flat tire HYUNDAI I40 2014 Owner's Guide

Downloaded from www.Manualslib.com manuals search engine 769
Maintenance
4. Tire ply composition and material
The number of layers or plies of rub-
ber-coated fabric are in the tire. Tire
manufacturers also must indicate the
materials in the tire, which include
steel, nylon, polyester, and others.
The letter "R" means radial ply con-
struction; the letter "D" means diago-
nal or bias ply construction; and the
letter "B" means belted-bias ply con-
struction.
5. Maximum permissible inflationpressure
This number is the greatest amount
of air pressure that should be put in
the tire. Do not exceed the maximum
permissible inflation pressure. Refer
to the Tire and Loading Information
label for recommended inflation
pressure.
6. Maximum load rating
This number indicates the maximum
load in kilograms and pounds that
can be carried by the tire. When
replacing the tires on the vehicle,
always use a tire that has the same
load rating as the factory installed
tire.
7. Uniform tire quality grading
Quality grades can be found where
applicable on the tire sidewall
between tread shoulder and maxi-
mum section width.
For example:
TREADWEAR 200
TRACTION AA
TEMPERATURE A
Tread wear
The tread wear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specified govern-
ment test course. For example, a tire
graded 150 would wear one-and-a-
half times (1½) as well on the gov-
ernment course as a tire graded 100.
The relative performance of tires
depends upon the actual conditions
of their use, however, and may
depart significantly from the norm
because of variations in driving
habits, service practices and differ-
ences in road characteristics and cli-
mate.
These grades are molded on the
side-walls of passenger vehicle tires.
The tires available as standard or
optional equipment on your vehicles
may vary with respect to grade.WARNING - Tire age
Tires degrade over time, even
when they are not being used.
Regardless of the remaining
tread, it is recommended that
tires generally be replaced after
six (6) years of normal service.
Heat caused by hot climates or
frequent high loading condi-
tions can accelerate the aging
process. Failure to follow this
Warning can result in sudden
tire failure, which could lead to
a loss of control and an acci-
dent involving serious injury or
death.

Downloaded from www.Manualslib.com manuals search engine Maintenance
70
7
Traction - AA, A, B & C
The traction grades, from highest to
lowest, are AA, A, B and C. Those
grades represent the tires ability to
stop on wet pavement as measured
under controlled conditions on spec-
ified government test surfaces of
asphalt and concrete. A tire marked
C may have poor traction perform-
ance.
Temperature -A, B & C
The temperature grades are A (the
highest), B and C representing the
tire’s resistance to the generation of
heat and its ability to dissipate heat
when tested under controlled condi-
tions on a specified indoor laboratory
test wheel.
Sustained high temperature can
cause the material of the tire to
degenerate and reduce tire life, and
excessive temperature can lead to
sudden tire failure. Grades B and A
represent higher levels of perform-
ance on the laboratory test wheel
than the minimum required by the
law.
WARNING
The traction grade assigned to
this tire is based on straight-
ahead braking traction tests,
and does not include accelera-
tion, cornering, hydroplaning,
or peak traction characteristics.
WARNING - Tire
temperature
The temperature grade for this
tire is established for a tire that
is properly inflated and not
overloaded. Excessive speed,
underinflation, or excessive
loading, either separately or in
combination, can cause heat
build-up and possible sudden
tire failure. This can cause loss
of vehicle control and serious
injury or death.

Downloaded from www.Manualslib.com manuals search engine Maintenance
88
7
Headlight (HID type), position light
and dedicated lamp
If the light bulb does not operate, have
the vehicle checked by an authorized
HYUNDAI dealer.
✽ ✽ NOTICE
HID lamps have superior performance
vs. halogen bulbs. HID lamps are esti-
mated by the manufacturer to last twice
as long or longer than halogen bulbs
depending on their frequency of use.
They will probably require replacement
at some point in the life of the vehicle.
Cycling the headlamps on and off more
than typical use will shorten HID lamps
life. HID lamps do not fail in the same
manner as halogen incandescent lamps.
If a headlamp goes out after a period of
operation but will immediately relight
when the headlamp switch is cycled it is
likely the HID lamp needs to be
replaced. HID lighting components are
more complex than conventional halo-
gen bulbs thus have higher replacement
cost.
Headlight and front fog light aim-
ing (for Europe)
Headlight aiming
1. Inflate the tires to the specified pres-
sure and remove any loads from the
vehicle except the driver, spare tire,
and tools.
2. The vehicle should be placed on a flat floor.
3. Draw vertical lines (Vertical lines pass- ing through respective head lamp cen-
ters) and a horizontal line (Horizontal
line passing through center of head
lamps) on the screen.
4. With the head lamp and battery in nor- mal condition, aim the head lamps so
the brightest portion falls on the hori-
zontal and vertical lines.
WARNING - HID Headlight
low beam (if equipped)
Do not attempt to replace or
inspect the low beam (XENON bulb)
due to electric shock danger. If the
low beam (XENON bulb) is not
working, have your vehicle checked
by an authorized HYUNDAI Dealer.
OVF071050

Downloaded from www.Manualslib.com manuals search engine 789
Maintenance
5. To aim the low beam left or right, turnthe driver (1) clockwise or counter-
clockwise. To aim the low beam up or
down, turn the driver (2) clockwise or
counterclockwise.
To aim the high beam up or down, turnthe driver (3) clockwise or counter-
clockwise. AFLS type
1. Turn off the engine
2. Turn the light switch to the low beam
position.
3. Position the tires straight ahead with the steering wheel.
4. Turn on the engine.
5. Inflate the tires to the specified pres- sure and remove any loads from the
vehicle except the driver, spare tire,
and tools.
6. The vehicle should be placed on a flat floor.
7. Draw vertical lines (Vertical lines pass- ing through respective head lamp cen-
ters) and a horizontal line (Horizontal
line passing through center of head
lamps) on the screen.
8. With the head lamp and battery in nor- mal condition, aim the head lamps so
the brightest portion falls on the hori-
zontal and vertical lines.
9. To aim the low beam left or right, turn the driver (1) clockwise or counter-
clockwise. To aim the low beam up or
down, turn the driver (2) clockwise or
counterclockwise. To aim the high
beam up or down, turn the driver (3)
clockwise or counterclockwise.
Front fog light aiming
The front fog lamp can be aimed as the
same manner of the head lamps aiming.
With the front fog lamps and battery nor-
mal condition, aim the front fog lamps. To
aim the front fog lamp up or down, turn
the driver (1) clockwise or counterclock-
wise.
OVF071051

Downloaded from www.Manualslib.com manuals search engine Specifications & Consumer information
48
TIRES AND WHEELS
Item Tire size Wheel sizeInflation pressure bar (psi, kPa)
Wheel lug nut torque

Normal load Maximum load
Front Rear Front Rear
Full size tire 205/60R16 7.0J×16
2.3
(33, 230) 2.3
(33, 230) 2.3
(33, 230) 2.3
(33, 230)
9~11
(65~79, 88~107)
215/50R17
225/45R18 7.5Jx17
8.0Jx18
2.4
(35, 240) 2.4
(35, 240) 2.4
(35, 240) 2.4
(35, 240)
Compact
spare tire T125/80D16
T135/80D17 4.0Tx16
4.0Tx17
4.2
(60, 420) 4.2
(60, 420) 4.2
(60, 420) 4.2
(60, 420)
WEIGHT AND VOLUME
Item Gasoline 1.6LGasoline 2.0L Diesel 1.7L
Gross vehicle weight kg (lbs.)M/T 2030 (4475)
2050 (4519)2120 (4673)
A/T-2080 (4585)2150 (4739)
Luggage volume l(cu ft) Min. 553 (19.5)
Max. 1719 (60.7)
M/T : Manual transaxle
A/T : Automatic transaxle
Min. : Behind rear seat to upper edge of the seat back.
Max. : Behind front seat to roof.

Downloaded from www.Manualslib.com manuals search engine I3
Index
Emergency Stop Signal (ESS).....................................5-45
Hill-start assist control (HAC) ....................................5-45
Power brakes ...............................................................5-29
Vehicle stability management......................................5-44
Brakes/clutch fluid .........................................................7-48
Bulb replacement ...........................................................7-85
Bulb wattage ....................................................................8-3
Button start/stop, see engine start/stop button.................5-8
Camera (Rear view) .......................................................4-94
Capacities (Lubricants) ....................................................8-5
Care Exterior care ................................................................7-99
Interior care ...............................................................7-104
Tire care .......................................................................7\
-61
Cargo security screen...................................................4-147
Center console storage .................................................4-136
Central door lock switch................................................4-16
Certification label ............................................................8-8
Chains Tire chains ...................................................................5-70
Changing tires ..................................................................6-9
Checking tire inflation pressure.....................................7-63
Child restraint system ....................................................3-29 ISOFIX system ............................................................3-35 Seat belt .......................................................................3\
-30
Tether anchor system ...................................................3-33
Child-protector rear door lock .......................................4-19
Cigarette lighter ...........................................................4-140
Climate control air filter ......................................4-120, 131
Climate control air filter ................................................7-53
Clothes hanger .............................................................4-144
Combined instrument, see instrument cluster ...............4-48
Compact spare tire .........................................................6-14
Compact spare tire replacement ....................................7-66
Cool box.......................................................................4\
-137
Coolant ........................................................................\
...7-45
Cooling fluid, see engine coolant ..................................7-45
Crankcase emission control system .............................7-105
Cruise control system ....................................................5-48
Cup holder ...................................................................4-141\
Curtain air bag ...............................................................3-54
Dashboard illumination, see instrument panel illumination . ........................................................................\
......................4-49
Dashboard, see instrument cluster .................................4-48
Daytime running light..................................................4-102
Deadlocks.......................................................................4\
-18
Defogging (Windshield) ..............................................4-133
Defroster (Rear window) .............................................4-111
C
D

Downloaded from www.Manualslib.com manuals search engine I5
Index
Flat tire (with spare tire) ..................................................6-8Changing tires................................................................6-9
Compact spare tire .......................................................6-14
Jack and tools ................................................................6-8
Removing and storing the spare tire .............................6-9
Flat tire (with tire mobility kit) .....................................6-21
Floor mat anchor(s) .....................................................4-144
Fluid Brakes/clutch fluid ......................................................7-48
Washer fluid.................................................................7-49
Fog light (front) ...........................................................4-101
Fog light (rear) .............................................................4-101
Folding the rear seat ......................................................3-15
Front seat adjustment .......................................................3-5
Fuel filler lid ..................................................................4-32
Fuel filter .......................................................................7\
-50
Fuel gauge......................................................................4-\
51
Fuel requirements ............................................................1-2
Fuse switch ....................................................................7-73\
Fuses ........................................................................\
......7-71 Fuse switch ..................................................................7-73
Fuse/relay panel description ........................................7-75
Instrument panel fuse ..................................................7-72
Main fuse .....................................................................7-7\
4
Multi fuse ....................................................................7-74\
Gauge
Engine temperature gauge ...........................................4-50
Fuel gauge ...................................................................4-51
Glove box.....................................................................4-1\
36
Glove box lamp............................................................4-110
Hazard warning flasher..................................................4-95
Hazardous driving conditions ........................................5-65
Headlight (Headlamp) escort function ..........................4-96
Headlight (Headlamp) welcome function .....................4-96
Headlight bulb replacement ...........................................7-85
Headlight leveling device ............................................4-102
Headlight position..........................................................4-98
Headlight washer .........................................................4-107
Headrest(front) .................................................................3-8
Headrest(rear) ................................................................3-12
Heated steering wheel....................................................4-42
High - beam operation ...................................................4-99
Height adjustment ..........................................................3-20
Highway driving ............................................................5-67
Hill-start assist control (HAC).......................................5-45
Hood........................................................................\
.......4-30
Horn ........................................................................\
.......4-43
How to use this manual ...................................................1-2
H
GF

Downloaded from www.Manualslib.com manuals search engine I9
Index
Rear seat floor pocket ..................................................4-139
Rear view camera ..........................................................4-94
Recommended cold tire inflation pressures ..................7-61
Recommended lubricants and capacities .........................8-5Recommended SAE viscosity number ..........................8-7
Remote keyless entry .......................................................4-5
Replacement light bulb ..................................................7-85
Road warning ...................................................................6-2
Rocking the vehicle .......................................................5-65
Roof antenna ................................................................4-153
Room lamp...................................................................4-109\
Scheduled maintenance service .......................................7-9 Maintenance under severe usage conditions .....7-19,30,39
Normal maintenance schedule...........................7-10,21,32
Seat belt warning ...........................................................3-19
Seat belts ........................................................................\
3-18 Height adjustment........................................................3-20
Lap/shoulder belt .........................................................3-20
Pre-tensioner seat belt .................................................3-23
Seat belt warning .........................................................3-19
Seat warmer(front) .........................................................3-10
Seat warmer(rear) ..........................................................3-14
Seatback pocket .............................................................3-12 Seats ........................................................................\
.........3-2
Air ventilation seat ......................................................3-11
Armrest ........................................................................\
3-14
Folding the rear seat ....................................................3-15
Front seat adjustment...................................................\
..3-5
Headrest(front) ..............................................................3-8
Headrest(rear) ..............................................................3-12
Rear seat ......................................................................3-\
12
Seat warmer(front)....................................................\
...3-10
Seat warmer(rear) ........................................................3-14
Seatback pocket ...........................................................3-12
Shift lock system ...........................................................5-26
Side impact air bag ........................................................3-53
Smart cornering light .....................................................4-97
Smart key ........................................................................\
.4-9
Smooth cornering...........................................................5-66
Snow tires ......................................................................5-\
69
Smart parking assist system...........................................4-83
Spare tire Compact spare tire .......................................................6-14
Compact spare tire replacement ..................................7-66
Removing and storing the spare tire .............................6-9
Special driving conditions .............................................5-65 Driving at night ...........................................................5-66
Driving in flooded areas ..............................................5-67
Driving in the rain .......................................................5-67
S

Downloaded from www.Manualslib.com manuals search engine Index
10I
Hazardous driving conditions......................................5-65
Highway driving ..........................................................5-67
Rocking the vehicle .....................................................5-65
Smooth cornering ........................................................5-66
Speed limit control system ............................................5-53
Speedometer...................................................................4-49
Sports mode ...................................................................5-25
SRS components and functions .....................................3-45
Starting difficulties, see engine will not start ..................6-4
Steering wheel...........................................................\
.....4-41 Electric power steering ................................................4-41
Heated steering wheel .................................................4-42
Horn ........................................................................\
.....4-43
Tilt steering ..................................................................4-42
Storage compartment ...................................................4-136 Center console storage...............................................4-1\
36
Cool box ....................................................................4-13\
7
Glove box ..................................................................4-136
Luggage side partition ...............................................4-138
Luggage side tray ......................................................4-138
Luggage tray ..............................................................4-138
Rear seat floor pocket................................................4-139
Sunglass holder..........................................................4-137
Sunglass holder ............................................................4-137
Sunroof, see panorama sunroof .....................................4-35
Sunvisor .......................................................................4\
-142 Tachometer.....................................................................4-5\
0
Tailgate........................................................................\
...4-20
Non-powered tailgate ..................................................4-20
Power tailgate ..............................................................4-21
Tether anchor system .....................................................3-33
Theft-alarm system ........................................................4-12
Tilt steering ....................................................................4-42\
Tire chains......................................................................5-\
70
Tire pressure monitoring system ...................................6-16
Tire rotation ...................................................................7-64
Tire specification and pressure label ...............................8-9
Tires and wheels .....................................................7-61, 8-4 Checking tire inflation pressure ..................................7-63
Compact spare tire replacement ..................................7-66
Recommended cold tire inflation pressures ................7-61
Tire care .......................................................................7\
-61
Tire maintenance .........................................................7-67
Tire replacement ..........................................................7-65
Tire rotation .................................................................7-64
Tire sidewall labeling ..................................................7-67
Tire traction .................................................................7-67
Wheel alignment and tire balance ...............................7-65
Wheel replacement ......................................................7-66
Towing ........................................................................\
...6-26T