ignition Mercury Grand Marquis 2006 s Repair Manual

of driving (engine break-in period). You will get a more accurate
measurement after 2,000 miles-3,000 miles (3,000 km–5,000 km).
Filling the tank
The advertised fuel capacity of the fuel tank on your vehicle is equal to
the rated refill capacity of the fuel tank as listed in theRefill capacities
section of this chapter.
The advertised capacity is the amount of the indicated capacity and the
empty reserve combined. Indicated capacity is the difference in the
amount of fuel in a full tank and a tank when the fuel gauge indicates
empty. Empty reserve is the small amount of fuel remaining in the fuel
tank after the fuel gauge indicates empty.
The amount of usable fuel in the empty reserve varies and should
not be relied upon to increase driving range. When refueling your
vehicle after the fuel gauge indicates empty, you might not be
able to refuel the full amount of the advertised capacity of the
fuel tank due to the empty reserve still present in the tank.
For consistent results when filling the fuel tank:
•Turn the engine/ignition switch to the off position prior to refueling,
an error in the reading will result if the engine is left running.
•Use the same filling rate setting (low — medium — high) each time
the tank is filled.
•Allow no more than two automatic click-offs when filling.
•Always use fuel with the recommended octane rating.
•Use a known quality gasoline, preferably a national brand.
•Use the same side of the same pump and have the vehicle facing the
same direction each time you fill up.
•Have the vehicle loading and distribution the same every time.
Your results will be most accurate if your filling method is consistent.
Calculating fuel economy
1. Fill the fuel tank completely and record the initial odometer reading
(in miles or kilometers).
2. Each time you fill the tank, record the amount of fuel added (in
gallons or liters).
3. After at least three to five tank fill-ups, fill the fuel tank and record
the current odometer reading.
2006 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
242

EMISSION CONTROL SYSTEM
Your vehicle is equipped with various emission control components and a
catalytic converter which will enable your vehicle to comply with
applicable exhaust emission standards. To make sure that the catalytic
converter and other emission control components continue to work
properly:
•Use only unleaded fuel (or E85, if equipped with the FFV engine).
•Avoid running out of fuel.
•Do not turn off the ignition while your vehicle is moving, especially at
high speeds.
•Have the items listed inscheduled maintenance information
performed according to the specified schedule.
The scheduled maintenance items listed inscheduled maintenance
informationare essential to the life and performance of your vehicle
and to its emissions system.
If other than Ford, Motorcraft or Ford-authorized parts are used for
maintenance replacements or for service of components affecting
emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
Do not park, idle, or drive your vehicle in dry grass or other dry
ground cover. The emission system heats up the engine
compartment and exhaust system, which can start a fire.
Illumination of the
indicator, charging system warning light or the
temperature warning light, fluid leaks, strange odors, smoke or loss of
engine power, could indicate that the emission control system is not
working properly.
An improperly operating or damaged exhaust system may allow exhaust
to enter the vehicle. Have a damaged or improperly operating exhaust
system inspected and repaired immediately.
Exhaust leaks may result in entry of harmful and potentially
lethal fumes into the passenger compartment.
Do not make any unauthorized changes to your vehicle or engine. By
law, vehicle owners and anyone who manufactures, repairs, services,
sells, leases, trades vehicles, or supervises a fleet of vehicles are not
permitted to intentionally remove an emission control device or prevent
2006 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
245

Item Ford part
nameFord part
numberFord
specification
Automatic
transmission
(4R75E)Motorcraft
MERCONV
AT F
3
XT-5-QM
MERCONV
Rear Axle
LubricantMotorcraft SAE
80W-90
Premium Rear
Axle Lubricant
2
XY-80W90-QL WSP-M2C197-A
Windshield
washer fluidMotorcraft
Premuim
Windshield
Washer
ConcentrateZC-32-A WSB-M8B16–A2
1Use only brake fluids certified to meet Ford specifications. DOT 3 fluid is
recommended. However, if DOT 3 is not available, DOT 4 fluid can be used.
2Add 4 oz. (118 ml) of Additive Friction Modifier XL–3 or equivalent
meeting Ford specification EST-M2C118-A for complete refill of
Traction-Lok rear axles.
3Ensure the correct automatic transmission fluid is used. Transmission
fluid requirements are indicated on the dipstick or on the dipstick
handle. MERCONand MERCONV are not interchangeable. DO NOT
mix MERCONand MERCONV. Refer to yourscheduled maintenance
informationto determine the correct service interval.
ENGINE DATA
Engine 4.6L V8 engine 4.6L FFV V8 engine
Cubic inches 281 281
Required fuel 87 octane 87 octane or Ethanol
(E 85)
Firing order 1-3-7-2-6-5-4-8 1-3-7-2-6-5-4-8
Ignition system Coil on plug Coil on plug
Spark plug gap 0.052–0.056 inch
(1.32–1.42 mm)0.041–0.047 inch
(1.04–1.20 mm)
Compression ratio 9.4:1 9.4:1
2006 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
255

recommendations ...................227
refill capacities ........................252
specifications ..................254–255
Exhaust fumes ..........................171
F
Fail safe cooling ........................235
Flexible Fuel Vehicle (FFV) ....236
Floor mats ...................................82
Fluid capacities .........................252
Foglamps .....................................42
Fuel ............................................236
calculating fuel
economy ......................57, 76, 241
capacity ...................................252
choosing the right fuel ...........239
comparisons with EPA fuel
economy estimates .................244
detergent in fuel .....................241
filling your vehicle with
fuel ...................................236, 242
filter, specifications ........236, 251
fuel pump shut-off switch .....186
improving fuel economy ........241
octane rating ...........240, 255–256
quality ......................................240
running out of fuel .................241
safety information relating to
automotive fuels .....................236
Fuel - flex fuel
vehicle (FFV) ............236, 239–240
Fuses ..................................187–188
G
Gas mileage
(see Fuel economy) .................241
Gauges .........................................14H
Hazard flashers .........................185
Head restraints ...........................99
Headlamps ...................................40
aiming ........................................42
autolamp system .......................40
bulb specifications ....................46
daytime running lights .............41
flash to pass ..............................41
high beam .................................41
replacing bulbs .........................47
turning on and off ....................40
Heating
heating and air conditioning
system .................................36–37
Homelink wireless control
system ..........................................70
Hood ..........................................222
I
Ignition .......................168, 255–256
Illuminated visor mirror .............53
Infant seats
(see Safety seats) .....................135
Inspection/maintenance (I/M)
testing ........................................246
Instrument panel
cleaning ...................................217
cluster ........................................10
lighting up panel and
interior .......................................42
J
Jack ............................................195
positioning ...............................195
storage .....................................195
2006 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
263

Jump-starting your vehicle ......201
K
Keyless entry system .................91
autolock .....................................90
keypad .......................................91
programming entry code .........91
Keys .......................................83, 96
positions of the ignition .........168
L
Lamps
autolamp system .......................40
bulb replacement
specifications chart ..................46
daytime running light ...............41
fog lamps ...................................42
headlamps .................................40
headlamps, flash to pass ..........41
instrument panel, dimming .....42
interior lamps .....................44–47
replacing bulbs .........................47
Lane change indicator (see
Turn signal) .................................44
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........173
Limited slip axle
(see Traction Loc) ....................178
Load limits .................................157
Locks
autolock .....................................90
childproof ..................................84
doors ..........................................83
Lubricant specifications ...254–255
Lug nuts ....................................200
Lumbar support, seats .............103
M
Message center .....................74–75english/metric button ...............78
system check button ................77
warning messages .....................79
Mirrors .........................................65
automatic dimming rearview
mirror ........................................64
fold away ...................................65
heated ........................................65
side view mirrors (power) .......65
Moon roof ....................................70
Motorcraft parts ........219, 236, 251
O
Octane rating ............................240
Oil (see Engine oil) ..................225
P
Parking brake ............................174
Parts (see Motorcraft parts) ....251
Passenger Occupant
Classification Sensor .................106
Pedals (see Power adjustable
foot pedals) .................................66
Power adjustable foot pedals .....66
Power distribution box
(see Fuses) ...............................191
Power door locks ..................83, 90
Power mirrors .............................65
Power point .................................63
Power steering ..................176–177
fluid, checking and adding ....247
fluid, refill capacity ................252
fluid, specifications .................254
Power Windows ...........................63
R
Radio ....................17, 19, 21, 25, 30
2006 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
264