
NOTE: For steos 2 - 8. refer to the schematic dia-
gram for the Stereo Sound System on page 150.
2. Are fuses 28 (in the under-dash fuse box) and
fuse 47 (in the under-hood fuse box) OK?
Yes - Go to step 4.
No - Replace the blown fuse, then go to the
nen steo.
3. Does the fuse blow again?
Yes - Locate and repair the short.
No- Retest the system.
4. ls the vehicle equipped with the optional security
system?
Yes - Go to the next steP.
No - Go to steD 6.
5. Does the keyless entry work correctly when the
security control unit connector is disconnected?
Yes - Faulty security system, go to security
system for f urther troubleshooting.
No - Go to the next step.
6. ls there battery voltage at terminal 4 of the radio
main harness connector (A)?
7.
=A
Yes - Go to the nen step.
No - Locate the open in the wiring between
tuse 47 and the radio.
ls there battery voltage at terminal 5 of the radio
main harness connector (A), when the ignition
switch is in the ACC (l) or ON (ll) position?
Yes - Go to the next step.
No - Locate the open in the wiring between
fuse 28 and the radio.
130-8
8. ls there continuity from terminal 14 of the radio
main harness connector (A) to ground?
Yes - Replace the radio.
No - Repair the open in the wiring between the
radio and the ground (G501).
9. Does the transmitter LED come on when any ot
the buttons are oressed?
Yes - Go to steo 12.
No - Go to the next steo.'10.ls the transmitter battery installed with the
positive side facing up?
Yes - Ensure that the battery contact tabs are
repositioned, then replace the battery.
Remove the key from the ignition, then
close the doors and trunk. Press the
LOCK button on the transmitter six times,
then go to the next step.
No - Ensure that the baftery contact tabs are
repositioned, then reinstall the batlery
correctly. Then reprogram the transmitter
and retest it. Use the procedure on page
1 30-4 f or transmitter programming.
11 . Does the transmitter LED come on when any of
the buttons are oressed?
Yes - Go to the next step.
No - Replace the transmitter and program it by
using the procedure on page 130-4.
12.Does the system work properly in all modes?
Yes - Finished. The system is OK.
No - Go to the next steD.

Power Door Locks (cont'd)
Keyless Door Lock Control Unit Input Test
The following tests are performed with the keyless door lock control unit connector disconnected.
TerminalNo.WireColorTest ConditionTest: Desir€d ResultPossible Cause if result ls not obtain€d
1LT GRN/BLKCeiling light switch in"middle position"Connect to ground: The ceilinglight should come on.
aBlown No. 43 (7.5A) luse in theunder-hood tuse/relay box
Blown ceiling light bulb
Faulty ceiling light
An open in the wire
o
a
a
3BLU/RED
lgnition key insertedinto the ignition keyswitch
Ch€ck lor voltage to ground:There should be I V or less.aPoor ground (G401, G402)
Faulty ignition key switch
An open in the wire
Short in the wire
a
a
o
lgnition key removedlrom the ignition keyswitch
Check for voltage to ground:There should be 4 V or more.
BLfiEtlgnition switch ON (ll)Check lor voltage to ground:
There should be batteryvoltage.
. Blown No. 14 (7.54) fuse in theunder-dash fuse/relay box
. An open in the wire
bREO/BLKHeadlight switch inPARK OT HEAD
Check for voltage to ground:
There should be batteryvoltage.
aBlown No. 32 (7.5A) luse in theunder-dash fuse/relay box
A faulty headlight switch
An open in the wire
a
o
LT GRN/RED
Each door opened,one at a timeCheck lor continuity to ground:
There should be continuitv.
oFaulty door switch
An open in the wireo
15GRYUnder all conditionsConnect to ground:
Horn should sound.
. Blown No. 52 (154) fuse in theunder-hood fuse/relay box
. Faulty horn
. Faulty horn relay
o An open in the wire
BLKUnder all conditionsCheck lor continuity to ground:
There should be continuity.
aPoor ground (G401 , G402)
An open in the wirea
130-16

Security System
- '96-'98 USA: HX, LX, EX; '96-'98 Canada: EX. Si
UNDER-HOODFUSE/RELAYBOX
t"'1,",*
,";;;i[ftT"fi'
'lffi;?'- 1
Dfstnoulon. fuO wnr I yEL
,-l_""__
UNDER.DASHFUSE/RELAYBOX
@@
.-"*luuu' ",-f
*'^'*'
,..1
f::T;J
I I
-Tl[3,*,,,*-"""
| |
%;1 l
FUSE 3
I I C5s1 !--Jt--JC423 (Not,i!r13 " u".al
_::;=ffi
HORNRELAY
PHA|O 129 (9A nodel)
{'96-97 models 3)
i'"---i[
il il
'98 model'96-97 models
I Horn Baitery tgnition I: control\
lgnition key II i*iiirr inilt eround IL------ -----J
- -l-s-f---- --------tiY
8LU FEo ll BLU aED I
;t,-
fon:*,
vlEw 21
8LU/FED
1
GAN
t'I
HORN
a-. =--
e.r,".o ll
, Ag::l^.aLu neo ll v,rwoo-'gr-u.neo sersarr R,I v,rw DU BLU/BEo See Seat BeltO -( and tgnition Keyeru neo ll Reminders
' + c4is
.,u*i,l( il,?l?.uo
r-{---- sTEERTNG;:E[t-:--.rsrEERrNG *.1
i l-flb'fitg"# i".e"er;;
-
|
ll-Ukevinisnition l I
:r:["_-----r
ilrff,i$t ! ilr,tlp:
lgnltion Ksy I LOCKSwftch I PHoro z1Closed with
c201
vlEw 30
133
J!@i---;""i ".*l
o"n"'o''
]t ____ __ __ _ _ _i__ _ _ _ _ _ I

V
- '98-'00 CX and DX Models (cont'd on page 133-10)
NOTE: Wires that look like this e=-* are part of the optional Security System harness installed
between lactory harness connectors.STEERINGLOCK
UNOER-HOODFUSE/RELAYBOX
HORNRELAY
PHOIO t35 ( 99 0o models)
;.;l
HOBN
c926OPTION
i-t
t -fii;r,'im:";
9"" cnv llConnectorHorns ll
PHO|O 62
sEcuRrwIN.LINEFUSEHOLDER
,"" l-l--';] L ii+ TBriE:,, ;.'".*"' ll
'Jl '' lL--l[JL---:-----------C
i. rl::t ;;;[.?jsor+3r i
lff],
-,
;,:"1.
- . :-
- -
;_:
- - -
tt*
I ii}"*:*'t--J'''*uo lc,o,na i Y#,iln,"o* i 9JlflB'],iff, iw,E"L:;; -'- ---J ---.l.--- -J------- Jrs y- - -i'. - -s-J[- - - -
l-
- ]sf
ll ; eLu ll ' BLU REo | | ".r,".o 2 gLu neo see seat
i 'fi i ".,".oii----iiiu
-
[tJ.li'fll5"t
i r{i y*sr.. : z!9X;2""|"i!'}?.""
ll i l/rlu'-'u"i
"i-jttz---'rsrEER,
Fii;i," ll ;i'".'J^ ,# i iQffi*"it*"ll : ll L--IF-----J*-
ll
' BLK
ll i
"'u*TI
"o,u
' 11 ' --- --;' Bett and
SWITCH ' BLU^YHr f i;;;i;" l{ -l-'- ' -';r{iss"-
STEERTNG
, r atv r- lt PHofo 60. - - - -. _8!K ll v/Ew '4
: G401
fl
-1[::_5J*nt
s Y c3s1
,n"r,".o I i[o"to,'
, tr ft?;","
liuF;lt"ls'rs?rl
iL:"::Ifui i'--T'Il,].----r
Itr
133-9

UNDER.HOODl t FUsE4s I FUSEiRELAY! xamucnr ! BoX
I I.A I PHoro 7
LJ,----Jc352
vtEw 27
Soe Pow€r Distdbulion,page 1&12,
Combination LightSwitch ConnectorE2
SeelndicatorsCOMBINATIONI I LIGHT SWITCH
| | v;iw; -
LIGHTFLASHERRELAY
4aLU or ALU/YEI
c503
iTFffiliBi+B,il:"'s#Ji"" I coNrRoL
i#$ iI input IL ----J3YBLU/BLK ll:aBrui 8rK ll
*,rlfr ftT-f.","
,^ftslllfl li^ir,, Ha,chback
vtEw 58
Coupa tndSedan
Combination LightSwitqh Connector
r = l\,lale - Femaletermrnals reversedlor'99-'00 models
See HeadlightSwiich,peg61(n.
EXTERIORLIGHTS
Seo GroundDistribution
"'u'"t*X
".u,"."aE,<
-*;"1
SeeTrunkLight
'9+ 97 models
aau,"a" fi
'*9#1",,,
BLU/BLKrf vEwe g8-,oo modets
l
qi*$qli-
TRUNKLATCHswrTcH
":^f se€ Ground
5--r< !#itl8".* I o"o'
or 14-11
.|- PHOIO ro2lorcoDr'99 oo sedan): PHofo 113
";-f "^'
FE
I-I-t HATCH LATCHI I I swtrcx
lljij::,:}#x""'*if
"tut
seecroundo tr e.* | Page 14-12'
+ 9131",,,
133-11