maintenance schedule HYUNDAI IX20 2011 Owner's Guide

Maintenance
40
7
✽✽
NOTICE
New automatic transaxle fluid should be
red. The red dye is added so the assem-bly plant can identify it as automatic
transaxle fluid and distinguish it from
engine oil or antifreeze. The red dye,
which is not an indicator of fluid quali-
ty, is not permanent. As the vehicle isdriven, the automatic transaxle fluid
will begin to look darker. The color may
eventually appear light brown.
Therefore, have an authorized
HYUNDAI dealer change the automatictransaxle fluid according to theScheduled Maintenance at the begin-ning of this section.
Use only specified automatic transaxle
fluid. (Refer to "Recommended lubricantsor capacities" in section 8.) Changing the automatic transaxle fluid
Have the automatic transaxle fluid
changed by an authorized HYUNDAIdealer according to the MaintenanceSchedule at the beginning of this section.
JC ENG 7.QXP 9/7/2010 11:59 AM Page 40
procarmanuals.com

743
Maintenance
AIR CLEANER
Filter replacement
You can clean the filter when inspecting the air cleaner element.
Clean the filter by using compressed air.
1. Loosen the air cleaner cover attaching clips and open the cover. 2. Wipe the inside of the air cleaner.
3. Replace the air cleaner filter.
4. Lock the cover with the cover attaching
clips. Replace the filter according to the
Maintenance Schedule.
If the vehicle is operated in extremely
dusty or sandy areas, replace the ele- ment more often than the usual recom-
mended intervals. (Refer to “Maintenance under severe usage condi-tions” in this section.)
OYN079014OYN079015
CAUTION
 Do not drive with the air cleaner
removed; this will result in exces-sive engine wear.
 When removing the air cleaner fil- ter, be careful that dust or dirtdoes not enter the air intake, or
damage may result.
 Use a HYUNDAI genuine part. Use of nongenuine parts could dam-age the air flow sensor, tur-bocharger or engine.
JC ENG 7.QXP 9/7/2010 11:59 AM Page 43
procarmanuals.com

785
Maintenance
EMISSION CONTROL SYSTEM
The emission control system of your
vehicle is covered by a written limited
warranty. Please see the warranty infor-
mation contained in the Service Passport
in your vehicle.
Your vehicle is equipped with an emis- sion control system to meet all emission
regulations. There are three emission control sys-
tems which are as follows.
(1) Crankcase emission control system
(2) Evaporative emission control system(3) Exhaust emission control system In order to assure the proper function of
the emission control systems, it is rec-
ommended that you have your vehicle
inspected and maintained by an author-
ized HYUNDAI dealer in accordance with
the maintenance schedule in this manu-al. Caution for the Inspection and
Maintenance Test (With Electronic
Stability Program (ESP) system)
 To prevent the vehicle from misfir-
ing during dynamometer testing,
turn the Electronic Stability
Program (ESP) system off by press-
ing the ESP switch.
 After dynamometer testing is com- pleted, turn the ESP system back on
by pressing the ESP switch again. 1. Crankcase emission control
system
The positive crankcase ventilation sys-
tem is employed to prevent air pollution
caused by blow-by gases being emitted
from the crankcase. This system supplies
fresh filtered air to the crankcase through
the air intake hose. Inside the crankcase,
the fresh air mixes with blow-by gases,
which then pass through the PCV valveinto the induction system.
2. Evaporative emission control system
The Evaporative Emission Control
System is designed to prevent fuel
vapors from escaping into the atmos-
phere.
JC ENG 7.QXP 9/7/2010 12:02 PM Page 85
procarmanuals.com

Specifications & Consumer information
6
8
Recommended SAE viscosity
number
Engine oil viscosity (thickness) has an
effect on fuel economy and cold weather
operating (engine start and engine oil
flowability). Lower viscosity engine oils
can provide better fuel economy and cold
weather performance, however, higher
viscosity engine oils are required for sat-
isfactory lubrication in hot weather. Using
oils of any viscosity other than those rec-ommended could result in engine dam-
age.When choosing an oil, consider the
range of temperature your vehicle will be
operated in before the next oil change.Proceed to select the recommended oil
viscosity from the chart.
CAUTION
Always be sure to clean the area
around any filler plug, drain plug, ordipstick before checking or drain-ing any lubricant. This is especially
important in dusty or sandy areas and when the vehicle is used onunpaved roads. Cleaning the plugand dipstick areas will prevent dirt
and grit from entering the engine and other mechanisms that couldbe damaged.
Temperature Range for SAE Viscosity Numbers
Temperature
Gasoline
Engine Oil * 1
(For Europe) °C
(°F)-30 -20 -10 0 10 20 30 40 50 -10 0 20 40 60 80 100 120
Diesel
Engine Oil * 45W-30
15W-40
10W-30
0W-40, 5W-30, 5W-40
Gasoline
Engine Oil * 2
(Except Europe)20W-50
10W-30
15W-40
5W-20* 3
, 5W-30
* 1
: For better fuel economy, it is recommended to use the engine oil of a viscosity
grade SAE 0W-40, 5W-30, 5W-40 (API Service SL, SM / ACEA A5 or above).
* 2
: For better fuel economy, it is recommended to use the engine oil of a viscosity
grade SAE 5W-20,5W-30 (API SL, SM / ILSAC GF-3 or above). However, if the
engine oil is not available in your country, select the proper engine oil using the
engine oil viscosity chart.
* 3
: In Middle East, do not use the engine oil of viscosity grade SAE 5W-20.
* 4
: If your vehicle follows 30,000 km/ 1 year interval in normal maintenance schedule,
use the engine oil of viscosity grade, SAE 5W-30 or SAE 0W-30.
5W-40
0W-30, 0W-40
JC ENG 8.QXP 9/7/2010 1:43 PM Page 6
procarmanuals.com

Index
4
I
Displays, see instrument cluster ····································4-40 Display illumination, see instrument
panel illumination ·······················································4-41
Door locks ·······································································4-13 Central door lock/unlock switch ······························4-14
Child-protector rear door lock ·································4-16
Drinks holders, see cup holders ···································4-105
Driver's air bag ·······························································3-44
Driving at night ······························································5-47
Driving in flooded areas ················································5-48
Driving in the rain ·························································5-48
Economical operation ····················································5-43
Electric chromic mirror (ECM) ·····································4-35
Electric power steering ··················································4-33
Electronic stability program (ESP) ·································5-31
Emergency starting ··························································6-5 Jump starting ······························································6-5
Push starting ·······························································6-7
Emergency tailgate safety release ··································4-18
Emergency towing ·························································6-29
Emergency while driving ·················································6-3
Emission control system ················································7-85 Crankcase emission control system ·························7-85
Evaporative emission control system ······················7-85
Exhaust emission control system ·····························7-86 Engine ···············································································8-2
Engine compartment ················································2-6, 7-2
Engine coolant ·······························································7-35
Engine number ·································································8-8
Engine oil ·······································································7-34
Engine overheats ······························································6-8
Engine start/stop button ···················································5-8
Engine temperature gauge ·············································4-42
Engine will not start ·························································6-4
Evaporative emission control system ····························7-85
Exhaust emission control system ···································7-86Explanation of scheduled maintenance items ················7-30
Exterior care ···································································7-79
Flat tire ·············································································6-9
Changing tires ··························································6-10
Jack and tools ·····························································6-9
Removing and storing the spare tire ························6-10
Flat tire (with TireMobilityKit) ······································6-17
Floor mat anchor(s) ·····················································4-108Fluid Brake/clutch fluid ·····················································7-38
Washer fluid ·····························································7-41
Folding the rear seat ······················································3-10
Front fog light ·································································4-73
Front fog light bulb replacement ···································7-74
E
F
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 4
procarmanuals.com

I7
Index
Position light bulb replacement ·······························7-73
Rear combination light bulb replacement ················7-75
Rear fog light bulb replacement································7-77
Side repeater light bulb replacement ·······················7-74
Smart cornering light bulb replacement····················7-72
Turn signal light bulb replacement ··························7-73
Lighting ··········································································4-69 Battery saver function ··············································4-69
Daytime running light ···············································4-73
Front fog light ···························································4-73
Headlight escort function ··········································4-69
Headlight leveling device··········································4-74
Lighting control·························································4-70
Rear fog light ····························································4-73
Smart cornering light ················································4-69
Turn signals and lane change signals························4-72
Lubricants and capacities ·················································8-4
Luggage boad································································4-109
Luggage net (holder) ···················································4-108
Luggage room lamp ························································4-18 Main fuse ········································································7-63Maintenance
Explanation of scheduled maintenance items ···········7-30Maintenance services ················································· 7-3
Maintenance under severe usage conditions ···7-17, 7-28 Normal maintenance schedule ···························7-8, 7-19
Owner maintenance ····················································7-5
Scheduled maintenance service ·································7-7
Tire maintenance ······················································7-55
Maintenance services ·······················································7-3
Manual climate control system ······································4-81 Air conditioning ·······················································4-86
Climate control air filter ··········································4-88
Heating and air conditioning ····································4-82
Manual heating and air conditioning ·····························4-92
Manual transaxle ····························································5-18
Map lamp ········································································4-79
Memory fuse ··································································7-62Mirrors ···········································································4-35 Day/night rearview mirror ·······································4-35
Electric chromic mirror (ECM) ·······························4-35
Inside rearview mirror ··············································4-35
Outside rearview mirror ···········································4-36
Moonroof, see panorama sunroof ··································4-29
Multi fuse ·······································································7-60M
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 7
procarmanuals.com

Index
8
I
Neck restraints, see headrest ··································3-6, 3-12 Odometer ·······································································4-43
Oil (Engine) ···································································7-34
Outside mirror defroster ················································4-80
Outside temperaure ·······················································4-103
Outside rearview mirror ·················································4-36Overheats ·········································································6-8
Owner maintenance ·························································7-5
Panorama sunroof ··························································4-29
Parking brake ·································································5-27
Parking brake inspect ·····················································7-41
Passenger's front air bag ················································3-44
Position light bulb replacement ·····································7-73
Power brakes ··································································5-27
Power outlet ·································································4-106
Power window lock switch ············································4-22
Pre-tensioner seat belt ····················································3-21
Push starting ·····································································6-7 Rear combination light bulb replacement ······················7-75
Rear fog light ··································································4-73
Rear fog light bulb replacement ·····································7-77
Rear seat adjustment ·························································3-9
Rear parking assist system ·············································4-63
Rear window defroster····················································4-80
Rearview camera ···························································4-67
Recommended cold tire inflation pressures ··················7-50
Recommended lubricants and capacities ·························8-4
Recommended SAE viscosity number ······················8-6
Remote keyless entry ·······················································4-5
Road warning ···································································6-2
Rocking the vehicle ·······················································5-46
Room lamp······································································4-79
Scheduled maintenance service ·······································7-7 Normal maintenance schedule ··························7-8, 7-19
Maintenance under severe usage conditions ··7-17, 7-28
Seat····················································································3-2 Armrest ·····························································3-5, 3-13
Folding the rear seat ·················································3-10
Front seat adjustment ··················································3-4
Headrest ····························································3-6, 3-12
Rear seat adjustment ···················································3-9
R
S
O
P
N
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 8
procarmanuals.com