transmission HONDA S2000 2007 2.G User Guide

Check the f luid level with the
transmission at normal operating
temperature and the vehicle sitting
on level ground. Remove the
transmission f iller bolt, and caref ully
f eel inside the bolt hole with your
f inger. The f luid level should be up
to the edge of the bolt hole. If it is
not, add Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the hole. Install
the f iller bolt, and tighten it securely.If you are not sure how to check and
add f luid, contact your dealer. The transmission should be drained
and ref illed with new f luid according
to the intervals shown on the
inf ormation display. If Honda MTF is not available, you
may use an SAE 10W-30 or 10W-40
viscosity motor oil with the API
Certif ication seal that says ‘‘FOR
GASOLINE ENGINES’’ as a
temporary replacement. However,
motor oil does not contain the proper
additives, and continued use can
cause stiffer shifting. Replace as
soon as it is convenient. Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely.
Manual T ransmission Fluid
152
CORRECT LEVEL
FILLER BOLT

If you need to park your vehicle f or
an extended period (more than 1
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your vehicle back on the road. If
possible, store your vehicle indoors.Fill the f uel tank.
Change the engine oil and f ilter.
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc., are
completely dry.
Raise the convertible top cover.
Leave the parking brake off. Put
the transmission in reverse. Block the rear wheels.
If the vehicle is to be stored f or a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the vehicle is being stored
indoors).
Disconnect the battery.
Cover the vehicle with a
‘‘breathable’’ cover, one made
f rom a porous material such as
cotton. Non-porous materials, such
as plastic sheeting, trap moisture,
which can damage the paint.
Support the f ront wiper blade
arms with a f olded towel or rag so
they do not touch the windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and trunk seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and trunk seals. If possible, periodically run the
engine until it reaches f ull
operating temperature (the
cooling f an cycles on and of f
twice). Pref erably, do this once a
month.
Vehicle Storage
Maint enance
171

Thesizedifferencemayalsocause
damage to the rear dif f erential, so do
not mount the compact spare on the
rear. If either rear tire goes f lat,
remove the f ront tire on that same
side, mount the compact spare tire
on the f ront, then mount the f ront
tire on the rear.Park the vehicle on f irm, level, and
non-slippery ground. Put the
transmission in reverse. Apply the
parking brake.
Turn on the hazard warning lights,
and turn the ignition switch to the
LOCK (0) position. Have your
passenger get out of the vehicle
while you change the tire. Open the trunk. Lift up the tool
box lid, and take the jack, the
wheel nut wrench, and the
extension out of the tool box.
Thecompactsparetireissmaller
than a standard tire, which will affect
the vehicle’s handling. Drive
cautiously when this spare is
mounted on your vehicle. If you have a f lat tire while driving,
stop in a saf e place to change it.
Drive slowly along the shoulder until
you get to an exit or an area to stop
that is far away from the traffic lanes.
3.
1.
2.
CONT INUED
Changing a Flat Tire
T aking Care of t he Unexpect ed
175
TOOL BOX LID
JACK
The vehicle can easily roll off
the jack, seriously injuring
anyone underneath.
Follow the directions for
changing a tire exactly, and
never get under the vehicle
when it is supported only by the
jack. Use the jack that came with your
vehicle. If you try to raise another
vehicle with this jack or use another
jack to raise your vehicle, the vehicle or
jack can be damaged.

Diagnosing why the engine won’t
start falls into two areas, depending
on what you hear when you press
the ENGINE START button.
You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
faster than normal, but the engine
does not start up and run. When
you press the ENGINE
START button, you do not hear the
norm al noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Check these things:
Check the transmission interlock.
The clutch pedal must be pushed
all the way to the floor or the
starter will not operate.
Turn the ignition switch to the ON
(II) position. Turn on the
headlights, and check their
brightness. If the headlights are
very dim or do not come on at all,
the battery is discharged. See
on page . Press
the ENGI NE START button,
then release it. If the headlights do
not dim, check the condition of the
fuses.IfthefusesareOK,thereis
probably something wrong with
the electrical circuit for the
ignition switch or starter motor.
You will need a qualified mechanic
to determine the problem. (See
on page .)
182 196
Nothing Happens or the Starter
Motor Operates Very Slowly
Jump Starting Emergency T owing
If theEngineWon’tStart
180

´´
Although this seems like a simple
procedure, you should take several
precautions.
Open the hood, and check the
physical condition of the battery.
In very cold weather, check the
condition of the electrolyte. If it
seems slushy or f rozen, do not try
jump starting until it thaws.
To jump start your vehicle:
Connect one jumper cable to the
positive ( ) terminal on your
battery. Connect the other end to
the positive ( ) terminal on the
booster battery.
Turn of f all the electrical
accessories: heater, A/C, audio
system, lights, etc. Put the
transmission in neutral, and set
the parking brake. The numbers in the illustrations
show you the order to connect the
jumper cables.
3.
1.
2.
Jump Starting
182
A battery can explode if you do
not follow the correct procedure,
seriously injuring anyone
nearby.
Keep all sparks, open flames,
and smoking materials away
from the battery.
If a battery sits in extreme cold, the
electrolyte inside can f reeze.
Attempting to jump start with a f rozen
battery can cause it to rupture.

Look for any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you find a leak, it
must be repaired before you
continue driving (see
on page ).
If
the temperatu re gauge stays at
the red mark, turn off the engine.
If you do not see steam or spray,
leave the engine running, and
watch the temperature gauge. If
the high heat is due to overloading,
the engine should start to cool
down almost immediately. If it
does, wait until the temperature
gauge comes down to the midpoint,
th en continue driving.
If
you see steam and/or spray
coming from under the hood, turn
off the engine. Wait until you see
no more signs of steam or spray,
th en open the hood.
Safely
pull to the side of the road.
Put the transmission in neutral,
and set the parking brake. Turn
off the all accessories, and turn on
the hazard warning indicators.
If you don’t find an obvious leak,
check the coolant level in the
radiator reserve tank. Add coolant
if the level is below the MIN mark
(see on
page ).
2. 1.
3. 4.
5.
6.
149 196
Emergency
Towing
A dding Engine Coolant
If theEngineOverheats
184
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.

The transmission number is on a
label underneath the transmission. The engine number is stamped on
the f ront right corner of the engine
block, below the valve cover.
Identif ication Numbers
Technical Inf ormation
201
TRANSMISSION NUMBERENGINE NUMBER

Î
Î
´
µ
Î
Î
Specif ications
202
Dimensions
Engine WeightsCapacities
162.0 in (4,115 mm)
68.9 in (1,750 mm)
50.6 in (1,285 mm)
94.5 in (2,400 mm)
57.9 in (1,470 mm)
59.4 in (1,510 mm) 13.2 US gal (50)
132 cu-in (2,157 cm
)
11.1 : 1 1.72 US gal (6.5
)
2.01 US gal (7.6)
5.1 US qt (4.8
)
4.8 US qt (4.5)
5.9 US qt (5.6)
1.6 US qt (1.5)
1.7 US qt (1.6)
0.78 US qt (0.74
)
0.81 US qt (0.77)
2.6 US qt (2.5)
6.3 US qt (6.0)
3.43 x 3.57 in (87.0 x 90.7 mm)
Length
Width
Height
Wheelbase
Track
See the certification label attached
to the driver’s doorjamb.Water cooled 4-stroke DOHC
VTEC 4-cylinder gasoline engine
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Spark Plug Gap
0.04 in (1.1 mm)PK22PR-L11S PFR7G-11S
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity:
0.16 US gal (0.6
)
Excluding the oil remaining in the engine
Gross vehicle weight rating
(GVWR)
Fuel tank
Engine coolant
Engine oil
Manual
transmission
fluid
Differential
fluid
Windshield
washer
reservoir
Front
Rear
1:
2:
NGK :
DENSO : Change
Total
Change
Total
Change
Total
Change
Total
U.S. Vehicles
Canadian
Vehicles
0mm
0.1 mm
1
2
Including filter
Without filter

ÎÎÎ
Changing Oil
........................................
How to .147
......................................
When to .135
...
Charging System Indicator . 46, 186
............
Checklist, Bef ore Driving . 123
.....................................
Child Saf ety .29
..............................
Booster Seats .38
...................................
Child Seats .34
.....
Important Saf ety Reminders . 32
..........................
Larger Children .37
.......................
Risk with Airbags .30
.............................
Small Children .33
.......................................
Child Seats .34
.......................
Cleaning Seat Belts .160
.................................................
Clock .54
...................................
Clutch Fluid .154
........................
CO in the Exhaust .207
............
Cold Weather, Starting in . 124
......................
Compact Spare Tire .174
...............
Consumer Inf ormation . 212
.............
Controls, Instruments and . 43
..............................
Convertible Top .70
...............
Convertible Top Cover . 72
..
Lowering the Convertible Top . 70
................................
Maintenance .74
.....
Raising the Convertible Top . 73Coolant
........................................
Adding .149
....................................
Checking .114
.........................
Proper Solution .149
...................
Temperature Gauge . 53
Crankcase Emission Control ........................................
System .207
................
Cruise Control Indicator . 47
............
Cruise Control Operation . 106
......................................
Cup Holder .78
.............
Customer Service Of f ice . 212
...............
DANGER, Explanation of . iii
...................................
Dashboard . 3, 44
..............
Dashboard Lower Pocket . 80
................
Daytime Running Lights . 57
Daytime Running Lights .......................................
Indicator .48
.................................
Dead Battery .182
.........
Defects, Reporting Safety . 214
................
Def ogger, Rear Window . 59
................
Defrosting the Windows . 87
..........................
Dif f erential Fluid .153
....................................
Dimensions .202 ...............
Dimming the Headlights . 57
Dipstick ..................................
Engine Oil .113
..........................
Directional Signals .57
........
Disc Brake Wear Indicators . 128
.....................
Disposal of Used Oil .149
...................
Do Not Tow a Trailer . 131
Doors ..............
Locking and Unlocking . 63
.......................
Monitor Indicator .47
......................
Power Door Locks .63
........
DOT Tire Quality Grading . 204
Downshif ting, Manual .............................
Transmission .126
...........
Driver and Passenger Safety . 5
...........................................
Driving .121
....................................
Economy .114
........................
Driving Guidelines .122
..................
DustandPollenFilter . 161
..............................
Economy, Fuel .114
..................................
Emergencies .173
.............
Battery, Jump Starting . 182
...........
Brake System Indicator . 188
Index
D
E
II

CONT INUED
................
Changing a Flat Tire . 175
.....
Charging System Indicator . 186
..................
Checking the Fuses . 191
...
Closing the Convertible Top . 189
.........
Hazard Warning Flashers . 58
............................
Jump Starting .182
.....
Low Oil Pressure Indicator . 186
...
Malf unction Indicator Lamp . 187
..................
Overheated Engine . 183
.......................................
Towing .196
...........................
Emergency Brake .76
......................
Emergency Flashers .58
......................
Emergency Towing .196
............
Emergency Trunk Opener . 64
.......................
Emissions Controls .207
.............
Emissions Testing, State . 210
Engine ............
Adding Engine Coolant . 149
....
Coolant Temperature Gauge . 53
.........................
If It Won’t Start .180
Malf unction Indicator ................................
Lamp . 47, 187
.......................
Oil Lif e Indicator .136
........
Oil Pressure Indicator . 46, 186
..............
Oil, What Kind to Use . 146
...............................
Overheating .183 ............................
Specif ications .202
............................
Speed Limiter .126
...............................
Start Button .124
.......................................
Starting .124
......................
Ethanol in Gasoline .110
...
Evaporative Emission Controls . 207
...............................
Exhaust Fumes .41
Expectant Mothers, Use of Seat ........................................
Belts by .14
.....................................
Fan, Interior .85
...........................................
Features .83
....................
Filling the Fuel Tank . 111
Filters .........................
Dust and Pollen .161
...............................................
Oil .147
.............
Flashers, Hazard Warning . 58
...................
Flat Tire, Changing a . 175
Fluids ..........................................
Brake .154
.........................................
Clutch .154
..............
Manual Transmission . 152
..................
Windshield Washer . 151
..........................
Four-way Flashers .58 .................................................
Fuel .110
......................
Fill Door and Cap .111
...........................................
Gauge .52
.....................
Low Fuel Indicator .49
................
Octane Requirement . 110
...............................
Oxygenated .110
........................
Tank, Ref ueling .111
...............................
Fuel Economy .114
..............
Fuel Station Procedures . 111
.....................
Fuses, Checking the .191
...............
Gas Mileage, Improving . 114
.........................................
Gasoline .110
...........................................
Gauge .52
.....................
Low Fuel Indicator .49
................
Octane Requirement . 110
........................
Tank, Ref ueling .111
.............................................
Gauges .51
...
Engine Coolant Temperature . 53
...............................................
Fuel .52
Gearshif t Lever Positions ..............
Manual Transmission . 126
Index
F
G
INDEX
III