radiator Lexus GS350 2008 Owner's Manual
[x] Cancel search | Manufacturer: LEXUS, Model Year: 2008, Model line: GS350, Model: Lexus GS350 2008Pages: 598, PDF Size: 14.03 MB
Page 397 of 598
396
4-2. Maintenance
GS_G_U
June 19, 2008 12:54 pm
General maintenance
Engine compartment
ItemsCheck points
Brake fluid• At the correct level? (→P. 4 1 6 )
Engine coolant• At the correct level? ( →P. 4 1 4 )
Engine oil• At the correct level? (→ P. 4 0 9 )
Exhaust system• No fumes or strange sounds?
Radiator/condenser/hoses• Not blocked with foreign matter?
(→ P. 4 1 5 )
Wa s h e r f l u i d• At the correct level? (→ P. 4 2 0 )
12 volt battery•Maintenance-free (→P. 4 1 7 )
Listed below are the general maintenance items that should be performed
at the intervals specified in the “Warranty and Services Guide/Owner’s
Manual Supplement”. It is recommended that any problem you notice
should be brought to the attention of your Lexus dealer or qualified service
shop for advice.
GS_U_G.book Page 396 Thursday, June 19, 2008 12:54 PM
Page 402 of 598
401
4-3. Do-it-yourself maintenance
4
Maintenance and care
GS_G_U
June 19, 2008 12:54 pm
ItemsParts and tools
Engine oil level (→P. 4 0 9 )
• “Toyota Genuine Motor Oil” or
equivalent
• Rag or paper towel, funnel (used
only for adding engine oil)
Fuses (→ P. 4 4 2 )• Fuse with same amperage rating as
original
Headlight aim ( →P. 4 6 7 )• Phillips-head screwdriver
Radiator and condenser (→P. 4 1 5 )
Tire inflation pressure ( →P. 4 3 1 )• Tire pressure gauge
• Compressed air source
Wa s h e r f l u i d ( →P. 4 2 0 )
• Water washer fluid containing anti-
freeze (for winter use)
•Funnel
GS_U_G.book Page 401 Thursday, June 19, 2008 12:54 PM
Page 403 of 598
402
4-3. Do-it-yourself maintenance
GS_G_U
June 19, 2008 12:54 pm
CAUTION
The engine compartment contains many mechanisms and fluids that may move sud-
denly, become hot, or become electrically energized. To avoid death or serious injury,
observe the following precautions.
■When working on the engine compartment
●Keep hands, clothing, and tools away from the moving fan and engine drive belt.
●Be careful not to touch the engine, radiator, exhaust manifold, etc. right after driv-
ing as they may be hot. Oil and other fluids may also be hot.
●Do not leave anything that may burn easily, such as paper or rags, in the engine
compartment.
●Do not smoke, cause sparks or expose an open flame to fuel or the 12 volt battery.
Fuel and 12 volt battery fumes are flammable.
●Be extremely cautious when working on the 12 volt battery. It contains poisonous
and corrosive sulfuric acid.
■When working near the electric cooling fan or radiator grille
Be sure the “ENGINE START STOP” switch is OFF.
With the “ENGINE START STOP” switch in IGNITION ON mode, the electric
cooling fan may automatically start to run if the air conditioning is on and/or the
coolant temperature is high. (→P. 4 1 5 )
■Safety glasses
Wear safety glasses to prevent flying or falling material, fluid spray, etc. from getting
in the eyes.
NOTICE
■If you remove the air cleaner filter
Driving with the air cleaner filter removed may cause excessive engine wear due to
dirt in the air. Also a backfire could cause a fire in the engine compartment.
GS_U_G.book Page 402 Thursday, June 19, 2008 12:54 PM
Page 407 of 598
406
4-3. Do-it-yourself maintenance
GS_G_U
June 19, 2008 12:54 pm
Engine compartment
GS460
Engine oil level dipstick(→P. 4 0 9 )
Engine oil filler cap (→P. 4 1 0 )
Brake fluid reservoir (→P. 4 1 6 )
Fuse box ( →P. 4 4 2 )
Washer fluid tank (→P. 4 2 0 )Engine coolant reservoir
(→P. 4 1 4 )
Electric cooling fans
Condenser ( →P. 415)
Radiator ( →P. 415)
Fuse box ( →P. 4 4 2 )
12 volt battery ( →P. 417)
GS_U_G.book Page 406 Thursday, June 19, 2008 12:54 PM
Page 408 of 598
407
4-3. Do-it-yourself maintenance
4
Maintenance and care
GS_G_U
June 19, 2008 12:54 pm
GS350
Engine oil level dipstick(→P. 4 0 9 )
Engine oil filler cap (→P. 4 1 0 )
Brake fluid reservoir (→P. 4 1 6 )
Fuse box ( →P. 4 4 2 )
Washer fluid tank (→P. 4 2 0 )Engine coolant reservoir
(→P. 4 1 4 )
Electric cooling fans
Condenser ( →P. 415)
Radiator ( →P. 415)
Fuse box ( →P. 4 4 2 )
12 volt battery ( →P. 417)
GS_U_G.book Page 407 Thursday, June 19, 2008 12:54 PM
Page 415 of 598
414
4-3. Do-it-yourself maintenance
GS_G_U
June 19, 2008 12:54 pm
CoolantThe coolant level is satisfactory if it is between the “FULL” and “LOW”
lines on the reservoir when the engine is cold. Reservoir cap
“FULL”
“LOW”
If the level is on or below the
“LOW” line, add coolant up to the
“FULL” line.
■If the coolant level drops within a short time after replenishing
Visually check the radiator, hoses, reservoir cap, radiator cap, drain cock and water
pump.
If you cannot find a leak, have your Lexus dealer pressure test the cap and check for
leaks in the cooling system.
■Coolant selection
Only use “Toyota Super Long Life Coolant” or similar high quality ethylene glycol
based non-silicate, non-amine, non-nitrite, and non-borate coolant with long-life
hybrid organic acid technology.U.S.A.: “Toyota Super Long Life Coolant” is a mixture of 50% coolant and 50% deionized water. (Enabled: -31 °F [-35 °C])
Canada: “Toyota Super Long Life Coolant” is a mixture of 55% coolant and 45% deionized water. (Enabled: -44 °F [-42 °C])
For more details about coolant, contact your Lexus dealer.
GS_U_G.book Page 414 Thursday, June 19, 2008 12:54 PM
Page 416 of 598
415
4-3. Do-it-yourself maintenance
4
Maintenance and care
GS_G_U
June 19, 2008 12:54 pm
Radiator and condenserCheck the radiator and condenser and clear any foreign objects.
If either of the above parts are extremely dirty or you are not sure of their
condition, have your vehicle checked by your Lexus dealer.
CAUTION
■When the engine is hot
Do not remove the radiator and reservoir cap.
The cooling system may be under pressure and may spray hot coolant if the cap is
removed, causing burns or other injuries.
NOTICE
■When adding the coolant
Coolant is neither plain water not straight antifreeze. The correct mixture of water
and antifreeze must be used to provide proper lubrication, corrosion protection
and cooling. Be sure to read the antifreeze or coolant label.
■If you spill coolant
Be sure to wash it off with water to prevent it from damaging to parts or paint.
CAUTION
■When the engine is hot
Do not touch the radiator or condenser, as they may be hot and you may be burned.
GS_U_G.book Page 415 Thursday, June 19, 2008 12:54 PM
Page 534 of 598
5
When trouble arises
533
5-2. Steps to take in an emergency
GS_G_U
June 19, 2008 12:54 pm
If your vehicle overheats
If your engine overheats:
Stop the vehicle in a safe place and turn off the air conditioning
system.
Check to see if steam is coming out from under the hood.
If you see steam: Stop the engine and carefully lift the hood.
If you do not see steam: Leave the engine running and carefully lift the hood.
Remove the engine compartment cover. ( →P. 4 0 8 )
Check to see if the cooling fan is operating.
If the fan is operating: Wait until the engine coolant temperature gauge begins to
fall and then stop the engine.
If the fan is not operating: Stop the engine immediately and call your local Lexus
dealer.
After the engine has cooled
down sufficiently, check the
coolant level and inspect the
radiator core (radiator) for any
leaks.STEP1
STEP2
STEP3
STEP4
STEP5
GS_U_G.book Page 533 Thursday, June 19, 2008 12:54 PM
Page 535 of 598
534
5-2. Steps to take in an emergency
GS_G_U
June 19, 2008 12:54 pm
■Overheating
In the following situations, your vehicle may be overheating.
●The engine coolant temperature gauge enters the red zone or a loss of power is
experienced.
●Steam is coming from under the hood.
CAUTION
■To prevent an accident or injury when inspecting under the hood of your vehicle
●Keep hands and clothing away from the fan and engine drive belt while the
engine is running.
●Do not loosen the radiator cap while the engine and radiator are hot.
Serious injury, such as burns, may result from hot coolant and steam released
under pressure.
Add coolant if necessary.
Water can be used in an emer-
gency measure if coolant is
unavailable. (→P. 5 4 6 )
Have the vehicle checked at your nearest Lexus dealer as soon as pos-
sible.
STEP6
GS_U_G.book Page 534 Thursday, June 19, 2008 12:54 PM
Page 590 of 598
589
Alphabetical index
GS_G_U
June 19, 2008 12:54 pm
Parking brake ........................................... 131
Parking lightsReplacing light bulbs ....................... 470
Switch ........................................................ 142
Wattage ................................................. 552
Personal lights ....................................... 339
Power outlet ........................................... 353
Power windows.........................................64
Pre-collision system ..............................190
Radar cruise control ............................. 153
Radiator...................................................... 415
Radio ..........................................................229
Radio data system.................................. 231
Rear sunshade........................................357
Rear turn signal lights
Replacing light bulbs ....................... 470
Wattage ................................................. 552
Rear view monitor system .................. 179
Rear window defogger .......................225
Replacing Electronic key battery ..................... 440
Fuses .........................................................442
Light bulbs ............................................ 470
Reporting safety defects for U.S. owners ......................................... 578
Seat belts Adjusting the seat belt ....................... 53
Automatic locking retractor............ 55
Child restraint system installation ............................................102
Cleaning and maintaining the seat belts..................................... 392
Emergency locking retractor ......... 55
How to wear your seat belt............. 53 How your child should wear
the seat belt ..........................................56
Pre-collision seat belts .......................55
Pregnant women, proper seat belt use .........................55
Reminder light .................................... 490
Seat belt extenders ..............................56
Seat belt pretensioners ...................... 54
Seat heaters/ventilators.....................355
Seating capacity ..................................... 198
Seats Adjustment ............................................... 45
Adjustment precautions .................... 46
Child seats/child restraint
system installation............................ 102
Cleaning .................................................. 391
Driver’s seat position memory ....... 47
Head restraint ...........................................51
Properly sitting in the seat ................ 78
Seat heaters ..........................................354
Service reminder indicators ............. 136
Shift lever Automatic transmission ................... 125
If the shift lever cannot be shifted from “P” ................................ 524
Shift lock system .................................... 524
Shopping bag hooks............................360
Side airbags............................................... 80
Side marker lights Switch.........................................................142
Side mirror Adjusting and folding.......................... 62
Mirror position memory.................... 47P
R
S
GS_U_G.book Page 589 Thursday, June 19, 2008 12:54 PM