battery lexus LC500 2018 Workshop Manual

300
-$@-$I@0.@0.&@ &&

5-6. Using the other interior features
enabled.
 If the green indicator light flashes, an
emergency call is being made
(either automatically or manually).
 If no indicator lights illuminate, the
system is not enabled.
 If the red indicator light illuminates
any time other than immediately
after the engine switch switch> is turned IGNITION ON
mode , the system may
be malfunctioning or the backup
battery may be depleted. Contact
any authorized Lexus retailer or
Lexus authorized repairer, or any
reliable repairer.
The service life of the backup battery is 3
years or more.
WARNING
■When the Emergency Call may not be made
●Any of the followings may occur. In such cases, report to the Public Safety
Answering Point (PSAP) by other means such as nearby public phones.
• It may sometimes be difficult to con- nect to the Public Safety Answering Point (PSAP) even in the reception
area of the cellular phone due to the reception level, or if the line is busy.In such cases, you may not be able to
connect to the Public Safety Answer- ing Point (PSAP) and thus will not be able to make emergency calls and
report to the emergency departments even though the system tries to con-nect to the Public Safety Answering
Point (PSAP).
• When the vehicle is out of the cellular
phone service area, the Emergency Call cannot be made.
• When any related equipment (such as the “SOS” button panel, indicator lights, microphone, speaker, DCM,
antenna, or any wires connecting the equipment.) has an abnormality, is damaged or broken, the Emergency
Call cannot be made.
• During the Emergency Call, the sys-
tem makes repeated attempts to con- nect to the Public Safety Answering Point (PSAP). However, if it cannot
connect to the Public Safety Answer- ing Point (PSAP) due to poor radio wave reception, the system may not be
able to connect to the cellular network and the call may finish without con-necting. The red indicator light will
blink for approximately 30 seconds to indicate this disconnection.
• This device may not function if a shock is applied to it.

301
5
-$@-$I@0.@0.&@ &&

5-6. Using the other interior features
Interior features
WARNING
●If the 12-volt battery’s voltage decreases or there is a disconnection, the system may not be able to access
the Public Safety Answering Point (PSAP).
■When replacing DCM to a new one
ERA-GLONASS have to be activated. Contact any authorized Lexus retailer or
Lexus authorized repairer, or any reliable repairer.
■For your safety
●Please drive safely.The function of this system is to assist
you in making the Emergency Call in case of accidents as traffic accidents or sudden medical emergencies, and it
does not protect the driver or the pas- sengers in any way. Please drive safely and fasten your seatbelts at all times
for your safety.
●In case of an emergency, make lives the top priority.
●If you smell anything burning or another unusual smell, do not stay
inside the vehicle and evacuate to a safe area immediately.
●Since the system detects shocks, the automatic reporting may not always
occur synchronized with the operation of the airbag system. (If the vehicle is bumped from behind, etc.)
●The airbag may not inflate even in case
of an accident, if it does not involve high impact. In such cases, the system may not make emergency calls auto-
matically. The system may also not make automatic emergency calls even if the airbag has been inflated. If any of
these should occur, please report to the Public Safety Answering Point (PSAP) by operating the “SOS” but-
ton.
●For safety, do not make the Emergency Call while driving.
Making calls during driving may cause mishandling of th e steering wheel, which may lead to unexpected acci-
dents. Stop the vehicle and confirm the safety of the area before making the Emer-
gency Call.
●When changing fuses, please use fuses that correspond to the described stan-dard.
If you use fuses other than those described, it may cause ignition or smoke in the circuit and may lead to a
fire.
●Using the system while there is smoke or an unusual smell may cause a fire. Stop using the system immediately and
consult any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer.
NOTICE
■To prevent damage
Do not pour any liquid on to the “SOS”
button panel etc. and make any impact to it.
■If the “SOS” button panel malfunc-tions
It may not be able to make the Emer-
gency Call or inform you of the correct condition of the system. If the “SOS” but-ton panel has been broken, please con-
sult any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer.

6
303
-$@-$I@0.@0.&@ &&

6
Maintenance and care
Maintenance and care
6-1. Maintenance and care
Cleaning and protecting the vehi-
cle exterior ................................ 304
Cleaning and protecting the vehi-
cle interior ................................. 307
6-2. Maintenance
Maintenance requirements ... 312
6-3. Do-it-yourself maintenance
Do-it-yourself service precautions
......................................................... 314
Hood ............................................... 316
Positioning a floor jack............. 316
Engine compartment................ 318
12-volt battery............................. 325
Tires ................................................ 327
Replacing the tire ...................... 339
Tire inflation pressure.............. 345
Wheels .......................................... 346
Air conditioning filter............... 347
Electronic key battery ............. 349
Checking and replacing fuses
........................................................ 350
Light bulbs .................................... 355

305
6
-$@-$I@0.@0.&@ &&

6-1. Maintenance and care
Maintenance and care
■Notes for a smart entry & start system
If the door handle becomes wet while the
electronic key is within the effective range, the door may lock and unlock repeatedly. In that case, follow the following correction
procedures to wash the vehicle:
●Place the key in a position 2 m (6 ft.) or
more separate from the vehicle while the vehicle is being washed. (Take care to ensure that the key is not stolen.)
●Set the electronic key to battery-saving mode to disable the smart entry & start
system. ( P.124)
■Aluminum wheels
●Remove any dirt immediately by using a
neutral detergent.
●Wash detergent off with water immedi-
ately after use.
●To protect the paint from damage, make
sure to observe the following precau- tions.• Do not use acidic, alkaline or abrasive
detergent • Do not use hard brushes• Do not use detergent on the wheels when
they are hot, such as after driving or park- ing in hot weather
■Brake caliper coating
●When using detergent, use neutral deter-gent. Do not use hard brushes or abra-
sive cleaners, as they will damage the coating.
●Do not use detergent on the brake cali-pers when they are hot.
●Wash detergent off immediately after use.
■Bumpers
Do not scrub with abrasive cleaners.
■Front side windows water-repellent coating
●The following precautions can extend the effectiveness of the water-repellent coat-ing.
• Remove any dirt, etc. from the front side windows regularly.• Do not allow dirt and dust to accumulate
on the windows for a long period. Clean the windows with a soft, damp cloth as soon as possible.
• Do not use wax or glass cleaners that contain abrasives when cleaning the win-dows.
• Do not use any metallic objects to remove condensation build up.
●When the water-repellent performance has become insufficient, the coating can be repaired. Contact any authorized
Lexus retailer or Lexus authorized repairer, or any reliable repairer.
WARNING
■When washing the vehicle
Do not apply water to the inside of the
engine compartment. Doing so may cause the electrical components etc. to catch fire.
■When cleaning the windshield
Set the wiper switch to off. If the wiper switch is in AUTO, the wipers
may operate unexpectedly in the follow- ing situations, and may result in hands being caught or other serious injuries
and cause damage to the wiper blades.
Off
AUTO
●When the upper part of the windshield where the raindrop sensor is located is
touched by hand
●When a wet rag or similar is held close to the raindrop sensor
●If something bumps against the wind-shield
A
B

308
-$@-$I@0.@0.&@ &&

6-1. Maintenance and care
■CFRP (Carbon Fiber Reinforced Plas- tic) parts (if equipped)
CFRP is used for the scuff plates. When cleaning the scuff plates, remove dirt using a water-dampened soft cloth or synthetic
chamois, and then wipe the surface with a dry soft cloth to remove any remaining moisture.
WARNING
■Water in the vehicle
●LC500: Do not splash or spill liquid in the vehicle.Doing so may cause electrical compo-
nents etc. to malfunction or catch fire. LC500h: Do not splash or spill liquid in the vehicle, such as on the floor, on
the rear seats, in the hybrid battery (traction battery) air vents or in the trunk. ( P.68)
Doing so may cause the hybrid battery, electrical components, etc. to mal-function or catch fire.
●Do not get any of the SRS components
or wiring in the vehicle interior wet. ( P.35) An electrical malfunction may cause
the airbags to deploy or not function properly, resulting in death or serious injury.
■Cleaning the interior (especially
instrument panel)
Do not use polish wax or polish cleaner.
The instrument panel may reflect off the windshield, obstructing the driver’s view and leading to an accident, resulting in
death or serious injury.
NOTICE
■Cleaning detergents
●Do not use the following types of
detergent, as they may discolor the vehicle interior or cause streaks or damage to painted surfaces:
• Non-seat portions: Organic sub- stances such as benzene or gasoline,
alkaline or acidic solutions, dye, and bleach
• Seats: Alkaline or acidic solutions, such as thinner, benzene, and alcohol
●Do not use polish wax or polish cleaner. The instrument panel’s or
other interior part’s painted surface may be damaged.
■Preventing damage to leather sur-faces
Observe the following precautions to avoid damage to and deterioration of
leather surfaces:
●Remove any dust or dirt from leather surfaces immediately.
●Do not expose the vehicle to direct sunlight for extended periods of time.
Park the vehicle in the shade, espe- cially during summer.
●Do not place items made of vinyl, plas-tic, or containing wax on the uphol-
stery, as they may stick to the leather surface if the vehicle interior heats up significantly.
■Water on the floor
Do not wash the vehicle floor with water. Vehicle systems such as the audio system
may be damaged if water comes into contact with electrical components such as the audio system above or under the
floor of the vehicle. Water may also cause the body to rust.

309
6
-$@-$I@0.@0.&@ &&

6-1. Maintenance and care
Maintenance and care
Clean the air intake vents and filters by
the following procedures to prevent
dust from accumulating in them, or to
prevent them from clogging.
The filters are attached to the back side of
the air intake vent grilles.
■Cleaning the air intake vents and
filters
Remove the dust from the vents and fil-
ters with a vacuum cleaner etc.
Clean the vents of the both sides.
■Cleaning the filters
If “Maintenance required for Traction
battery cooling parts See owner’s man-
ual” is shown on the multi-information
display, contact any authorized Lexus
retailer or Lexus authorized repairer,
or any reliable repairer or remove the
air intake vent grilles under the rear
seat and clean the filters.
1 Remove the grille.
NOTICE
■When cleaning the inside of the wind- shield (vehicles with Lexus Safety System+)
Do not allow glass cleaner to contact the lens. Also, do not touch the lens.
( P.204)
■Cleaning the inside of the rear win- dow
●Do not use glass cleaner to clean the rear window, as this may cause dam-age to the rear window defogger
heater wires or antenna. Use a cloth dampened with lukewarm water to gently wipe the window clean. Wipe
the window in strokes running parallel to the heater wires or antenna.
●Be careful not to scratch or damage the heater wires or antenna.
Cleaning the air intake vents and
filters (LC500h)

310
-$@-$I@0.@0.&@ &&

6-1. Maintenance and care
2Remove the filter.
3 Remove dust using a vacuum
cleaner etc. to clean the filter.
Also, remove dust on the grille as well as on the filter using a vacuum cleaner.
4 Install the filter in its original posi-
tion, and then install the grille.
5 Start the hybrid system and check
that the warning message on the
multi-information display disap-
pears.
It may take several minutes before the warning message disappears.
■Cleaning the air intake vents and filters
●Dust on the air intake vents or filters may interferes cooling of the hybrid battery (traction battery) and results in poor fuel
consumption. Clean the air intake vents and filters periodically.
●If continuing to drive the vehicle with “Maintenance required for Traction bat-tery cooling parts See owner’s manual”
shown on the multi-information display, the hybrid battery (traction battery) input and output may be restricted, leading to a
reduction in hybrid battery (traction bat- tery) output and a malfunction. It may cause poor fuel consumption or a mal-
function. If the warning message is shown, contact any authorized Lexus retailer or Lexus authorized repairer, or any reliable
repairer or clean the air intake vents and filters immediately.
●Improper handling may result in damage to the grille or filters. If you have any con-cerns about cleaning the filters, contact
any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer.
●If the warning message on the multi-infor-mation display does not disappear after
cleaning the filters, have the vehicle inspected by any authorized Lexus retailer or Lexus authorized repairer, or
any reliable repairer.
●Timing of cleaning filters differs depend-
ing on the use environment of the vehicle.
NOTICE
■When cleaning the air intake vents
and filters
Observe the following precautions. Fail-
ure to do so may cause damage to the vehicle.
●When removing the air intake vent grille, make sure to turn the power
switch off to stop the hybrid system.
●Do not use water or other liquid to clean the air intake vents or filters.
●Do not allow water or foreign matter to enter the air intake vent when the grille
is removed.
●Carefully handle th e removed filters not to damage.If the filter is damaged, have it replaced
with a new filter by any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer.

312
-$@-$I@0.@0.&@ &&

6-2. Maintenance
6-2.Maintenance
■Where to go for maintenance service?
In order to maintain your vehicle in the best possible condition, Lexus recommends that maintenance service operations as well as
other inspections and repairs be carried out by authorized Lexus retailer or Lexus authorized repairer, or any reliable repair-
ers. For repairs and services covered by your warranty, please visit an authorized Lexus retailer or repairer, who will use gen-
uine Lexus parts in repairing any difficulties you may encounter. There can also be advantages in utilizing authorized Lexus
retailers or repairers for non-warranty repairs and services, as members of the Lexus network will be able to expertly assist
you with any difficulties you may encounter.
Your Lexus retailer or Lexus authorized
repairer, or any reliable repairer will per- form all of the scheduled maintenance on your vehicle reliably and economically due
to their experience with Lexus vehicles.
Scheduled maintenance should be
performed at specified intervals
according to the maintenance sched-
ule.
For details about maintenance items and
schedules, refer to the “Lexus Service
Booklet” or “Lexus Warranty Booklet”.
What about do-it-yourself mainte-
nance?
Many of the maintenance items are easy to
do yourself if you have a little mechanical
ability and a few basic automotive tools.
Note, however, that some maintenance
tasks require special tools and skills. These
are best performed by qualified techni-
cians. Even if you’re an experienced do-it-
yourself mechanic, we recommend that
repairs and maintenance be conducted by
any authorized Lexus retailer or Lexus
authorized repairer, or any reliable
repairer. Any authorized Lexus retailer or
repairer will keep a record of maintenance,
which could be useful should you ever
require Warranty Service. Should you
choose to select a qualified and equipped
professional other than an authorized
Lexus repairer to service or maintain your
vehicle, we recommend that you request
that a record of maintenance be kept.
■Does your vehicle need repairs?
Be on the alert for changes in performance and sounds, and visual tip-offs that indicate
service is needed. Some important clues are:
●Engine missing, stumbling or pinging
Maintenance requirements
To ensure safe and economical driv-
ing, day-to-day care and regular
maintenance are essential. Lexus
recommends the following mainte-
nance:
WARNING
■If your vehicle is not properly main-
tained
Improper maintenance could result in
serious damage to the vehicle and possi- ble death or serious injury.
■Handling of the 12-volt battery
12-volt battery posts, terminals and related accessories contain lead and lead compounds which are known to
cause brain damage. Wash your hands after handling. ( P.325)
Scheduled maintenance
Do-it-yourself maintenance

314
-$@-$I@0.@0.&@ &&

6-3. Do-it-yourself maintenance
6-3.Do-it-yourself maintenance
Do-it-yourself service pre-
cautions
If you perform maintenance by
yourself, be sure to follow the cor-
rect procedure as given in these
sections.
Maintenance
ItemsParts and tools
12-volt battery
condition
( P.325)
•Grease
• Conventional wrench
(for terminal clamp
bolts)
Engine coolant
level (LC500)
( P.322)
• “Toyota Super Long Life
Coolant” or a similar
high quality ethylene
glycol-based non-sili-
cate, non-amine, non-
nitrite and non-borate
coolant with long-life
hybrid organic acid
technology
“Toyota Super Long Life
Coolant” is pre-mixed
with 50% coolant and
50% deionized water.
• Funnel (used only for
adding coolant)
Engine/power
control unit
coolant level
(LC500h)
( P.322)
• “Toyota Super Long Life
Coolant” or a similar
high quality ethylene
glycol-based non-sili-
cate, non-amine, non-
nitrite and non-borate
coolant with long-life
hybrid organic acid
technology
“Toyota Super Long Life
Coolant” is pre-mixed
with 50% coolant and
50% deionized water.
•Funnel (used only for
adding coolant)
Engine oil level
( P.319)
•“Toyota Genuine Motor
Oil” or equivalent
• Rag or paper towel
•Funnel (used only for
adding engine oil)
Fuses
( P.350)
•Fuse with same amper-
age rating as original
Light bulbs
( P.355)
• Bulb with same number
and wattage rating as
original
Radiator and
condenser
( P.323)

Tire inflation
pressure
( P.345)
• Tire pressure gauge
• Compressed air source
Washer fluid
( P.324)
• Water or washer fluid
containing antifreeze
(for winter use)
•Funnel (used only for
adding water or washer
fluid)
ItemsParts and tools

319
6
-$@-$I@0.@0.&@ &&

6-3. Do-it-yourself maintenance
Maintenance and care
LC500h
Engine oil level dipstick ( P.319)
Power control unit coolant reservoir ( P.323)
Engine oil filler cap ( P.320)
Fuse boxes ( P.350)
Washer fluid tank ( P.324)
Engine coolant reservoir ( P.322)
Electric cooling fan
Condenser ( P.323)
Radiator ( P.323)
For right-hand drive vehicles:
One of the fuse boxes is located on the opposite side of the engine compartment.
■12-volt battery
 P.325
With the engine at operating tempera-
ture and turned off, check the oil level
on the dipstick.
A
B
C
D
E
F
G
H
I
Checking and adding the engine
oil