brake pads MERCEDES-BENZ C-Class COUPE 2017 CL205 Owner's Manual
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2017, Model line: C-Class COUPE, Model: MERCEDES-BENZ C-Class COUPE 2017 CL205Pages: 354, PDF Size: 8.66 MB
Page 132 of 354
Notesonb reaking-in anew vehicle
Important safety notes
Thes ensors ystemofs omedriving and driving
safety systems adjusts automaticall ywhile a
certai ndistance is being driven after the vehicle
ha sb eend elivere dorafter repairs. Full system
effectiveness is not reache duntilthe end of this
teach-i nprocedure.
New and replaced brake pads and discs only
reach their optimum braking effect after several hundred kilometers of driving. Compensate for
thi sb yapplyin ggreate rforce to the brake pedal.
The first 1000 miles (150 0km)
Them orey ou look after the engine when it is
new ,the mor esatisfied yo uwillbew ithi ts per-
formance in the future.
RYo us houl dtherefore drive at varying vehicle
and engine speeds for the first 1000 miles
(1500 km).
RAvoi dheavy loads, e.g .driving at full throttle,
during thi speriod.
RWhen changing gear smanually, change up in
good time, befor ethe tachomete rneedl erea-
ches Ôof the wa ytothe red area of the tach-
ometer.
RDo not manuall yshift to alower gear to brake
the vehicle.
RTry to avoi ddepressing the accelerator pedal
beyond the point of resistanc e(kickdown).
RAllv eh icle s(exce pt Mercedes-AMG vehi-
cles): ideally, for the first 1,000 miles
(1,500 km), drive in drive program E.
Additiona lbreaking-i nnote sfor Mercedes-AMG
vehicles:
RDo not drive fastert han8 5m ph (14 0km/h)
for the first 1,000 mile s(1,500 km).
ROnl yallow the engine to reach amaximum
engine spee dof4,500 rpm briefly.
RChang egearing oodt ime.
RIdeally ,for the first 1,000 mile s(1,500 km),
drive in program C.
After 1000 mile s(1500 km), you can increase
th ee ngi
n espeed gradually and accelerate th e
vehicl etofull speed.
You should also observ ethese note sonbreak-
in ginift heengin eorp artsoft hedrive train on
your vehicl ehaveb een replaced. Always observ
ethe maximum permissibl e
speed.
Self-lockin greara xled ifferential
(Mercedes-AMG vehicles)
Your vehicl eisequipped wit haself-locking dif -
ferential on th erear axle.
Change th eoil to improv eprotection of th erear
axl ed ifferential:
Rafter abreaking-i nperiod of 1,850 mile s
(3,00 0km)
Revery 31,00 0miles( 50,00 0km) or 3years
These oil changes prolon gthe servic elife of th e
differential. Hav ethe oil chang ecarrie dout at a
qualified specialist workshop .
Driving
Important safety notes
GWARNIN G
Objects in th edriver's footwell can restrict th e
pedal travel or obstruct adepressed pedal .
The operating and roa dsafet yoft hevehicl eis
jeopardized. There is ariskofana ccident.
Mak esuret hata ll objects in th evehicl eare
stowed correctly, and that they canno tenter
th ed river's footwell. Install th efloormats
securel yand as specified in order to ensur e
sufficien tclearance for th epedals. Do no tuse
loos efloormats and do no tplac efloormats on
to pofo neanother.
GWARNIN G
Unsuitable footwear can hinder correc tusage
of th epedals, e.g. :
Rshoes withthick sole s
Rshoes wit hhigh heels
Rslipper s
There is ariskofana ccident.
Wear suitable footwear to ensur ecorrect
usage of th epedals.
130Driving
Driving and parking
Page 160 of 354
When you take advantage of engine braking, a
drive wheel may not turn for some time, e.g.
on aslippery road surface. This could cause
damage to the drive train. This type of damage is not covered by the Mercedes-Benz war-
ranty.
Heavy and light loads
GWARNING
If you rest your foot on the brake pedal while
driving, the braking system can overheat. This increases the stoppin gdistanc eand can even
cause the braking system to fail. There is a
risk of an accident.
Never use the brake pedal as afootrest. Never
depress the brake pedal and the accelerator
pedal at the same time.
!Depressin gthe brake pedal constantly
results in excessive and premature wear to
the brake pads.
If the brakes have been subjected to aheavy
load, do not stop the vehicle immediately. Drive
on for ashort while. This allows the airflow to
cool the brakes more quickly.
Wet roads
If you have driven for along time in heavy rain
without braking, there may be adelayed reac-
tion from the brakes when braking for the first
time. This may also occur after the vehicle has
been washed or driven through deep water.
You have to depress the brake pedal more
firmly. Maintain agreater distanc efrom the
vehicle in front.
After driving on awet road or having the vehicle
washed, brake firmly while paying attention to
the traffic conditions. This will warm up the
brake discs, thereby drying them more quickly
and protecting them against corrosion.
Limited braking performance on salt-
treated roads
If you drive on salted roads, alayer of salt resi-
due may form on the brake discs and brake
pads. This can result in asignificantly longer
braking distance.
RIn order to prevent any salt build-up, apply the
brakes occasionally while paying attention to
the traffic conditions.
RCarefully depress the brake pedal and the
beginnin gand end of ajourney.
RMaintain agreater distanc etothe vehicle
ahead.
Servicing the brakes
!The brake fluid level may be too low, if:
Rif the red brake warning lamp lights up in
the instrument cluster and
Ryou hear awarning ton ewhile the engine is
running
Observe additional warning messages in the
multifunction display.
The brake fluid level may be too low due to
brake pad wear or leaking brake lines.
Have the brake system checked immediately. Consult aqualified specialist workshop to
arrange this.
!Vehicles with 4MATIC: function or per-
formance test smay only be carried out on a2-
axle dynamometer. If you wish to operate the
vehicle on such adynamometer, please con-
sult aqualified specialist workshop in
advance. You could otherwise damage the
drive train or the brake system.
!Vehicles with 4MATIC: the ESP®system
operates automatically. The engine and the
ignition must therefore be switched off (the
SmartKey must be in position 0or 1in the
ignition lock or the Start/Stop button must be
in position 0or 1)ift he electric parking brake
is tested on abrake dynamometer.
Brakin gtriggered automatically by ESP
®may
cause severe damage to the brake system.
All checksa nd maintenance work on the brake
system must be carried out at aqualified spe-
cialist workshop.
Have brake pads installed and brake fluid
replaced at aqualified specialist workshop.
If the brake system has only been subject to
moderate loads, you should test the functional-
ity of your brakes at regular intervals.
Information on BAS (Brake Assist )(
Ypage 62)
and BAS PLUS (Brake Assist PLUS) (Ypage 62).
158Driving tips
Driving and parking
Page 161 of 354
For safety reasons, Mercedes-Benz recom-
mends only installing the following brake disks
and brake pads/linings:
Rbrake disks that havebeena pproved by
Mercedes-Benz
Rbrake pads/lining sthat hav ebeena pproved
by Mercedes-Benz or that are of an equivalent
standard of quality
Other brake disks or brake pads/lining scan
compromise the safety of your vehicle.
Alway sreplace al lbrake disks and brake pads/
linings on an axl eatthe sam etime. Always
install new brake pads/lining swhenr eplacing
brake disks.
The vehicle is equipped with lightweight brake
disks to which the wheel assembly with rim and
threaded connectio nismatched.
The use of brake disks other than those
approved by Mercedes-Benz can chang ethe
track width and is subject to approval ,ifappli-
cable.
Shock-typ eloads whe nhandling the brake
discs, such as whe nchanging wheels ,can lead
to areduction in comfortw hend riving with light-
weigh tbrake discs. Avoid shock-type loads on
the lightweight brake disks, particularly on the
brake plate.
Mercedes-Benz recommends that yo uonly use
brake fluid that has bee nspeciall yapproved for
your vehicle by Mercedes-Benz, or which corre-
sponds to an equivalent quality standard .Brake
fluid which has not bee napproved for
Mercedes-Benz vehicles or which is not of an
equivalent quality could affect your vehicle's
operating safety.
High-performance and ceramic brakes
(Mercedes AMG vehicles)
The AMG brake systems are designe dfor heavy
loads. Thism ay leadtonoisew henb raking. This
will depend on:
RSpeed
RBraking force
REnvironmental conditions, such as tempera-
ture and humidity
The wear of individua lcomponents of the brake
system, such as the brake pads/lining sorbrake
discs, depends on the individua ldriving style
and operating conditions.
For this reason, it is impossible to state amile-
ag ethat will be valid under al lcircumstances. An aggressive driving styl
ewilll ea dtoh ighw ear.
You can obtain more information on this from a
qualified specialist workshop.
New and replaced brake pads and discs only
reach thei roptimum braking effect afte rseveral
hundred kilometers of driving. Compensate for
this by applying greater force to the brake pedal.
Kee pthis in mind ,and adap tyou rd riving and
braking accordingly during this break-in period.
Excessive heavy braking results in correspond-
ingl yhighb rake wear. Observe the brake wear
warning lamp in the instrument cluster and note
any brake statu smessages in the multifunction
display. Especiall yfor hig hperformance driving,
it is important to maintain and hav ethe brake
system checked regularly.
Drivin gonw etroads
Hydroplaning
If water has accumulated to acertain depth on
the roads urface,there is adanger of hydro-
planing occurring, even if:
Ryo ud rive at low speeds.
Rthe tires hav eadequate treadd epth.
For this reason, in the event of heavy rai norin
conditions in which hydroplaning may occur,
yo um ustd rive in the following manner:
Rlower your speed.
Ravoid ruts.
Ravoid sudden steering movements.
Rbrake carefully.
Drivin gonfloodedroads
!Bearinm ind that vehicles traveling in front
or in the opposite directio ncreate waves. This
may cause the maximum permissibl ewater
depth to be exceeded.
Failure to observe these notes may result in
damag etothe engine, electricals ystems and
transmission.
If yo uhavetod rive on stretche sofroadonw hich
water has collected ,please bea rinmind that:
Rin the case of standing water, the water level
may be no higher than the lower edg eofthe
vehicle body
Ryo us hould drive no faster than at awalking
pace
Drivin gtips159
Drivin gand parking
Z
Page 227 of 354
Display messagesPossible causes/consequences andMSolutions
The yellow!warning lamp lights up and th ered F (USAonly)
or ! (Canada only) indicator lamp flashes .
It is no tpossibl etoapply th eelectric parking brak emanually.
XShift th etransmission to position P.
XVisitaqualified specialist workshop .
$(USA
only)
J(C anada
only)
Check Brake Fluid
Level
There is no tenough brak efluidint hebrak efluid reservoir .
In addition ,the $ (USAonly) or J (Canada only) warning lamp
lights up in th einstrumen tcluste rand aw arning tone sounds.
GWARNIN G
The braking effec tmay be impaired.
There is ariskofana ccident.
XPull overand stop th evehicl esafely as soo naspossible, payin g
attention to roa dand traffic conditions. Do no tcontinue driving
under any circumstances.
XSecur ethe vehicl eagainst rollin gaway (Ypage 152).
XConsult aqualified specialist workshop .
XDo notadd brak efluid .This does no tcorrect them alfunction .
#
CheckBrakePadWear
The brak epads/linings hav ereached their wear limit.
US Ao nly: th e$ red brak esystem warning lamp is lit while th e
engin eisrunning.
XVisit aqualified specialist workshop .
G
Inoperative
Oneorm orem ain features of th embrace system are malfunctioning .
XVisitaqualified specialist workshop .
Collision Preven‐tionAssist Plu sCurrently Unavaila‐ble See Operator' sManual
COLLISION PREVENTION ASSIST PLU Sistemporarily no toperational.
Possibl ecauses are:
Rther adar sensor system is temporarily inoperative, e.g. due to elec -
tromagneti cradiation emitted by nearby TV or radi ostation sor
other source sofelectromagneti cradiation .
Rthes ystem is outside th eoperating temperature range.
Rtheo n-bo ardv oltag eistoolow.
Whe nthe causes state dabov enol onger apply, th edisplay message
disappears.
COLLISION PREVENTION ASSIST PLU Sisoperational again .
If th edisplay message does no tdisappear :
XPull overand stop th evehicl esafely as soo naspossible, payin g
attention to roa dand traffic conditions.
XSecur ethe vehicl eagainst rollin gaway (Ypage 152).
XRestart th eengine.
Display messages22 5
On-boardc omputer andd isplays
Z
Page 250 of 354
Safety systems
Warning/
indicator
lampNSignal type
Possible causes/consequences and M
Solutions
$JN$ (USA only), J(Canada only): the red brake system warning lamp is lit
while the engine is running.
Aw arning tone also sounds.
GWARNING
The brake boosting effect is malfunctioning and the braking characteristics may be
affected.
There is arisk of an accident.
XPull over and stop the vehicle safely as soon as possible, paying attention to road
and traffic conditions. Do not continue driving under any circumstances.
XSecure the vehicle against rolling away (Ypage 152).
XConsult aqualified specialist workshop.
XObserve the additional display messages in the multifunction display.
$JN$ (USA only), J(Canada only): the red brake system warning lamp is lit
while the engine is running.
Aw arning tone also sounds.
There is not enough brake fluid in the brake fluid reservoir.
GWARNING
The braking effect may be impaired.
There is arisk of an accident.
XPull over and stop the vehicle safely as soon as possible, paying attention to road
and traffic conditions. Do not continue driving under any circumstances.
XSecure the vehicle against rolling away (Ypage 152).
XDo not add brake fluid. Adding more will not correct the malfunction.
XConsult aqualified specialist workshop.
XObserve the additional display messages in the multifunction display.
$NUSA only: the red brake system warning lamp is lit while the engine is running.
The multifunction display also shows adisplay message with the #symbol.
The brake pads/linings have reached their wear limit.
XVisit aqualified specialist workshop.
248Warning and indicator lamp sinthe instrument cluster
On-board computer and displays
Page 294 of 354
Drivingabroad
An extensive Mercedes-Ben zService networ kis
also available in other countries. You can obtain
further information from any authorized
Mercedes-Ben zCenter.
Car e
General notes
HEnvironmental not e
Dispose of empty packagin gand cleanin g
cloths in an environmentally responsible man -
ner.
!Fo rc leanin gyour vehicle, do no tuse any of
th ef ollowing:
Rdry, rough or har dcloths
Rabrasiv ecleanin gagents
Rsolvents
Rcleanin gagents containin gsolvents
Do no tscrub .
Do no ttou ch th esurfaces or protective films
wit hh ardo bjects ,e.g.a ringori cescraper.
You could otherwise scratch or damage th e
surfaces and protective film.
!Do no tparkt he vehicle fo ranextende d
period straight after cleanin git,particularly
after havin gcleaned th ewheels wit hwhee l
cleaner. Wheel cleaners could cause
increase dcorro sion of th ebrake discs and
brake pads/linings. Fo rthisr eason ,you
should drive fo rafewminutes after cleaning.
Brakin gheat sthe brake discs and th ebrake
pads/linings, thus drying them. The vehicle
can then be parked.
Regular car eofyour vehicle is aconditi on for
retainin gthe qualit yint he longterm.
Use car eproducts and cleanin gagents recom -
mended and approved by Mercedes-Benz.
Washing th evehicle an dcleaning th e
paintwor k
Automatic car was h
GWARNING
Brakin gefficiency is reduce dafter washin g
th ev ehicle. There is ariskofana ccident.
Afte rthe vehicle has bee nwashed, brake
carefully whil epayin gattenti on to th etraffic
condition suntil full braking powe risrestored .
!If DISTRONIC PLU SortheHOLD function is
activated, th evehicle brake sautomatically in
certain situations.
To preven tdamage to th evehicle, deactivat e
DISTRONIC PLU Sand th eHOLDf unction in
th ef ollowin goro ther similar situations:
Rwhen towin gthe vehicle
Rin th ecar wash
!Never clean your vehicle in aTouchless
Automatic Car Wash as these use special
cleanin gagents .These cleanin gagents can
damage th epaintwor korplasticparts .
!Mak esuret hat:
Rthes idew indows and th eslidin gsunroof
are full yclosed.
Rth ev entilation/heatin gisswitched of f(th e
OF Fb utto nhas bee npressed).
Rthew indshield wipe rswitch is at position 0.
Rthe3 60°c amera or rea rviewc amera is
switched off.
The vehicle may otherwise be damaged .
!If theSmartKey is within th ereard etection
range of KEYLESS-GO ,the followin gsitua-
tions, fo rexample, could lead to th euninte
n
-
tional opening of th etrunk :
Rusin gac ar wash
Rusingap owerwasher
Mak esuret hatthe SmartKey is at leas t10ft
(3 m) away from th evehicle.
!Mak esuret hatthe automatic transmissio n
is in neutral position Nwhen washin gyour
vehicle in atow-throu gh car wash .The vehicle
may otherwise be damaged .
ROperatingwitht he SmartKey:
Do no tremov ethe SmartKey from th eigni-
tion lock. Do no topent he driver's doo r
292Care
Maintenance an dcare
Page 297 of 354
Cleaning thevehicle parts
Cleaning th ewheels
GWARNING
The wate rjet from acircular je tnozzle (dirt
blasters)c an causeinvisible exterior damage
to th etires or chassis components .Compo-
nent sdamaged in this way may fail unexpect-
edly. Thereisar iskofana ccident.
Do no tuse power washers withc ircular jet
nozzles to clean th evehicle .Haved amaged
tires or chassis components replaced imme-
diately.
!Do no tuse acidic wheel cleanin gproducts
to remove brak edust.T his coul ddamage
wheel boltsa nd brakecomponents.
!Do no tpark th evehicle for an extended
period straigh tafter cleanin git, particularly
after having cleane dthe wheelsw ithwheel
cleaner. Wheelc leaners couldcause
increased corrosion of th ebrak ediscsa nd
brak epads/linings. For this reason,y ou
should driv efor afew minute safter cleaning.
Brakin gheatst hebrak ediscsa nd thebrake
pads/linings, thus dryin gthem. The vehicle
can then be parked.
Cleaning th ewindows
GWARNING
You coul dbecome trapped by th ewindshield
wipersift heys tart moving while cleanin gthe
windshield or wiper blades.T hereisarisko f
injury.
Always switch off th ewindshield wipersa nd
th ei gnition before cleanin gthe windshield or
wiper blades.
!Do no tuse dry cloths, abrasive products,
solvents or cleanin gagents containing sol-
vents to clean th einside of th ewindows. Do
no ttou ch th einsides of th ewindows with
hard objects, e.g .anice scrape rorring. There
is otherwise ariskofd amaging th ewindows.
!Clean th ewaterdrainage channels of the
windshield and th erear window at regular
intervals. Deposits suchasl eaves, petals and
pollenm ay undercertain circumstances pre- ven
twate rfromd raining away. This can lead
to corrosion damagea nd damagetoelec-
tronic components.
XClean th einside and outside of th ewindows
withad amp cloth and acleanin gproduct that
is recommended and approved by Mercedes-
Benz.
Cleaning wiper blades
GWARNING
You coul dbecome trapped by th ewindshield
wipersift heys tart moving while cleanin gthe
windshield or wiper blades.T hereisarisko f
injury.
Always switch off th ewindshield wipersa nd
th ei gnition before cleanin gthe windshield or
wiper blades.
!Do no tpull th ewiper blade. Otherwise, the
wiper blade coul dbedamaged.
!Do notclean wiper blades to ooften and do
no trub them to ohard .Otherwise, th egraph-
ite coatin gcoul dbed amaged. This could
caus ewiper noise.
!Holdthe wiper arm securely when folding
back .The windshield coul dbedamaged if the
wiper arm smacks against it suddenly.
XFol dthe windshield wiper arm saway from the
windshield (Ypage 116).
XCarefully clean th ewiper blades withad amp
cloth.
XFol dthe windshield wiper arm sback again
before switching on th eignition.
Cleaning th eexterior lighting
!Only use cleanin gagents or cleanin gcloths
whicha re suitable for plastic light lenses.
Unsuitable cleanin gagents or cleanin gcloths
coul dscratch or damag ethe plastic light len-
ses.
XClean th eplastic lenses of th eexteri or light-
ing usingaw et sponge and amild cleaning
agent, e.g .Mercedes-Ben zcar shampoo or
cleanin gcloths.
Care295
Maintenance and care
Z